RoadVitals

2003 Workhorse W20 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
11
Latest Mar 24, 2009
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2003 Workhorse W20, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

11
reports

From owner reports, verbatim

2ND OCCURRENCE OF BRAKE STICKING / DRAG DURING THIS TRIP. R REAR BRAKE DID NOT RELEASE AFTER BRAKING CAUSING DRAG & OVERHEATING. THIS (AND THE PREVIOUS REPORTED INCIDENT) OCCURRED AFTER GOING THROUGH A SECTION OF IN-TOWN STOP & GO TRAFFIC & STOP LIGHTS. THIS OCCURRENCE WAS RECOGNIZED QUICKLY AND WAS NOT AS SEVERE AS THE PREVIOUS ONE. I WAS ABLE TO COOL THE BRAKES DOWN AND THEY RELEASED. *TR

NHTSA ID 10262913 · filed Mar 24, 2009

BRAKE FAILURE - LOCKUP OF FRONT BRAKE CALIPER / ROTOR CAUSING OVERHEATING AND BRAKE FAILURE. NO SERIOUS INJURY RESULTED. CAUSED TRIP DELAY AND SIGNIFICANT COST TO REPAIR REPLACE BRAKE COMPONENTS AFFECTED. DEALER INSPECTED AND DIAGNOSED SIGNIFICANT OVERHEATING AND CRACKING OF THE FRONT ROTORS AND RECOMMENDED REPLACEMENT OF SAME AND PADS & SEALS AT A COST OF APPROX $900. THIS UNIT WAS PURCHASED USED WITH APPROX 37600 MILES AT WHICH TIME THE DEALER (WH SERVICE CENTER) INSPECTED AND REPLACE BRAKE PADS ON ALL 4 WHEELS. THIS UNIT IS STORED FOR SEVERAL MONTHS AT A TIME BUT HAS ALWAYS BEEN INSIDE STORAGE AND THE UNIT IS NOT DRIVEN IN WINTER WEATHER. *TR

NHTSA ID 10262068 · filed Mar 16, 2009
All 11 reports naming brakes →

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .