2002 Volkswagen Beetle Problems

VEHICLE WAS IN MOTION (ABOUT 25 MPH) WHEN A FRONT END COLLISION OCCURRED WHICH RESULTED IN THE PASSENGER SIDE AIRBAG ACTIVATING ONLY. THE DRIVER SIDE STEERING WHEEL AIRBAG DID NOT ACTIVATE. DRIVER'S FACE HIT THE STEERING WHEEL.

TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE.

Unknown

I WAS DRIVING ON THE HIGHWAY WITH MY DAUGHTER AND GIRLFRIEND WHEN SUDDENLY THE CAR CAUGHT AN ELECTRICAL FIRE OUT OF NOWHERE. I PULLED OVER AND CLOUDY SMOKE WAS ARISING LUCKILY THE STATE TROOPER HAD A FIRE EXTINGUISHER TO PUT IT OUT BEFORE THE CAR CAUGHT ON HEAVY FLAMES.

Unknown

WHEN I DRIVE THE CAR GO SLOW THEN FAST

02M TRANSMISSION 6 SPEED; SHIFT FORK IN 1ST AND 2ND GEAR FAIL, A SMALL RIVET IS USED TO SECURE THIS FORK (BRASS FORK AND STEEL SHAFT) TOGETHER. MY 1ST AND 2ND GEAR WERE HARD TO GET INTO AND PROGRESSIVELY GOT WORSE OVER TIME; UNTIL THE SHIFT FORK FAILED AND 1ST, 2ND GEAR ARE NONEXISTENT; ALL OTHER GEARS WORK FINE. THIS IS A KNOWN ISSUE AND WIDELY REPORTED PROBLEM ON WEBSITES SUCH AS VWVORTEX. THIS PARTICULAR CAR; 2002 NEW BEETLE TURBO S; ONLY HAS ABOUT 70K WHICH IS LOW FOR A CATASTROPHIC FAILURE SUCH AS THIS. *TR

OUR 2002 VW TRANSMISSION WENT OUT @ 75,000 MILES WITH NO NOTICE. JUST ONE DAY IT WOULD NOT BACK UP. THEN IT WAS ALMOST LIKE IT JUMPED INTO REVERSE AND THEN WHEN WE PUT IT IN DRIVE YOU COULD JUST TELL IT WAS NOT RIGHT. WE LIMPED IT AROUND FROM PLACE TO PLACE GETTING OPINIONS ON WHAT WAS WRONG AND GETTING ESTIMATES ON REPAIR. HAD ONE GARAGE TAKE THE COVER OFF SIDE OF TRANSMISSION SEEING METAL SHAVINGS WAS WHEN WE GOT IT REPLACED. THAT REPLACEMENT LASTED A TOTAL OF 3 DAYS, IT WAS USED WITH ONLY 23000 MILES ON IT AND ONLY LASTED 3 DAYS. IT JUST STOPPED IN THE MIDDLE OF ROAD AND WOULD NO GO INTO ANY GEAR. REPLACED THAT ONE WITH ANOTHER ( BOTH WERE FDF TRANSMISSIONS) AND NOW THE SPEEDOMETER IS OFF X 8-13 MPH, THE RPM ARE RUNNING HIGH AROUND 2800 TO 3000 @ 55 -60 MPH. FUEL MILEAGE IS DOWN CUT IN HALF. HAVE TAKEN IT TO A VW DEALER AND WAS TOLD THERE WERE NO CODES ANYWHERE AND THEY DID NOT KNOW WHAT WAS WRONG OR WHY THESE PROBLEMS WERE HAPPENING. THIS TELLS ME THERE IS A BIG PROBLEM SOMEWHERE WITH VW TRANSMISSIONS AND SOMEONE NEEDS TO INQUIRE INTO THIS. THE INTERNET IS FULL OF VW TRANSMISSION PROBLEMS. *TR

I was driving down the road an the car started accelerating all by it's self so I pulled over but every time I let off the break it acted like I had the gas to the floor. The O2 sensor wire's shorted and burnt up the ECM making the CPU light to come on.

TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE. WHILE DRIVING 60 MPH, THE ABS MAIN CONTROL UNIT INDICATOR ILLUMINATED. AN INDEPENDENT MECHANIC STATED THAT THE ABS WAS MALFUNCTIONING. THE CONTACT TOOK THE VEHICLE TO THE DEALER (VOLKSWAGEN OF OAKLAND, 2740 BROADWAY, OAKLAND, CA 94610) WHO STATED THAT THERE WERE NO ACTIVE RECALLS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 89,605. *TT

TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT WHILE DRIVING 60 MPH IN RAINY WEATHER, THE WINDSHIELD WIPERS BECAME INOPERABLE. THE DEALER WAS NOTIFIED OF THE FAILURE WHO ADVISED THAT THERE WERE NO RECALLS FOR THE FAILURE AND THAT THE WINDSHIELD WIPERS SENSORS WOULD HAVE TO BE DISENGAGED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 190,000.

