RoadVitals

2003 Workhorse W20

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
11
Latest Mar 24, 2009
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Apr 3, 2009
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 11 NHTSA owner-reported complaints for the 2003 Workhorse W20, most frequently naming the brakes category. 1 safety recall has been issued covering this model year; and 2 NHTSA investigations name it.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
09V110000

SERVICE BRAKES, HYDRAULIC

Apr 3, 2009
48,876 units potentially affected
The defect: NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
The risk: THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
The remedy: WORKHORSE DEALERS WILL REPLACE ALL FOUR BOSCH BRAKE CALIPER ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.
NAVISTAR, INCManufacturer number 50901-C & 51101-CView on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

EA07016ClosedEngineering Analysis

OVERHEATING DISC BRAKE CALIPER

Opened Nov 16, 2007
Closed Aug 19, 2009

THE EA WAS OPENED TO GAIN A TECHNICAL UNDERSTANDING OF THE CAUSES FOR ONE OR MORE DISC BRAKE CALIPERS ON A SUBJECT VEHICLE TO SUFFER SEVERE OVERHEATING. THE OVERHEATING CAUSED BRAKE DRAG, MELTING ABS SENSORS, SMOKING, BRAKE LINING FIRES, AND IN SOME CASES BOILING BRAKE FLUID RESULTING IN DIMINISHED STOPPING CAPABILITY.BASED ON TESTING, WARRANTY AND COMPLAINT DATA ANALYSIS, FIELD TRIPS AND INTERVIEWS WITH OWNERS, MECHANICS AND SERVICE MANAGERS, ODI BELIEVES THE LIKELY CAUSE OF THE ALLEGED DEFECT IS WATER SWELL OF THE PHENOLIC CALIPER PISTON AND SUBSEQUENT FAILURE OF THE PISTON TO FULLY RETURN AFTER THE PEDAL IS RELEASED.A TECHNICAL REPORT IS ATTACHED WITH FULL DETAILS.

SERVICE BRAKES, HYDRAULICLed to recall 09V110000
PE07032ClosedPreliminary Evaluation

OVERHEATED BRAKE CALIPERS

Opened Jun 25, 2007
Closed Nov 19, 2007

ON JUNE 25, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED OVERHEATING DISC BRAKE CALIPERS AND POOR BRAKE PERFORMANCE IN MODEL YEAR (MY) 2000-2005 WORKHORSE CHASSIS RECREATIONAL VEHICLES.CURRENTLY ODI IS AWARE OF 651 SPECIFIC COMPLAINTS ON THE SUBJECT VEHICLES (ODI AND WORKHORSE COMPLAINT POPULATION).ODI ANALYSIS OF THE WARRANTY AND COMPLAINT DATA FURNISHED BY WORKHORSE ON SEPTEMBER 11, 2007, IN RESPONSE TO ODI'S INFORMATION REQUEST INDICATES A DRAMATIC DROP IN BRAKE RELATED COMPLAINTS AFTER THE MAY 2004 BUILD DATE.AT THAT TIME, WORKHORSE INCORPORATED INTO PRODUCTION ZERK FITTINGS AND GREASING OF THE BRAKE MASTER CYLINDER'S BELL CRANK LINKAGE.ODI IS ALSO AWARE OF 3,782 UNIQUE WARRANTY COUNTS RELATED TO THE ALLEGED DEFECT IN THE SUBJECT POPULATION.A REVIEW OF THE WARRANTY CLAIMS REVEALS THAT OF THE CLAIMS FILED, ONLY 88 WERE SUBMITTED ON VEHICLES PRODUCED AFTER THE MAY 2004 PRODUCTION LINE CHANGE (ADDITION OF ZERK FITTINGS).ODI INTENDS TO OBTAIN AN UNDERSTANDING OF WHY THERE ARE SEEMINGLY SIGNIFICANT DIFFERENCES IN THE COMPLAINT DATA AND WARRANTY CLAIMS BEFORE AND AFTER THE MAY 2004 DESIGN CHANGE AND THE SAFETY CONSEQUENCES OF THE PRE-CHANGE DESIGN. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-016) FOR FURTHER INVESTIGATION.

