2019 Toyota Tundra Problems

We had just exited the interstate when my Toyota Tundra stopped. We had it towed to the closest Toyota dealer. We had to have fuel pump replaced. They said the previous year Tundra was recalled for this issue, but ours was not. I just found out that some of the 2019 models had been recalled for this issue. They said my VIN was not recalled. That does not make sense. It was the same problem, same year, just at a different plant. Now we are having other fuel issues and the dealer says it all stems from the replacement of the pump, which we had to pay out of pocket. If we had not just exited the interstate it could have caused a major accident.

The contact owns a 2019 Toyota Tundra. The contact stated that while starting the vehicle, the engine sounded rough. The check engine warning light was illuminated. The vehicle was turned off and failed to restart. The vehicle was towed to an independent mechanic, where the ECU was reset; however, the failure reoccurred. The mechanic referenced NHTSA ID Number: 20V682000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 104,000.

Keep getting the messages "Trailer brake error, if towing come to a stop with manual controls" And "Pre-collision system malfunction" The messages go away usually after restarting the vehicle but eventually comes back on

Having fuel pump issue. Car stalls very badly and pre collision light and engine lights start flashing. Severe jumping by car driving down the road. When accelerating the car has no acceleration and hesitates very badly.

The contact owns a 2019 Toyota Tundra. The contact stated that while parked for 5-10 minutes, the contact noticed a burning plastic odor, and upon looking up moments later, the contact noticed flames coming from the driver's side headlight, and the flames were 6 inches above the headlight. The contact started extinguishing the fire with water bottles. The contact drove to a water hose, which the contact also used to extinguish the fire. The contact sustained minor smoke inhalation. No police report was filed. The contact was able to drive to the nearby residence. The contact related the failure to NHTSA Campaign Number: 21V688000(Exterior Lighting, Electrical System), which included the VIN. The manufacturer was notified of the failure and sent a field inspector, who inspected the vehicle and informed the contact that the inspection report would be completed on the same day; however, the manufacturer would follow up with the contact within 45-60 days. The contact followed up with the manufacturer three days later and was provided with the same information. The dealer was not contacted. The vehicle was not diagnosed or repaired. The failure mileage was approximately 100,500.

Intermittent message displaying "Trailer Brakes Disconnected" while towing. Trailer lights continued to operate even while message was displayed. On average trailer connected and disconnected every 2-3 minutes

Intermittent message displaying "Trailer Brakes Disconnected" while towing. Trailer lights continued to operate even while message was displayed. On average trailer connected and disconnected every 2-3 minutes

The contact owns a 2019 Toyota Tundra. The contact stated that while replacing the shocks, the contact noticed that the shocks were oily. The vehicle was taken to the local dealer for warranty repair, and the contact was informed that the brake pads on the rear axle were soaked with oil. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 30,000.

The contact owns a 2019 Toyota Tundra. The contact stated that while parked for 5-10 minutes, the contact noticed a burning plastic odor, and upon looking up moments later, the contact noticed flames coming from the driver's side headlight, and the flames were 6 inches above the headlight. The contact started extinguishing the fire with water bottles. The contact drove to a water hose, which the contact also used to extinguish the fire. The contact sustained minor smoke inhalation. No police report was filed. The contact was able to drive to the nearby residence. The contact related the failure to NHTSA Campaign Number: 21V688000(Exterior Lighting, Electrical System), which included the VIN. The manufacturer was notified of the failure and sent a field inspector, who inspected the vehicle and informed the contact that the inspection report would be completed on the same day; however, the manufacturer would follow up with the contact within 45-60 days. The contact followed up with the manufacturer three days later and was provided with the same information. The dealer was not contacted. The vehicle was not diagnosed or repaired. The failure mileage was approximately 100,500.

Factory installed OEM LED HEADLIGHTS: While driving in WET SNOW and SNOW conditions, headlights get covered in snow and visibility is greatly reduced to almost zero.

This is the second chrome hood bulge that I've put on it and it keep breaking with the wind and just flys off. Also the collision light will come on by itself.

Sunroof shattered while driving on highway. Noise similar to a gun being fired, caused momentary disorientation; however, was able to keep vehicle on the road. No warning, no other vehicles around that could have kicked up a rock, debris, etc. Smooth conditions on the road (no potholes, bumps, etc.). Sunroof was in the tilt up position, side windows down, and rear window down - even temperature outside and inside (74 degrees F). Small glass "shards" in eyes and hair; however, most of it went up/out. Vehicle gets inspected tomorrow (09-21) for insurance purposes.

I had to have the steering rack assembly replaced in my vehicle due to a leak. This is one of the complaints and a recall but I never got a notification.