CURRENTLY HAVE VERY LOW MILEAGE(NOW UNDER 20000) 2002 VW NEW BEETLE PURCHASED NEW. AFTER TIME WARRANTY EXPIRED BOTH POWER WINDOW(PASSENGER AND DRIVER SIDES) REGULATORS FAILED (AT DIFFERENT TIMES AND MILEAGES) SPONTANEOUSLY NOT DUE TO ANY EXTERNAL EVENT.. BOTH REGULATORS REQUIRED REPLACEMENT AT CONSIDERABLE COST. THIS IS VERY UNUSUAL BECAUSE AUTO WINDOW REGULATORS USUALLY ARE VERY DURABLE WHEN NOT DAMAGED BY EXTERNAL CRASH OR THE LIKE. I REPORTED THIS TO VOLKSWAGEN BUT GOT NO SATISFACTION. ON THE INTERNET I HAVE FOUND MANY OTHER COMPLAINTS FROM OWNERS ABOUT THIS PROBLEM TO THEIR DISMAY AND WITHOUT SATISFACTION FROM VOLKSWAGEN. THERE SHOULD HAVE BEEN A RECALL FOR THE DEFECTIVE PARTS! *TR

THE FRONT SEAT BELT BUCKLE BECOMES DEFECTIVE AND SETS AN AIRBAG CODE MAKING THE AIR BAG LIGHT TURN ON AND POSSIBLY NOT WORK. THIS IS THE THIRD TIME I HAVE HAD TO REPLACE THE BUCKLE ON THIS VEHICLE IN 187,000 MILES. I HAVE CHECKED A NUMBER OF VW CLUB FORUMS AND HAVE FOUND THIS IS A VERY COMMON ISSUE ON THESE VEHICLES. I FEEL THIS IS A SAFETY ISSUE THAT NHTSA SHOULD LOOK INTO. *JS

SEAT BELT/AIR BAG LIGHT CAME ON. TOOK TO LOCAL, QUALIFIED MECHANIC. THEY SAID ONLY VW DEALER COULD FIX AND RESET. DEALER SAID IT WAS LOWER SEAT BELT HARNESS ($380), BUT COULD BE MORE (ABOVE $800) AND THE SERVICE WRITER ENCOURAGED US TO DO THE MORE EXPENSIVE WORK. TOLD THEM TO DO THE HARNESS AND SEE IF LIGHT WOULD GO OUT, WHICH IT DID. LIGHT CAME BACK ON AROUND 12/10/2010 AT APPROXIMATELY 79,000 MILES. JUST PRIOR TO THIS, WE PURCHASED ANOTHER VW BEETLE, A 2003 CONVERTIBLE WITH 69,500 MILES WITH THE SEAT BELT/AIRBAG LIGHT ON. SELLER SAID HE COULD NOT GET IT FIXED BY HIS MECHANIC AND HAD TO HAVE VW DEALER REPAIR IT FOR AROUND "$380", MAYBE MORE. SINCE HE MADE OTHER REPAIRS, WE LET IT GO. NOW WE HAVE TWO TO FIX AT THE MERCY OF THE VW DEALER. MY CONCERNS ARE SEVERAL: 1. THIS IS A RECURRING PROBLEM FOR US AND FOR NUMEROUS OTHERS (VW BEETLE FORUM) 2. THE REPAIRS CAN ONLY BE COMPLETED BY A HIGH COST VW DEALER AND THE COMPUTER RESET BY THEM ONLY 3. THE MATERIALS APPEAR TO BE DEFICIENT/DEFECTIVE AND THE ENGINEERING OF THE HARNESS/WIRING SYSTEM SUBSTANDARD 4. REPAIRS NEED TO BE MADE IN THE 60-85,000 MILE RANGE - A CONTRIVED MAINTENANCE/REPAIR ITEM THAT BRINGS WINDFALL REVENUE/PROFIT TO VW DEALERS IN THE $400-1,000 RANGE PER OCCURRENCE WHEN MANY OF THE CARS ARE WORTH ONLY $4,000-7,000. 5. SINCE IT IS A BASIC SAFETY ITEM AND WE DON'T KNOW IF THE AIRBAG SYSTEM WORKS OR NOT, WE ARE FORCED TO REPAIR THIS PROBLEM BECAUSE IT MAKES US APPEAR AS IF WE ARE NEGLIGENT WHEN IN FACT THIS PROBLEM SHOULD NOT EXIST AND BE COVERED BY THE MANUFACTURER LIKE EMISSION SYSTEMS TO WELL PAST 100-150,000 MILES. IN SUMMARY, VW HAS COLLUDED WITH ITS DEALERS TO CREATE THIS SITUATION AND ALLOW THIS "REPAIR" TO EMERGE AS A WAY TO GENERATE REVENUES AND PROFITS ON CARS THAT WOULD NORMALLY NOT HAVE A REASON TO BE BROUGHT IN TO A VW DEALER. IT IS NON-COMPETITIVE, FRAUDULENT AND UNNECESSARY.

