2003 Toyota Avalon Owner Complaints

March 13, 2026, I was on a road trip from CA to AZ and while driving around 75-80mph (speed limit), something in the driver's side seat belt or the shoulder holster exploded, the belt tightened, and something metal or plastic flew off. Shortly after (within 30 seconds or so), the passenger's side seat belt did something similar where something in the seat belt mechanism exploded and another part went flying. There was an electrical buzzing noise. I was looking for a place to pull over when the air bags went off. There was no bump in the road or a dip and I did not hit anything. I don't remember the order the air bags exploded but it was one after the other. The driver's side air bag exploding left a red abrasion on my left hand. The vehicle was brought to a nearby dealership (Anderson Toyota) where they said they could not verify what the issue was. The safety of myself and others on the road were at risk as the explosions were very loud and the air bags occluded my view while traveling at a high speed. The vehicle has been inspected by a 3rd party representative from Bosch (Apr 2nd) as sent by Toyota corporate and Toyota has not given me any updates. Calling them several times they have failed to return calls, and after a call today, they said the case was filed as closed without my prior notice. I do not recall warning lamps, messages, or other symptoms.

NHTSA ID

11732589

Incident

Mar 13, 2026

I was driving back home, out of no where my car went out of control, went left, then right, hit something and flipped over twice to end in a hill against the traffic with 4 flat tires. The air bag did not deployed. I did hit the windshield. The car was total.

NHTSA ID

11523134

Incident

May 19, 2023

Purchased car used 11/2020 Jan 14 2021 had 2 open recalls steering casting defect and wire harness filter to deflect noise from ecm . I lost control of communication of operations. 12/2022 steering lock bar The past 2 years uncovered everything on my own. Learned somebody died in 2003 Avalon in Texas about steering locking up. Plan to talk to class action lawyers over airbag and steering. And arrange my own lawyer with settlement lawyers to make this repair and all tsb to be performed. I will never buy a car unless I can find all tsb problems associated with that car. I hope recalls can be opened especially when you guys in government state safety ,compliance and emissions do not expire. Recall

NHTSA ID

11500232

Incident

Dec 7, 2022

turn off the lights inside panel. The level of heat all the way up, the same with the gasoline level. The internal lights blink. Loss of power.

NHTSA ID

11442744

Incident

Dec 5, 2021

The contact owns a 2003 Toyota Avalon. The contact stated while driving 40 mph, the vehicle started smoking and the engine stalled. The contact stated no warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with the engine needing to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 96,000.

