2021 Toyota Highlander Hybrid Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2021 Toyota Highlander Hybrid, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Airbags847.1%
- Body & structure423.5%
- Brakes15.9%
- Driver assistance15.9%
- Electrical15.9%
- Fuel system15.9%
- Other / unspecified15.9%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
The contact owns a 2021 Toyota Highlander Hybrid. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2021 Toyota Highlander Hybrid. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
The contact owns a 2021 Toyota Highlander Hybrid. The contact stated that the hatchback failed to open completely. The vehicle was taken to the dealer, and the dealer recommended that the hatchback motor be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a related recall. The failure mileage was approximately 50,000.
The contact owns a 2021 Toyota Highlander Hybrid. The contact received notifications of NHTSA Campaign Numbers: 23V720000 (Structure) and 23V865000 (Air Bags); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
The contact owns a 2021 Toyota Highlander Hybrid. The contact stated that while driving at slower speeds, the braking system experienced intermittent brake failures, causing the brakes to erroneously release while being depressed. During the failure, the vehicle unintendedly lurched forward. The vehicle was taken to the local dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not contacted regarding the failures. The failure mileage was 6,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
The contact owns a 2021 Toyota Highlander Hybrid. The contact stated while depressing the brake pedal, the vehicle continued to accelerate forward before coming to a stop. The vehicle was taken to the local dealer on several occasions but no cause for the failure was found. The contact was informed that the vehicle operated normally due to the hybrid system. The manufacturer was not contacted. The failure mileage was 10.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
The contact owns a 2021 Toyota Highlander Hybrid. The contact stated that upon starting the vehicle, the instrument panel lights were flashing. The vehicle then independently turned off and restarted repeatedly. The vehicle was towed to the dealer, where it was determined that the battery level was low and needed to be replaced. The battery was replaced, and other unknown repairs for shifting failure were performed. The vehicle was driven back to the residence; however, the failure recurred upon starting the vehicle the following day. Additionally, the seat belt chime reminders engaged even though the seat belts were securely fastened, and the tailgate had failed to open. The dealer was notified of the failure and informed the contact that the VIN was not included in TSB Number: T-SB-0019-21. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact requested a trade-in or buy-back assistance. The failure mileage was approximately 77,900.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
2 ISSUES- THE DISTANCE TO EMPTY ONLY READS 425 MILES. WITH A FULL 17 GALLON TANK IT SHOULD BE AROUND 600. WHEN YOU FILL IT, IT CLICKS OFF 3-4 GALLONS SHORT OF FULL, ONLY HOLDING ABOUT 14 GALLONS. THE FUEL GAUGE SHOWS FULL. I THEN HAD TO TRICKLE IN THE REMAINING 3.5 GALLONS. HOW COULD IT SHOW FULL WITH 3.5 MORE GALLONS GOING IN? WHY IS THE TANK NOT ABLE TO TAKE THE FULL AMMOUNT OF FUEL?
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
The contact owns a 2021 Toyota Highlander Hybrid. The contact stated while depressing the brake pedal, the vehicle continued to accelerate forward before coming to a stop. The vehicle was taken to the local dealer on several occasions but no cause for the failure was found. The contact was informed that the vehicle operated normally due to the hybrid system. The manufacturer was not contacted. The failure mileage was 10.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .