2025 Toyota RAV4 Problems

What component or system failed or malfunctioned, and is it available for inspection upon request? The concern involves the vehicle's Toyota Safety Sense (TSS) active safety systems, specifically Lane Tracing Assist (LTA), Steering wheel assistance and the Pre-Collision System (PCS) with Dynamic Radar Cruise Control (DRCC).The suspected systems/components involved include the forward-facing camera, front radar sensor, steering assistance/LTA system, and related ADAS software calibration. The vehicle is available for inspection upon request. The issue is with system performance during operation, not a visible physical component failure. How was your safety or the safety of others put at risk? While driving on highways or non-highways with clear lane markings and LTA/DRCC activated, the vehicle has shown inconsistent lane-centering behavior. The vehicle can weave within the lane and has drifted toward an adjacent lane without intentional steering input from me. This creates concern about unintended lane departure and reduced driver confidence in a safety assistance feature.I also have concerns regarding the Pre-Collision System's ability to detect stopped vehicles ahead early enough to provide appropriate warning or automatic braking intervention. A delayed response from an active safety system could increase the risk of a collision. Has the problem been reproduced or confirmed by a dealer or independent service center? I have reported the concern to the Longo Toyota dealership multiple times in Prosper, Texas. The dealership inspection identified. However, to my knowledge, the dealer has not successfully reproduced or documented the specific driving conditions required to observe the issue (highway or non-highway driving with LTA/DRCC active) with me present. The issue continues after the service visit. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Only Toyota Dealership inspected No warnings displayed .

On July 31, 2026, while traveling approximately 55 mph on a Maryland highway, my 2025 Toyota RAV4 unexpectedly lost power and shut off while in motion. There was no check-engine warning before the failure. The vehicle became disabled in a travel lane. Police responded, and the lane had to be closed because the vehicle could not be safely moved. There was no crash, fire, or injury. The vehicle was taken to an authorized Toyota dealership. The dealer documented that it had “shut off mid drive,” reported finding no codes in the engine ECU, and performed service campaign 26TC03 concerning an incorrect mass airflow sensor reading. The dealer replaced a radiator air guide and stated that the vehicle should return for further diagnosis if it stalled again. On August 2, only approximately 36 miles after that service, the vehicle failed to restart at approximately 40,529 miles and required a jump. LTA and pre-collision system malfunction warnings appeared. The pre-collision warning returned while the vehicle was moving, and the Toyota connected app also recorded the malfunction. The vehicle was then towed back to the dealership and is available for inspection. The cause remains unknown. The concern involves an intermittent engine shutdown/no-start condition, a possible 12-volt electrical or charging-system failure, and the loss of forward-collision and lane-assistance functions. The dealer’s prior multipoint inspection marked the battery as acceptable, but no actual CCA battery-test result was documented.

On August 25, 2026 when I went to turn my vehicle on in the morning, and I started to drive the vehicle alert the LTA malfunction Visit your dealer on the dash. Call dealer and scheduled service for the next day August 26, 2026. In the morning I went to go start my vehicle to take it in and it wont start at this point on the dashboard was showing Not Ready to Drive and it would not start and I reached out again to the dealer and the had roadside assistance to tow the vehicle in to the dealer. When roadside assistance I gave him my keys and the vehicle started up but now vehicle dash alerted Drive-start Control Malfunction visit your dealer. Roadside did nothing but up the key in the ignition. Vehicle once towed to the dealer was running and no alerts showed on the dashboard and the dealer informed that the multi- point vehicle everything checked out. Jayleen informed that tech ran the computer and saw the alert but could not do no repair due to at the time of service there was no sign on the dash and if where to happen to bring the vehicle in to the dealer. Jayleen also mention that wire my have been chewed.I asked it they inspected for that, she informed No due to no alerts where I dashboard. Then she when on to say that it was my dash camera that was draining my battery. I mention to her that the vehicle was not coming in for battery issues. So I uninstalled my dash camera to see if that was the issues. My vehicel has been parked mostly. Now today September 7,2026 car did not start and show pre-Collision System Malfuntion.

Drove home vehicle under 20,000 miles 2025, got to drove way parked and car stalled shaking amd stated steering power low, and shut off. Tried to re start it and did the same thing stalled shook amd shut off with the same warning. No previous issues

On August 25, 2026 when I went to turn my vehicle on in the morning, and I started to drive the vehicle alert the LTA malfunction Visit your dealer on the dash. Call dealer and scheduled service for the next day August 26, 2026. In the morning I went to go start my vehicle to take it in and it wont start at this point on the dashboard was showing Not Ready to Drive and it would not start and I reached out again to the dealer and the had roadside assistance to tow the vehicle in to the dealer. When roadside assistance I gave him my keys and the vehicle started up but now vehicle dash alerted Drive-start Control Malfunction visit your dealer. Roadside did nothing but up the key in the ignition. Vehicle once towed to the dealer was running and no alerts showed on the dashboard and the dealer informed that the multi- point vehicle everything checked out. Jayleen informed that tech ran the computer and saw the alert but could not do no repair due to at the time of service there was no sign on the dash and if where to happen to bring the vehicle in to the dealer. Jayleen also mention that wire my have been chewed.I asked it they inspected for that, she informed No due to no alerts where I dashboard. Then she when on to say that it was my dash camera that was draining my battery. I mention to her that the vehicle was not coming in for battery issues. So I uninstalled my dash camera to see if that was the issues. My vehicel has been parked mostly. Now today September 7,2026 car did not start and show pre-Collision System Malfuntion.

Driving my one owner 2025 Rav 4 Hybrid- pulling into a parking spot while gently pressing on the brake to slow car. Car was slowing then suddenly accelerated while brake pedal still being pressed, lunged forward and hit a wall in front of the parking space. No warning lamps/alarms went off and drivers seat belt did not engage. Called dealership to report incident.

My windshield spontaneously cracked from the outside frame down 10 inches and then across the glass through site line of driver. There was no outside influence (Rock chip and etc) I am not the first RAV4 owner to experience this.

On August 29, 2026, at approximately 9:04 PM, my vehicle was turned off and parked in my driveway. I entered the driver’s side of the vehicle and closed the driver’s door normally. Immediately after the door was closed, the rear windshield/back glass completely shattered without warning. There was no known impact to the rear windshield at the time of the incident. The outside temperature was approximately 76°F with 85% humidity, and the incident occurred after dark. I did not notice any warning lights, messages, visible damage, or other symptoms before the glass shattered. The sudden failure created a safety risk because shattered glass could strike or injure vehicle occupants and left the vehicle without an intact rear windshield. The cause of the failure is UNKNOWN at this time.

The moonroof on my car spontaneously shattered while I was driving on the highway. It made a very loud noise like a large object hitting the top of my car. There was no prior warning and no other vehicles were close to me at the time. I was not driving under a bridge or overpass. The sliding roof panel was closed, but I heard wind and there was shattered glass on the top of sliding roof panel. If it had been open, passengers would have had been showered in broken glass. The glass pieces went flying across the roof and scratched the paint. I took the car to a glass shop and the Toyota dealership. Toyota inspected it for defects in the seal/gasket that holds the moonroof, but found nothing. Our insurance company did cover replacing the moonroof glass and the paint damage. This happened at the end of February on a very cold & clear day (about -15 degrees), so I had auto-started and warmed up my car before driving.

I purchased my vehicle new from the dealership in 2025. After driving the vehicle for several months I noticed the back seat floors were filling with road dirt and debris. I also noticed water was getting into the doors frames. This will certainly cause rust to the doors early on. I made an appointment with the dealership to investigate the problem, and looked forward to them resolving the issues. The dealership had the regional tech person (FTS) come out to look into the matter. I was told there was nothing they could do it was part of the car design. I expressed it was a design flaw that needs to be addressed. I have reached out to Toyota Brand Engagement Center (7/29/26), and received no follow-up to date. I would to request an investigation into these issues.

Driving my one owner 2025 Rav 4 Hybrid- pulling into a parking spot while gently pressing on the brake to slow car. Car was slowing then suddenly accelerated while brake pedal still being pressed, lunged forward and hit a wall in front of the parking space. No warning lamps/alarms went off and drivers seat belt did not engage. Called dealership to report incident.

The brakes have been overly sensitive... but then, without warning, braking power is completely lost. This has happened on 2 separate occasions... the pedal goes all the way to the floor and provides ZERO braking power. We can no longer trust this car on the road. Toyota sent someone to inspect the vehicle and they claim that they have found no problems or issues and that they have not been able to reproduce the problem. There were no warning lamps or message; there were no prior symptoms, other than the brakes were overly sensitive. These symptoms occurred immediately after purchasing the car. Toyota refuses to purchased the car back from us, and now we are stuck with a very dangerous vehicle. Interestingly, I have found others talking about EXACTLY the same symptoms on other Toyota Rav4 vehicles.

UNKNOWN - On XXX, at just 7,741 miles, my 2025 Toyota RAV4 XLE Premium AWD (VIN: [XXX]) suffered a catastrophic and life-threatening complete mechanical and hydraulic transmission failure. The vehicle completely lost forward propulsion when placed in Drive mode, rendering it entirely immobile. When placed in Reverse gear, the transmission violently over-pressurized, causing the vehicle to suddenly surge and jump uncontrollably. Simultaneously, the dashboard displayed 6 critical safety system failures: 1. Check Engine — electronic control malfunction 2. Vehicle Stability Control System (VSC/TRAC) malfunction 3. Secondary Collision Brake System malfunction 4. Pre-Collision System malfunction 5. Parking Brake System malfunction 6. Advanced Ultrasonic Detecting and Ranging System malfunction Ourisman Toyota Chantilly (RO# XXX) has confirmed complete transmission failure. Fault codes found: P28167F — Pressure Control Solenoid H Actuator Stuck Off, P08BA7F — Pressure Control Solenoid L Actuator Stuck Off. Estimated repair cost: $11,347.42. While this failure fortunately occurred on a local road, had it occurred while merging onto I-66 or I-95 at highway speeds, it would have inevitably caused a catastrophic high-speed collision. This represents an extreme manufacturing defect and life-threatening safety hazard. Toyota Corporate Cases opened: #XXX (original case) and #XXX (full replacement request). I am requesting full vehicle replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2025 Toyota RAV4 XLE 4 door utility 2.5L 4 Cyl Gas A AWD unexpected sudden acceleration My safety as well as other vehicles and occupants as could have been at risk. National Transportation Safety Boaed has confirmed 57 cpmplaints of same issue. Vehicle determined total loss by insurance inspector, Va State Police. No warning lamps, messages, or other symptoms proir to the problem.

