2016 Toyota Tacoma Owner Complaints

Toyota has a paint problem on the tacomas. The paint is the bright white, .040 . They have painted all 4 doors,both front fenders and the pillars on each side of the windshield. I’m having the same problem on my hood,top of windshield and bed . Toyota refuses to take responsibility for these areas. They call this a customer satisfaction program instead of a recall so they don’t have to paint the whole truck. I have a 25 year old truck that has better paint than it. I just wanted to let you know about this situation. Thanks [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11748666

Incident

Oct 1, 2022

The contact owns a 2024 Ford Edge. The contact stated that the vehicle was shaking while driving. The contact noticed there was fluid emerging from the rear of the vehicle near the tire. There were no warning lights illuminated. The vehicle was taken to the local dealer, who confirmed there was no recall or leak. The vehicle was not repaired. The manufacturer was contacted, who referred to the local dealer. The failure mileage was approximately 100,000.

NHTSA ID

11738757

Incident

May 16, 2026

Mileage

100,000 mi

The original low pressure fuel pump failed at 114,700 miles. The symptoms of the failure were loss of power on the freeway, quickly followed by the engine stumbling, then shutting off completely forcing me to change lanes without power. The vehicles has had to be towed on 2 occasions because of this. The pump was replaced at 114,700 miles by a Toyota dealer at my own cost (no warranty, no recall). Now only 20k miles later the fuel pump has failed again. This issue has put my family at serious risk of accident to complete engine shut off at highway speeds. Now that I am on my third low pressure fuel pump, I have little confidence that this is being addressed by the pump manuf. and Toyota.

NHTSA ID

11736613

Incident

Nov 24, 2023

Dear Toyota Japan Customer Experience Team, I am the owner of a 2016 Toyota Tacoma currently registered in Guam, U.S.A. I am writing to request your assistance regarding a water leak issue from the rear brake light area, which has caused the carpets and seats to become wet and develop mold. I originally purchased this vehicle in Saipan and recently relocated to Guam. When I visited the Guam Toyota Service Center, they kindly inspected my vehicle and informed me that this issue is related to the 3rd brake light gasket recall; however, the recall period has already expired. Unfortunately, I was never notified of this recall while the vehicle was in Saipan. Continuous exposure to mold has seriously affected both my health and my daughter’s health. Because of this, I had the vehicle professionally cleaned and sanitized by a specialist company. The Tacoma has always been our family’s favorite car, but now I drive it only because I have no choice. Every time I get in, I feel anxious and uneasy. The water leak itself is concerning, but the mold issue worries me even more. I truly hope this water leak and the mold problem can both be resolved so that I can once again enjoy driving my Tacoma with peace of mind. The blue circles in the attached photos indicate areas suspected of mold. These photos were taken right before I sent the car for cleaning. According to the cleaning company, when they removed the seats, they found water underneath the seats and carpets. Whenever I drive the vehicle, I experience persistent coughing and headaches due to mold exposure. This has become a serious health and safety concern. Since this issue is directly related to a previously recalled safety defect, I kindly request Toyota Japan to consider a Goodwill Repair or Safety Exception to address the water leak and the resulting interior damage.

NHTSA ID

11730507

Incident

Oct 21, 2025

Severe clear coat and paint fading on hood, roof and sides of truck.

NHTSA ID

11724836

Incident

Jul 10, 2025

2016 Toyota Tacoma is known to have an issue with the timing cover leaking oil. This is a Fire Hazard: Oil leaking onto hot engine components can vaporize and ignite, posing a fire risk to the vehicle and surrounding areas and can cause environmental pollution.

NHTSA ID

11722712

Incident

Jul 5, 2024

The rear passenger door lock actuator on my 2016 Toyota Tacoma failed prematurely, causing the door to no longer lock or unlock properly. The failure required replacement of the entire actuator assembly at a Toyota dealership at a cost of $727.19. This failure occurred without abuse or unusual use and is not consistent with normal wear and tear. I am aware of numerous similar complaints and pending class action lawsuits involving door lock actuator failures across multiple Toyota models, indicating this is a known and recurring defect. A door that cannot reliably lock or unlock presents a safety and security concern, particularly for passengers and children, and increases the risk of unauthorized entry or inability to exit the vehicle in an emergency.

NHTSA ID

11710609

Incident

Jan 5, 2026

2016 Toyota Tacoma – severe clear coat and paint failure on the hood and roof. The clear coat began peeling in 2022 and has progressively worsened. Large sections of the hood and roof show complete delamination, oxidation, and exposed basecoat. This is a widely reported defect for 2015–2017 Tacomas across multiple paint colors. Toyota Customer Care confirmed today that my VIN is not included in Customer Support Program 23TE08 and that no goodwill repair would be authorized, even though the defect is identical to the vehicles Toyota acknowledges as affected. This appears to be a manufacturing defect that compromises durability and corrosion resistance. Photos and documentation are available upon request.

NHTSA ID

11702846

Incident

Jan 1, 2022

Paint on hood and roof is fading significantly.

NHTSA ID

11701789

Incident

Nov 27, 2025

The seat heater pins have melted, leaving black residue. thus showing possibilities of a fire

NHTSA ID

11699183

Incident

Mar 12, 2024

The contact owns a 2016 Toyota Tacoma. The contact stated that while driving, there was a musty odor coming from the interior of the vehicle. The contact was unable to locate the source of the odor. The contact stated that on a separate occasion, while vacuuming the vehicle, the contact noticed that the carpet and floor mats from the rear passenger’s side were wet. The vehicle was taken to the dealer, where it was diagnosed and determined that the rear quarter duct vents had fractured, and water was entering the interior of the vehicle. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 80,000.

NHTSA ID

11696786

Incident

Aug 21, 2025

Mileage

80,000 mi

Bought 2016 Tacoma in 2022 w/ 53k miles. Hit 58,850 (ish) and had an noticable oil leak… apparently this was a “Well Known” issue, as the mechanic @ Surprise, AZ Dealership (Toyota of Surprise, 13543 N. Auto Show Ave., Surprise, AZ 85388) told my wife and I…. it’s from this same thing that google showed me also: “Engine oil leaks: Reports on Consumer Reports and other forums detail expensive repairs to fix oil leaks from the front seal or timing cover, which can cost $5,000 or more because the engine often needs to be removed for the repair.” And this was 100% my case- and confirmed by the Toyota Dealers Mechanic verbally. Leaks were without engine light indicators “at all”. The dealership added a dye, told me to drive 100-500 miles and return to have a re-inspection done after their initial one came with no results. Initially I spotted this while I was conducting a regular 3,000 mile oil change. (2nd oil change since owning the truck. So my out of pocket was around $5,700+, for an apparent (see attached) “well-known” Dealer issue. @ 60k, a major repair cost for this should NOT but coming from the consumer, and needs to be listed as a “recall”. Had I not noticed the missing oil, this could have left me stranded, my family stranded, or caused many other traveling issues throughout my driving experiences. I repaired this around two years ago, but have been terrified to drive my truck! I’ve driven about 1,000 miles or less since the repair (in 2 years time). I’m selling first chance I can, BUT, I WANT MY MONEY BACK! I have the receipt in a safe for when this becomes a recall - to prove i paid it, and to get a FULL REFUND!!! That is not how good business is done by Toyota. I owned a 2004 and 2005 Camrys prior, as well as a 2014 Lexus GS 350 F Sport (all in my name), this truck was a dream, now a nightmare. Please, for everyone complaining online and those that have had to also pay for these repairs @ low mileage, MAKE THIS INTO A RECALL FOR 2016 TACOMAs.

NHTSA ID

11693320

Incident

Nov 27, 2023

I am reporting a persistent and unsafe issue with the factory-installed Entune infotainment system in my 2016 Toyota Tacoma. While driving — whether locally or on the highway — the system frequently freezes, becomes unresponsive, or abruptly resets itself, often multiple times per drive. This directly affects my ability to safely use the navigation, backup camera, and audio controls while in motion. The system’s crashes divert my attention from the road, especially when I’m relying on navigation and it either stops functioning or forces me to interact with the screen to regain control. These interruptions increase the risk of distracted driving and could easily contribute to an accident. I have attempted to install the software update provided on Toyota’s official website, but the update is older than the version already installed on my vehicle (0101A0), so the system blocks the update. There is no way for a consumer to reinstall or flash the current version, and any potential resolution is only available at a dealership for a fee, effectively putting the fix behind a paywall. Toyota has not issued a recall or service bulletin for this issue, despite dozens of reports from other owners on Tacoma and Prius forums describing the same crash behavior and software version conflicts. This is a significant safety concern, especially when the infotainment system is used for navigation during high-speed or complex driving conditions. The inability to maintain consistent functionality puts drivers and others on the road at risk. I am requesting that NHTSA investigate this widespread issue and press Toyota to issue a free repair or software patch for all affected vehicles. Symptoms: •Frequent infotainment restarts while driving •Frozen or unresponsive touchscreen •Glitched navigation system and lost GPS routing •Driver distraction due to repeated system failure

NHTSA ID

11677329

Incident

Jul 1, 2025

I have experienced two major failures on my 2016 Toyota Tacoma TRD Sport with less than 90,000 miles: a leaking coolant crossover pipe, which required partial engine disassembly and cost me approximately $2,500, and a leaking timing chain cover, which required a full front-end teardown and cost over $4,500. Both issues are known problems across 2016+ Tacoma models with the 3.5L V6 (2GR-FKS engine), yet Toyota has not issued a recall or warranty enhancement. These failures present safety risks related to overheating and oil loss and result in significant financial burden to owners. Toyota needs to be held accountable for these premature, design-related failures.

NHTSA ID

11670387

Incident

Dec 7, 2022

During a safety inspection, it was found out that the steering rack was leaking. In a quick research on Google, it appears that many people that own this particular year and tacomas are experiencing the same issue. It is the first time for any car that we own and we keep our cars for more than 10 years. To us, this could be a manufacturing defect that should be investigated and a recall issue. We had it fixed so it can pass inspection, but something just doesn't make sense.

NHTSA ID

11669160

Incident

Jun 20, 2025

When using four-wheel drive, the vehicle was unable to make a left turn. I disengaged four-wheel drive, and the vehicle was stuck in four-wheel drive. This happened on two occasions. The first time was approximately August 2022 and the second time was last year. When I took it to the dealership, they said here was nothing wrong with it and they told me that I probably used the four-wheel drive incorrectly. Luckily, I was able to get the truck into a parking lot. The way that I was able to disengage it was to put the truck into reverse and back up a few yards then go forward a few yards and repeat until I hear a loud thump.

NHTSA ID

11644868

Incident

Apr 1, 2024

Heated seat had stopped working, checked and found the problem. The module that controls the heated seats had a melted connector and wires, causing the seat to no longer be able to have heated seats.

NHTSA ID

11635559

Incident

Jan 10, 2025

Upper Intake manifold flap actuator ( part: Toyota 17190-0P101 ) brakes in the intake resulting in wrong air reading and forcing vehicle into limp mode causing the vehicle to rapidly decrease speed, and creating a potential accident with other vehicles and semi's. this will continue to happen but this will give a person a false sense of security since error codes will reset once vehicle is turned off and on, a reassurance to a person that the issue has resolved itself since this will only happen at high speeds. the part is designed for fuel efficiency, as the flap opens and closes air is controlled properly for emission, but once broken will throw error codes, and force vehicle into limp mode this part is not be repairable, the part needs to be changed completely. this would happen to me while accelerating on highways, up mountain passes and pushing vehicle over 4000 rpm.

NHTSA ID

11630259

Incident

Apr 10, 2024

Rear Coolant Bypass Joint leak. Coolant leaking through this pipe and accumulating.

NHTSA ID

11626758

Incident

Nov 1, 2024

Paint is chipping off in several places and have read this is a major problem with tacomas in the white color

NHTSA ID

11622470

Incident

Oct 10, 2024

Coolant leaking

NHTSA ID

11620850

Incident

Oct 20, 2024

The paint on my 2016 Toyota Tacoma is failing after a few years of owning the truck, it has been well maintained and washed but the problem keeps getting worse. I have searched online and it seems to be an issue with white and magnetic grey colored Toyota cars but no recall on magnetic grey paint.

NHTSA ID

11619340

Incident

Jan 1, 2018

Seat heating module for my driver seat has melted and is further irrepairable without buying the entire harness to fix the issue. There are multiple reports of this happening across forums.

NHTSA ID

11617153

Incident

Apr 22, 2024

I have recently been made aware of the Super White paint recall and know that is not yet in full force or able to be serviced at this time. That being said, it appears that the recall only covers " paint peeling along the exterior door window frames and front inner fenders under the hood on certain Tacoma vehicles with 040 Super White paint color", But there are multiple reports of this entire paint job being defective over multiple generations as well as paint outside of these areas specified. This recall should cover an entire repaint and is extremely frail in quality otherwise.

NHTSA ID

11617152

Incident

Apr 22, 2024

I purchased the vehicle new and noticed right away that the transmisson would clunk right away when I put it into gear[ it's an automatic]. I asked the dealership about it and they said it was normal and no issues. Now I'm [XXX] and have owned many cars so.... Anyway, over the years I've asked several times and they say no issue. Now, just this morning, my wife found an article about the issue and Toyota is finally admitting there IS an issue. What can I do? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11614574

Incident

Sep 14, 2024