1996 Toyota Camry Engine Problems

THE STEERING SUCKS IVE TRIED EVERYTHING BUT NOTHING IT STILL DRIVES MY SUCKS

NHTSA ID

11385727

Incident

Oct 17, 2018

1996 TOYOTA CAMRY DEVELOPED PROBLEMS STALLING OUT IN TRAFFIC AND WOULD BUCK LIKE A BRONCO SOMETIMES WHEN DRIVING (BEFORE STALLING). DEALERSHIP REPAIRS COST ME THOUSANDS OF DOLLARS. VERY DANGEROUS TRYING TO GET FROM HERE TO THERE IN THIS VEHICLE. TECHNICIANS KEPT TAKING THE CAR BACK DOWN TO THE ENGINE BLOCK. SENT A LETTER TO TOYOTA REQUESTING THEY EXAMINE THE INVOICES AND REPAIRS ON A CAR WITH SUCH LOW MILEAGE. THE SENT A LETTER BACK. ONE LINE-"NOTHING IN THESE INVOICES IS UNDER WARRANTY" TOYOTA WAS NOT INTERESTED IN FIXING THEIR MISTAKES AND WAS NOT INTERESTED IN LEARNING FROM THEM. THEY WERE NOT INTERESTED IN THE SAFETY OF THEIR CUSTOMERS. I KNEW AT THAT TIME THEY WERE INTERESTED IN GROWTH AND PROFIT AND LET IT BE KNOWN TO MY FRIENDS AND FAMILY THAT THEY SHOULD NOT BUY TOYOTA VEHICLES. *TR

NHTSA ID

10313607

Incident

Mar 10, 1999

Mileage

18,000 mi

DAUGHTER WAS DRIVING HER 1996 CAMRY VEHICLE CUT OFF WHILE DRIVING SHE COASTED TO THE SIDE OF THE ROAD VEHICLE HAD TO BE TOWED. LATER LEARNED FROM TWO DIFFERENT MECHANICS THAT ENGINE HAD SEIZED UP FOR NO APPARENT REASON. *TR

NHTSA ID

10226996

Incident

Apr 30, 2008

Mileage

117,000 mi

TL*THE CONTACT OWNS A 1996 TOYOTA CAMRY. THE CONTACT STATED THAT NOTHING WAS WRONG WITH HER VEHICLE WHEN SHE TOOK IT TO HAVE AN OIL CHANGE. THE MECHANIC PERFORMING THE OIL CHANGE STATED THAT THE VALVE COVER GASKET NEEDED TO BE REPLACED. THE CONTACT WAS ALSO INFORMED THAT THERE WAS MOTOR FAILURE, HOWEVER SHE STATES OTHERWISE. THE MOTOR WAS REPLACED AND NOW THE VEHICLE SHAKES WHEN STARTED, SOUNDS LIKE A TRACTOR, AND SHE SMELLS DIESEL FUMES IN THE PASSENGER COMPARTMENT. THE PURCHASE DATE AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 14,000.

NHTSA ID

10192366

Incident

Jan 24, 2007

Mileage

14,000 mi

TL* - THE CONTACT CALLED REGARDING THE 1996 TOYOTA CAMRY. THE CONTACT STATED THAT DURING A ROUTINE OIL CHANGE THE MECHANIC DISCOVERED A STICKY SUBSTANCE AROUND THE VALVE COVER GASKET. THE MECHANIC DIAGNOSED THE VEHICLE AS NEEDING A NEW ENGINE. THE CONTACT BELIEVED THISWAS A SAFETY DEFECT. THE FAILURE MILEAGE WAS 140,578. *AK THE POWER STEERING PUMP WAS RE-SEALED, THE TIMING BELT AND AXLE SEALS WERE REPLACED. UPDATED 04/12/07. *JB

