2012 Toyota Highlander Problems

Popping and clunking sound in steering or suspension. Can be produced at speeds and at stand still. Could it be this? https://static.nhtsa.gov/odi/tsbs/2013/SB-10075792-2280.pdf https://www.carcomplaints.com/Toyota/Highlander/2013/steering/steering.shtml NHTSA Action Number: EA18006 https://www.consumerclasslawyersblog.com/snap-crackle-pop-intermediate-shaft-noise-coming-from-toyota-highlanders/

WHEN I DRIVE THE VEHICLE YOU CAN HEAR A CLUNKING SOUND IN THE STEERING COLUMN. IT HAPPENS AT LOW AND HIGH SPEEDS. WHEN MAKE A TURN RIGHT, OR LEFT YOU HEAR CLUNKING IS THE STEERING COLUMN. IT FEELS LIKE THE STEERING WANTS TO COME OFF, TOOK IT TO THE DEALER AND THEY STATE TO FIX IT WILL COST OVER 1000$. I HEAD THERE WAS A DEFECT IN THE STEERING COLUMN WHICH TOYOTA KNOWS ABOUT, BUT HAS NOT DONE ANYTHING TO RECALL AND FIX THE PROBLEM.

I think there is odometer fraud by this company selling this car. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2012 TOYOTA HIGHLANDER was locked & battery was dead. Could not unlock using either the key fob or the mechanical key in the fob. Was told even the mechanical key requires battery power.

The contact owns a 2012 Toyota Highlander. The contact stated that 5,000 miles after purchasing the vehicle, the contact noticed an oil leak. The contact performed the oil changes and had noticed that engine oil had leaked down onto the weather seal in the vehicle. The contact noticed several oil stains on the ground during rainy weather. The contact noticed that the new tires that the dealer installed at the time of the vehicle sale were worn out. The contact checked the tires and noticed that the plastic rubber on the front strut was severely damaged. The vehicle was taken to an independent mechanic who diagnosed that the timing cover had a leak, and that the timing cover area was smeared with an unknown silicone patch. The struts were replaced. The contact stated that the failure persisted. The manufacturer was not notified of the failure.  The failure mileage was approximately 160,000.

I think there is odometer fraud by this company selling this car. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The paint is malfunction , and is available for inspection upon request.

Hello, to whom it may concern: My 2012 Toyota Highlander Color Pearl White vin [XXX] ) has a repaint recall before Nov 2024. I was told at the dealer that I have to contact the Toyota dealers until I get the opportunity to get it paint. I was told that I had to contact any Toyota dealer until I get a date of acceptance. Thinking that it was not fair to delegate the responsibility on myself I made a few calls until I did get an appointment to get my SUV painted. The recall period is almost over (Nov 2024) I was told and I will put a claim on Toyota Corporation for not making sure all the vehicles are completely painted. I will also put a lawyer to help me get across my claim if I am not informed from Toyota the date that they will work on my SUV with the repaint recall. Respectfully, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

THE REAR WIPER QUITS WORKING. INITIALLY THE DEALERSHIP TOOK IT APART, CLEANED IT AND IT WORKED TEMPORARILY. BUT THEN THE WIPER QUIT WORKING AGAIN. THERE APPEARS TO BE A PROBLEM WITH THE MECHANISM AND/OR REAR WINDOW ALLOWING IN MOISTURE FOR THIS TO CONTINUE OCCURRING, REQUIRING THE NEED TO KEEP GOING IN AND CLEANING IT OR HAVING TO REPLACE IT AS SOME HAVE REPORTED WHICH APPEARS TO BE THE POINT I AM AT THE LAST TIME I TOOK IT IN.

REAR WINDSHIELD BLEW OUT ON THE INTERSTATE. THE CAR WAS WARMED PRIOR TO DRIVING AND FONT AND REAR WINDSHIELD WERE ON DEFROST PRIOR TO THE REAR WINDSHIELD EXPLODING.