NHTSA ID

11419230

Incident

Aug 12, 2020

Mileage

96,000 mi

What component or system failed or malfunctioned, and is it available for inspection upon request? 1- AUG 2020- MEGA MOTERS- PURCHASSED AUTO- CARFAX AND AUTO GURO- RECOMMENDED THIS VEHISCAL AND SALES PITCH INCLUDED THESE COMPANIES- HE SAID HE DOES GOOD BUSINESS- HE SAID HE WILL FIX ALL ISSUES IF THE ISSUE WAS WITH-IN 30 DAYS- CAR DROVE FINE- HE PUT AN INSPECTION STICKER- IT DID NOT SMOKE THEN BECAUSE HE HAD A HELPER WHO STARTED THE CAR AND PLACED INSPECTION STICKER READIN 10;2021? BUT IT WAS AUGUST 2020? THE HELPER DROVE IT TO THE FRONT OF THE DEALERSHIP- AFTER I PAID 7000.00 AND THUS DID NOT SEE START UP SMOKE AT THE DEALERSHIP 2. AT START UP - TOOK MY TWO SISTERS FOR A TEST DRIVE- GREY SMOKE- SAME DAY- AS PURCHASSED - SHOCK ISSUES-SUSPENTION AND DEALER- MY SISTER WAS DRIVING AS i CALLED TO TELL HIM i LOVED THE CAR AND IT SEEMED TO RUN FINE- EXCEPT FOR THE SMOKE ANDRED OIL LIGHT AND THE SHOCKS- SUSPENTION- UNCOMFORTABLE SCRAPING SOUND- I WILL FIX- AS HE SAID HE FORGOT TO PUT THE NEW OIL CAP ON OIL AND SENSOR- HE SAID HE WOULD PLACE THE TIRE SHOCKS TO FIX SUSPENTION. 2- I LIVE FAIRLY CLOSE- AND ONLY DRIVE SHORT DISTANCE- LIGHT OF OIL CAME ON- BUT GAGES READ NORMAL- MILES WERE AT 9800, DROVE FINE- JUST WAS CONCERNED ABOUT THE LOUD SCRAP SOUND ON ANY DIPS ON ROAD AND THE SMOKE- AT START UP - AND DEALER AT MEGA MORTOR- SAID- TO BRING IT IN HE FORGOT TO PUT A SENSOR AND THE SHOCKS HE HAS THEM AT THE SHOP AND THE NEW OIL CAP- 2 RETURNED THE FOLLOWING MORNING- NO ONE WAS AT THE SHOP- I CALLED HIM HE SAID HE WOULD BE THERE AT 10 AM- - THE CAR SMOKED AT START INCREASED- - HE WAS NOT THERE AT 1030AM- CALLED HIM HE SAID HE COULD NOT FIX IT AS HE WAS BUSY- HE ASKED ME TO COME IN THE NEXT DAY- i CALLED NO ANSWER- CALLED AGAIN- AND HE SAID HE NEEDED ME TO BRING IT SATURDAY MORNING- AND HE WILL FIX- HE WAS RUDE AND SAID HE WAS BUSY- IT WAS SEPTEMBER- AND THE CAR IS HAZARD- IT STOPPED ON MY WAY INTO HIS SHOP AND GOT IT HOME- I GOT COVID 10-2020 TO 4/2020- LONGHAUL-

NHTSA ID

11418364

Incident

Aug 15, 2020

CAR'S STEERING STOPS TURNING WHILE DRIVING IN THE INITIAL 5 MINUTES OF DRIVE, IT OCCURS MOSTLY WHEN WEATHER IS HUMID ( RAINING). THE EPISODE OCCURS WHEN I TRY TO TURN THE STEERING AND RECOVERS AFTER I FORCIBLY TURN THE STIFF STEERING.

NHTSA ID

11194433

Incident

Mar 27, 2019

Mileage

4 mi

TL* THE CONTACT OWNS A 2003 TOYOTA AVALON. THE CONTACT STATED THAT THE REAR BRAKE LIGHTS WERE PERMANENTLY ILLUMINATED. THE VEHICLE WAS TAKEN TO KENDALL TOYOTA (10943 S DIXIE HWY, MIAMI, FL 33156) WHERE IT WAS DIAGNOSED THAT THE REAR BRAKE LIGHT SENSOR WAS DAMAGED AND NEEDED REPLACEMENT. THE BATTERY WAS ALSO REPLACED. AFTER THE VEHICLE WAS REPAIRED, THE BRAKE PEDAL TRAVELED ALL THE WAY DOWN TO THE FLOORBOARD AND THE VEHICLE DID NOT ACCELERATE. FOR THE PAST YEAR AND A HALF, A STRONG ODOR OF FUEL WAS PRESENT INSIDE THE CABIN. THE VEHICLE WAS TAKEN TO SEVERAL INDEPENDENT MECHANICS, BUT THE CAUSE OF THE ODOR COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND A COMPLAINT WAS FILED. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.

NHTSA ID

11182815

Incident

Dec 20, 2018

Mileage

25,000 mi

THE AUTO SURGES FORWARD AS I'M TRYING TO STOP EITHER AT A STOP LIGHT OR PARKING SPOT. THIS HAS HAPPENED 3 OR 4 TIMES AND MY MECHANIC SAID THE ONLY WAY TO FIX IT WOULD BE FOR IT TO HAPPEN WHILE HE WAS DRIVING IT. THERE'S NO PATTERN TO WHEN IT HAPPENS BUT IT'S SCARY AND I'M AFRAID TO LET MY WIFE DRIVE IT. IT HAPPENED YESTERDAY AS I WAS COMING TO A COMPLETE STOP BEFORE ENTERING A 2 LANE HIGHWAY. THE OTHER TIMES IT HAPPENED WAS PULLING INTO A PARKING SPOT AND APPLYING THE BRAKES TO STOP. I NOW PUT THE CAR IN NEUTRAL WHEN IT HAPPENS AND THE ENGINE IS RACING AWAY. PUTTING MY FOOT ON THE BRAKE ISN'T ENOUGH TO COME TO A COMPETE STOP. I'VE READ OTHER COMPLAINTS ABOUT THIS HAPPENING WITH NO HONEST ANSWER FOR CORRECTING IT. MOSTLY TRAIL AND ERROR. TOYOTA HAS TO KNOW THE ANSWER BUT THERE'S NO SERVICE BULLETINS FROM THEM. I'M AFRAID THAT IT'S GOING TO CAUSE A SERIOUS ACCIDENT OR BODILY INJURY TO ME OR MY WIFE. NHTSB HAS GOT TO LOOK INTO THIS ASAP. P.S. MY CAR HAS 71000 MILES ON IT.

NHTSA ID

11174487

Incident

Feb 4, 2019

Mileage

71,000 mi

TL* THE CONTACT OWNS A 2003 TOYOTA AVALON. WHILE DRIVING ON SEVERAL OCCASIONS, THE SRS WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO BEECHMONT TOYOTA (8667 BEECHMONT AVE, CINCINNATI, OH 45255, (513) 388-3800) TO BE DIAGNOSED, BUT THE MECHANIC WAS UNABLE TO RETRIEVE A FAULT CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 230,807.

NHTSA ID

11164181

Incident

Dec 28, 2018

Mileage

230,807 mi

TL* THE CONTACT OWNS A 2003 TOYOTA AVALON. WHILE DRIVING AT AN UNKNOWN SPEED, THE FRONT DRIVER'S SIDE AIR BAG DEPLOYED WITHOUT WARNING OR IMPACT. THE CONTACT SUSTAINED INJURIES TO THE FACE, BUT MEDICAL ATTENTION WAS NOT REQUIRED. THE CONTACT WAS ABLE TO COAST THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO RICE TOYOTA (2630 BATTLEGROUND AVE, NC GREENSBORO, NC 27408, (336) 387-6004), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OPENED CASE NUMBER: 1808082730. THE APPROXIMATE FAILURE MILEAGE WAS 244,000.

NHTSA ID

11118623

Incident

Aug 8, 2018

Mileage

244,000 mi

I DROVE INTO A PARKING SPOT, PUT MY CAR INTO PARK & RELEASED MY FOOT FROM THE BRAKE. THE CAR ROLLED BACK AS IF IT WAS IN REVERSE. I APPLIED THE BRAKES, SHIFTED THE GEAR INTO DRIVE & DROVE BACK UP INTO THE SPACE. I PUT THE CAR BACK INTO PARK, RELEASED THE BRAKES, ONLY TO HAVE THE CAR ROLL BACK AGAIN. I PULLED BACK UP INTO THE PARKING SPOT, SHIFTED BACK INTO PARK & THIS TIME PUT ON PARKING BRAKES. I GOT OUT OF THE CAR & WENT INTO THE STORE. WHEN I CAME BACK, MY CAR WOULD NOT START. NOT ONLY WOULD IT NOT START, IT WOULD NOT MAKE ANY SORT OF NOISE (WHICH IS HOW I KNEW IT WASN'T THE BATTERY). I CALLED FOR A TOW & THE TOW TRUCK OPERATOR WAS ABLE TO GET IT TO START IN GEAR NEUTRAL.