NHTSA ID

10183614

Incident

Feb 2, 2007

Mileage

140,578 mi

8/2003 BOUGHT CAR. AT 75.000 MILES, FREEZE PLUGS STARTED TO GO. ONE AFTER THE OTHER. LEAVING ME STRANDED MANY TIMES. AFTER WE REPLACED THE FREEZE PLUGS, 76.000 MILES THE CAR STARTED DUMPING ITS COOLANT THROUGH THE OVERFLOW TANK.. COULD NOT GET ANSWERS FROM PHILLIPS TOYOTA. STARTED LOOSING OIL. THE OBD LIGHT HAS NEVER COME ON. THE CAR RUNS QUITE AND SMOOTH. MADE SEVERAL ATTEMPTS TO TAKE CARE OF THIS PROBLEM WITH THE CORPORATION, BUT THEY WILL NOT HELP. ALSO, THE BRAKES HAVE ALWAYS MADE LOUD NOISES, AND THE CRUISE CONTROL HAS A MIND OF ITS OWN. CAR HAS NOW, 130000 MILES ON IT, AND ALL I CAN DO, IS ADD WATER EVERY 25 MILES OR SO. NONE OF THE SHOPS WE HAVE TAKEN IT TO CAN TELL US WHAT THE PROBLEM IS. CAN YOU HELP ME PLEASE. *JB

NHTSA ID

10172605

Incident

Mar 25, 2004

Mileage

75,000 mi

DT: SINCE SEPTEMBER 2004 CONSUME HAS BEEN INHALING SULFUR FUMES ON THE INSIDE AND OUTSIDE OF THE VEHICLE. SMELL WAS SO GREAT THAT IT MAD. DAUGHTER PHYSICALLY ILL. TWO CONVERTERS HAVE BEEN REPLACED WITH NO SUCCESS. DEALER SAID TO CHANGE GAS BRANDS, TSB INDICATED LARGE AMOUNTS OF SULFUR IN GAS. VEHICLE WAS IN A FLOOD, DEALER STATED OTHER VEHICLES THAT WERE NOT IN FLOOD WERE EXPERIENCING THE SAME PROBLEM. *AK

NHTSA ID

10120266

Incident

Sep 15, 2004

Mileage

95,000 mi

1.) THE BLACK PAINT ON THE WINDSHIELD WIPERS HAS WORN OFF, EXPOSING A BRIGHT METALLIC SURFACE WHICH REFLECTS SUNLIGHT DIRECTLY INTO THE DRIVER'S EYES.; 2.) HAVING ONLY 37,000 MILES ON THE VEHICLE, THE EXHUAST SYSTEM IS IN NEED OF REPLACEMENT!!!*AK

NHTSA ID

10114383

Incident

Sep 20, 2004

THE OIL PASSAGE WAS TOO NARROW, NOT LETTING OIL INTO THE CRANK SHAFT. THIS CAUSED A ROD TO BLOW THROUGH THE BLOCK, WHICH CAUSED THE ENGINE TO FAIL AND NO LONGER TO OPERATE. MANUFACTURER WAS CONTACTED BY OWNER.*AK ENGINE WAS REPLACED WITH A USED MOTOR, TIMING BELT, WATER PUMP AND CAP ROTOR WIRES. MANUFACTURER WAS NOTIFIED BUT DID NOT DO ANYTHING. *TT

NHTSA ID

10109120

Incident

Jan 16, 2005

Mileage

67,000 mi

CAR CONTINUTES TO STALL WHEN AT A STOP AND SLOWLY IDLING REPETITIVELY. CREATES DANGEROUS SITUATION FOR EXAMPLE WHEN LIGHT TURNS GREEN AND CAR WON'T GO! TOLD IDLE AIR VALVE WHICH I SEE IN DOING RESEARCH SEEMS TO BE A VERY COMMON PROBLEM. EXPENSIVE REPAIR. PERHAPS A RECALL WOULD BE IN ORDER?*AK

