Electrical
Filed Aug 6, 2026
DESIGN FLAW & SAFETY RISK: Toyota critically mismatched the standard battery to the vehicle's electrical charging profile; an AGM battery should be specified from the factory. Engine programming drops alternator voltage during cruising, deeply discharging the battery, and forces high-voltage surges (15V+) into it during deceleration. Because standard batteries cannot handle these rapid recharge loads during deceleration, the internal thermal load routinely overheats and boils the liquid electrolyte, even when brand new. This continuous boiling vents volatile hydrogen gas and discharges corrosive battery acid inside the engine bay. This structural flaw culminated in an immediate safety hazard when the battery physically exploded under the hood, creating a severe risk of engine compartment fire, chemical acid burns, and complete vehicle electrical blackout in active traffic. COLLATERAL DAMAGE & HISTORY: The chronic discharge and boiling of highly corrosive battery electrolyte severely damaged and corroded surrounding critical vehicle components. The acid completely corroded the transmission mount, the metal battery holder restraint, and the body paint. Furthermore, the corrosive boil-over burned off and destroyed several electrical connectors, plastic shrouds, plumbing hoses, and sections of the primary engine wiring cable harness. Since owning this 2020 Toyota Corolla, the vehicle has suffered systematic electrical degradation, requiring a full battery replacement at least once every single year. The exploded battery could not be safely retained due to its hazardous, ruptured state. WARNINGS & INSPECTIONS: No dashboard warning lamps, battery alerts, or diagnostic codes were triggered on the display prior to the physical battery failure. The rupture and electrical blackout occurred instantaneously. The vehicle has not been inspected by police or insurance representatives as no crash resulted directly from the blast.
- NHTSA ID
- 11755366
- Incident
- Aug 6, 2026
Powertrain (other)
Filed Aug 6, 2026
FAILED COMPONENT & AVAILABILITY: The manual transmission Concentric Slave Cylinder (CSC) failed internally. Due to caustic hydraulic fluid contamination and severe system pressure loss, I had to replace the internal CSC unit, the clutch disc, the pressure plate, the flywheel, the master clutch cylinder, and the hydraulic clutch lines. The failed components have been retained and are available for inspection upon request. SAFETY RISK: The plastic housing of the OEM slave cylinder cracked internally, spraying caustic hydraulic brake fluid inside the transmission bell housing and completely coating the flywheel, pressure plate, and clutch friction disc. This caused an immediate, sudden loss of hydraulic pressure, forcing the clutch pedal to drop and stick flat to the floorboard. This put my safety and the safety of others at extreme risk, as it suddenly prevented me from disengaging the clutch, shifting gears, or safely dropping the vehicle into neutral while driving in active traffic.CONFIRMATION & REPAIR: A certified Toyota dealership diagnosed the issue and issued an unaffordable repair estimate of $4,800 to fix this recurring manufacturer defect. Because of this extreme cost, I was forced to drop the transmission and perform the entire rebuild myself. The total out-of-pocket cost just for replacement parts was $3,200. The vehicle has not been inspected by police or insurance representatives as no crash resulted. WARNINGS & MILEAGE SYMPTOMS: There were no prior dashboard warning lamps, error messages, or clear physical indicators before either failure occurred. The loss of clutch pedal pressure happened instantaneously. This vehicle has suffered this catastrophic internal failure twice: the original factory-installed unit (part number 31400-19025) failed prematurely at 59,000 miles. The updated replacement part (superseded part number 31400-19027), which suffers from the exact same defective plastic composition, failed again just 40,000 miles later.
- NHTSA ID
- 11755364
- Incident
- Aug 6, 2026
Part is the coolant bypass valve. Toyota has been taken to court but dealership claims now that I’m over 100k miles I can’t do it. There was also a second part about 10 years but I wasn’t clear on the details of the outcome. Toyota has acknowledged this issue in court but failed to do so at the customer level in my case. engine light came on at 97k and now I’m at 104k which is over that 100k mark. Issue is I’ve only take my car to Toyota for repairs. They have known about this but failed to repair or notify me of it. I would have immediately brought my car in at 97k if. I had known. This puts not only me but my 3 kids and entire family at risk every time i drive. This is known to the dealership and they been taken to court for failures to notify customers of this known defect. It’s been inspected by Toyota the last time I took it in about a week ago at 104k miles.