NHTSA ID

11090483

Incident

Apr 13, 2018

Mileage

170,000 mi

TL* THE CONTACT OWNS A 2003 TOYOTA AVALON. THE CONTACT STATED THAT THE AIR BAG INDICATOR ILLUMINATED. THE CONTACT CALLED A LOCAL DEALER (PUEBLO TOYOTA, 2220 U S 50 W, PUEBLO, CO 81008) WHERE IT WAS DIAGNOSED THAT THE DRIVER'S SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 174,457.

NHTSA ID

11074553

Incident

Feb 23, 2018

Mileage

174,457 mi

CAR WAS IDLING IN PARK, PLACED SHIFT INTO REVERSE, CAR ACCELERATED FORWARD WITH MOTOR RACING INTO A BENCH, DESTROYING IT. JAMMED SHIFT BACK INTO PARK SHUT OFF MOTOR. RESTARTED CAR. PLACE SHIFT IN REV AND BACKED OFF BENCH. CAR WORKED PROPERLY. HAD CAR TOWED TO REPAIR SHOP.

NHTSA ID

11058295

Incident

Dec 16, 2017

Mileage

160,000 mi

AIR BAG INDICATOR AND SEAT BELT NOT ON INDICATORS KEEP COMING ON INTERMITTENTLY. DEALER CAN'T DO ANYTHING ABOUT IT UNLESS THESE INDICATOR COMES ON WHEN THEY DO THE TEST DRIVE. SO IT'S NOT ALWAYS REPRODUCIBLE BY THE DEALERSHIP.

NHTSA ID

11022375

Incident

Sep 7, 2017

Mileage

150,000 mi

TL* THE CONTACT OWNED A 2003 TOYOTA AVALON. WHILE STATIONARY, THE VEHICLE ACCELERATED BACKWARDS RAPIDLY WITHOUT WARNING. THE CONTACT ENGAGED THE DRIVE GEAR IN AN EFFORT TO STOP THE VEHICLE, BUT THE VEHICLE ACCELERATED FORWARD ON ITS OWN A SECOND TIME. THE CONTACT STATED THAT THE ACCELERATOR PEDAL BECAME STUCK AND THE VEHICLE CRASHED INTO THREE OTHER VEHICLES. M&M TIRE COMPANY OF GREENSBORO, NORTH CAROLINA WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS TOTALED. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND PROVIDED CASE NUMBER: 0458794831. THE FAILURE MILEAGE WAS 103,000.

NHTSA ID

11003097

Incident

Jul 2, 2017

Mileage

103,000 mi

I HAVE BEEN WAITING OVER A YEAR FOR THIS TO BE REMEDIED. THIS IS UNACCEPTABLE

NHTSA ID

10990458

Incident

May 1, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2003 TOYOTA AVALON. WHILE DRIVING APPROXIMATELY 20 MPH, THE AIR BAG WARNING INDICATOR ILLUMINATED AND THE FRONT DRIVER AND PASSENGER SIDE AIR BAGS DEPLOYED AND CAUSED THE VEHICLE TO RUN OVER A CURB. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW YARD. THE VEHICLE WAS LATER TOWED TO THE DEALER, BUT WAS NEITHER DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THEIR LEGAL DEPARTMENT WROTE TO THE CONTACT, STATING THAT THE FAILURE WAS NOT RECALL RELATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V043000 (AIR BAGS). THE FAILURE MILEAGE WAS 136,000. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