NHTSA ID

10112026

Incident

Feb 21, 2005

Mileage

77,700 mi

THE CONSUMER WAS CONCERNED THAT THE VEHICLE MAY CATCH ON FIRE BECAUSE THE VEHICLE WAS LEAKING OIL. *NM THE REAR MAIN SEAL LEAKED. SMOKE WAS ALSO PRESENT. *SC *JB

NHTSA ID

10057606

Incident

Jul 5, 2002

4 CYLINDER ENGINE HAS STARTING PROBLEMS WHEN COLD. IT TAKES ABOUT THREE OR FOUR ATTEMPTS TO START (STALLS A LOT.) TOOK VEHICLE TO INDEPENDENT SHOP AND WAS TOLD IT "PROBABLY" NEEDED A TIMING BELT. $1200 LATER AND THE CAR WAS GOOD FOR ABOUT THREE MONTHS. THE STALLING PROBLEM IS BACK. TOYOTA SAID IT CANNOT DIAGNOSE IF THEY CANNOT DUPLICATE PROBLEM. NO CODES SET AND IT WILL NOT HAPPEN ALL THE TIME. IT IS BECOMING FUSTRATING THOUGH.*AK

NHTSA ID

10086331

Incident

Mar 16, 2004

Mileage

114,750 mi

AIR FUEL SENSOR FAILED. AS A RESULT THE WARNING LIGHT CAME ON. PART IS NOT ABLE TO BE MAINTAINED BY ANYONE INCLUDING A MECHANIC, AND THERE WAS NO WAY OF CHECKING UNLESS THE PART FAILED. *AK

NHTSA ID

10076077

Incident

Mar 12, 2004

Mileage

52,000 mi

FAILURE TO PASS SMOG TEST. MY 1996 CAMRY HAS BEEN SERVICED REGULARLY, MOSTLY BY DEALER. HAD ITS 60,000 MILE SERVICE IN AUGUST LAST YEAR BY TOYOTA (AND 45,000 SERVICE IN 02). FAILED THE SMOG TEST AT 70,271 MILES. TOYOTA DEALER THEN DID INVESTIGATION (SAID FAILING HC READING SLIGHTLY OVER LIMIT). CHECK 02-SS SIGNAL ON BOTH SENSOR AND PCV VALVE. THEY ALSO SAID THEY "REMOVED AND CLEAN MASS AIR FLOW AND PCV SYSTEM". JUST DOESN'T SEEM RIGHT THAT THE CAR DIDN'T PASS THE SMOG CHECK, WHEN TOYOTA HAS BEEN MAINTAINING CAR, AND WHEN THE CAR REALLY ISN'T THAT OLD (WITH NO MODIFICATIONS). *NM

NHTSA ID

10062385

Incident

Mar 12, 2004

Mileage

70,250 mi

AFTER PURCHASING THE CAR IN MARCH 2002, ALL OIL CHANGES WERE PERFORMED BY ME. THE PREVIOUS OWNER IS A FRIEND, AND I KNOW THE CAR WAS MAINTAINED VERY WELL (APPEARANCE OF THE CAR ALSO REFLECTS THIS). IN EARLY MAY 2003, WITH MY WIFE DRIVING, THE CAR THREW #1 PISTON ROD THROUGH THE BLOCK. THE ENGINE STILL HAD AMPLE OIL, AND ONLY HAD 1500 MILES AFTER AN OIL CHANGE (I CHANGE THE OIL BETWEEN 3-4000 MILES, RELIGOUSLY). THIS IS NOT THE TYPE OF ENGINE FAILURE TO EXPECT FROM A WELL MAINTAINED CAR, AND AFTER PULLING THE MOTOR OUT, I NOTICED SLUDGE ALL OVER THE OIL PAN, VALVE COVERS, AND ON VARIOUS ENGINE COMPONENTS.