SERVICE BRAKES, HYDRAULIC

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 11
Brakes
Filed Mar 24, 2009

2ND OCCURRENCE OF BRAKE STICKING / DRAG DURING THIS TRIP. R REAR BRAKE DID NOT RELEASE AFTER BRAKING CAUSING DRAG & OVERHEATING. THIS (AND THE PREVIOUS REPORTED INCIDENT) OCCURRED AFTER GOING THROUGH A SECTION OF IN-TOWN STOP & GO TRAFFIC & STOP LIGHTS. THIS OCCURRENCE WAS RECOGNIZED QUICKLY AND WAS NOT AS SEVERE AS THE PREVIOUS ONE. I WAS ABLE TO COOL THE BRAKES DOWN AND THEY RELEASED. *TR

NHTSA ID
10262913
Incident
Mar 18, 2009
Mileage
48,850 mi
Brakes
Filed Mar 16, 2009

BRAKE FAILURE - LOCKUP OF FRONT BRAKE CALIPER / ROTOR CAUSING OVERHEATING AND BRAKE FAILURE. NO SERIOUS INJURY RESULTED. CAUSED TRIP DELAY AND SIGNIFICANT COST TO REPAIR REPLACE BRAKE COMPONENTS AFFECTED. DEALER INSPECTED AND DIAGNOSED SIGNIFICANT OVERHEATING AND CRACKING OF THE FRONT ROTORS AND RECOMMENDED REPLACEMENT OF SAME AND PADS & SEALS AT A COST OF APPROX $900. THIS UNIT WAS PURCHASED USED WITH APPROX 37600 MILES AT WHICH TIME THE DEALER (WH SERVICE CENTER) INSPECTED AND REPLACE BRAKE PADS ON ALL 4 WHEELS. THIS UNIT IS STORED FOR SEVERAL MONTHS AT A TIME BUT HAS ALWAYS BEEN INSIDE STORAGE AND THE UNIT IS NOT DRIVEN IN WINTER WEATHER. *TR

NHTSA ID
10262068
Incident
Mar 14, 2009
Mileage
48,560 mi
Brakes
Filed Feb 18, 2009

LTR FROM CONGRESSMAN BISHOP ON BEHALF OF CONSTITUENT RE AN UPDATE ON AN INQUIRY HE PREVIOUSLY SUBMITTED RE W20 AND W22 CHASSIS BRAKES. *NJ THE CONSUMER STATED THE REAR BRAKE ROTORS OVERHEATED. THE BOILING BRAKE FLUID ALSO LEAD TO THE BRAKE FAILURE. *JB

NHTSA ID
10259068
Incident
Oct 5, 2007
Brakes
Filed Aug 23, 2008

PARTIAL LOCKUP OF REAR CALIPERS ON A 2003 WORKHORSE W-20 CHASSIS ON A 2004 FLEETWOOD FLAIR 33R MOTORHOME AFTER TRAVELING APPROXIMATELY 100 MILES ON RELATIVELY FLAT HIGHWAY ENTERING TRAFFIC WITH STOPLIGHTS. AFTER ABOUT 10 MILES IN THE STOP AND GO TRAFFIC, A SLIGHT 'BRAKE SMELL' WAS NOTICED. THIS WAS APPROXIMATELY 10 MILES FROM HOME. I GOT OUT AND CHECKED THE WHEELS AND BOTH REAR WHEELS WERE HOT TO THE TOUCH. AT APPROXIMATELY 1 MILE FROM HOME THE ABS LIGHT CAME ON AND THE BRAKE PEDAL WENT TO THE FLOOR. WHEN THIS HAPPENED, I PUMPED THE PEDAL A FEW TIMES AND HAD BRAKES. I LIMPED HOME IN THIS CONDITION. PARKED AT HOME I NOTICED THE MASTER CYLINDER WAS HOT, THE BRAKE LINE TO THE REAR BRAKES WAS HOT, A SENSOR HAD MELTED OFF THE RIGHT REAR DUAL, AND A LENGTH (APPROX. 18 INCHES) OF FINE, COILED, COPPER WIRE WAS HANGING FROM THE CALIPER. TO ME IT LOOKED LIKE IT CAME OUT OF THE MELTED SENSOR. THE LEFT WHEEL WAS HOT, AND NOTHING WAS MELTED. AN APPOINTMENT WAS MADE TO GET IT LOOKED AT ON 8/26/08. *TR