Steering wheel showing red signal on the dashboard, and sometimes, when I park and want to restart the car , steering wheel block, not letting me start my car. Steering wheel block start about 5 months after I purchased the car and happened on August 2026.Steering wheel showing red signal start on July.

On two separate occasions, my car has shaken violently and stopped both times while idling one in my driveway one at a stoplight and then an alert that says engine stopped steering power low came on

Properly inflated at all times "Firestone Destination LE2 225/65R17" tire ruptured suddenly! There is a 1" radial slit in the sidewall near the beginning of the tread line.

Sidewall randomly cracked while traveling late at night on sparsely populated interstate. No debris on road or potholes encountered to explain why this occurred.

Driving my one owner 2025 Rav 4 Hybrid- pulling into a parking spot while gently pressing on the brake to slow car. Car was slowing then suddenly accelerated while brake pedal still being pressed, lunged forward and hit a wall in front of the parking space. No warning lamps/alarms went off and drivers seat belt did not engage. Called dealership to report incident.

This is not about my car. It is about other cars. I have seen multiple SUVs traveling on the highway with their front lights on, but no rear lights. This happened the other day when it was dark and with heavy rain. This is a safety issue. A Gemini AI search says this is a problem with many new cars. It is a switch setting error. You need to correct this situation before someone gets rear ended. There should be no switch setting that allows driving with front but no back lights, or at least there should be a warning light on the dash board.

SUPPLEMENTAL TO COMPLAINT ID: 11728745. My 2025 RAV4 failed at 39,919 miles. Toyota Corporate is acting in bad faith to deny the 60,000-mile Powertrain Warranty. The Case Manager repeatedly calls only after 6:30 PM when the dealership is closed to avoid resolution. Furthermore, the representative is now using "legal threats"-directing me to their legal department-as a tactic to stop me from pursuing this valid warranty claim. This is a safety hazard and a violation of federal warranty law.

My 2025 Toyota RAV4 (39,919 miles) has a permanent "Check Engine" light. On March 18, 2026, diagnostic codes P24517F and P214502a were found, indicating a failure in the switching valve and fuel tank pressure sensor. Toyota USA and the dealer are refusing to honor the 60,000-mile Powertrain Warranty and Federal Emissions Warranty. I am reporting this as a safety defect because the vehicle may lose power or stall on the highway, creating an immediate crash risk. The manufacturer's refusal to repair a known emission/fuel defect in a new 2025 model has left me with an unsafe vehicle for over 15days.

I purchased this car used in December 2025 with 10k miles on it. After 15k mileage, the rear tires were bald and I had to buy new tires. I then took it back to the dealer and had to pay to get an allignment, as I was concerned that is what was causing the tires to go bald so fast. That was less than 2 months ago and now I'm in getting the 20k service appointment and the rear allignment is now off way more than when I paid to get it checked. Apparently the rear wheels cannot be adjusted? The right rear is way off and this is for sure causing uneven wear on my tires. It is for sure an issue and should not be, in that the car is new. It is obvious it is a fault in design and for sure can cause major safety issues, let alone burn my money up in needing new tires every less than a year.

The front camera fails which does not allow for the cruise control to operate. The speed odometer does not specify the correct speed when driving the car. The feature of telling you how fast you are supposed to go does not operate correctly specifying the wrong speed you are supposed to go. The tires have already been replaced because the metal was coming out of the tires causing the car to not operate correctly there was wobbling in the tires causing the car to feel like the tires were about to come off the tires. The transmission not shifting properly in eco mode.

Steering wheel showing red signal on the dashboard, and sometimes, when I park and want to restart the car , steering wheel block, not letting me start my car. Steering wheel block start about 5 months after I purchased the car and happened on August 2026.Steering wheel showing red signal start on July.

On 9/5, a car darted out in front of me while I was traveling straight at 45 miles per hour. I hit the brakes but t-boned him. The car then spins around and hits me again on the passenger quarter panel. No emergency brake, precollision no warning light came on. The airbag didnt deploy. I hit my chest on the steering while and my head on the window. The seat belt didnt lock me down. I purchased the brand new Rav4 a week prior.