VEHICLE WAS IN MOTION (ABOUT 25 MPH) WHEN A FRONT END COLLISION OCCURRED WHICH RESULTED IN THE PASSENGER SIDE AIRBAG ACTIVATING ONLY. THE DRIVER SIDE STEERING WHEEL AIRBAG DID NOT ACTIVATE. DRIVER'S FACE HIT THE STEERING WHEEL.

TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE CONVERTIBLE. WHILE DRIVING APPROXIMATELY 40 MPH IN THE RAIN, WATER SUDDENLY LEAKED INTO THE CABIN OF THE VEHICLE AND ONTO THE DRIVER. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 29,000.

TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE. WHILE DRIVING VARIOUS SPEEDS AT NIGHT, THE HEADLIGHTS AND TAIL LIGHTS FAILED TO WORK INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 32,000.

SERIOUS ELECTRICAL LONG TERM QUALITY ISSUES, STARTING WITH UNDER HOOD WIRING FOR GLOW PLUGS MELTED AWAY, AIR BAG/SEAT BELT WIRING BROKE/FAILED, SEAT HEATER FAILED, PASSENGER DOOR SWITCH FAILED, TURN SIGNAL BULB HOLDER FAILED, REPEATED HEAD LAMP AND TAIL LIGHT FAILURES, ALTERNATOR PULLEY CLUTCH FAILED(EXPLODED) FACTORY ALARM PROBLEMS - JUST SETS OFF, AIR BACK LIGHT ON DASH ON, SERVICE ENGINE LIGHT ON. *TR

I was driving down the road an the car started accelerating all by it's self so I pulled over but every time I let off the break it acted like I had the gas to the floor. The O2 sensor wire's shorted and burnt up the ECM making the CPU light to come on.

WHEN I DRIVE THE CAR GO SLOW THEN FAST

THE INTERIOR SMELLS STRONGLY OF CRAYONS AND WILL NOT GO AWAY WITH SHAMPOOING, CLEANING AND/OR OTHER METHODS OF ODOR REMOVAL. THE ODOR IS VERY STRONG AND RUBS OFF ON CLOTHING AND SKIN WHILST SEATED.

VW DEALER ADVISES THAT AIRBAG LIGHT INDICATES AIRBAGS ARE DISABLED AND CAUSED BY A MALFUNCTION IN THE SEATBELT LATCH ASSEMBLY COSTING $386 TO REPAIR. VW DEALER SAYS THIS HAPPENS A LOT. VW DEALER SAID THAT AIRBAGS WOULD NOT HAVE DEPLOYED. VW DEALER SAID THAT WIRING INSIDE THE LATCH "JUST BREAKS" EVENTUALLY. FAILURE OF SAFETY EQUIPMENT SHOULD BE AN AUTOMATIC RECALL AND MANUFACTURERS SHOULD BE REQUIRED TO REPAIR DEFECTS AT THEIR COSTS AND NOT COST TO THE CONSUMER. *TR

