2013 Volkswagen Cc

In August 2015, VW launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clock spring. VW’s recall indicated that debris entry into the steering wheel hub can result in the contamination and ultimately failure of the clock spring in 2010-2014 MY CC, Eos, GTI, Golf, Jetta, Jetta Sportwagen, Passat, and Tiguan models. The contamination of the clock spring by debris, such as human hair, can cause the flat ribbon cable to tear. This results in the loss of the electrical connection to the front driver air bag and any steering wheel mounted controls. The clock spring is designed so that the flat cable inside will break with minimum force to prevent it from impeding movement of the steering wheel. The loss of the electrical connection to the front driver air bag results in the immediate illumination of the air bag warning light and prevents the deployment of the front driver air bag in a collision of sufficient severity. A torn clock spring also causes audible grinding noises from the area of the steering wheel/driver air bag or steering column while steering. The failure of the clock spring does not impair vehicle control or drivability (steering, brakes, acceleration). In November 2017, the Office of Defects Investigation (ODI) opened Recall Query RQ17009 after receiving complaints that alleged the failure of the clock spring in the subject models. While the majority of these complaints involved vehicles excluded from the original recall, several complaints involved vehicles that had received the remedy for Recall 15V-483. On April 18, 2018, ODI upgraded the investigation to Engineering Analysis EA18003 after receiving additional complaints concerning the recall remedy and scope of Recall 15V-483. During the investigation, VW identified certain 2015-2018 MY vehicles that share a common steering wheel clock spring with the vehicles covered under Recall 15V-483.  VW began using a different clock spring design starting with the 2019 MY Jetta. This new part is not compatible with previous model years due to the communication properties between the clock spring and the vehicle, including the air bag control module. In October 2018, VW released Warranty Extensions AWA-18-18 and VWP-18-11, which established a 15-year, unlimited mileage coverage for the Steering Wheel Clock Spring for vehicles included in the scope of Recall 15V-483. For certain 2010-2018 MY vehicles outside of the recall scope, a 10-year, 120,000-mile coverage was given. Vehicles repaired under these warranty extensions receive replacement clock springs at no charge to the consumer. In early 2023, VW updated AWA-18-18 (now AWA-23-01) and VWP-18-11 to upgrade certain vehicles and model years from the 10-year, 120,000-mile coverage to the 15-year, unlimited mileage coverage option. These warranty extensions cover vehicles with recall remedy failures as well as vehicles outside of the Recall 15V-483 scope that exhibited similar failures. In view of the circumstances, including the high detectability of the subject failure and warranty extensions issued by VW, ODI is closing this Engineering Analysis. NHTSA reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.

While I was driving I notice my steering wheel making a crumbling of plastic noise when I made any kind of turn . A few days later my Airbag error lamp started to blink. I parked and restarted my engine then the airbag became solid . My dash read “Airbag Error” . I notice all my steering wheel buttons do not work . Came home and neither does my horn . My car has never been in accident , but I feel it’s a safety hazard . I’m basically driving mute and I’m sure my airbag will not deploy in case of accident . Also, Vw does have a recall on the Clock spring but was never completed due to not hearing back from manufacturer . That was a few years back and do not understand how recalls work , but a recall was started for a reason and NOT completed. Is that even possible? This a serious safety issue if I’m in an accident without an Airbag . Also the horn will not work in case to warn other drivers of a possible fatal hazard

NHTSA ID

11516993

Incident

Apr 1, 2023

The contact owns a 2013 Volkswagen CC. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. Additionally, the horn was inoperable. The vehicle was taken to an independent mechanic who informed the contact that no fault codes were retrieved. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,652.

NHTSA ID

11475324

Incident

Jul 22, 2022

Mileage

79,652 mi

The contact owns a 2013 Volkswagen CC. The contact stated that while operating the vehicle, the air bag warning light would remain illuminated and the horn would not operate. In addition, the cruise control was inoperable. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure and the contact was informed that the vehicle was not included in NHTSA campaign number: 15V483000 (Air Bags). The contact indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 115,000.

NHTSA ID

11422933

Incident

Apr 1, 2021

Mileage

115,000 mi

TL* THE CONTACT OWNS A 2013 VOLKSWAGEN CC. WHILE THE CONTACT WAS APPROACHING AN INTERSECTION TO MAKE A LEFT TURN, ANOTHER VEHICLE CRASHED INTO THE REAR PASSENGER DOOR OF HER VEHICLE AT A SPEED OF BETWEEN 55-70 MPH. THE CONTACT STATED THAT ONLY THE STEERING WHEEL AIR BAG DEPLOYED. NONE OF THE SIDE IMPACT AIR BAGS DEPLOYED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE IMPACT OF THE CRASH CAUSED THE GEAR SHIFT, DASHBOARD, AND BATTERY COMPARTMENTS OF THE CONTACT'S VEHICLE TO CRUMBLE INWARD AND BREAK APART. AS A RESULT, THE CONTACT'S RIGHT LEG AND HIP WERE PINNED DOWN. THE CONTACT STRUCK THE WINDSHIELD AND SUFFERED A DISLOCATED KNEE CAP, PELVIS FRACTURES IN THREE PLACES, FOUR BROKEN RIBS, NINE STITCHES TO THE FOREHEAD, CUTS AND BRUISES ON BOTH ARMS, TWO SEIZURES, AND A BURN TO THE FACE DUE TO THE STEERING WHEEL AIR BAG. THE OTHER DRIVER SUFFERED HEAD INJURIES. THE CONTACT WAS HOSPITALIZED FOR FIVE DAYS. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED BY THE CONTACT'S INSURANCE COMPANY TO THEIR LOCATION FOR INVESTIGATION. FINDLAY VOLKSWAGEN (983 AUTO SHOW DR, HENDERSON, NV 89014, (702) 558-6600) WAS INFORMED OF THE FAILURE AND ADVISED THE CONTACT TO CALL NHTSA. THE VEHICLE WAS CURRENTLY IN THE PROCESS OF BEING APPRAISED TO DETERMINE IF IT WAS TOTALED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 48,000.

NHTSA ID

11253720

Incident

Sep 1, 2019

Mileage

48,000 mi

TL* THE CONTACT OWNS A 2013 VOLKSWAGEN CC. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V148000 (AIR BAGS). THE CONTACT CALLED HERITAGE VOLKSWAGEN OF SOUTH ATLANTA AT 678-263-3711 (LOCATED AT 305 JONESBORO RD, UNION CITY, GA 30291) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT PROVIDED.

NHTSA ID

11242356

Incident

Mar 6, 2018

REGARDING THE ONGOING INVESTIAGTION FOR FAILED REPLACEMENT OF THE CLOCK SPRING RECALL. (NHTSA ACTION NUMBER: EA18003). TWO WEEKS AGO, WHILE TURNING INTO A PARKING SPOT MY STEERING WHEEL MADE A DISCERNING CLICKING SOUND. AFTER RETURNING TO MY CAR I NOTICED AN AIRBAG ERROR AS WELL AS ALL CONTROLS ON THE STEERING WHEEL NOT FUNCTIONING INCLUDING THE HORN. SINCE THEN THESE PROBLEMS HAVE REMAINED. I HAVE CHECKING MY VIN TO SEE IF THE PREVIOUS OWNER HAD THE CLOCK SPRING REPLACED FOR THE RECALL BUT THERE ARE NONE. I PRESUME THAT THE REPLACEMENT CLOCK SPRING IS FAULTY JUST LIKE THE ONE THAT WAS REPLACED.

NHTSA ID

11234060

Incident

Jul 5, 2019

Mileage

77,000 mi

WHILE DRIVING IN RUSH HOUR TRAFFIC AT 43 TO 50 MPH, VEHICLE SUDDENLY LOSS ABILITY TO MOVE WHILE ENGINE WAS STILL RUNNING, (LIKE IT HAD BEEN SWITCHED TO NEUTRAL). THE ENGINE JUST REVVED AS THE CAR CAME TO A STOP ON THE HIGHWAY WITHOUT WARNING. THE PARK BRAKE LIGHT CAME ON AND THE DRIVE INDICATOR LIGHT STARTED FLASHING. THIS WAS A VERY UNSAFE CONDITION WHILE OTHER DRIVERS WERE BLOWING AND YELLING AT ME FOR BLOCKING TRAFFIC. AFTER SITTING FOR ABOUT 7 TO 10 MINUTES THE VEHICLE WAS RESTARTED AND DROVE NORMALLY.

NHTSA ID

11232364

Incident

Jul 9, 2019

Mileage

49,391 mi

LOW BEAM LIGHTS STOP WORKING. TURN LIGHTS OFF AND THEN BACK ON, LIGHTS WOULD WORK FOR 3 MINUTES. MUST REPEAT TO KEEP LIGHTS ON. THIS IS BOTH IN MOTION AND STATIONARY.

NHTSA ID

11222607

Incident

Jun 25, 2019

Mileage

40,000 mi

Prevent Sporatic Misfire Faults.

Reprogramming Control Module process

Engine missfire diagnostic aid

Identifying and Mixing Volkswagen Engine Coolants

Safety Related Inquiry and Reporting

Suggested fuel additive