2004 Toyota Tacoma Owner Complaints

Immediately after the manufacturer recall requiring full frame replacement (completed November 2017 by the same dealership referenced below), the vehicle developed abnormal handling not present before the repair, including improper tracking and rear end instability. No warning lights/diagnostic messages were present. These issues were reported to the servicing dealership within weeks and repeatedly over the following years. Despite multiple short initial inspections and two extended service periods—totaling approximately fourteen months in the dealership’s possession—the dealership repeatedly reported no defect found and continued to advise that the vehicle was safe to operate. Due to ongoing safety concerns, an independent inspection was recently obtained. It confirmed measurable rear axle offset and a thrust angle deviation outside acceptable tolerances. The defect is visually apparent: the rear wheels are not symmetrically aligned, and the vehicle exhibits a noticeable “crab walking” effect when viewed from behind. The root cause remains undetermined and would require further diagnostic work and significant disassembly. All documentation and inspection findings are available upon request. Safety risk: The vehicle does not track correctly and shows instability, especially in low traction conditions such as rain or snow, increasing the risk of loss of control. The manufacturer has been formally notified through repeated outreach, including ongoing contact with the Brand Engagement Center since December 2025 and multiple certified letters to Toyota North America Legal/Consumer Affairs between January and March 2026. The only response received was a generic statement from the Brand Engagement Center indicating that the vehicle is out of warranty and an offer to return it to the same dealership that performed the frame replacement and failed to identify the defect. No other response, investigation, or resolution has been provided by Toyota North America.

NHTSA ID

11726891

Incident

Nov 20, 2017

I was turning into a gas station and all the sudden the vehicle came to a complete stop i was unable to move the vehicle and sat there until the tow truck was able to show up. Looked under the vehicle and on the passenger side front suspension the lower ball joint was no longer where it belongs.

NHTSA ID

11717952

Incident

Jan 31, 2026

My 2004 Toyota Tacoma was part of the frame replacement back in the fall of 2018 when Bobby Rahal Toyota in Mechanicsburg, PA has by truck for over 6 months while they replaced my frame.  It has been determined that my rear differential is rusted and is now to the point of needing replaced.  For over the last year I have tried working with Bobby Rahal to come to and understanding on having this repaired due to the fact that my mechanic believes that this rust is in fact the same issue as the frame and should have been replaced when the frame was.  All they will tell me is that the recall is closed and there is nothing they can do.   Very disappointed in the fact that this was handled when it should have been.  Now I am stuck trying to figure out how to pay for this myself.  I have taken very good care of my truck for over 21 years and there is no reason for me to have to pay out of pocket for something that they should have taken care of during the recall.  I don't have a lift to check the underneath of my truck, I trust when there is a recall that the dealership will do its job and fix everything safely and not put an unsafe vehicle back on the road and wait until a vehicle rusts completely through.  Bobby Rahal was also inspecting the truck at this time so they knew the rear differential was rusted.  My current mechanic said the Rear differential has been rusted since the time they replaced the frame and and has been for many years.   It is irresponsible for Bobby Rahal Toyota to have not replaced the Rear differential axel knowing it was rusted and unsafe.

NHTSA ID

11696970

Incident

Nov 18, 2018

The frame broke

NHTSA ID

11688089

Incident

Sep 1, 2025

The contact owns a 2004 Toyota Tacoma equipped with Toyo Tires, Tire Line: Open Country HT, Tire Size: 265/70/R16, DOT Number: CXLJA881918. The contact stated while driving at various speeds, the steering wheel was shuddering significantly. The vehicle was taken to Walmart for the tires to be balanced and the wheels rotated. The mechanic informed the contact that the service could not be performed because the front tires were out of round, the tires belts were separated, and the tire beads were fractured. The tires were not replaced. The tires were replacement tires. The manufacturer was notified of the failure and informed the contact that the tire warranties were not transferable from the previous owner. The vehicle failure mileage was approximately 144,549. The tires failure mileage was approximately 20,000. The VIN was not available.

NHTSA ID

11667780

Incident

Apr 18, 2025

Mileage

20,000 mi

I am writing to report a safety related issue with a 2004 Toyota Tacoma that I purchased from an auction on 12/21/2022. The vehicle has an expired recall that I believe has not been properly addressed, potentially affecting the safety of the vehicle. I have attempted to resolve this issue through Toyota's customer service and local dealership, but I have been informed that the recall is no longer active and will not be addressed. It has a Virginia rebuilt title. It failed inspection due to rust on the frame.

NHTSA ID

11656088

Incident

Dec 21, 2022

The vehicle has an open recall (NHTSA Recall #12V542) for the spare tire carrier lift plate. I brought the vehicle to a Toyota dealership to have the recall addressed, but the dealership refused to perform the repair, stating that the frame is too rusted to proceed safely. They recommended a full frame replacement due to severe rust damage, which includes holes and significant structural weakening. Toyota has refused to provide a replacement frame under any existing recall or warranty program. This means the recall cannot be completed, and the vehicle remains unsafe to drive. Additionally, I cannot locate a replacement frame for this vehicle through Toyota or the aftermarket, leaving no practical solution to address the safety risks. The refusal to honor the recall and the lack of available replacement parts put me and others at significant risk. The problem has been confirmed by the Toyota dealership during inspection, and the rust damage makes the vehicle structurally unsound. The unresolved recall, combined with the excessive frame rust, has created a double safety hazard that needs urgent resolution

NHTSA ID

11631075

Incident

Dec 13, 2024

Bringing to your urgent attention a significant safety concern regarding a 2004 Toyota Tacoma owned by my brother, [XXX] , bought in 2004, which has severe frame rust affecting the vehicle’s structural integrity and safety. Despite multiple attempts to resolve this matter directly with Toyota, we have been unable to obtain assistance, as Toyota states the Customer Support Notice for this issue has expired. Given the potential risk this poses to both the driver and other motorists, we are seeking your intervention to address this pressing matter. In September 2024, while retrieving an item from under the truck, my brother discovered extensive rust damage on the vehicle’s frame. We promptly took the truck to Antwerpen Toyota on September 4, 2024, where a technician confirmed the severe rust corrosion and deemed the truck unsafe to drive. The dealership informed us that Toyota had previously issued a Customer Support Notice addressing rust issues on this model but explained that the program had expired. They recommended we contact Toyota directly for potential support or compensation to help acquire a safe vehicle. We reported the case to Toyota (Case No. [XXX]) on September 4, 2024, and have since been in regular contact, yet have only been met with repeated delays and dismissals. Toyota representatives acknowledged that a notice had been issued for this problem, but despite knowing the serious nature of the rust and its impact on the vehicle’s safety, they have not provided us with any solution. We have requested escalation to senior management, but those requests have not been honored. Toyota’s refusal to address this safety defect, even with our willingness to discuss options, has left us with no alternative but to turn to your agency for help. We understand that the notice has expired and that my brother was not the vehicle’s original owner. However, this issue goes beyond a typical warranty claim, as it concerns the fundamental safety and road. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT

NHTSA ID

11624320

Incident

Sep 4, 2024

Vehicle was taken to dealer with frame rust, crack and holes. Toyota refused to fix , repair or offer parts to repair.

NHTSA ID

11568678

Incident

Jan 29, 2024

2011- check engine light was illuminated. Toyota dealership attempted repairs 11 times but could not find a cause. They replaced 7 different sensors, replaced gas cap, charcoal filter.. still could not get light to go off. refused to continue servicing same issue with no fault. Since 2011, I have had to run diagnostics on a regular basis to ensure there are no other mechanical issues. 2022- gas tank fell off of truck while driving. The straps snapped off due to rust and tank fell to the ground. This issue could have caused GREAT bodily injury or DEATH. 2023-lost brakes while driving. TOTAL brake failure. local mechanic stated it was a proportioning valve failure. The housing for it was rusted through and cannot be removed safely. After multiple days of research, a replacement could not be located. Even contacting Toyota, part is unavailable so vehicle CANNOT be fixed. Total brake failure could have led to GREAT bodily injury or DEATH. ONGOING-- vehicle frame is extremely rusted. bumper has fallen off, spare tire fell off, brush guard rusted and fell off. The frame under cab near bed of truck is rusted through. gas tank straps rusted through and tank fell off. You can literally push fingers/hand through the flaking metal. ALL previous recalls were completed including undercoating but the rust has gotten so bad the vehicle is not safe to drive.

NHTSA ID

11527190

Incident

May 30, 2023

Lower ball joint detached, nearly caused major problems for me on the road

NHTSA ID

11518998

Incident

Apr 25, 2023

The contact owns a 2004 Toyota Tacoma. The contact had taken the vehicle to Kolosso Toyota (3000 W Wisconsin Ave, Appleton, WI 54914) to have his exhaust replaced. While there, he was informed that the entire sub frame was corroded with several cracks and holes had formed around both front leaf springs. The mechanic informed him that the vehicle was unsafe to drive due to the failure. Prior to the failure, the contact took the vehicle to another local dealer where the vehicle was inspected under NHTSA Campaign Number: 05V225000 (Suspension). The contact was informed that a special coating was sprayed onto the sub frame to prevent corrosion; however, the recall remedy failed to prevent the corrosion. The manufacturer was contacted but provided no assistance. The vehicle was not repaired. The failure mileage was 51,641.

NHTSA ID

11513413

Incident

Jun 19, 2018

Mileage

51,641 mi

I was driving on a highway at the posted speed and suddenly the front right wheel broke off the vehicle and caused me to roll 6 times on the highway and I was wrongly accused of being at fault.

NHTSA ID

11512108

Incident

Jul 27, 2021

Mileage

200,000 mi

Bought the vehicle in May 2022 from a dealer. By November of 2022 it was discovered that the frame was totally rusted. The dealer won't help so I paid $10,000 for a truck that lasted 6 months. I then found out this was a common problem that Toyota knew about so I called them for assistance. They would not help. I have been renting a vehicle at a cost of $800 a month because I don't have the money to buy another vehicle.