NHTSA ID

10070937

Incident

May 15, 2003

Mileage

140,000 mi

ORIGINAL ENGINE VALVE SEALS FAILED PREMATURELY AT 38K MILES ARE WERE REPAIRED BY DEALER UNDER WARRANTY. AFTER ANOTHER 40K MILES THE SEALS FAILED AGAIN. DEALER ESTIMATE FOR SECOND PREMATUER VALVE SEAL REPAIR IS $1,000.

NHTSA ID

10070812

Incident

Apr 15, 1999

Mileage

38,391 mi

COMPLAIN I OWN A 1996 TOYOTA CAMRY THAT RECENTLY EXPERIENCED AN ENGINE DAMAGE DUE TO THE BUILD-UP OF OIL SLUDGE BEFORE 80,000 MILES. MY CAR HAS THE SAME 2.2L 4 CYLINDER ENGINE AS THEIR CAMRY 1997-2001 MODELS, WHICH TOYOTA AGREED TO COVER THE COST OF REPAIRING THOSE ENGINES. HOWEVER, DESPITE THE FACT THAT MY CAR HAS THE SAME ENGINE AND IT WAS PRODUCED TWO MONTHS PRIOR TO THAT TIME FRAME, BECAUSE IT IS IN A 1996 MODEL, TOYOTA HAS REFUSED TO COVER THE COST OF REPAIRING IT. THERE IS NO DISPUTING THAT THE FAILURE OF THOUSANDS OF THESE ENGINES AS A RESULT OF A BUILD-UP OF OIL SLUDGE CAN BE ATTRIBUTABLE ONLY TO THE FACT THAT THESE ENGINES ARE DEFECTIVE. AS SUCH, IT IS ABSOLUTELY OUTRAGEOUS THAT TOYOTA SHOULD TAKE RESPONSIBILITY FOR THE REPAIR OF SOME OF THESE DEFECTIVE ENGINES AND NOT OTHERS. THANK YOU FOR YOUR CONSIDERATION.

NHTSA ID

10070411

Incident

Jun 15, 2003

Mileage

79,988 mi

TOOK CAMRY TO DEALER (WORLD TOYOTA) DISCOVERED ENGINE SLUDGE PROBLEM, ENTIRE ENGINE NEEDS TO BE REPLACED, CANNOT RE-BUILD.. NOTIFIED CUSTOMER SERVICE TWICE AT TOYOTA MAIN OFFICE. STILL HAVE NOT RESOLVED ISSUE.

NHTSA ID

10070240

Incident

Apr 15, 2003

Mileage

158,000 mi

IDLE PROBLEM. TAKEN TO MECHANIC TWICE. HAVE REPLACED ISC VALVE AT LEAST ONCE A YEAR SINCE 1996 (TWICE IN 1997 AND 1998), IN THE LAST YEAR CAR HAS STALLED WHEN SLOWING DOWN TO COMPLETE ENGINE SHUTDOWN IN MIDDLE OF ROADWAY. ENGINE TAKES A FEW TRIES TO START AGAIN.

NHTSA ID

10070209

Incident

Apr 15, 2003

Mileage

64,600 mi

I HAVE ENGINE GELLING THAT HAS LED TO ENGINE DAMAGE SEVERE ENOUGH THAT I WILL EITHER NEED A NEW SHORT BLOCK OR NEW ENGINE (ACCORDING TO TOYOTA). EVEN WITH ALL OF THE WORK THAT I HAVE ALREADY HAD ON THE VEHICLE, THE ENGINE IS NOT IN PROPER RUNNING ORDER AND WILL TAKE THOUSANDS OF DOLLARS TO REMEDY THE ISSUE.