- NHTSA ID
- 11755244
- Incident
- Jul 31, 2026
Powertrain (other)
Filed Jul 31, 2026
Design issue: The 12th-generation (E210) Corolla manual transmission utilizes a CSC unit containing plastic/ABS components that owners and forum communities frequently cite as a weak point prone to premature leakage and mechanical failure. This occured to my corolla on a roadway and presented a severe safety hazard.
- NHTSA ID
- 11754045
- Incident
- Jul 30, 2026
Transmission
Filed Jun 29, 2026
The contact owns a 2020 Toyota Corolla. The contact stated that while driving at an undisclosed speed, the clutch failed to operate as intended. The contact stated that the clutch seized, and the RPM increased. No warning lights were illuminated. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,330.
- NHTSA ID
- 11747193
- Incident
- May 29, 2026
- Mileage
- 90,330 mi
A message came on the screen saying “engine maintenance required” and it’s not going away. Upon doing a google search, there is a common failure in the cooling system for these cars reported by a lot of owners.
- NHTSA ID
- 11742614
- Incident
- Jun 6, 2026
Electrical
Filed May 21, 2026
The contact purchased a 2020 Toyota Corolla. The contact stated that they discovered a mileage discrepancy after the purchase. The vehicle was a private sale on Facebook market. At the time of purchase, the vehicle mileage was 52,000. It was later discovered that the vehicle’s title mileage was 132,000. The contact stated went the DMV, and he discovered the mileage 132,483.
- NHTSA ID
- 11739330
- Incident
- May 20, 2026
- Mileage
- 132,483 mi
Replace Heater Control Valve - Diagnostic code P2681 indicates an internal electrical failure within the heater control valve assembly, a condition commonly seen on Toyota vehicles. Testing showed the electrical portion of the valve is open and no longer maintaining proper circuit continuity, requiring replacement of the heater control valve assembly.
- NHTSA ID
- 11739095
- Incident
- May 19, 2026
Powertrain (other)
Filed May 13, 2026
"On 04/09/26, I took my vehicle for regular maintenance and an oil change; no potential issues were reported. I operated the vehicle in good faith, trusting its safety. However, on Sunday, 05/03/2026, while driving at highway speeds, the clutch pedal failed and [stuck to the floor / slipped severely]. This caused an immediate loss of power to the wheels in high-speed traffic, creating a life-threatening situation and a high risk of a rear-end collision. No warning lights appeared prior to this failure."
- NHTSA ID
- 11737720
- Incident
- May 3, 2026
Visibility
Filed May 6, 2026
Windshield Wiper Intermittent setting stopped working, and wipers no long return to their home position. This appears to be a common issue with Toyota. When driving in the rain, the wipers will freeze in the up setting, which is very dangerous for it to occur during heavy rain on the highway causing visibility issues. No warnings of any kind given, the wiper switch appears to just go bad, or wear out over time.
- NHTSA ID
- 11736152
- Incident
- May 6, 2026
EngineFuel system
Filed Apr 24, 2026
The contact owns a 2020 Toyota Corolla. The contact stated that while at a red light, the vehicle shut off with the check engine and several other unknown warning lights illuminated. The vehicle restarted after several attempts. The vehicle was taken to an independent mechanic and the failure was duplicated. The mechanic retrieved DTC: P1603; "Engine Stall History" (ECM recording an unexpected engine shutdown or a communication error with the Transmission Control Module (TCM). The mechanic associated the failure with NHTSA Campaign Number: 20V682000 (Fuel System, Gasoline) and referred the contact to the dealer for assistance. Several dealers were contacted, and the contact was informed that the VIN was not included in the recall. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 59,000.
- NHTSA ID
- 11733489
- Incident
- Apr 1, 2026
- Mileage
- 59,000 mi
Coolant water control valve short circuit. Causes dealer message that won't clear and dealer wants $600 to replace a $30 part. Part is extremely difficult to get to and should not be a wear item.
- NHTSA ID
- 11730593
- Incident
- Mar 16, 2026
Car shows the below message when A/C is turned on: Engine Maintenance Required Visit Your Dealer
- NHTSA ID
- 11729914
- Incident
- Apr 7, 2026
Message on dashboard that says, "Engine Maintenance Required. Visit Dealer." This message came on at around 31,000 miles and I was told it was three different things all different prices at my dealer. So, I looked into it and found out it was the Coolant Bypass Valve, and asked the dealership about it and they said 700 dollars to replace. I did not want to pay that much especially since I saw online others were having the same problem. Message still pops up to this day when I turn on my A/C. Car now has around 205,000 miles on it and is six years old.
