2024 Toyota Grand Highlander Steering Problems

While traveling at highway speed on I-75 northbound, the vehicle experienced a complete and total loss of electrical power. and propulsion. The following conditions were present simultaneously: - Complete loss of propulsion - Inability to shift transmission to neutral — vehicle could not be moved out of the active traffic lane - Complete loss of hazard lights — no ability to warn approaching traffic - Vehicle remained stranded in active highway traffic for approximately 15 minutes - Electrical power spontaneously restored after approximately 15 minutes - Vehicle was then driven off the interstate under its own power That was a life-threatening event. My wife and I could have been struck from behind by highway traffic with no warning lights, no ability to move the vehicle, and no way to signal distress. DEALER VISIT 1 — SATURDAY, APRIL 26, 2026 Dealer: Sarasota Toyota, Sarasota, Florida Complaint presented: Complete electrical shutdown on I-75 the previous day as described above Action taken by dealer: Performed recall repair for black screen issue Outcome: Vehicle returned to customer same day Post-repair symptom: Low voltage warning appeared on drive home from Sarasota Toyota Saturday afternoon Note: Dealer did not perform full electrical diagnostic. Dealer did not flag battery failure. Dealer did not retain vehicle for further investigation despite being informed of complete highway electrical shutdown the previous day. DEALER VISIT 2 — MONDAY, APRIL 28, 2026 Dealer: Germain Toyota of Naples, Naples, Florida Complaint presented: Complete electrical failure on I-75, low voltage warning after Sarasota repair, battery failure Findings: Battery confirmed dead. Alternator confirmed functioning normally. Dealer assessment: Condition described as unusual. Case escalated to Toyota Field Technical Specialist. Current status: Vehicle retained at Germain Toyota of Naples. Rental vehicle provided to customer.

NHTSA ID

11734470

Incident

Apr 24, 2026

Front brakes were worn prematurely and rotors had to be resurfaced multiple times under warranty and once more after warranty. Premature wear would cause shaking in the steering wheel when medium to heavy braking force was applied.

NHTSA ID

11733492

Incident

Dec 1, 2025

When making turns under acceleration at various speeds, there is a noticeable clunk noise from the front section of the vehicle. The sound can be described as a coil that is being compressed/decompressed and creates the noise. The noise is heard when loading and unloading the steering wheel during a turn.

NHTSA ID

11733491

Incident

Apr 19, 2026

clicking noises from front of engine area/tire area whenever steeing wheel turned left or right turned out to be cv axels and replaced feb 2. 2026 -so far will monitor for recurrence - grand highlander forum with numerous such complaints

NHTSA ID

11715972

Incident

Jan 16, 2026

When I turn to the left or right I hear a clicking/popping noise. Took it to the dealer and they said it was the CV axle. So they replaced the driver side. After the repair, it would make the same sound from time to time so I took it back in to the dealer(Northside Toyota in San Antonio, TX) they couldn't recreate the sound and notated my account. This was all when the car had less than 30k miles. The grand highlander now has 47k miles and it is making the noises alot more. Im on a grand highlander forum and a lot of other owners are having the same issues. Some are already on their 3rd set of cv axles.

NHTSA ID

11709793

Incident

Jan 8, 2026

Toyota T-SB-0082-24 / Rotational Clicking Noise From Front Drive Shaft Assembly ( CV JOINT) CV joint defect poses an unreasonable risk to safety, especially if it fails while you are driving. An unreasonable risk is one where the potential for harm is much greater than the potential benefit of taking the risk. Driving with a compromised CV joint fits this definition because it can lead to a complete loss of vehicle control, which can result in a serious accident.

NHTSA ID

11685533

Incident

Sep 25, 2024

When making left or right turns loud knocking noise is heard until turn is completed and going straight.

NHTSA ID

11641018

Incident

Jan 20, 2025

Check axel joint problems. Every time the car turns either way there is a loud clicking sound. This could be a big problem because it is a steering system. It has been confirmed by the dealership and part are on order. They said it is not a safety issue but I feel the steering and axle is a big component and if it fails it could result in damage of property or life. This has not been inspected by the police or insurance only the dealership confirmed it. There are also many others with this type of vehicle having this problem. There were no warning lamps or anything to show something was wrong only the loud clicking noise.

NHTSA ID

11637425

Incident

Jan 21, 2025

Every time we turn in the vehicle it knocks/clicks. A lot of research shows the CV Axle is causing this problem.

NHTSA ID

11565051

Incident

Jan 12, 2024