2020 Volkswagen Atlas Cross Sport Engine Problems

February 2025, just outside the warranty period, the hood latch had become disconnected/broken under the hood. There is a point where the two piece cable is joined under the hood and the cable breaks at this point. There is an obvious defect in the hood latch system and puts drivers at risk as the hood cannot be opened if needed possibly stranding a driver on the road with a non-functioning vehicle and no way to assess or repair the issue. Think low oil, overheating engine, no wiper fluid, fuse blown, no way to assess the issue. This is a common problem as found in internet forums. Many complaints have been filed with the NHTSA see campaign numbers 11693537, 11691685, 11681799, 11648046, 11630017. The fix involves removing the left front tire, removing the wheel well trim and and under fender skirting (25+ torx head screws), locating and opening cable junction box in the engine compartment from under the wheel well and pulling the cable with pliers to open the hood. The broken cable has to be removed by removing two interior panels inside the car cabin and pulling cable and grommet out. Then fishing replacement cable back through firewall into channel and up to the cable junction box. This is a 2-3 hour process. Cost is in excess of $500-700 at most dealers. The replacement cable is of the same design, so likely to also fail at some point. There should not be so many failures of a part that is only used 3-5 times per year.

NHTSA ID

11718465

Incident

Feb 13, 2026

I purchased a new 2020 Atlas Cross Sport in 2020. The car currently has 108,000 miles. In the time I have owned the car I have had to replace the heater core THREE times. The heater core has failed once again and I must replace it a FOURTH time. The dealer (Nucar, Norwood, MA) nor VW will admit the defect and I must pay $1000.00 to replace the defective part. This part is obviously defective. I want nothing more than to have the part replaced with a quality VW replacement part. I would also recommend that your organization investigate VW for a parts issue that is impacting many VW owners.

NHTSA ID

11710602

Incident

Jan 8, 2026

on 11/18/24 Spark plug issues and misfire cylinder causing loss of power and acceleration with engine light check light on ,EPC and tire pressure. Other Issue with navigation system giving false of whereabout and wrong directions/turns. Occasional lost of power while driving on the street. Navigation system has been replaced twice but problem still continue. in 2021 and 2023.

NHTSA ID

11626449

Incident

Nov 18, 2024

At a stop or slow speed the vehicle stalls. Acted like the start stop feature was engaging. Stalling out crossing lanes of traffic you have to out it in park and restart. Start stop feature is disabled but dangerous to stall in traffic this way

NHTSA ID

11618215

Incident

Oct 4, 2024

The vehicle randomly turns off and a message appears that states manually start the vehicle. It’s not the ECO start and stop system. I researched the Atlas online forum and this is a noted problem. The comments were very consistently noting that VW has not properly addressed the issue. There were numerous comments that the dealerships were unable to address the issue leaving the owner with a very dangerous defect. I encourage you to pursue this matter further. Thank you

NHTSA ID

11550954

Incident

Oct 19, 2023

While driving at approximately 10-15mph the engine shut off and was forced to come to a stop and restart the engine. The error read "Engine start/stop error, manually restart engine." I have been reading that this is a known issue by Volkswagon but they are not addressing. Luckily my car was just going onto an offramp when the engine shut off.

NHTSA ID

11534606

Incident

Jul 26, 2023

2020 Atlas Cross Sport SE 4 MOTION. At 15,000, vehicle exhibited unusual and dangerous transmission behavior that compromises the safety and longevity of the vehicle. The vehicle demonstrated severe acceleration lag from stop, revving at high RPM's before moving, harsh grinding gear shifts, "start/stop errors", and bucking at lower gears. Car was taken to service center for the first time and diagnosed with a transmission leak due to a faulty gasket, which was repaired. However, problems persisted and worsened. Shortly thereafter, car was taken a second time to service center and diagnosed with a faulty transmission valve and solenoids. Vehicle was returned, but continues to have rough gear shifts and hesitation under heavy acceleration. Car is in the service center for a third time, as of now, without fix. In addition, the vehicle was also sent to the service center for suspension issues-- unusual noise when going over bumps, and noise when turning at slow speeds. Sway bar was replaced on initial inspection, but noise while turning persists. No fix as of this complaint.

NHTSA ID

11451543

Incident

Dec 1, 2021

The contact owned a 2020 Volkswagen Atlas Cross Sport. The contact stated that while driving at 40 mph, he crashed into another vehicle and within seconds, his vehicle's engine compartment caught fire and exploded twice. The vehicle was engulfed in flames when the fire department arrived on the scene. The contact did not receive medical attention or sustain injuries however, the contact's wife received medical attention for injuries sustained and transported to the hospital by ambulance. A police report was filed. The vehicle was towed to an auto service center and deemed totaled by the insurance company. The dealer and manufacturer were not made aware of the failure. The failure mileage was 16,643.

NHTSA ID

11421699

Incident

Jun 20, 2021

Mileage

16,643 mi

PLEASE SEE ATTACHED DOCUMENT AS IT EXPLAINS IT ALL

NHTSA ID

11396572

Incident

Feb 11, 2021

Mileage

7,000 mi