NHTSA ID
10239439
Incident
Aug 21, 2008
Mileage
8,681 mi
Brakes
Filed Jul 9, 2008

WHILE MY 2003 FLEETWOOD SOUTHWIND MOTOR HOME ON A WORKHORSE CHASSIS WAS IN FOR A RECALL ON THE INSTRUMENT CLUSTER (ABS) I WAS INFORMED THAT MY BRAKE FLUID HAD OVER HEATED AND THE BRAKE SYSTEM REQUIRED REPLACEMENT (CALIPERS, PADS, ROTORS). ACCORDING TO THE DEALER THE FLUID OVERHEATED, TURNED TO A JELLY AND WOULD NOT ALLOW THE PISTONS TO RETRACT AFTER THE BRAKES HAD BEEN APPLIED. WORHORSE WAS CONTACTED BY DEALER AND THEY REFUSED TO ACKNOWLEDGE THERE WAS AN ISSUE WITH THE BRAKES. I RETAINED 2 OF THE BRAKE CALIPERS AFTER REPAIRS WERE COMPLETE. RELATED TO NHTSA EA07016. *TR

NHTSA ID
10233626
Incident
Aug 17, 2007
Mileage
15,962 mi
Brakes
Filed Apr 24, 2008

WE HAVE A 2003 MOTORHOME WITH A W20 WORKHORSE FRAME. I HAVE LOST THE HYDRAULIC BRAKES DUE TO THE FLUID BOILING TWICE DURING NORMAL DRIVING ON LEVEL ROADS (NO HILLS OR MOUNTAINS) BOTH TIMES THE HEAT DESTROYED THE ABS WHEEL SENSORS. *TR

NHTSA ID
10225639
Incident
Jul 16, 2006
Mileage
27,684 mi
Brakes
Filed Mar 11, 2008

REAR BRAKES OVERHEATING. NO COMPLETE FAILURE. ONLY CAUSED LOSS OF RV VACATION AND MAJOR INCONVENIENCE. PULLED OFF TO SIDE OF ROAD TO ALLOW COOL DOWN. DELIVERED TO MECHANIC FOR FLUID CHANGE AND CHECKING AND LUBRICATING OF CALIPERS. THIS SAME THING HAPPENED 10 MONTHS LATER. *TR

NHTSA ID
10220759
Incident
Mar 1, 2007
Mileage
27,200 mi
Brakes
Filed Jan 3, 2008

TL*THE CONTACT OWNS A 2003 WORKHORSE W20. WHILE DRIVING 40 MPH, THE VEHICLE WOULD NOT ACCELERATE AS FAST AS IT NORMALLY WOULD. IN ADDITION, THE CONTACT NOTICED A BURNING SMELLING COMING FROM THE REAR OF THE VEHICLE. THE MECHANIC STATED THAT THE CALIPERS CAUSED THE FAILURE AND THEY REPLACED THE LEFT AND RIGHT REAR BRAKE CALIPERS. THERE IS AN OPEN DEFECT INVESTIGATION FOR THE SERVICE BRAKES: HYDRAULIC (NHTSA ACTION NUMBER EA07016). THE FAILURE MILEAGE WAS 16,000 AND CURRENT MILEAGE WAS 17,000. UPDATED 02-06-08. *KB THE CONSUMER STATED AT THE FIRST OBSERVATION THE LEFT REAR CALIPER WAS EXTREMELY HOT TO THE TOUCH AND ALL OTHER CALIPERS SEEMED TO HAVE NORMAL TEMPERATURE. UPDATED 02/06/08 *TR

NHTSA ID
10213573
Incident
Sep 26, 2007
Mileage
16,000 mi

Compare model years

Complaint and recall counts across every year of this model

Workhorse W20 by model year
YearComplaintsRecallsInvestigationsIssue Index
2008010—
2007010—
2006320—
2005322—
2004722—
2003Viewing111235.8
2002623—
2001233—
2000112—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.