- NHTSA ID
- 11724474
- Incident
- Mar 18, 2021
Visibility
Filed Feb 26, 2026
The wipers are turning on randomly by themselves, even when the control switch is set to the “off” position. This has occurred multiple times and happens without any input or activation from me. The issue appears to be intermittent but persistent, and it raises concerns about a potential electrical or control system malfunction.
- NHTSA ID
- 11720827
- Incident
- Nov 1, 2025
I am having a problem with my 2020 Toyota Corolla's brakes. I live in [XXX] . In the winter when the car is cold the brakes work normally. When the car has been driven for a while, the car has warmed up, and the brake fluid has thinned, the brakes behave abnormally. When I stop at a red light, after 20 to 40 seconds, the brake pedal slowly drops towards the floor. My understanding is that this could indicate a problem with the master brake cylinder. My fear is that there could be a sudden failure of the cylinder causing an accident. I brought the car to Rudy Luther Toyota in Golden Valley. When I brought the car in, it was warm and the brakes were malfunctioning. Unfortunately, they let the car sit for several hours, the brake fluid cooled, and the mechanic was unable to duplicate the problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- NHTSA ID
- 11719920
- Incident
- Jan 5, 2026
Powertrain (other)
Filed Feb 23, 2026
The clutch slave cylinder failed at 48,000 miles. On the freeway, I had difficulty shifting into gear and I had cars passing me at high speeds, putting my life and others' lives at risk. This part defect is due to the plastic clutch slave cylinder failing. This common issue is well-documented by numerous other owners, with the part failing before the routine clutch maintenance cycle. My car was inspected by an independent mechanic, who said the lack of clutch pressure is due to the clutch slave cylinder failing. The worst part is that there were no warning lamps or messages before this happened. Toyota is claiming there is no recalls for this part, whic his astounding because the clutch is essential for the 6speed transmission.
- NHTSA ID
- 11719864
- Incident
- Feb 22, 2026
ElectricalVisibility
Filed Jan 30, 2026
when I use blinker windshield wipers turn on and sometimes when I call or somebody calls my cell phone I can hear them, but they cannot hear me. does not happen all the time, but I was concerned since there was a recall on certain toyota corolla that says a short circuit may develop in the OCS sensor, preventing front passenger air bag from deploying and my son who is a mechanic said both of these could be a problem with the wiring in the column and I thought it may be connected to the same recall as the air bags? the wipers coming on is happening more often these days and that is why I mentioned it to my son who is a mechanic. he will not touch it since it is still under my extended protection but he is concerned about it getting worse since the blinker is attached to the column. as far as using not being heard by callers or when I call I am concerned if I need to call in an emergency the ones I call cannot hear me. as far as when this started I do not remember but I know it's been at least 6 months if not longer, it just seems to be doing it more often lately
- NHTSA ID
- 11714511
- Incident
- Jul 1, 2025
Visibility
Filed Jan 18, 2026
The windshield wiper switch assembly (column stalk/switch) malfunctions intermittently, sending unintended signals that activate the wipers despite the stalk being firmly in the OFF position. The component is still installed in the vehicle and is available for inspection upon request. Suspected part numbers include 84652-06400 or similar variants. How was your safety or the safety of others put at risk? Sudden, unexpected wiper activation (typically 1-2 wipes, occasionally more) while driving creates a serious distraction and safety hazard. It can startle the driver, cause momentary loss of vehicle control or focus (especially at highway speeds or in traffic), and briefly obstruct vision. This risk is heightened during rain, when wipers are needed but behave erratically, or during acceleration/turns where vibration triggers it—potentially leading to accidents. Has the problem been reproduced or confirmed by a dealer or independent service center? No, the Toyota dealership has not reproduced or confirmed it during short test drives, as the issue is highly intermittent and occurs mainly after warmup from extended driving (20+ minutes), on hot days or after parking off for ~1 hour in heat/vibration. Similar cases reported by other 2020 Corolla owners on Reddit (r/COROLLA) and Toyota Nation forums were eventually diagnosed and fixed by replacing the wiper switch due to worn internal contacts/PCB from heat/vibration. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle was brought to a Toyota dealership, but no detailed inspection or repair occurred due to lack of replication. No inspections by police, insurance, Toyota corporate (manufacturer), or others have taken place. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lamps, messages, dashboard indicators, or prior symptoms
- NHTSA ID
- 11711699
- Incident
- Jan 1, 2022
On the morning of January 7, 2026, while I was on my way to work, I experienced a dangerous incident involving my vehicle. As I arrived at the first stop on the street, I suddenly heard a loud explosion. Immediately afterward, pieces of glass began falling onto my windshield. I pulled over and exited the vehicle to assess the situation. Upon inspection, I discovered that the sunroof of my car had completely shattered. Glass was scattered across the roof, windshield, and interior of the vehicle. Prior to the explosion, there were no visible signs of damage to the sunroof. The incident occurred without warning and posed a serious safety risk. I am submitting this complaint to formally document what happened and to request that the matter be investigated and addressed appropriately.
- NHTSA ID
- 11711360
- Incident
- Jan 7, 2026
BrakesPowertrain (other)
Filed Jan 15, 2026
Clutch slave cylinder started leaking leading to a sticking clutch pedal, making it difficult to engage the transmission with the engine, and a lower brake/clutch fluid level which could have caused braking issues if the fluid got too low.
- NHTSA ID
- 11711259
- Incident
- Dec 21, 2025
Engine coolant bypass valve
- NHTSA ID
- 11707273
- Incident
- Dec 27, 2025
Powertrain (other)
Filed Dec 11, 2025
Clutch Slave Cylinder at 51,000 miles failed causing vehicle clutch to not return and loss of fluid. Brake fluid and clutch fluid are used in the same reservoir and could cause issues causing vehicle to not be able to stop. Vehicle has been inspected by shop and has been replicated. The part exploded and leaks fluid inside of transmission housing. This also causes the clutch to fail as-well. Vehicle has always been serviced and maintained and this is a common issue with all vehicles that have 6 speed manual transmission with varying mileage. It is not a matter of if, it’s when and due to this being something that happens with generally no warning signs can be dangerous. There needs to be an updated part that can handle the design Toyota chose for this transmission.
- NHTSA ID
- 11704423
- Incident
- Dec 10, 2025
Powertrain (other)
Filed Nov 29, 2025
FAULTY HYDRAULICS IN THE TRANSMISSION SYSTEM. FAULTY SLAVE CYLINDER LEAKING FLUID AND POTENTIALLY CAUSING VEHICLE TO BECOME "STUCK" IN GEAR WHILE DRIVING OR UNABLE TO SHIFT INTO GEAR WHILE PARKED. NOT AN UNCOMMON ISSUE WITH THESE MODELS.
- NHTSA ID
- 11701983
- Incident
- Nov 26, 2025
BrakesElectricalPowertrain (other)
Filed Nov 22, 2025
Beginning on April 18, 2025, my 2020 Toyota Corolla LE began experiencing repeated failures involving multiple safety systems while driving. Without warning, several lights illuminate at the same time, including: Brake System Malfunction, Pre-Collision System, Parking Brake System, Vehicle Stability Control, Check Engine, and Secondary Collision Brake System. These warnings appear suddenly during normal driving, then sometimes disappear, then return again unpredictably. These failures disable several integrated safety systems and create a serious safety risk due to changes in braking performance, loss of stability control, and disabled collision-avoidance functions. Diagnostic scans from both the dealership and an independent mechanic repeatedly show: P1578 — Brake System Malfunction P265B — Rocker Arm Actuator Position Sensor Circuit Range/Performance (Bank 1) Both codes reappear even after being cleared. The vehicle was with Loving Toyota Lufkin, TX multiple times over seven months. They received over $7,100 in insurance payments for repairs, $463 towing cost (due to the negligence of Loving Toyota) and almost $1,500 in rental cars (Paid by State Farm) but were unable to diagnose or fix the underlying failure. Loving Toyota also provided a courtesy rental for 7+ weeks while they did no repairs to the car. The safety warnings continue to occur. Toyota Corporate is now involved but the vehicle remains unsafe to drive. The same code P265B is present that was present back in April 2025. This car is not safe! The problem has been reproduced by me, the dealership, and an independent shop. The vehicle is available for inspection. All scans, photos, videos, and documentation are available upon request. Date first occurred: April 18, 2025 Issue continues intermittently to present day
- NHTSA ID
- 11700972
- Incident
- Apr 18, 2025
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.