1999 Toyota Tacoma Body & structure Problems

The contact owns a 1999 Toyota Tacoma. The contact stated that while driving at an undisclosed speed, the vehicle was not driving smoothly. The vehicle was driven to the residence. The contact stated that while disconnecting the trailer hitch, the contact proceeded to inspect the vehicle. The contact stated that the undercarriage was severely corroded. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 103,000.

NHTSA ID

11588530

Incident

Mar 5, 2024

Mileage

103,000 mi

Hi, i had the recall preventive performed by toyota for rusting and corrosion of the frame. Now, the vehicle is rusting throughout the frame and is very very unsafe to drive. TOYOTA is claiming that it was a program and not a recall and had no documentation to prove. Toyota performed the recall and now the frame is still at risk to crack and very unsafe.

NHTSA ID

11577368

Incident

Mar 14, 2024

The contact owns a 1999 Toyota Tacoma. The contact stated while driving at various speeds, an unknown popping sound was coming from the rear-end of the vehicle. Upon inspection, the contact discovered severe corrosion and a crack that had formed on the rear passenger’s side fender. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was 147,813.

NHTSA ID

11493076

Incident

Oct 20, 2022

Mileage

147,813 mi

TL* THE CONTACT OWNS A 1999 TOYOTA TACOMA. THE VEHICLE WAS TAKEN TO BE STATE INSPECTED, BUT IT DID NOT PASS DUE TO SEVERE RUST UNDER THE BED OF THE VEHICLE. THE CONTACT WAS INFORMED THAT THE LEAF SPRINGS WERE RUSTED AND NEEDED A NEW FRAME. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

NHTSA ID

11222126

Incident

Jun 24, 2019

Mileage

150,000 mi

TL* THE CONTACT OWNS A 1999 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 01E041000 (TRAILER HITCHES). THE MANUFACTURER HAD NOT SENT A RECALL NOTIFICATION. THE VEHICLE WAS PURCHASED FROM AN INDEPENDENT SOURCE WHO DID NOT MENTION IF THE VEHICLE WAS INSPECTED BEFORE IT WAS SOLD. THE CONTACT WAS NOT INFORMED OF THE VEHICLE'S EXTENSIVE RUST, CORROSION, AND HOLES PERTAINING TO THE FRAME UNTIL AFTER IT WAS PURCHASED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER ISSUED 14 TECHNICAL SERVICE BULLETINS REGARDING THE STRUCTURE. THE MANUFACTURER WAS CONTACTED TO DETERMINE IF THE RECALL REMEDY WOULD STILL APPLY. THE CONTACT WAS WAITING ON THEIR RESPONSE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

NHTSA ID

11174446

Incident

Feb 6, 2017

Mileage

103,000 mi

TL* THE CONTACT OWNS A 1999 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME WAS DETERIORATED AND RUSTED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE VEHICLE WAS NOT ABLE TO BE REPAIRED DUE TO THE FRAME. THE CONTACT RESEARCHED AND FOUND THAT THE VEHICLE WAS NOT INCLUDED IN A WARRANTY. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE FIFTEEN YEAR WARRANTY FOR THE FRAME HAD EXPIRED. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 164,603.

NHTSA ID

11172142

Incident

Jan 21, 2019

Mileage

164,603 mi

TL* THE CONTACT OWNS A 1999 TOYOTA TACOMA. WHILE DRIVING 20 MPH OVER A BUMP IN THE ROAD, THE CONTACT HEARD A LOUD ABNORMAL NOISE COMING FROM THE VEHICLE. UPON INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE REAR SHOCK ABSORBER FRACTURED AND THAT THERE WAS A HOLE IN THE FRAME. DEL TOYOTA (2945 LINCOLN HWY E, THORNDALE, PA 19372, (610) 383-6200) WAS CONTACTED AND STATED THAT THE VEHICLE WAS SOLD AS IS WITHOUT FURTHER ASSISTANCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000.

NHTSA ID

11160941

Incident

Dec 8, 2018

Mileage

83,000 mi

FRAME PERFORATED DUE TO RUST, UNSAFE TO DRIVE.

NHTSA ID

11129533

Incident

Sep 13, 2006

THE BODY IS TOTALLY RUST AND BROKEN. IS UNSAFE TO DRIVE. I AM THE THIRD OWNER

NHTSA ID

11123093

Incident

May 9, 2017

BOUGHT 99 TOYOTA TACOMA TRUCK.VERIFIED WITH DEALER WHO DID THE FRAME EXAM IN 2014 FOR RUST. AT 207000 MILES. IT PASSED IMSPECTIOM IN 2014??? NOW 4 YRS LATER AND 18000 ADDITIONAL MILES, IT'S RUSTED IN HALF?