I took my vehicle in for scheduled maintenance. During the safety inspection the Toyota authorized tech advised me about a serious safety issue with rust on the undercarriage of my vehicle. He advised that the control arms as well as sway bars and suspension , shocks, struts had heavy rust on them. He advised that this is a safety issue as if something breaks I could lose control. I have enclosed the video. I then contacted First Team Toyota and they initially wanted me to bring the truck in for inspection. The next day they called and told me that since I was no longer under warranty , That they could not help me. I was also told that the undercoating I paid extra for does not cover the parts that are rusted. I contacted Toyota corporate and they opened a case #[XXX]. After several days they decided that there was nothing they could do for me. I have my vehicle serviced routinely and have never been advised of any rust problems on my truck. Then after the warranty runs out, I’m advised of this problem. I take extreme care of my truck and spray the under carriage with fresh water whenever I drive thru rain or puddles. I am extremely concerned regarding the safety of this vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owned a 2019 Toyota Tundra. The contact stated that while driving at approximately 45 MPH, an oncoming vehicle did not obey a stop sign and proceeded to crash into the rear driver's side of the contact's vehicle. As a result, the contact lost control of the vehicle and crashed into the platform of an 18-wheeler. No air bags deployed. No warning lights were illuminated. The vehicle was towed to his residence. A police report was filed. The vehicle was deemed destroyed by the insurance company. The contact who was the driver sustained severe back pain and an injured left knee pending further treatment at a clinic. The front passenger sustained bruising to the left arm and back pain but did not seek medical attention. The rear passenger sustained bruising to the right arm and back pain but did not seek medical attention. The other vehicle occupants did not sustain injuries. A dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 75,000.

The contact owns a 2019 Toyota Tundra. The contact stated that while driving approximately 75 mph, a 2008 Lincoln struck the rear passenger side of her vehicle which caused her vehicle to tail spin and crash into the guardrail. The vehicle continued to tailspin. The air bags did not deploy. All the warning indicator lights were flashing after the crash. The contact sustained a laceration on the neck, a bruised hip, and leg pain and was provided medical attention at the hospital. A police report was filed. There were no reported fires. The vehicle was towed to a towing lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 80,000.

TL* THE CONTACT OWNS A 2019 TOYOTA TUNDRA. WHILE DRIVING APPROXIMATELY 70 MPH, AN EXPLOSION WAS HEARD. THE VEHICLE WAS PULLED OVER AND THE CONTACT NOTICED THAT THE SUN ROOF EXPLODED WITHOUT AN IMPACT OR WARNING. THERE WERE NO INJURIES. THE CONTACT CALLED OAKBROOK TOYOTA AT 630-789-9600 (LOCATED AT 550 E OGDEN AVE, WESTMONT, IL 60559) AND WAS INFORMED THAT THE FAILURE HAD TO BE CAUSED BY SOMETHING STRIKING THE SUN ROOF. THE DEALER DENIED ALL RESPONSIBILITY. THE MANUFACTURER WAS CALLED, BUT THERE WAS NO RESPONSE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 4,800. *LN

TL* THE CONTACT OWNS A 2019 TOYOTA TUNDRA. WHILE DRIVING 65 MPH, THE SUN ROOF EXPLODED WITHOUT IMPACT. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO BIG TWO TOYOTA OF CHANDLER (1250 S GILBERT RD, CHANDLER, AZ 85286) AND THE CONTACT WAS INFORMED THAT THEY WOULD REPLACE THE SUN ROOF. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS CURRENTLY AT THE DEALER. THE FAILURE MILEAGE WAS 5,142.

Having fuel pump issue. Car stalls very badly and pre collision light and engine lights start flashing. Severe jumping by car driving down the road. When accelerating the car has no acceleration and hesitates very badly.

3 times in the last few mos the BRAKE! warning came on. Nothing was causing this warning to engage. This happened again today. Another issue is when the Valdosta Toyota (GA) dealer attempted to fix the fuel pump recall on 22 JUL 2020 it was assembled incorrectly. I called the dealership and told them to come and get my Tundra because gas was dripping onto my driveway. They sent a tow truck and it was supposedly fixed and they brought it back to me in about 2 hrs. It really does run the way it did before they “re-fixed” it. Very often now when it is driving I feel something like a failing fuel pump. It fades away but it is not comfortable taking it long distances. It feels like there is a clog in the fuel system or something, although there is not. I have 33,400 miles on it today and I can’t help but wonder if Valdosta Toyota didn’t just exchange the original fuel pump with a different used one?

I was on a camping trip in Wyoming, and I started my Tundra up on a chilly morning. It was running for about 5 minutes before I came back to it and entered the cab. Immediately upon entering I noticed a strange smell. I also noticed at that time that the driver’s seat was extremely warm. I quickly shut off the heat warmer (original equipment on the truck). Inspecting the seat, I could see where the leather was just starting to melt. Luckily, I caught this in time, for if I would have left it longer, the vehicle could have caught fire. An online search discovered previous problems with Toyota seat warmers. My contact with Toyota was not helpful, for they simply told me that it was out of warranty, despite being a safety issue.

The seat heater control module has failed causing the plastic to burn and melt, nearly starting a fire. Toyota knows about this but refuses to issue a safety recall.

