2020 Volkswagen Atlas Cross Sport Problems

HVAC water tubing has leaked on to the airbag control module causing airbag errors and many other electrical faults. This is a known safety problem under recall 87H4, NHTSA campaign 21V892. However, Volkswagen stated my VIN is not eligible for this recall. Note: this diagnostic was not performed at a dealership but at an independent German car repair shop.

While driving, the vehicle experiences intermittent electrical malfunctions affecting multiple systems. The door locks cycle repeatedly, windows roll down on their own, and when attempting to roll the windows back up, they immediately roll back down. The dashboard lights flicker, become extremely bright, and at times go out completely. The central display (including Apple CarPlay) also shuts off entirely. Multiple warning alerts appear, including emergency brake warnings. These failures occur while the vehicle is in motion and create a safety risk due to loss of system visibility, inability to control vehicle functions, and unexpected vehicle behavior. The vehicle was initially taken to an independent repair shop due to these issues, where I was informed of Recall 97GF (wiring harness issue), which is associated with the same electrical failures. The vehicle was then taken to a dealership for recall service. The dealership retained the vehicle for approximately one week and advised that the repair resolved the issue. The vehicle operated normally for approximately three weeks following the repair. However, on or about [XXX], the same electrical issues reoccurred. The vehicle was returned to the dealership on February 20th, where it remained in service for over 45 days. Despite multiple repair attempts and extended time in service, the issue was not resolved and continues to occur. The dealership has indicated that the recall procedure was completed, but the original condition persists. The issue was also escalated directly to Volkswagen of America through a customer care case. The manufacturer reviewed the situation and stated that the recall procedure had been completed and the condition was no longer considered related to the recall. The case was subsequently closed without resolution, and the vehicle continues to experience the same electrical failures. Video of issue: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Volkswagen Atlas Cross Sport. The contact stated that while driving at an undisclosed speed, the air bag, cruise control, electronic parking brake, and several other unknown warning lights illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the HVAC drain tube had leaked onto the air bag control module and the air bag control module and the drain tube needed to be replaced. The contact researched and became aware of NHTSA Campaign Number: 21V892000 (Visibility, Air Bags); however, the VIN was not included. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 134,000.

HVAC water tubing has leaked on to the airbag control module causing airbag errors and many other electrical faults. This is a known safety problem under recall 87H4, NHTSA campaign 21V892. However, Volkswagen stated my VIN is not eligible for this recall. Note: this diagnostic was not performed at a dealership but at an independent German car repair shop.

While traveling south on Wheeler Road at the underpass of the Long Island Expressway my 2020 Volkswagon Atlas Cross Sport's emergency braking system gets activated. This has happened multiple times at approximatly 12:20 AM while heading home from work. I took the car to the dealer but the dealer said there was no way to check what happened unless the diagnostic machine was connected at the time it happened. Again, this has happened multiple times, the most recent being both January second and the third. There is no reason why this happenes as it is dark and not a sunglare issue, therei s no change of lighting, no pavement changes or obstructions, and no traffic in front of me. When this happens it scares the hell out of me because there isnt any reason why I would expect it to happen thus creating a bit of a dangerous situation for me. Maybe others have reported the same issue to you that you did or could look into the cause of this, possible a radar or broadcast system that could be the cause of the sensor activation so maybe the issue can get corrected and prevent it from happening again. Thank You for any help you can provide. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On Sep 25 2025 my wife parked car in parking lot to check phone messages. The car was in park. When she finished she placed the car in drive. It began to accelerated rapidly even after the brakes were applied and struck a tree. Her foot was not on the accelerator. The car then rolled over onto the driver side door. A police officer in a nearby building saw the crash and said the car was probably at 30mph when it hit the tree. He and two other officers got my wife out of the car. After the car was towed away we contacted VW customer care and asked that the car be examined. The said when the car was returned to drivable condition they would examine it. Hartford insurance totaled the car and said they were not responsible to examine the care and referred us back to VW. Again VW will not go the a salvage yard to examine the car. The car had intermittent electronic signal issues and a previous recall on doors needed to be redone because originally the wrong part was installed. I did experience a previous incident months before where I felt the car accelerated quicker than I expected from a stop with slight pressure on the pedal but it was only momentary.