I was driving and arrived home and suddenly lost my braking and almost hit my house if I didn't steer the wheel towards my lawn and put on my parking brake it would have been a disaster. I felt so unsafe that I had my vehicle towed for repair and had to replace the brake master cylinder. Two weeks later, we went on a family trip and parked my vehicle with my family and it was on a slight slope and went to put on the parking brake and it was still slightly moving forward only to put my vehicle in reverse QUICKLY in order in NOT DRIVE INTO A LAKE WITH MY FAMILY IN THE vehicle!!! I have just read the complaints and this is an ongoing problem since 2011 and I am quite SHOCKED that this is NOT ON RECALL!!! My wife has a Prius V 2013 and have not had any problems at all, BUT has a recall on a Brake Hydro-Boost pump fail for her vehicle, BUT nothing is wrong with her brakes, ONLY THE 2012 TOYOTA HIGHLANDER!!! Please let me know what Toyota needs to do to get this this fixed!!! I know there are probably more that no one is reporting this and I guess there must be a fatality in order for Toyota to fix this problem!!!!

On December 29, 2021, while backing up my 2012 Toyota Highlander accelerated at speed that I was unable to control. One car that was packed in the driveway was damaged beyond repair. An office building where I was working was damaged and has been accessed with a loss of over $100,000. I contacted Toyota after knowing that there was a recall regarding unintended acceleration in some Toyota cars. Toyota sent an inspection team to Geico Insurance company which had taken over possession of the car. The inspection team and the Toyota representative assured me a final report would be sent to me within a month after the inspection had been completed but even up to this moment Toyota has not responded to my email requesting for the report. You can reach out to Toyota and reference File # 220105001224. For the six years I owned the car, i have never been informed of any recall. My car was regularly serviced by Toyota Ourisman Chantilly and Ourisman Toyota Fairfax.

All brake warning indicators lit up. Took it to a mechanic that specializes in hybrids and they diagnosed it as a brake assembly/actuator issue, with a diagnostic code of C1391, with a repair estimate of $4888. Found online that there was a Toyota Customer Support Program 21TE03 that addressed this issue, but my vehicle was outside of both the primary and secondary coverage periods. My issue is that if they knew this was a very serious safety defect for older hybrid vehicles, why would they only offer to address it during a very short period of time?? There are many people reporting online that the same thing happened to them (problem arose after coverage period expired). Toyota says they “care about the customers’ ownership experience,” but by neglecting to help those of us experiencing this issue, they are showing the exact opposite. Hope you will help the roughly 74,700 owners potentially impacted by this, by encouraging Toyota to be accountable for the safety of their owners. Thanks.

This is the second Highlander Hybrid I've owned that has had the brake actuator and booster assembly fail affecting the functionality of the car's braking system. Replacing these two parts has an absurd price of over 3k at the dealership and other independent hybrid repair shops. My car only has 70k miles on it and I've read this issue applies to almost all other Toyota Hybrids. If most hybrid's brakes will fail eventually, putting at risk owners, why is there not a recall to fix this "not a matter of if, but when" possible life threatening issue?

The front passenger side airbag light has been going off and on for a few months when someone is sitting in the seat now and now the sea is showing up

Major issue with Airbags July 2021. A warning appeared shortly after Passenger Sensor malfunction, that stated “Check SRS Airbag System. Have your vehicle checked by dealer immediately.” Dealer did Diagnostic. Toyota Dealer has tried to fix airbags three times in three weeks but it fails within a day or so and warning comes back on. Toyota has issued a recall for 2012 Highlanders for seats and front airbag that describes the issue this vehicle has however Toyota Dealer said our Vin is not included. The recall is under Campaign no. 13V014000 Report Date Jan 16 2013 Component Seats.

The contact owns a 2012 Toyota Highlander. The contact stated while driving 65 MPH, the driver’s side sun visor detached and fell on the contact. The contact took the vehicle to the local dealer, where it was diagnosed with needing the driver side sun visor to be replaced. The vehicle was repaired. The contact stated that in September 2022, the driver's and the passenger's side sun visors detached. The contact took the vehicle to the second local dealer, Capitol Toyota (6800 Automall Pkwy, Gilroy, CA 95020, (408) 335-0587) where the vehicle was diagnosed and determined that the driver’s and the passenger's side sun visors needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was unknown.

Major issue with Airbags July 2021. A warning appeared shortly after Passenger Sensor malfunction, that stated “Check SRS Airbag System. Have your vehicle checked by dealer immediately.” Dealer did Diagnostic. Toyota Dealer has tried to fix airbags three times in three weeks but it fails within a day or so and warning comes back on. Toyota has issued a recall for 2012 Highlanders for seats and front airbag that describes the issue this vehicle has however Toyota Dealer said our Vin is not included. The recall is under Campaign no. 13V014000 Report Date Jan 16 2013 Component Seats.