10984855

Incident

Jan 17, 2017

Mileage

136,000 mi

TL* THE CONTACT OWNS A 2003 TOYOTA AVALON. WHILE DRIVING APPROXIMATELY 25 MPH, THE AIR BAG DEPLOYED WITHOUT WARNING AND OBSCURED THE DRIVER'S VISION. THE VEHICLE CRASHED INTO A CONCRETE DIVIDER. A POLICE REPORT WAS FILED. THE DRIVER WAS NOT INJURED. THE VEHICLE WAS EXTENSIVELY DAMAGED AND WAS TOWED TO A TOW YARD. THE FAILURE MILEAGE WAS APPROXIMATELY 116,000. *TR

NHTSA ID

10948467

Incident

Jan 2, 2017

Mileage

116,000 mi

TL* THE CONTACT OWNS A 2003 TOYOTA AVALON. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V043000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

10917828

Incident

Apr 22, 2016

THE RECALL REMEDY FOR NHTSA CAMPAIGN 15V043000 IS A FAILURE. AN IDENTICAL SYMPTOM TO THE ORIGINAL PROBLEM HAS RECURRED ON TWO OCCASIONS (INTERMITTENT ILLUMINATION OF THE SRS SYSTEM WARNING LIGHT). PRIOR TO THE RECALL, WE ATTEMPTED TO HAVE THE ERROR CODE DIAGNOSED BY THE DEALERSHIP FOLLOWING ILLUMINATION OF THIS WARNING LAMP. HOWEVER, NO ERROR CODES WERE STORED. NOW, THE DEALERSHIP (LOU FUSZ, ST. LOUIS) CLAIMS THAT THEY MUST CHARGE US TO ATTEMPT TO READ ANY STORED CODES. OBVIOUSLY, TOYOTA ENGINEERS DO NOT KNOW WHAT THE PROBLEM IS AFTER HAVING A FIRST RECALL THAT FAILED FOLLOWED BY A SECOND RECALL AND NOW RECURRENCE OF IDENTICAL SYMPTOMS.

NHTSA ID

10908447

Incident

Sep 21, 2016

Mileage

185,000 mi

TOYOTA INFORMED ME OF SAFETY RECALL 15V-043. IT REQUIRES REPLACING TWO CIRCUIT BOARDS. THE CONDITION IS THAT THE CAR CAN DEPLOY THE AIRBAGS AT ANY TIME WITHOUT WARNING AND WITHOUT ANY IMPACT. TODAY, AFTER WAITING 90 DAYS THE PARTS STILL HAVE NOT ARRIVED. TOYOTA DEALER (JOSEPH AIRPORT TOYOTA) IS UNABLE TO TELL ME WHEN THEY WILL ARRIVE. TOYOTA CORPORATION IS UNABLE TO TELL ME WHERE I AM ON THE WAITING LIST. MY LOCAL DEALER TRIES TO HELP BUT THEY CAN'T DO ANYTHING. THIS IS MY WIFE'S CAR AND SHE NOW REFUSES TO DRIVE IT. SHE IS AFRAID IN IT. WE NEED TO GET THIS FIXED QUICK. IS THERE ANYTHING THAT CAN BE DONE? A COMPANY LIKE TOYOTA SHOULD SURELY HAVE SOME INFORMATION THEY COULD PROVIDE REGARDING THIS PART. IT DOES NOT TAKE THREE MONTHS TO MAKE THESE PARTS!

NHTSA ID

10885552

Incident

Apr 18, 2016

Mileage

129,000 mi

TL* THE CONTACT OWNS A 2003 TOYOTA AVALON. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V043000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

10873022

Incident

Jun 5, 2015

THE SRS SIDE AIRBAG SYSTEM LIGHT FLASHES WHILE DRIVING, STATES THAT THEY FIXED IT BUT STILL AIRBAG SYSTEM LIGHT FLASHES WHILE DRIVE, IT WAS A RECALL.

NHTSA ID

10871308

Incident

Jun 1, 2015

TL* THE CONTACT OWNS A 2003 TOYOTA AVALON. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V043000 (AIR BAGS). THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

10871264

Incident

Jan 27, 2015