NHTSA ID

10070178

Incident

Feb 15, 2000

Mileage

39,486 mi

MY 1996 CAMRY WAS RECENTLY DIAGNOSED WITH A MAJOR SLUDGE PROBLEM REQUIRING A NEW ENGINE AFTER ONLY 80,000 MILES. THE CAR HAS THE SAME 2.2L 4 CYLINDER ENGINE THAT HAS BEEN SHOWN TO BE SUSCEPTIBLE TO THIS SLUDGE PROBLEM, BUT TOYOTA HAS REFUSED TO COVER THE COST OF REPAIRING MY ENGINE UNDER THE "SPECIAL POLICY" REPAIR PROGRAM THAT THEY IMPLEMENTED TO ADDRESS THE PROBLEM WITH THIS ENGINE. TOYOTA DID NOT DISPUTE THAT IT WAS THE SAME ENGINE THAT HAS EXPERIENCED THIS PROBLEM - INSTEAD, THE RIDICULOUS AND TOTALLY ILLOGICAL REASON THEY GAVE WAS THAT THEIR "SPECIAL POLICY" REPAIR PROGRAM WAS LIMITED TO THE ENGINES MANUFACTURED DURING AN ARBITRARY TIME PERIOD AND THE ENGINE IN MY CAMRY FELL OUTSIDE THAT PERIOD BY TWO MONTHS. IN OTHER WORDS, THEY ARE FIXING SOME OF THESE DEFECTIVE ENGINES BUT NOT OTHERS.

NHTSA ID

10070121

Incident

Mar 15, 2003

Mileage

80,000 mi

TOOK MY CAR IN TO HAVE THE TIMING BELT REPLACED AND TO FIND OUT WHAT THE CAUSE OF THESE PROBLEMS WERE; CAR WORKED FINE OTHERWISE: RATTLE LING NOISES COMING FROM VALVE COVER, ENGINE CONSUMING COOLANT, FRONT ENGINE SEALS LEAKING. TOTAL COST FOR THESE REPAIRS WAS $1992.42 GOT MY CAR BACK FROM THE DEALER, FOUR DAYS LATER THE CAR DIES ON THE ROAD. CAR WAS TOWED BACK TO DEALER AT THEIR EXPENSE. DEALER FOUND THAT THE TIMING BELT HAD SKIPPED. THEY REPLACED THE TIMING BELT, DECLARED CAR FIXED AND GAVE ME THE KEYS. I DROVE OFF AND GOT AS FAR AS TWO BLOCKS AWAY FROM DEALER BEFORE THE CAR DIED AGAIN. THIS TIME THE DEALER SAID THAT THE PROBLEM WAS DUE TO ENGINE GEL. THE DEALER SAID THE REPAIRS WOULD BE COVERED BY TOYOTA BUT ONLY IF I COULD SHOW PROOF OF OIL CHANGES RECEIPTS, WHICH I PROVIDED. I'M NOW TRYING TO RECOVER A REFUND FOR THE REPAIRS THAT I PREVIOUSLY PAID FOR THAT WERE DUE TO THE ENGINE GEL PROBLEMS.

NHTSA ID

10070056

Incident

Feb 15, 2003

Mileage

59,000 mi

ENGINE WAS RUNNING FINE BUT WAS TAKING IT IN FOR 60K MILE SERVICE. TOYOTA DEALERSHIP INFORMED ME OF A BAD OIL SLUDGE PROBLEM AND ESTIMATED THE REPAIRS TO BE $4500. I TOOK IT TO ANOTHER MECHANIC AND HE SAID THAT THERE WAS A CHANCE THE ENGINE HAS NOT BEEN DAMAGED, BUT ONLY A CHANCE. I LET HIM PERFORM THE WORK OF CLEANING THE OIL PAN AND RUNNING A COUPLE OF OIL CHANGES TO CLEAN THE SLUDGE. THE ENGINE SEEMED TO BE RUNNING FINE, BUT NOW (JANUARY 2003) I AM GETTING A LOT OF SMOKE FROM THE EXHAUST AND THEY TELL ME THAT SOMETHING MUST HAVE BEEN DAMAGED BUT THEY CAN'T TELL WITHOUT TAKING THE ENGINE APART.