Toyota Piston and Ring defect. My 2012 Toyota Highlander engine has defective pistons and rings that have led to excessive oil consumption and the potential for a serious accidents as it causes the engine to lose compression and conk out, all of a sudden, in traffic, and costly repair for us customers with less than 150,000 miles. Piston/ring issue diagnosed by Toyota Dealer in Panama City, Florida. A class Action lawsuit needs to be initiated, immediately, for the 2012 Toyota Highlander. Toyota has already had a Class Action Lawsuit for this same problem in 2014 for their other Toyota models.

MY VEHICLE WAS FINE NO NOISE NOTHING ALL OF SUDDEN THE TRANSMISSION FAIL TO SHIFT GEARS

The unmatched handle completely broke. So now the insert and the base are stuck together and I can not unlatch them to use this carseat properly to transport my son. I have to take the base and all out of the car as one piece

Toyota and other vehicle brands use wheel lug nuts that become "swollen" over time. This happens because a cosmetic cap (with no mechanical purpose) made from a different metal is bonded over the metal of the lug nut. The cosmetic cap deforms or swells, because of its different properties compared to the lug nut itself. On 12 August 2021 I was unable to change a flat tire because the lug nut wrench that came with the vehicle no longer would fit over the lug nuts in order to loosen them. The lug nut wrench would not fit any of the 20 lug nuts on the vehicle. There is not one single mention in the 636-page owner's manual about swollen lug nuts, only an advisory to use genuine Toyota wheel nuts and wrenches, which easily become incompatible. The genuine Toyota wrench no longer fit, I had no other means of loosening the lug nuts, and became stranded. I was fortunate that a friendly motorist with a set of different sockets and a breaker bar came along and was able to assist me. Such fortune is not always the case. Being stranded puts the personal safety of the motorist in jeopardy, as can be confirmed in numerous reported incidences. On 13 August 2021 I went to the dealer to repair / replace the flat tire. The dealer acknowledged that the swollen lug nuts were a known mechanical defect with many Toyota vehicles, but refused to install lug nuts on my vehicle without this defect. The only recourse offered was for me to buy new lug nuts of the same style, which would not have improved the situation. Because of the personal safety issues involved, intentionally selling vehicles with know mechanical defects to unsuspecting buyers should come with serious consequences for a manufacturer. Refusing to repair such defects when pointed out to the dealers should also carry consequences.

The contact owns a 2012 Toyota Highlander. The contact stated that the TPMS warning light was illuminated. The vehicle was taken to a Tire Center, which was unable to determine the cause of the failure. Upon further investigation, the contact linked the failure to NHTSA Campaign Number: 24V452000 (Tires). The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 90,200.

2012 TOYOTA HIGHLANDER. CONSUMER WRITES REGARDING A DEFECT WITH TIRE PRESSURE MONITOR. *LD THE CONSUMER STATED THE TIRE PRESSURE WARNING LIGHT WAS ILLUMINATED, BUT THE TIRES ARE ALL AT THE CORRECT PRESSURE LEVELS. THE CONSUMER REQUESTED TO HAVE THE TPMS DEACTIVATED UNTIL A FIX WAS AVAILABLE. *JS

WHEN FILLING THE HIGHLANDER WITH FUEL, IT LOOKS LIKE A WATERFALL OF FUEL LEAKING ONTO THE GROUND. IT DOES NOT APPEAR TO BE A GAS TANK ISSUE BUT A PROBLEM WITHIN THE LINES? ONCE YOU STOP FUELING WITH THE MAJOR LEAK AND GO TO ANOTHER AREA THERE IS NO FUEL DROP UNDERNEATH THE TANK.

ON (OR ABOUT) THE LAST WEEK OF MAY 2015, I HAD MY AUTO SERVICED AT THE DEALSHIP. I WAS ADVISED THAT THE 'THROTTLE BODY' NEEDED 'CLEANING' AND THIS WAS DONE BY THE DEALERSHIP AT THAT TIME. ON JUNE 4, 2015, I WAS BACKING INTO A PARKING SPOT ON A PARKING LOT, WIITH THE CAR 'COASTING' BACK AND MY FOOT ON THE BRAKE. ABOUT HALF WAY INTO THE 'SPOT' THE CAR ENGINE SUDDELY ACCELLERATED AND I HAD TO USE EXTREME PRESSURE ON THE BRAKE PEDAL TO OBTAIN A 'MINIMUM' OF SLOWING. THE CAR ONLY CAME TO A STOP WHEN THE REAR TIRES, MADE CONTACT WITH AN 'IN-PLACE' CEMENT PARKING BARRIER AND THE ENGINE ACCELERATION ONLY CEASED WHEN I PUT THE CAR IN 'PARK' GEAR. IT HAS NOT OCCURED SINCE, NOR HAS IT EVER OCCURED WHILE DRIVING FORWARD. I AM A RETIRED POLICE OFFICER WITH YEARS OF TRAINING IN DRIVING AND DRIVER SAFETY, AND AM CERTAIN OF THIS ACTION OCURRING AS I HAVE DESCRIBED.

The contact owns a 2012 Toyota Highlander. The contact stated that 5,000 miles after purchasing the vehicle, the contact noticed an oil leak. The contact performed the oil changes and had noticed that engine oil had leaked down onto the weather seal in the vehicle. The contact noticed several oil stains on the ground during rainy weather. The contact noticed that the new tires that the dealer installed at the time of the vehicle sale were worn out. The contact checked the tires and noticed that the plastic rubber on the front strut was severely damaged. The vehicle was taken to an independent mechanic who diagnosed that the timing cover had a leak, and that the timing cover area was smeared with an unknown silicone patch. The struts were replaced. The contact stated that the failure persisted. The manufacturer was not notified of the failure.  The failure mileage was approximately 160,000.

FOR SEVERAL MONTHS NOW I HAVE BEEN HEARING A CLUCKING NOISE WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT AND UPON BREAKING A THUD SOUND IN THE FRONT OF MY CAR. AFTER TAKING MY CAR IN TO THE DEALERSHIP THEY CAME BACK AND SAID THAT THE NOISE WAS COMING FROM THE INTERMEDIATE SHAFT. I ASKED WELL HOW DO YOU DAMAGE A WHOLE INTERMEDIATE SHAFT? THEY SAID IT OCCURS OVER A PERIOD OF TIME. MY VEHICLE HAS 92,000 MILES ON IT BUT ITS BEEN MAINTAINED AND SERVICED AND NOT DRIVEN ROUGHLY BUT TO MAKE A LONG STORY SHORT THEY SAID IT WOULD COST ME ABOUT $615.00 TO HAVE THE VEHICLE REPAIRED PLUS AN ADDITIONAL $89.95 FOR THE ALIGNMENT. THIS APPEARS TO BE A MANUFACTURE ISSUE AND NEEDS TO HAVE A RECALL. I'M VERY DISAPPOINTED IN TOYOTA SINCE THEY PRIDE THEMSELVES AS BEING ONE OF THE LEADING AUTO MAKERS AROUND THE WORLD.

TL* THE CONTACT OWNS A 2012 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE HEAD LIGHTS WERE TOO DIM, MAKING IT DIFFICULT FOR NIGHT DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN VERIFIED THE FAILURE AND ADJUSTED THE LIGHTS HOWEVER, THE FAILURE WAS NOT REMEDIED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 4,000. ... UPDATED 02/27/13 *BF UPDATED 03/04/13

TL* THE CONTACT OWNS A 2012 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH AND STEERING TO THE RIGHT, THE ENGINE SUDDENLY EMITTED AN ABNORMAL NOISE. THE CONTACT ALSO STATED THAT THE HEADLIGHTS WOULD NOT SHUT OFF INTERMITTENTLY WHEN POWERING OFF THE VEHICLE. IN ADDITION, THE DEFROSTER FOR THE REAR WINDOW WOULD NOT FUNCTION PROPERLY, CAUSING THE WINDOWS TO REMAIN FOGGY FOR A LONG PERIOD OF TIME. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THAT THERE WERE NO FAILURES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 1,000 AND THE CURRENT MILEAGE WAS 3,300. UPDATED 1/29/13 *CN

TL* THE CONTACT OWNS A 2012 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE MALE SEAT BELT CONNECTOR FAILED TO CONNECT INTO THE FEMALE CONNECTOR. THE SEAT BELT INDICATOR WAS ILLUMINATED. THE DEALER DIAGNOSED THAT THE FEMALE SEAT BELT CONNECTOR FAILED AND NEEDED TO BE REPLACED. THE SEAT BELT CONNECTOR WAS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.