ON JUNE 13TH I WAS DRIVING MY CAR AND I WENT TO TURN OFF THE AC AND IT MADE A LOUD CLICKING NOISE, AFTER THE NOISE THE AC WOULDN'T TURN OFF SO I ENDED UP DRIVING 3 HOURS WITH THE AC FULL BLAST. A FEW DAYS AFTER THIS I WAS ABLE TO TURN OFF THE AC, AND LEFT IT LIKE THIS FOR ABOUT 2 WEEKS. AT THIS POINT THE MIDDLE KNOB WAS STUCK AND THE AC WOULD RANDOMLY WORK AND NO LONGER WOULD TURN AT ALL. ON JUNE 30TH AS I WAS LEAVING THE PARKING LOT OF MY APARTMENT AND WENT TO TURNED ON THE AC, IT MADE A WEIRD NOISE BUT I CONTINUED DRIVING ANYWAYS. THE AC STOPPED WORKING SO I TURNED THE KNOB AGAIN AND I STARTED GETTING A BURNING SMELL, I LOOKED DOWN AND SAW SMOKE COMING OUT FROM BEHIND THE KNOB SO I DROVE BACK TO MY APARTMENT BECAUSE I DECIDED IT WASN'T SAFE TO DRIVE ON THE FREEWAY. IN A MATTER OF A MINUTE THE SMOKE GOT WORSE AND STARTED COMING OUT FROM THE ENTIRE AREA UNDER MY RADIO. I PARKED MY CAR ONCE I GOT BACK HOME AND STOOD OUTSIDE AS I ALLOWED MY CAR TO AIR OUT, NOT LONG AFTER THIS I SAW FLAMES COMING OUT FROM THE MIDDLE KNOB AND GROWING BIGGER. I WAS LUCKILY ABLE TO PUT IT OUT WITH A CUP OF WATER AND WAS FORCED TO CALL 911 TO MAKE SURE THE FIRE WAS COMPLETELY OUT. THIS IS ONE OF THE WORST EXPERIENCES THAT HAS EVER HAPPENED TO ME AND IT WAS TERRIFYING, IF I DIDN'T HAVE A CUP OF WATER AT THE TIME THE FIRE COULD HAVE EASILY BURNED UP THE REST OF MY CAR IN A MATTER OF SECONDS. *TR

2002 VW BEETLE TURBO 1.8 WHILE DRIVING THE RED LIGHT SENSOR WOULD COME ON STATING MY CAR WAS OVERHEATING. NOTHING WAS LEAKING, SENSORS WERE REPLACED A FEW MONTHS PRIOR DUE TO THE SAME ISSUE ALONG WITH A RING AND IT HAPPENED AGAIN. THE RED LIGHT FLASHES THEN ABOUT 2 MILES LATER THE OIL LIGHT GOES ON AND IF THE CAR IS NOT PULLED OVER IMMEDIATELY THEN YOU RISK ENGINE DAMAGE. THE ENTIRE ENGINE IS MADE UP OF PLASTIC PARTS PRETTY MUCH WHICH CRACK AND MELT VERY EASY WHEN HEAT GETS TO THEM. SO NOW AFTER SPENDING MONEY ON WATER PUMPS, ASSEMBLIES, HOSES, SENSORS WHICH TOTAL OVER 3K IT IS NOW AN ISSUE ONCE AGAIN AND THE CAR IS UNDRIVABLE. I AM EXTREMELY DISAPPOINTED IN THIS VEHICLE. ALSO MY IGNITER COILS WERE REPLACED 8 TIMES (2X EACH ONE) PRIOR TO A RECALL AND THEY DO NOT REIMBURSE YOU ALL THE MONIES SPENT. NOW THERE IS A RECALL IN MY SUNROOF WHICH THE DEALERSHIP WILL NOT FIX SINCE THE WATER DAMAGE IS ALREADY AFFECTING THE ROOF OF THE VEHICLE. SO WITH ALL OF MY RECEIPTS NOT INCLUDING RENTAL CARS FOR REPAIRS ONLY I HAVE INVESTED OVER 6K IN A CAR WORTH LESS AND I DOUBT NO ONE WILL PAY TO TAKE IT OFF MY HANDS WHICH WILL LEAVE A SINGLE MOTHER CAR LESS. *TR

THERE IS AN UNUSUALLY STRONG, AND OBNOXIOUS, ODOR (SMELLING OF BURNT CRAYONS) COMING FROM THE INTERIOR OF THE CAR. THE SMELL IS SO OVER-POWERING I HAVE TO OPEN THE WINDOWS, AND LEAVE THEM OPEN, THE ENTIRE TIME I AM DRIVING THE CAR, OTHERWISE I BECOME DIZZY AND NAUSEOUS. I SEARCHED THE INTERNET, AND THERE ARE MANY PEOPLE WHO HAVE BLOGGED THEY HAVE A CAR MADE BY VOLKSWAGEN WITH THE SAME ODOR PROBLEM -- A FEW OF THESE WEBSITES ARE; ----(1) HTTP://WWW.FIXMYSTINKYCAR.COM/?P=706 ----(2) HTTP://FORUMS.AUTOMOTIVE.COM/70/6371584/VOLKSWAGEN/CHEMICAL-ODOR/INDEX.HTML ----(3) HTTP://WWW.CARSURVEY.ORG/REVIEWS/VOLKSWAGEN/JETTA/2001/PAGE-57/ ----(4) HTTP://WWW.WEBANSWERS.COM/AUTOMOBILES/WHAT-IS-CAUSING-MY-CAR-SMELL-5B4BD0. *TR

CHEMICAL ODOR INSIDE CAR. RECENTLY PURCHASED A 2002 VW BEETLE. THE INSIDE OF THE CAR SMELLS LIKE BURNT CRAYONS. IT IS SO STRONG IT BURNS MY EYES AND THE SMELL GETS IN YOUR HAIR AND IN YOUR CLOTHING. THIS CANNOT BE HEALTHY TO BE BREATHING. I LIVE IN MS AND THE HEAT SEEMS TO MAKE THE SMELL STRONGER. I'VE READ MANY THREADS WITH A LOT OF PEOPLE ON LINE COMPLAINING OF THIS SAME PROBLEM BUT VW DEALERSHIP SAYS THEY CANNOT HELP. *TR

REAR COLLISION ACCIDENT IN 2004, NOW SEATBELT LATCH MECHANISM NOT WORKING, STRUTS AND WHEEL BEARINGS DAMAGED AND NEED REPLACEMENT ALONG WITH SUBFRAME AND EMERGENCY BRAKE SYSTEM. *TR

I WAS DRIVING DOWN THE STREET AT APPROXIMATELY 20 MILES PER HOUR WHEN SUDDENLY MY CAR BEGAN TO SOUND LIKE I WAS DRAGGING METAL ACROSS THE ROAD. I TRIED TO TURN THE CAR TO THE RIGHT TO PULL OVER AND PARK, AND THE CAR LOCKED. THREE AIRBAGS THEN DEPLOYED. THE STEERING LOCKED AND CAUSED THE CAR TO SIDESWIPE ANOTHER. THE OFFICER THAT RESPONDED TO THE ACCIDENT, ADVISED ME TO REPORT IT ON TO THIS SITE. HE CLAIMED THAT HE HAS NEVER SEEN ANYTHING LIKE THIS BEFORE AND SAID IT WAS A DEFECT IN THE WHEEL. THE LOWER CONTROL ARM BOLT COMPLETELY BROKE CAUSING THE SUSPENSION FRAME TO BREAK. THE POLICE OFFICER REPORTED THIS AS A DEFECT IN THE VEHICLE. THE VEHICLE IS A 2002 VOLKSWAGEN BEETLE WITH 44,000 MILES. *TR

THIS IS MY DAUGHTERS CAR AND WE ARE CONCERNED ABOUT THE SAFETY OF IT WITH HER GOING TO SCHOOL AND WORK. IT HAS BEEN JERKING VERY HARD ENOUGH TO THROW YOU WHOLE BODY FORWARD I JUST CAN'T BELIEVE THE COMPLAINTS I'VE SEEN WITH THIS CAR I WOULD HAVE NEVER BOUGHT IT KNOWING ALL THESE PROBLEMS. PARENTS CONCERNED PLEASE HELP TO GET FIXED. VW SHOULD BE HELD ACCOUNTABLE AND FIX THESE DANGEROUS ISSUES I PRAY EVERYDAY SHE IS OK DRIVING, CAN'T AFFORD TO GET ANOTHER CAR LET ALONE FIX IT!!! ALSO HAVE HAD OTHER ISSUES TOO BUT THIS ONE IS THE MOST CONCERNING!! *TR

TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE. THE CONTACT STATED WHILE TRAVELING APPROXIMATELY 75MPH, THE TRANSMISSION INDEPENDENTLY DOWNSHIFTED YET THERE WAS AN UNUSUAL INCREASE IN ENGINE RPMS. THE VEHICLE ABNORMALLY DECELERATED FROM 75 TO 15 MPH WITHIN SECONDS. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE TRANSMISSION REAR DIFFERENTIAL GEAR WAS DEFECTIVE. THE MECHANIC ALSO ADVISED THAT THE TRANSMISSION WOULD NEED TO BE REPLACED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 100,000.

WHILE DRIVING AT 65 MPH, THE LEFT REAR TIRE EXPLODED. THE DRIVER WAS ABLE TO PULL OVER TO THE SHOULDER. THE DRIVER HAD THE VEHICLE TOWED TO A GAS STATION TO REPLACE THE TIRE. *PH

AIR CONDITIONER COMPRESSOR CLUTCH FELL OFF CAR UNDER NORMAL USE. THIS WOULD HAVE BEEN A SERIOUS SAFETY ISSUE HAD THE DUST COVER ON THE BOTTOM OF THE MOTOR COMPARTMENT NOT HAVE CAUGHT IT AND THE CLUTCH WAS THROWN INTO TRAFFIC.. *TR