I took my vehicle in for scheduled maintenance. During the safety inspection the Toyota authorized tech advised me about a serious safety issue with rust on the undercarriage of my vehicle. He advised that the control arms as well as sway bars and suspension , shocks, struts had heavy rust on them. He advised that this is a safety issue as if something breaks I could lose control. I have enclosed the video. I then contacted First Team Toyota and they initially wanted me to bring the truck in for inspection. The next day they called and told me that since I was no longer under warranty , That they could not help me. I was also told that the undercoating I paid extra for does not cover the parts that are rusted. I contacted Toyota corporate and they opened a case #[XXX]. After several days they decided that there was nothing they could do for me. I have my vehicle serviced routinely and have never been advised of any rust problems on my truck. Then after the warranty runs out, I’m advised of this problem. I take extreme care of my truck and spray the under carriage with fresh water whenever I drive thru rain or puddles. I am extremely concerned regarding the safety of this vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

REAR AXLES AREN'T THE PROPER FIT, CAUSING THEM TO SHAKE WHICH CAUSES THE ROTORS TO VIBRATE THAT PRODUCES AN SQUEAKY/STRETCHING NOISE WHEN BRAKING. WAS ORIGINALLY TOLD IT WAS NORMAL UNTIL I CONTACTED TOYOTA CUSTOMER CARE. SERVICE TECHS STATES THAT 'IT'S SAFE TO DRIVE' BUT I DIDN'T TRUST IT. MY TRUCK ISN'T THE ONLY TRUCK, THERE ARE SERVAL MORE THAT MAKING THIS SAME EXACT NOISE. ABOUT TO TURN MY TRUCK BACK IN TO TOYOTA UNDER THE LEMON LAW.

275/55r20. only have around 10,000 miles. just rotate the tire at Walmart in Texas . on my way to Georgia my rear tire exploded without any warning at 75 mph . I almost lost control over the vechle .

VIBRATION IN TIRES COULD NOT BE BALANCED. THREE COMPLETE SETS(4) AND TWO REPLACED RECENTLY. I KEPT THE TIRES

VEHICLE PARKED ON BOAT LAUNCHING RAMP 25-30% SLOPE CONCRETE SURFACE WITH 24 FOOT ALUMINUM TRAILER IN TOW; BOAT OFF TRAILER, TRUCK FACING AWAY FROM WATER, TRAILER CLOSEST TO WATER. SUNNY, RAMP WAS DAMP, WITH SOME WOOD AND AQUATIC VEGETATION ON RAMP. VEHICLE WAS IN 2 WHEEL DRIVE. AFTER UNLOADING BOAT USING A LAUNCH CORD AND PULLING BOAT ONTO RAMP, DEPRESSED BRAKE AND MOVED SHIFTER FROM DRIVE TO PARK. PARK ENGAGED AND STEPPED FROM VEHICLE WHEN TRUCK BEGAN TO ROLL BACKWARD. LUNGED INTO CAB, SAW SHIFTER WAS NOW IN NEUTRAL! WAS ABLE TO REACH SHIFTER AND ATTEMPTED TO PUT INTO PARK. GEAR SHIFT MOVED TO PARK BUT VEHICLE CONTINUED TO ROLL AND I HEARD AN AUDIBLE CLICKING FROM TRANSMISSION AREA. TRUCK (AND ME) CONTINUED BACKWARD INTO LAKE, ALMOST DROWNED BUT FOR HELP OF A GOOD SAMARITAN ON SHORE. WHEN TRUCK RECOVERED IT WAS IN PARK, WRECKER OPERATOR HAD TO MANUALLY BYPASS THIS TO LOAD ON FLATBED. MY PRIOR 2019 TUNDRA CREW CAB DID SAME THING I CANNOT BELIEVE THIS HAPPENED. IN 2007 ON YOUR SITE SOMEONE REPORTED SAME TUNDRA ISSUE UNDER CONTROLLED CONDITIONS. SOMETHING IS WRONG WITH THIS TRUCK'S TRANSMISSION. NEVER HAPPENED UNDER ANY OTHER CIRCUMSTANCES BUT I ASSURE YOU IT IS GOING TO RESULT IN SOMEONE DYING I ALMOST DID. BOTH CLAIMS HANDLED BY USAA INSURANCE, DATE OF ACCIDENT MONDAY, 5 AUG,

I took my vehicle in for scheduled maintenance. During the safety inspection the Toyota authorized tech advised me about a serious safety issue with rust on the undercarriage of my vehicle. He advised that the control arms as well as sway bars and suspension , shocks, struts had heavy rust on them. He advised that this is a safety issue as if something breaks I could lose control. I have enclosed the video. I then contacted First Team Toyota and they initially wanted me to bring the truck in for inspection. The next day they called and told me that since I was no longer under warranty , That they could not help me. I was also told that the undercoating I paid extra for does not cover the parts that are rusted. I contacted Toyota corporate and they opened a case #[XXX]. After several days they decided that there was nothing they could do for me. I have my vehicle serviced routinely and have never been advised of any rust problems on my truck. Then after the warranty runs out, I’m advised of this problem. I take extreme care of my truck and spray the under carriage with fresh water whenever I drive thru rain or puddles. I am extremely concerned regarding the safety of this vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)