Pulled out of driveway onto major road. Brake fluid alert showed up on dash. Brakes completely stopped working. Was able to roll the car to a stop. Called tow truck which delivered car to mechanic. Mechanic confirmed that there were no brakes and advised that the brake master cylinder leaked into the brake booster which caused the brake booster to be damaged. Mechanic needed to remove and replace the the brake master cylinder and the vacuum brake booster.

On Sep 25 2025 my wife parked car in parking lot to check phone messages. The car was in park. When she finished she placed the car in drive. It began to accelerated rapidly even after the brakes were applied and struck a tree. Her foot was not on the accelerator. The car then rolled over onto the driver side door. A police officer in a nearby building saw the crash and said the car was probably at 30mph when it hit the tree. He and two other officers got my wife out of the car. After the car was towed away we contacted VW customer care and asked that the car be examined. The said when the car was returned to drivable condition they would examine it. Hartford insurance totaled the car and said they were not responsible to examine the care and referred us back to VW. Again VW will not go the a salvage yard to examine the car. The car had intermittent electronic signal issues and a previous recall on doors needed to be redone because originally the wrong part was installed. I did experience a previous incident months before where I felt the car accelerated quicker than I expected from a stop with slight pressure on the pedal but it was only momentary.

February 2025, just outside the warranty period, the hood latch had become disconnected/broken under the hood. There is a point where the two piece cable is joined under the hood and the cable breaks at this point. There is an obvious defect in the hood latch system and puts drivers at risk as the hood cannot be opened if needed possibly stranding a driver on the road with a non-functioning vehicle and no way to assess or repair the issue. Think low oil, overheating engine, no wiper fluid, fuse blown, no way to assess the issue. This is a common problem as found in internet forums. Many complaints have been filed with the NHTSA see campaign numbers 11693537, 11691685, 11681799, 11648046, 11630017. The fix involves removing the left front tire, removing the wheel well trim and and under fender skirting (25+ torx head screws), locating and opening cable junction box in the engine compartment from under the wheel well and pulling the cable with pliers to open the hood. The broken cable has to be removed by removing two interior panels inside the car cabin and pulling cable and grommet out. Then fishing replacement cable back through firewall into channel and up to the cable junction box. This is a 2-3 hour process. Cost is in excess of $500-700 at most dealers. The replacement cable is of the same design, so likely to also fail at some point. There should not be so many failures of a part that is only used 3-5 times per year.

I purchased a new 2020 Atlas Cross Sport in 2020. The car currently has 108,000 miles. In the time I have owned the car I have had to replace the heater core THREE times. The heater core has failed once again and I must replace it a FOURTH time. The dealer (Nucar, Norwood, MA) nor VW will admit the defect and I must pay $1000.00 to replace the defective part. This part is obviously defective. I want nothing more than to have the part replaced with a quality VW replacement part. I would also recommend that your organization investigate VW for a parts issue that is impacting many VW owners.

Steering makes a noise. SOS light is red and it's the second time this happens. Last time the dealerships charged me $700.00 to fixed it. And now it's red again, and it hasn't even passed 2 months.

Having issues with the vehicle Power Train, Steering, Steering wheel locked, Suspension, Blind Spot Warning, Parking Collision, Automatic Emergency Braking are just a few I can remember. After all these dashboard lights started flickering the truck wouldn't turn back on leaving me stranded at least 3 times. I have called the local Volkswagen dealership since my lease is up in a few weeks and they will not take the truck if it isn't running. They advise to have it towed to the dealership to diagnose and give an estimate of the cost to get this fixed. It started with the dashboard lights turning on an off randomly.

Both day time running lights failed right after warranty expired. This repair requires over 2300$ repair because both entire headlights need to be replaced. This is a frequent problem that VW is aware yet refuses to rectify. It cause my vehicle to be less visible because of aporr design by VW.

Fuel pump failed Daytime running light failure Broken hood latch

Fuel pump failed Daytime running light failure Broken hood latch

GAS TANK SEAL FAILED CAUSING COLLAPSE OF GAS TANK AND DAMAGE TO FUEL PUMP. SIMILAR PROBLEM IN OTHER VOLKSWAGON VEHICLES SUCH AS JETTA AND GOLF THAT HAD RECALL IN PAST. VOLKSWAGON COSTUMER SERVICE WAS NOTIFIED, BE FAILED TO OFFER REPAIR COVERAGE DUE TO FACT I HAD THE OIL CHANGED AT A NON VOLKSWAGON SERVICE CENTER. NO WORK WAS DONE ON FUEL SYSTEM OUTSIDE OF OFFICIAL VOLKSWAGON DEALERSHIP.

February 2025, just outside the warranty period, the hood latch had become disconnected/broken under the hood. There is a point where the two piece cable is joined under the hood and the cable breaks at this point. There is an obvious defect in the hood latch system and puts drivers at risk as the hood cannot be opened if needed possibly stranding a driver on the road with a non-functioning vehicle and no way to assess or repair the issue. Think low oil, overheating engine, no wiper fluid, fuse blown, no way to assess the issue. This is a common problem as found in internet forums. Many complaints have been filed with the NHTSA see campaign numbers 11693537, 11691685, 11681799, 11648046, 11630017. The fix involves removing the left front tire, removing the wheel well trim and and under fender skirting (25+ torx head screws), locating and opening cable junction box in the engine compartment from under the wheel well and pulling the cable with pliers to open the hood. The broken cable has to be removed by removing two interior panels inside the car cabin and pulling cable and grommet out. Then fishing replacement cable back through firewall into channel and up to the cable junction box. This is a 2-3 hour process. Cost is in excess of $500-700 at most dealers. The replacement cable is of the same design, so likely to also fail at some point. There should not be so many failures of a part that is only used 3-5 times per year.

2020 Atlas Cross Sport- hood release cable snapped- known issue. Many complaints online. Needs a recall! Dangerous

Noise (Rattle) coming from LH rear wheel well while driving. Brought vehicle to dealer for inspection, found LH rear coil sheared in half. Dealer replaced both rear coil springs. There was a recall for the 2018/2019 Atlas/Cross Sport for the same issue. (NHTSA #18V904000) I believe VW needs to include some if not all 2020 models as well. The failure of the coil spring was not due to abusive driving. This was poor metallurgy. I've never in my life had a coil spring fail.

2020 Atlas Cross Sport SE 4 MOTION. At 15,000, vehicle exhibited unusual and dangerous transmission behavior that compromises the safety and longevity of the vehicle. The vehicle demonstrated severe acceleration lag from stop, revving at high RPM's before moving, harsh grinding gear shifts, "start/stop errors", and bucking at lower gears. Car was taken to service center for the first time and diagnosed with a transmission leak due to a faulty gasket, which was repaired. However, problems persisted and worsened. Shortly thereafter, car was taken a second time to service center and diagnosed with a faulty transmission valve and solenoids. Vehicle was returned, but continues to have rough gear shifts and hesitation under heavy acceleration. Car is in the service center for a third time, as of now, without fix. In addition, the vehicle was also sent to the service center for suspension issues-- unusual noise when going over bumps, and noise when turning at slow speeds. Sway bar was replaced on initial inspection, but noise while turning persists. No fix as of this complaint.

