2023 Toyota RAV4 Airbags Problems

The contact owns a 2023 Toyota Rav4. The contact stated the front passenger’s side Occupant Classification System (OCS) sensor failed to detect an occupant seated in the passenger’s seat and was deactivated on the instrument panel. The dealer was contacted and informed of the failure; however, the vehicle had not been taken to be diagnosed or repaired. The contact researched and found information on NHTSA Campaign Number: 22V519000 (Air Bags) and associated the failure with the recall. The manufacturer was informed of the failure, and the contact was informed that the VIN was not included in the recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 57,500

NHTSA ID

11717539

Incident

Jan 29, 2026

Mileage

57,500 mi

My wife was going at about 10 - 15 mph coming up about 2 car lengths to a small curve in a residential area when all of a sudden she heard a pop or snap and the Rav4 went to a super high speed by itself. The acceleration could not be stopped even though she had her feet on the brakes. She had both hands on the steering wheel to avoid hitting a house and ended up going through a wall in the yard. There were no warning sounds and no signals indicating a problem. it appeared that the display was blank. There was no pre-collision warning or braking except as my wife was pushing on the brakes. She also hit the right side into side wall. No air bags deployed even though Windshield and all door glass on sides shattered. My wife the driver was okay and not hurt, and the grandchild in the car seat behind my wife was fine also. Neither had injuries. There were checked by emt. The police looked but all would not try to get in except to remove my granddaughter. My wife was removed also because she could not get out the door was jammed against shed and rock, and handles broken off This happened after the recall work was done by toyota dealer on 12/04/2025. There were no problems prior to the recall. I've listed the recall below. 25TD01 Rear Traction Motor Cable Corrosion - Multiple Model & Model Year Toyota Hybrid (AWD) Vehicles NHTSA Recall ID AWAITING# Recall Date Dealer Reference ID 25TD01 Description The subject vehicles are equipped with a rear motor unit and an HV Floor Under Wire that provide high voltage to operate the motor. Mud, water, or road salt could potentially enter the HV Floor Underwire connector housing and could cause corrosion over time. Excessive corrosion could cause AM Radio Static during certain driving cycles, or the vehicle may not start. Status Remedy Available Remedy Any authorized Toyota dealer will apply a wire harness protector seal to the HV Floor Under Wire Connector. Toyota corporate engagement is looking into this.

NHTSA ID

11706225

Incident

Dec 10, 2025

Vehicle: 2023 Toyota RAV4 Hybrid Issue: Persistent brake noise, safety hazard, manufacturer negligence I leased a 2023 Toyota RAV4 Hybrid from Clermont Toyota (Florida). Well before reaching 5,000 miles, the brakes began squealing and grinding, posing a potential safety hazard. Multiple service visits failed to correct the issue. Toyota Motor Sales, U.S.A., Inc. and its distributor, Southeast Toyota Distributors LLC, have long been aware of this defect, as documented in Technical Service Bulletin TSB-0001-22 and numerous NHTSA consumer reports describing similar brake failures and noises in 2019–2023 RAV4 models. Despite repeated notice, Toyota refused to repair or replace the defective vehicle and denied my Lemon Law claim through an arbitration panel connected to manufacturer counsel. This unresolved brake defect creates danger to the driver, passengers, and others on the road. Toyota’s continued sale and lease of vehicles with known braking issues constitute a serious public safety concern. I request that NHTSA investigate Toyota’s knowledge of these defects, evaluate the adequacy of its response, and consider a recall to protect consumers nationwide. Contact: [XXX] – [XXX] – [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11695950

Incident

Jul 31, 2024

I was in a very bad accident on [XXX]. I was side swiped from the front passenger side of the car. I was not at fault of the accident. My car then hit a fire hydrant and a pole. The airbags did not deploy and my head hit the steering wheel I own a 2023 RAV4 XLe premium. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11694907

Incident

Oct 20, 2025

My 2023 Toyota RAV4 Hybrid has had squeaky brakes for many months (from 4,000 miles onward and consistently continues to be an annoyance, nuisance, and safety hazard while intensifying in frequency), but despite taking the vehicle to the Toyota dealer more than 4 times, they have been unable to repair the issue. At least twice the air bag sensors have come on for the backseat when there was nobody seated in the backseat, distracting me from safely driving. Toyota has done nothing to right the wrong mechanically, refund me for the vehicle (a lease) or offer a replacement. I have a 14 page document filed with the Florida Attorney General Lemon Law Division thoroughly indicating why these ongoing mechanical failures, safety hazards, nuisances and distractions to me the driver substantially impair the use, value, and safety of the vehicle—fulfilling key criteria under Florida Statutes § 681.102 and § 681.104, which I am happy to provide all consumers and attorneys willing to launch a CLASS ACTION against Toyota. Florida law defines "impairment of value" not by market collapse, but by any reasonable reduction in consumer confidence. Consumer disclosure laws require honesty about defects. Florida Statute § 681.102(15) defines a “nonconformity” as a defect that “substantially impairs the use, value, or safety of the motor vehicle.” My vehicle has been subject to repair more than 4 times for the same defect within 24 months and thus qualifies for relief. The manufacturer’s failure to permanently correct the squeaky brakes—even after attempted repairs—demonstrates a pattern of unresolved nonconformity. The squeaky brake issue is not a cosmetic inconvenience—it affects the vehicle's functionality, resale integrity, and safety assurance. Toyota acknowledges the problem exists (via TSB) but has failed to provide a lasting solution. If unresolved, this defect would materially concern any reasonable consumer and diminish confidence in the vehicle’s reliability and safety.

NHTSA ID

11670424

Incident

Sep 14, 2024

Sudden surge and acceleration upon parking. I had brakes depressed pulling into a parking space when the vehicle felt like it jumped and quickly accelerated. It veered left missing the parked van in front of me but crashing into the parked Honda Accord two spots over and one in front. It crashed into the back tire and fender area of the passenger side of the Honda pushing it completely out of its spot and sideways. My vehicle kept going even though pushing the brakes to stop. I had to force it into park to stop. The car’s air bags deployed but my Toyota’s airbags nor crash warning system worked.

NHTSA ID

11654811

Incident

Apr 13, 2025

Driving NB when a Toyota Corolla drove into my lane of traffic hitting me head on. No air bag deployed in my RAV but all air bags deployed in the Corolla. No air bag light was on prior to the accident. My vehicle data recorder was copied by a Bosch technician and forwarded to Toyota Corp. The body shop manager stated that my vehicle was the first he had encountered with the extent of front damage where the air bag(s) did not deploy

NHTSA ID

11597173

Incident

Jun 10, 2024

A car pulled out right infront of me at an intersection, I hit their back drivers side rear with most of the front of my car. I was doing approximately 41-45 mph. No airbags were deployed and my SOS button didn't work nor did it call for help.

NHTSA ID

11585406

Incident

Apr 17, 2024