NHTSA ID

11093513

Incident

May 9, 2018

Mileage

225,000 mi

99 TOYOTA FRAME IS RUSTED THROUGH WHEN CARFAX REPORT SPECIFICALLY LISTED A TOYOTA DEALER CHECKED SAME VEHICLE FOR FRAME RUST IN 2014 WITH 207000 MILES ON IT. IT PASSED IF THAT'S WHAT U WANT TO CALL IT. NOW IN 2018 WITH AN ADDITIONAL 15,000 MILES ON IT, IT HAS RUSTED THROUGH.

NHTSA ID

11093512

Incident

May 9, 2018

Mileage

225,000 mi

FRAME RUSTED OUT, CAUSING THE BODY TO DROP AND A BOLT TO SETTLE ON MY GAS TANK, RESULTING IN A FUEL LEAK. NEEDS A NEW FRAME TO FIX.

NHTSA ID

11041942

Incident

Oct 26, 2017

Mileage

156,000 mi

TL* THE CONTACT OWNS A 1999 TOYOTA TACOMA. THE CONTACT STATED DURING STATE INSPECTION THEY WERE MADE AWARE OF THE VEHICLE'S FRAME HAVING SEVERE CORROSION. THE SULLIVAN BROTHERS TOYOTA LOCATED IN KINGSTON, MA WAS CONTACTED WHERE IT WAS CONFIRMED THE FRAME NEEDED TO BE REPLACED. THE CONTACT DECLINED REPLACEMENT DUE TO THE COST OF THE REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 86,600. UPDATED 10/12/17*LJ *TR

NHTSA ID

11018837

Incident

Aug 21, 2017

Mileage

86,600 mi

WHEN I CHANGED THE OIL IN MARCH, I NOTICED A HUGE HOLE ON THE INSIDE OF THE LEFT FRAME MEMBER, NEXT TO THE GAS TANK. I THEN CHECKED THE RIGHT SIDE, AND FOUND A LONG LINE OF RUSTED THROUGH HOLES ALONG THE BOTTOM OF THAT FRAME MEMBER. I FEEL THIS IS A MAJOR SAFETY DEFECT BY THE OEM'S SELECTION OF STEEL GRADES.

NHTSA ID

11009908

Incident

Mar 20, 2017

Mileage

175,000 mi

THE FRAME HAS BEEN DIAGNOSED BY 2 SEPARATE REPAIR SHOPS AS BEING NOT DRIVABLE DUE TO HOLES. THIS MAKE AND MODEL WAS RECALLED FOR THIS REASON AND WAS BROUGHT INTO A TOYOTA SERVICE CENTER IN 2009. THE FRAME WAS INSPECTED "OK" AND NO WORK WAS DONE. THE FRAME IS NOW ROTTED AND I AM NOW BEING TOLD IT IS INELIGIBLE FOR REPAIR BECAUSE IT IS NOW OUTSIDE OF THE 15-YEAR WARRANTY WINDOW. THIS VEHICLE WAS, IN FACT, BROUGHT TO TOYOTA WITHIN THE WINDOW AND NOTHING WAS DONE ABOUT IT.

NHTSA ID

10995851

Incident

May 1, 2017

TOYOTA SENT A RECALL CARD IN 2011 TO RUST PROOF THE FRAME. THEY COVERED UP THE RUST AND SAID THE VEHICLE WAS GOOD TO GO. THE FRAME HAS RUSTED TO THE POINT THE VEHICLE IS NOT SAFE TO DRIVE. I HAVE A FRIEND THAT HAD THE SAME PROBLEM AND THEY PURCHASED HIS VEHICLE AND I KNOW SEVERAL PEOPLE HAVE HAD THEIR FRAME'S REPLACED AT NO CHARGE BY TOYOTA. THEY AVOIDED THE ISSUE AND NOW I HAVE A UNSAFE VEHICLE.

NHTSA ID

10992679

Incident

Jun 1, 2017

Mileage

180,000 mi

FRAME RUSTED SO BAD THERE ARE HOLES, AND A BRACKET HAS BROKEN LOSE CAUSING THE WHEEL TO MOVE. WAS TOLD TOO DANGEROUS TO DRIVE BY MECHANIC A COUPLE OF DAYS AGO.

NHTSA ID

10949215

Incident

Feb 1, 2017

Mileage

110,000 mi

HOLES RUSTED THROUGH ON FRAME. BELIEVE IT'S CALLED LIFT SPRING BRACKET BROKE BECAUSE OF RUST. MECHANIC INFORMED ME A COUPLE OF DAYS AGO WHEN I WANTED TO KNOW IF RUSTED OUT HOLE IN FRAME COULD BE REPAIRED

NHTSA ID

10949212

Incident

Feb 1, 2017

TL* THE CONTACT OWNS A 1999 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME ON THE VEHICLE WAS CORRODED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000.

NHTSA ID

10926925

Incident

Jun 16, 2016

Mileage

68,000 mi

THE FRAME IS RUSTING OUT AND FALLING APART. THIS HAS MADE THE VEHICLE UNSAFE TO DRIVE.

NHTSA ID

10914210

Incident

Jan 1, 2014

TL* THE CONTACT OWNS A 1999 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED SEVERE CORROSION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS CONFIRMED THAT THE VEHICLE WAS SEVERELY CORRODED AND THE REAR SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

NHTSA ID

10914187

Incident

Sep 29, 2016

Mileage

80,000 mi

THE FRAME OF THE TRUCK HAS COMPLETELY RUSTED THROUGH JUST BEFORE THE BACK DRIVERS SIDE WHEEL. IT HAS SPLIT COMPLETELY THROUGH THE METAL AND RUNS ALL THE WAY DOWN TOWARD THE FRONT . ALL THE WAY DOWN. IT SCARES ME TO DRIVE IT BNUT IT IS THE ONLY TRANPORTATION I HAVE AND NO CHOICE. THIS HAPPENED IN THE PAST YEAR.

NHTSA ID

10905975

Incident

Mar 1, 2016

Mileage

175,000 mi

TL* THE CONTACT OWNS A 1999 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE'S FRAME HAD RUSTED OUT. THE VEHICLE WAS TAKEN TO THE DEALER, BUT NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

NHTSA ID

10894825

Incident

Jun 15, 2011

Mileage

90,000 mi

TL* THE CONTACT OWNS A 1999 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS INSPECTED AT A TOYOTA DEALER FOR CORROSION. THE TECHNICIAN ASSURED THE CONTACT THAT THE VEHICLE WAS FINE. FIVE YEARS LATER, THE CONTACT BROUGHT THE VEHICLE IN FOR AN OIL CHANGE AND IT WAS DIAGNOSED THAT THE REAR SUSPENSION DETACHED FROM THE FRAME DUE TO SEVERE CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 172,000.

NHTSA ID

10887688

Incident

Jul 15, 2016

Mileage

172,000 mi

TOYOTA TACOMAS OF THIS YEAR ARE A SAFETY HAZARD DUE TO FRAMES THAT RUST THROUGH AND BECOME WEAK TO THE POINT OF FAILURE. TOYOTA HAS NOT DONE ENOUGH WITH ITS VOLUNTARY SERVICE REPAIR LEAVING THOUSANDS OF THESE TRUCKS ON THE ROAD AND PUTTING ALL DRIVERS AT RISK OF DEATH OR SERIOUS INJURY FROM FRAME BREAKAGE. TOYOTA SHOULD RECALL ANY AND ALL REMAINING TRUCKS AND PROVIDE FRAME REPAIR SUITABLE FOR SAFE ON-ROAD OPERATION. MY VEHICLE FRAME IS NEARLY ENTIRELY RUSTED THROUGH. IT WAS INSPECTED DURING TOYOTAS SERVICE CAMPAIGN AND FOUND NOT TO BE BAD ENOUGH FOR REPAIR, NOW IT IS TOO LATE AND NO LONGER QUALIFIES FOR REPAIR. THE PICTURE PROVIDED SHOWS MY DRIVER SIDE FRAME RAIL BOTTOM. THE TOP OF THIS FRAME RAIL IS SO SOFT I CAN PUSH THROUGH IT WITH MY FINGERS. THE PASSENGER SIDE FRAME RAIL HAS MARGINALLY LESS RUST THROUGH BUT IS STILL IN AN UNSAFE CONDITION. THESE VEHICLES ARE DANGEROUS AND SOMEONE WILL BE INJURED, IF SOMEONE ALREADY HASNT, AS A RESULT OF THESE POOR QUALITY FRAMES.

NHTSA ID

10885412

Incident

Jul 1, 2016