NHTSA ID

10069941

Incident

Dec 15, 2002

MY CAR HAS 135,000 MILES ON IT AND I WAS RECENTLY NOTICING THAT IT WOULD RUN HARD AND NOT SWITCH GEARS AS SMOOTHLY AS IT ONCE HAD. I TOOK IT IN TO A TOYOTA DEALERSHIP TO BE EVALUATED AND WAS TOLD IT HAD SLUDGE IN MY ENGINE PROBABLY DUE TO INFREQUENT OIL CHANGES I WAS THEN INFORMED BY THE SERVICE ADVISOR THAT IT NEEDED A NEW ENGINE AND THAT IT WOULD COST APPROXIMATELY $5000-$6000. I INFORMED THE ADVISOR THAT I ALWAYS HAD MY OIL CHANGED AS PER THE OWNER?S MANUAL, AND I REQUESTED A WRITTEN ESTIMATE AS TO THE EXACT DETAILS THAT FORMED THE BASIS FOR THIS PRICE QUOTE. I WAS ULTIMATELY DENIED THAT INFORMATION. THE GENTLEMAN TOLD ME HE WOULD CALL ME BACK AND/OR FAX IT TO ME, AFTER WHICH I RECEIVED NOTHING. I CALLED AGAIN, GOT HIS SUPERVISOR INSTEAD OF THE SERVICE ADVISOR, AND HE EXPLAINED THAT ENGINE SLUDGE WAS THE DIAGNOSIS AND THAT I COULD NOT GET A WRITTEN ESTIMATE BECAUSE THE EXACT PARTS NEEDED COULD NOT BE DETERMINED. HE STATED HE WOULD HAVE TO HAVE SOMEONE LOOK FURTHER INTO THE ENGINE'S PROBLEM TO GIVE ME THE ESTIMATE IN WRITING. I ASKED WHY THIS HADN'T BEEN DONE PRIOR TO THE COMPLETION OF THE DIAGNOSIS THAT I ORDERED, AND HE THEN BEGAN STAMMERING AND INFORMED ME THAT HE DIDN'T HAVE MY FILE IN FRONT OF HIM AND HE COULD CALL ME BACK AFTER LOOKING INTO IT FURTHER. HE THEN PROCEEDED TO ASK ME IF I WAS REALLY WILLING TO PAY THAT MUCH FOR AN ENGINE?. WHEN I ASKED WHAT MY OTHER ALTERNATIVES WERE, HE OFFERED TO TRANSFER ME TO A SALESMAN! I NEVER RECEIVED ANY FURTHER PHONE CALLS. IT HAS BEEN MY EXPERIENCE THAT IF I AM NOT WILLING TO BUY A NEW VEHICLE, THE LEVEL OF SERVICE I RECEIVE DECREASES DRAMATICALLY. I HAVE SINCE TAKEN MY CAR TO ANOTHER INDEPENDENT SHOP TO HAVE IT REPAIRED, WHERE I HAVE BEEN ABLE TO GET AN EXPLANATION BOTH IN WRITING AND BY THE ADVISOR IN CONVERSATION AS TO WHAT EXACTLY IS WRONG AND WHAT EXACTLY NEEDS TO BE FIXED.

NHTSA ID

10069726

Incident

Apr 15, 2002

Mileage

110,000 mi

IN APPROX JUNE OF 2002 MY TIMING BELT HAD TO BE REPLACED I NOW APPEAR TO HAVE THE OIL GELLING PROBLEM. APPROX MAY 2003 I GOT OUT OF THE CAR TO PUMP GAS AND THE DOOR WILL NOT OPEN ON THE DRIVER SIDE. APPROX AUGUST 2003 I BEGAN NOTICING IF DRIVING ON THE HIGHWAY AND I APPLY MY BRAKES MY WHOLE CAR BEGINS SHAKING.

NHTSA ID

10069487

Incident

Jun 15, 2002