We purchased a Chicco Fit360 car seat approximately two weeks ago. During normal use, we discovered that the magnetic chest clip/latch on the 5-point harness can appear to be connected but is not always mechanically latched. If the two halves of the magnetic chest clip are brought together lightly/loosely, the magnets pull the clip together and it appears closed, but the latch can separate without pressing the release buttons. The issue appears to be with the magnetic chest clip/chest latch portion of the harness system. This creates a safety concern because the chest clip may appear secured when it is not actually locked. If this occurred during driving or a crash, the harness straps may not remain properly positioned on the child’s chest/shoulders, which could reduce the effectiveness of the restraint system and increase the risk of injury or ejection. The clip seems to connect correctly most of the time when clipped deliberately, but it can fail when loosely clipped, which is concerning because a caregiver may reasonably believe the chest clip is secured due to the magnetic connection. The car seat/component is available for inspection upon request. We contacted Chicco customer service and reported the issue. Chicco stated they are sending a replacement magnetic chest clip and indicated that the replacement should fix the issue. Chicco has not physically inspected the seat or the original chest clip at this time. The seat has not been inspected by police, insurance, or any other third party. No crash or injury has occurred. The cause is UNKNOWN, but based on observation, the failure appears to involve the magnetic chest clip giving the appearance of being closed without the mechanical latch fully engaging.

The Pirelli Scorpion All Season Zero tires that came factory equipped on my 2020 VW Cross Sport have experienced a sidewall failure on Drivers Side front. 35,000 miles on the vehicle and Tries Rotated as recomended. The tire sizes is 245/45r21. Driving on highway at 70 mph, with out any sensor warnings a messaged flashed on the dash of complete loss of tire pressue and in a split second the tire exploded. Thankfully I was able to pull the side safely. The sidewall of the tire completely seperated from the body. Dealer is selling me new tires but no offer to investigate.

Having issues with the vehicle Power Train, Steering, Steering wheel locked, Suspension, Blind Spot Warning, Parking Collision, Automatic Emergency Braking are just a few I can remember. After all these dashboard lights started flickering the truck wouldn't turn back on leaving me stranded at least 3 times. I have called the local Volkswagen dealership since my lease is up in a few weeks and they will not take the truck if it isn't running. They advise to have it towed to the dealership to diagnose and give an estimate of the cost to get this fixed. It started with the dashboard lights turning on an off randomly.

car navigation system is inaccurate. There is a severe lag in displaying where the car actually is located versus where the car is displayed on navigation. Navigation then places me in a location a mile or so away from where I am located and then reports that I am off road. The directions are inaccurate as navigation cannot locate my location accurately and in real time.

The contact owns a 2020 Volkswagen Atlas Cross Sport. The contact stated that while driving at an undisclosed speed, the air bag, cruise control, electronic parking brake, and several other unknown warning lights illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the HVAC drain tube had leaked onto the air bag control module and the air bag control module and the drain tube needed to be replaced. The contact researched and became aware of NHTSA Campaign Number: 21V892000 (Visibility, Air Bags); however, the VIN was not included. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 134,000.

SEAT BELTS IN REAR LEFT SIDE DO NOT RETRACT, HAVE TO MANUALLY PUSH THE SEAT BELTS BACK IN TO GET THEM TO WORK

The contact owns a 2020 Volkswagen Atlas Cross Sport equipped with Continental Tires: Tire Line: Cross Contact LX Sport, Tire Size: 245/60/R18, DOT Number: A383WC9V2920. The contact stated that while driving at approximately 65 MPH, there was vibration in the rear passenger’s side and there was a loud popping sound. The contact heard the sound of some object slapping the roadway. The contact stated that the low tire pressure warning light had illuminated seconds before the tire failed. The contact replaced the tire with the spare tire. The vehicle was taken to a tire dealer. The tire was diagnosed and it was confirmed that the tread had separated from the sidewall of the passenger’s side rear tire. The manufacturer was not notified of the failure. The failure mileage for the vehicle and tire was 14,500.

The contact owns 2020 Volkswagen Atlas Cross Sport. The contact stated while driving approximately 40 MPH, the vehicle went into brake mode automatically. There was an unknown warning light that illuminated. The contact took the vehicle to a local dealer. The failure was diagnosed as a door harness failure. The manufacturer was notified of the failure. The approximate failure mileage was 13,974. The VIN was not available.