Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 540 NHTSA owner-reported complaints for the 2007 Toyota Tacoma. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 540 · page 1 of 22
I tried to take my 2007 Toyota Tacoma for a recall about the leaf springs to Modern Toyota in Winston-Salem, NC. Modern Toyota took my truck for inspection, but upon return, informed me the would not replace the component nor were the obligated to do so.
Single car accident resulting in rollover. Concerns about NO airbag deployment
I have a well cared for, garaged 2007 Tacoma. It had a recall for a known frame corrosion issue. I had it inspected by Toyota and they chose not to replace the frame, choosing instead to apply a CRC spray in 2016. I have learned that my vehicle was sprayed by a formula that was later known to Toyota to harbor water and accelerate rusting. My vehicle has just failed state inspection and was identified to have a cracked frame in two places. Both left and right sides of the frame, behind the cab, and directly across from one another. The fact that Toyota now chooses not to honor any warranties, or provide consumer help, (I just spoke with their "Brand Engagement Center"), when I am the recipient of 2 known and compounding failures seems a dereliction of responsibility. I have a vehicle that should have a lot of service life left but for inadequate steel being used in production, that was then given an inadequate remedy which was later discontinued by Toyota after being found to accelerate corrosion. This seems like an obvious case of manufacturer responsibility but I'm being told I'll receive no assistance from the Toyota corporation. I wonder whether the inspection done in the first place was adequately and responsibly performed.
Low miles 78000 in 2017 at 51000 miles toyta opted not to replacetbe frame and only treated it with crc now it is rusted out bad and unsafe to drive
The contact owned a 2007 Toyota Tacoma. The contact's lawyer stated that another vehicle lost control due to a dropped water bottle and collided with his client's vehicle on its front driver's side at 50 MPH. The contact's lawyer stated that no air bags deployed. The contact's lawyer stated that the contact sustained injuries to the pelvis, which was fractured, a concussion, and contusions to the head, left leg, and a laceration to the head and back. Medical attention was required. The contact's lawyer stated that a police report was filed. The contact's lawyer mentioned that the contact was in a coma for two months and was on a ventilator for four months. The vehicle was towed to a private location. The vehicle was deemed a total loss. The contact stated that the failure was not diagnosed by a dealer or independent mechanic. The manufacturer was not notified of the failure. The approximate failure mileage was 500,000.
My 2007 Toyota Tacoma has an open recall on the rear leaf springs due to the risk of fuel tank puncture and fire. However, Toyota and their authorized dealership are unable to perform this safety recall because the vehicle’s frame is too severely rusted. The dealership informed me that attempting the repair could further damage the vehicle, and they requested I sign a waiver releasing Toyota of liability if harm occurs during the recall process. They also informed me that replacement frames are no longer available, so the recall cannot be completed as I was interested to pay for this to get the recall safely completed This leaves me with a vehicle that presents a known, life-threatening safety hazard, which Toyota cannot resolve. The frame corrosion is due to a previously acknowledged defect for which Toyota offered limited-time frame replacements that expired before I owned the vehicle. I believe Toyota is violating its obligation to provide a remedy for this open recall. I am requesting that NHTSA investigate this issue, as it appears Toyota is leaving customers with dangerous, unrepaired vehicles and no available remedy.
It was determined by the Toyota dealer where this vehicle was purchased that there are rust holes in the frame. This vehicle's mileage is less than 100,000 miles. I understand there was a recall at one time however the Toyota dealership advised that this truck was not one of the vehicles in the recall at that time. This truck has always been garaged, has low miles and well maintained. You would think it would be able to be driven another 150k miles. This is a safety issue and I don’t feel I should be penalized for taking good care of this vehicle. It is a known fact within the industry that Toyota used bad steel for their frames during this year if manufacture. Please advise what you can do to remedy this situation. Thank you
The contact owns a 2007 Toyota Tacoma. The contact received notification of NHTSA Campaign Number: 14V604000 (SUSPENSION); and the vehicle was taken to a local dealer for the recall repair; however, the dealer declined to service the vehicle because of the excessive rust on the subframe of the vehicle. The contact was informed that the subframe needed to be replaced before the recall repair could be performed. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 198,000.
Purchased my 2 tacoma in 11/24 second party learned of leaf spring tested and failed sent me home in rent a car demanding it back 2 min upon my arrival home due to the frame was damaged. Said they put it up on lift but didn't it was too dangerous. Had to he my vehicle out of their shop Saturday morning without the fix. Driving it off the lot from toyota Pittsfield Massachusetts. Called another toyota she sees in 16 it was inspected with recall but never fixed. I know if a pervious owner was aware who wouldn't get a fix for free? It came from an auction, a.dealership according to history. With no reports of it ever being fixed. I believe from much research this is the second recall for leaf springs. It was never explained to be except via text that it was terrible w insulation shoved in parts. Who had done it I'm not sure. CT. Toyota is amazed by the treatment I endured from Pitts toyota. Noone spoke to me.of alternatives, danger, cost to fix but just let me drive away unsafe. I'm appalled that toyota gets away with this when so many people are at risk. New tires oil change and this test Noone saw?? Until it was being cared for but refused. NO. It should be fixed all of this issue. The truck as many is in great shape engine everything for this is why I purchased it also knowing thinking how great totota is/was would be fixed being a federal recall. There are 10s of thousands of consumers still with this issue that most were unaware of. I was never personally told except a message.
The frame has been rusting real bad and seen other Tacomas same year and style have the recall. Especially rusting where the running boards were attached too
The springs or decks are in poor condition, the material, I want to know if they have a warranty.
Despite dealer treatment of the frame in 2014 and an inspection in 2017 the frame rusted through and snapped where the bed meets the cab.
These vehicles have frame rot. It was addressed in cold weather states with a recall but the recall was not available in California. My vehicle was a california only truck. The corrosion if undressed will result in the frame breaking in half behind the rear left passenger seat. Toyota should have included all states in this recall and there are an abundance of toyotas manufactured from 2005 to 2010 on the road with this issue that are ticking time bombs. My vehicle only has 145K miles on it.
Over the years, Toyota has had to issue numerous recalls for their Toyota Tacomas and frame replacements/maintenance required by Toyota due to rust and corrosion. However, Toyota chose not to replace all frames, instead decided to "treat" the issue with underspray. My Toyota, like many others, has received the recalled Toyota undercoat spray to prevent rust and corrosion on a frame with known issues (once in 2015, another in 2019). I have just received a phonecall from my mechanic that my frame is now unsafe to drive and needs to be fixed or replaced. However, Toyota has claimed they have no guarantee on the vehicle and it isn't there problem because it is outside of the timeframe. However...this car DID participate in their recall 2x. And the recall and work done did not solve the problem or the recalled part: The frame that his crippled by corrosion and rust due to a flaw in the manufacturing process. This is leading to a car that is due for a very significant, expensive improvement that was at no cause by owners actions, or a very unsafe HIGH NUMBER of vehicles still on the road with failing frames due to Toyota's inability to fix their root cause issue on their initial recall in order to save a few bucks.
My Tacoma has a frame rust issue. I have been told that Toyota did a "voluntary recall" and replaced rusty frames under warranty but that program has ended. This is terrible because it wasn't in an official NHTSA recall, so a Carfax says nothing of 5his issue. I contacted Toyota and they are unwilling to do anything. I have been told that my frame can break in half while driving When reading about this issue, it seems like Toyota did not replace all frames. Instead, there was some way based on the state you lived in as to if you could get a frame replaced. My truck was titled in California. Can someone please help me to get Toyota to repurchase the vehicle from me, allow me to trade it in on a new truck, or replace the frame in the same way they had done so in the past? Thank you.
Frame corrosion safety card never been reported to us by mail, I stop by the dealer and they say is expired the recall. I reported to toyota springfield VA. they say this recall is close back in 2019 and they not be able to fixed. corrosion is extremely serious!
I bought this tacoma last year to someone who don’t do the chasis recall and I like to know if any possible way to do it. this chasis it’s in a very bad condition let me know what I can do thanks
The contact owns a 2007 Toyota Tacoma. The contact's husband took the vehicle to a service shop for maintenance and was informed of corrosion to the subframe of the vehicle. The contact took the vehicle to the local dealer, where it was diagnosed with needing the passenger’s side rear frame rail, leaf spring, and several other areas replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 189,000.
Gas tank gas strap bracket rusted off
Frame is massively rusted and is hazardous. Need full replacement.
As part of the Tacoma Frame Replacement program (ZH6 and H0F), I brought my Tacoma to my Toyota dealer. They deemed my frame to NOT qualify for the replacement and lazily applied corrosion resistant spray to the rust on the frame that quickly flaked off. As soon as the program ended, the frame deteriorated quickly. There are 3 spots on the frame where my hand can slide through near the front of the frame on both the driver side and the passenger side. I have removed about 5 pounds of frame/rust from the interior of the frame and the exterior of the frame. I have contacted Toyota several times and been told that there are no appeals or anything I can do except pay for a new frame out of pocket, sell, or try to repair.
Frame is completely rusted. the rear gas tank strap where it attaches to the frame corroded through and the strap dropped and was dragging on the ground. the gas tank also dropped and made it difficult to remove the gas cap. upon further inspection the frame is completely rusted through in spots. in 2014 a rust protective coating was applied by a dealer. it did nothing to stop the rust it just covered it. the steel is delaminating underneath the coating. It was just a band-aid to get them out of warranty period. these frames should have been a full recall. the strap could of easily hit the ground and bounced up and punctured a brake line or the gas tank. with it sparking on the ground a fire could of happened. The tacoma is in immaculate condition except for the frame. this is my 4th toyota and the only one that has had a problem.
2007 TOYOTA TACOMA. CONSUMER WRITES IN REGARD TO RUSTED FRAME. THE CONSUMER IS REQUESTING ASSISTANCE WITH A RUSTED FRAME AS THE VEHICLE WILL NOT PASS INSPECTION DUE TO THIS DEFECT.
We bought the truck used in 2021 when it had 114,000 mi. Looked great, drives great. Now our mechanic tells us there are rust spots all over the frame — and that there is a recall. I looked into the recall and the window closed last year. Is it legal for Toyota to stop a recall when it is such a big safety issue? Buyers of used cars need to know about this site to check for recalls. I think very few people know about this app.
Yesterday, 7/27/2022, I had my 2007 Toyota Tacoma Access Cab at my mechanic's shop for a minor issue. While on the lift he noticed significant rust on the frame rails. He brought me over and showed me extensive areas where the metal was completely rusted through. I have never seen anything like this on even the oldest of vehicles. Subsequently I did a search online and found that this was a known issue for many years of Tacoma truck frames, but I was never notified by Toyota or anyone including the local Toyota dealer where I have had services done. I cannot believe a company as well established as Toyota would allow such a potentially serious problem to go unaddressed. Toyota should be held responsible for selling defective and dangerous vehicles and be required to effect repairs as soon as possible completely at their cost. (see article below) https://www.vehiclehistory.com/articles/toyota-tacoma-most-years-are-reliable-but-some-2005-2010-models-struggle-with-rusty-frames-faulty-leaf-springs
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .