2011 Toyota Tundra Brakes Problems

On 11/25/22 I meet with American Auto Mall to buy a used truck I was assured through text, website and window sticker that the truck was in excellent condition inside and out.. I have all this documents proofing this.. I did van limited inspection at the lot and a test drive.. found nothing that stuck out.. other than the radio not working but the dealership said he would reimburse me if I got it fixed..so after that a down payment was made of $5550 dollars and paperwork was signed.. I drove the truck home and the next week I got in it and it wouldn't start, turns out it needed a battery and alternator, so I took it to a shop and was told that this vehicle was badly rusted and had a lot of hidden rust damage.. and improperly installed brakes., coolant leaks and exhaust leaks.. after finding this out I tried to call the dealership and he hasn't been replying.. I was also told this truck wouldn't pass a legal VA inspection.. so the current one was fraudulent I have all documents that support my case. I will like to turn this vehicle back in and given a full refund

NHTSA ID

11497842

Incident

Dec 12, 2022

WHEN ENGAGING BRAKE PEDAL TO STOP IF MY FOOT IS TO THE RIGHT ON THE PEDAL THE SPONGY BRAKE PEDAL TO CONTINUES ALMOST TO THE FLOOR THUS CAUSING ME TO PRESS ON THE ACCELERATOR PEDAL CAUSING THE TRUCK TO ACCELERATE WHEN I NEED TO STOP, VERY DANGEROUS.

NHTSA ID

11343477

Incident

Aug 5, 2020

Mileage

150,000 mi

TL* THE CONTACT OWNS A 2011 TOYOTA TUNDRA. WHILE DRIVING AND DEPRESSING THE BRAKE PEDAL, IT TRAVELED ALL THE WAY TO THE FLOORBOARD. THE CONTACT STATED THAT THE VEHICLE TOOK LONGER TO COME TO A COMPLETE STOP. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO MIKE CALVERT TOYOTA (2333 S LOOP W, HOUSTON, TX 77054, (713) 558-8100) WHERE IT WAS DETERMINED THAT THE REAR BRAKES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 66,500. THE VIN WAS UNKNOWN.

NHTSA ID

11282256

Incident

Oct 25, 2019

Mileage

66,500 mi

WHILE DRIVING TO WORK ONE MORNING, MY BRAKE PEDAL WENT DIRECTLY TO THE FLOOR WITH ALMOST NO STOPPING CAPABILITY. AFTER FINALLY GETTING THE VEHICLE TO STOP, THE PEDAL FELT NORMAL. THE NEXT DAY A SIMILAR SITUATION OCCURRED. SINCE THE OCCURRENCES WERE INCONSISTENT IN TIMING, SITUATION AND DRIVING CONDITIONS, IT WAS NOT EASY TO REPLICATE. UPON TAKING IT TO A LOCAL DEALERSHIP, THEY HAD THE SAME DIFFICULTY CAUSING IT TO HAPPEN. ALTHOUGH, ON THEIR "LAST" TRY, IT WENT TO THE FLOOR. LOCAL DEALERSHIP COULD NOT DIAGNOSE THE SPECIFIC ISSUE AND CALLED IN AN ENGINEER FROM TOYOTA. ULTIMATELY, SINCE THEY COULD NOT ISOLATE ONE SPECIFIC FAILURE, THEY DECIDED THAT THE *MAIN COMPONENTS OF BRAKE SYSTEM SHOULD BE REPLACED. *MAIN COMPONENTS INCLUDE MASTER CYLINDER, BRAKE BOOSTER AND ABS ACTUATOR. AS THE SERVICE TECHNICIAN INDICATED THAT THEY HAD SEEN SEVERAL OF THESE, I BEGAN A CASE WITH TOYOTA MOTORS USA TO TRY AND GET A CLEAR UNDERSTANDING WHETHER THEY THOUGHT THIS TO BE AN ISSUE. AFTER ALL, THIS VEHICLE IS MARKETED AS HAVING ONE OF THE MOST ROBUST BRAKE SYSTEMS IN ITS CLASS. TOYOTA MOTORS USA INDICATED IN EMAILS THAT THEY HAD NO INTEREST IN REVIEWING AND TOLD ME THAT AS THE CUSTOMER, I HAD EVERY RIGHT TO CHOOSE ANOTHER BRAND IF I DISAGREED WITH THEIR POSITION. SINCE BRAKES ARE AN ESSENTIAL SAFETY SYSTEM IN A VEHICLE, IT SHOULD BE A PRIMARY CONCERN TO THEM IN ORDER TO EVALUATE POTENTIAL FAILURES WHERE THE OUTCOME COULD BE FAR WORSE.

NHTSA ID

11001869

Incident

May 23, 2017

Mileage

94,000 mi

TL* THE CONTACT OWNS A 2011 TOYOTA TUNDRA. WHILE DRIVING APPROXIMATELY 60 MPH, THE ABS, CHECK ENGINE, AND 4 WHEEL DRIVE LOW SENSOR LIGHTS ILLUMINATED. THE VEHICLE'S SPEED SUDDENLY REDUCED TO APPROXIMATELY 30 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE AIR PUMP ASSEMBLY UNIT WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 70,000.

NHTSA ID

10872890

Incident

May 1, 2014

Mileage

70,000 mi

NOISE IN BRAKES WHEN GOING SLOWLY AND TURNING RIGHT. TOOK TO MY MECHANIC HE LET ME KNOW THIS IS HAPPENING TO MANY 2007-2013 TUNDRA'S AND THERE IS A SERVICE BULLETIN ON IT TSB0013-13 HOWEVER IT IS NOT A RECALL YET SO IT IS NOT COVERED BY TOYOTA. TO REPAIR THIS PROBLEM THEY HAD TO REMOVE THE OLD BEARING ASSEMBLIES, AND REPLACE BOTH REAR BACKING PLATES & BEARINGS, FRONT & BACK ROTORS, FRONT & REAR PADS, WHICH BROUGHT THIS TO A GRAND TOTAL OF $1,817.24. MY MECHANIC AND THE MECHANIC FROM THE TOYOTA DEALER, WHERE I PURCHASED THE TRUCK, INFORMED ME THAT IF THIS PROCEDURE WAS NOT DONE THE BRAKES WOULD EVENTUALLY GO OUT AT SOME POINT. THIS IS DEFINITELY A HUGE SAFETY RISK AND I AM NOT SURE WHY THIS IS NOT CONSIDERED A RECALL YET. I URGE TOYOTA TO RECONSIDER THIS PROBLEM AND QUALIFY IT AS A RECALL.

NHTSA ID

10746249

Incident

Jun 19, 2015

Mileage

71,697 mi

MY VEHICLE FIRST HAD ITS WIRING HARNESS DESTROYED BY A RODENT OF SOME SORT A COUPLE OF WEEKS AGO. AFTER SENDING IT TO THE REPAIR SHOP AND $7000 DOLLARS LATER, I BROUGHT MY TRUCK HOME AND EVERYTHING WORKED FINE. I TRIED MANY REMEDIES TO DISCOURAGE THE RODENTS FROM RETURNING BUT NOTHING SEEMS TO DETER THEM FROM THE SOY BASED INSULATION ON MY TRUCKS WIRING HARNESS. I NOW HAVE TO SEND MY TRUCK BACK FOR REPAIRS TO THE SAME WIRING HARNESS ($7000) AS BEFORE, AND ALSO ANOTHER WIRING HARNESS WHICH WILL PROBABLY COST CLOSE TO THE SAME. HOW CAN TOYOTA GET AWAY WITH MAKING INSULATION OUT OF RODENT FOOD WHEN THESE WIRES OPERATE THE ABS BRAKING SYSTEM? THIS PRACTICE NOT ONLY PUTS A FINANCIAL BURDEN ON THE OWNER BUT ALSO COMPROMISES THEIR SAFETY. *TR

NHTSA ID

10694252

Incident

Mar 12, 2015

TL* THE CONTACT OWNS A 2011 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 1 MPH, HE NOTICED A GRINDING NOISE FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WOULD NOT ACCELERATE AND THE BRAKE PEDAL SEIZED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING HOWEVER, THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE AND STATED THAT THE ANTI-SLIP HAD ACTIVATED, CAUSED THE THROTTLE TO DISENGAGE AND THE BRAKES TO ENGAGE, WHICH HE STATED WAS A CHARACTERISTIC OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. ON A LATER DATE WHILE THE CONTACT WAS DRIVING 75 MPH IN INCLEMENT WEATHER, THE BRAKES ENGAGED INDEPENDENTLY AND CAUSED HIM TO CRASH INTO A DITCH. THE CONTACT WAS NOT INJURED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40. *TR

NHTSA ID

10510261

Incident

May 1, 2011

Mileage

40 mi

BOUGHT TRUCK NEW WITH 99 MILES SHOWING,TESTDRIVE PULLED HARD TO RIGHT ,EXTREMELY HARD BROUGHT BACK TO DEALERSHIP 3 DAYS LATER TO PERFORM ITS FIRST ALIGNMENT,THEY DID SEVERAL THAT DAY , MORE THAN 16 ALIGNMENT AT THAT DEALERSHIP TRUCK STILL TRACKS RIGHT,EVERY DIP IN ROAD ,ANY BUMP ,TRUCK VEERS RIGHT, JULY 2012 I HAD LEMON LAW PROCEEDING ,THE MAN CAME OUT AND DIDN'T DRIVE ,JUST SAT IN PASS SEAT, DEALERSHIP HAD THE TRUCK OVERNIGHT ONCE IN JUNE2012 AND ONCE IN JULY 2012 BEFORE TO FIX ISSUE, WHICH DID GET BETTER, THEN WAS DENIED CAUSE IT IS UNDER WARRANTY, TRUCK HAD OIL CHANGE AROUND NOV2012 AND I COMPLAINED AGAIN ,ABOUT FRONT END DOG TRACKING ,THEY SAID ITS NORMAL AND NO FIX NEEDED ,BUT THE TRUCK WAS FIXED FROM DOG TRACKING BUT NOT PUT IN WRITING, STILL VEERS RIGHT,NOW THIS TRUCK HAS HAD PROBLEMS LIKE MAJOR VIBRATION, REPLACED DRIVESHAFT AT 2500 MILES,DEALERSHIP REPLACED WHEELS TWICE TRYING TO FIGURE WHERE ITS COMING FROM, WHILE BRAKING IT PULLED HARD TO RIGHT AND HAD TO FIGHT STEERING WHEEL ,NOW THIS IS FROM THE START IT COULD LITERALLY TAKE THE CAR OUT ON THE SIDE OF YOU,WITH A CROWN OR NO CROWN THE PULLING RIGHT IS EXCESSIVE,AND WAS ABOUT 80 % WORST BUT I WANT IT FIXED CORRECTLY,CAN ANYONE HELP ME GET THIS TRUCK TO ROLL STRAIGHT,IM AT 21,900 MILES ,YES I HAVE PAPER WORK . *TR

NHTSA ID

10503112

Incident

Aug 13, 2011

I HAVE A 2011 TUNDRA SR5 WITH A LOUD CLICKING NOISE THAT HAS BEEN COMING FROM THE STEERING COLUMN NEAR THE SHIFT LEVER. WHILE IN PARK, THE BRAKE PEDAL MUST BE PRESSED IN ORDER TO SHIFT THE TRUCK INTO GEAR. WHEN I PRESS THE BRAKE PEDAL, A LOUD CLICK CAN BE HEARD FROM THE COLUMN SHIFTER. THIS IS THE COLUMN SHIFT LOCKOUT SOLENOID AND IS NORMAL. HOWEVER, RECENTLY I CAN HEAR THE SOLENOID CLICKING ANYTIME I DEPRESS THE BRAKE PEDAL WHILE I'M IN GEAR. SOMETIMES IT IS A CLICK, TWO CLICKS AND SOMETIMES IT IS SERIES OF RAPID CLICKS. I HAVE TAKEN THE TRUCK TO THE DEALER TWICE. THE FIRST TIME I WAS TOLD THE CLICKING WAS NORMAL WHILE IN PARK AND THAT THEY COULD NOT DUPLICATE IT WHILE IN GEAR. THE SECOND TIME I TOOK IT TO THE DEALER, THEY "BLEW OUT THE EXCESS GREASE" FROM THE SHIFT LOCK. THEIR BEST EXPLANATION IS THAT THE COLUMN SHIFT LOCK SOLENOID COMES FROM THE FACTORY AS A SEALED UNIT AND IS PACKED WITH GREASE. THE 'EXCESS' GREASE CAN KEEP THE LOCKING ARM FROM FULLY RETRACKING OR ENGAGING AND THE SOLENOID WILL CHATTER BECAUSE IT IS TRYING TO PUT IT INTO POSITION. *TR

NHTSA ID

10488778

Incident

Dec 3, 2012

Mileage

23,000 mi