NHTSA ID

11511452

Incident

Nov 1, 2022

What component or system failed or malfunctioned, and is it available for inspection upon request? The whole frame, the chassis, it is rusty specially in the front How was your safety or the safety of others put at risk? when the rusty becomes worse, it will compromise the entire vehicle estructure, even the suspension and wheel parts. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, I can see Toyota run a recall process until 2019 Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No, just regular shop service, on which they reported high damage for the suspension and frame parts. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear?. It is making bad noises and suspension parts are difficult to replace

NHTSA ID

11507649

Incident

Jan 10, 2023

The contact owns a 2004 Toyota Tacoma. The contact stated while driving 20 MPH and making a right turn, the vehicle lost motive power and stalled. There was no warning light illuminated. The contact was able to veer to the side of the road. The vehicle failed to restart after several attempts. The vehicle was towed to the dealer, where it was diagnosed that the Electronic Fuel Injection (EFI) main fuse had blown due to a short circuit. The dealer replaced the Electronic Fuel Injection (EFI) main fuse; however, the failure persisted. Additionally, the dealer diagnosed that the subframe was severely corroded, including transmission components and fuel system components. The manufacturer was notified of the failure and informed the contact that they could not assist as unknown recalls had expired. The vehicle was not repaired. The failure mileage was approximately 150,000.

NHTSA ID

11501675

Incident

Nov 13, 2022

Mileage

150,000 mi

Frame is badly rusted as a result truck is not driveable..

NHTSA ID

11496303

Incident

Dec 1, 2022

The contact owns a 2004 Toyota Tacoma. The contact stated that while looking underneath the vehicle, he noticed that the subframe was rusted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 176,000.

NHTSA ID

11491583

Incident

Oct 30, 2022

Mileage

176,000 mi

I was driving home from a neighboring city after picking up a friend and on my way there on the interstate I noticed the back end of the vehicle was very loose. Upon arriving at my apartment and parking the vehicle I contacted a friend who was a prior state safety inspector, he looked under the vehicle and said the frame right where the shackle for the leaf spring on the driver's side had completely blown out and was no longer connected. Checked the passenger side and said it was connected by maybe 1/4 of an inch of frame. I was made aware of a safety recall that expired back in 2019 by Hailey Toyota and was informed they would not fix it for free. Neither myself or the original owner had every received documentation regarding this issue and was never informed that the entire frame had to be replaced under the recall/extended warranty. I have shelled out well over $600 in materials and labor to have my frame welded and patched with a kit specifically made for these vehicles and this issue and I'm still having problems out of it.

NHTSA ID

11490724

Incident

Sep 19, 2022

Took Toyota Tacoma (2004) to have loud sound coming from under truck checked by a reputable mechanic. Told that the frame was rusted beyond repair & leaf springs were about to fall out. Mechanic said vehicle was not drivable. The recall (which ended in 2019) was never received even though we bought vehicle new & have not changed address since 1998. Recall should be extended. Toyota should be forced to fix the problem and not on their timeline. The noise became evident approx. 5 months ago & got louder. The truck is sitting in our garage & could be taken to any interested party for inspection. Thank you

NHTSA ID

11487300

Incident

Sep 29, 2022

The contact owns a 2004 Toyota Tacoma. The contact stated upon taking the vehicle to an independent mechanic for a tire replacement, he was informed that the passenger’s side subframe was severely corroded. The contact notified several unknown dealers of the failure. The dealers informed the contact that there was no recall associated with the VIN. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 233,000.

NHTSA ID

11485662

Incident

Sep 20, 2022

Mileage

233,000 mi

Excessive Corrison through out the frame.Was informed bu certified mechanic really it is unsafe to drive. What can I do I still owe money on this vehicle.

NHTSA ID

11485341

Incident

Aug 23, 2022

The contact owns a 2004 Toyota Tacoma. The contact stated that while driving approximately 55 MPH, the passenger’s side axle fractured and the wheel detached. There were no warning lights illuminated. The vehicle was towed to an independent mechanic who replaced the ball joints. The local dealer was not contacted. On another occasion, while driving at an undisclosed speed, the driver’s side axle fractured and the wheel detached. The vehicle was towed to an independent mechanic who replaced the ball joints however, the failure recurred. The contact stated that the failure was related to NHTSA Campaign Number: 05V225000 (Suspension). The manufacturer was contacted but provided no assistance. The approximate failure mileage was 190,000.

NHTSA ID

11484796

Incident

Oct 11, 2018

Mileage

190,000 mi

Financed a 2004 Toyota Tacoma and found that frame of truck is rusted out and not sure what to do, can't afford new frame and still owe a little over 9 grand for it....please advise what to do next. Thank u

NHTSA ID

11483273

Incident

Aug 1, 2022

The frame has rusted and broke behind the cab

NHTSA ID

11471457

Incident

Jun 20, 2022