2011 Volkswagen Cc

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.

The contact owns a 2011 Volkswagen CC. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. Additionally, the horn was inoperable. The vehicle was taken to the dealer where it was diagnosed with clockspring failure. The dealer informed the contact that the clockspring needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA. The failure mileage was approximately 165,000.

NHTSA ID

11475774

Incident

Jul 25, 2022

Mileage

165,000 mi

TL* THE CONTACT'S SON OWNS A 2011 VOLKSWAGEN CC SPORT. THE CONTACT STATED THAT WHEN HER SON STARTED THE VEHICLE, THE STEERING COLUMN LOCK INDICATOR LIGHT FLASHED ON THE INSTRUMENT PANEL. THE VEHICLE TURNED OFF INDEPENDENTLY. THE CONTACT'S SON RESTARTED THE VEHICLE AND TURNED THE STEERING WHEEL TO DISENGAGE THE LOCK TO KEEP THE VEHICLE IDLING. THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO GENE LANGAN VOLKSWAGEN (816 NEW LONDON TPKE, GLASTONBURY, CT 06033, (860) 633-0261) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE STEERING CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DECLINED TO ASSIST WITH THE REPAIRS. THE FAILURE MILEAGE WAS 127,000.*DT THE CONSUMER STATED THEY HAD TO MAKE REPAIRS TO THE VEHICLE DUE TO THE FACT THE MANUFACTURER STATED THEIR VIN WAS NOT INCLUDED IN THE RECALL. *TR

NHTSA ID

11384681

Incident

Nov 16, 2020

Mileage

127,000 mi

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN CC. THE CONTACT STATED THAT THERE WAS A PROGRESSING INTERMITTENT ELECTRICAL AND FUEL SYSTEM FAILURE WITH THE VEHICLE. THE BATTERY WAS REPLACED MORE THAN FOUR TIMES. THE CONTACT STATED THAT THERE WAS REDUCED POWER TO THE POINT THAT THE VEHICLE COULD SHUT DOWN AT ANY MOMENT, CREATING THE RISK FOR A POTENTIAL CRASH. THE VEHICLE WAS DRIVEN TO CITY CHEVROLET OF SAN DIEGO (2111 MORENA BLVD, SAN DIEGO, CA 92110, (619) 597-1636). THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE, BUT INDICATED THAT IT MAY BE RELATED TO NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 4,700.

NHTSA ID

11231084

Incident

Jan 10, 2014

Mileage

4,700 mi

TIMING CHAIN TENSIONER

NHTSA ID

11204802

Incident

Apr 30, 2019

I WAS LEAVING THE STORE WHEN I NOTICED MY VEHICULAR WOULDN'T GO OVER 30 MPH. I PULLED INTO ANOTHER STORE TO ASSESS THE SITUATION. WHEN I TURNED MY CAR BACK ON AND WAS ATTEMPTING TO LEAVE MY CAR STOPPED WORKING. I HAD IT TOWED TO THE SHOP AND THEY ADVISED ME TO CALL VOLKSWAGEN BECAUSE THIS ISSUES WAS LIKELY COVERED UNDER A WARRANTY. I CALLED VOLKESWAGEN AND THEY SAID MY WARRANTY WOULD COVER IT UP TO 120K MILES AND TO TAKE IT TO THE LOCAL DEALERSHIP. I HAD THE CAR TOWED AGAIN TO THE DEALERSHIP AND THEY INFORMED ME THAT THE TIMING CHAIN WAS BROKEN AND THEY SAID MY WARRANTY JUST EXPIRED AT 100K MILES. MY CAR HAS 108K MILES. AFTER DOING A LOT OF RESEARCH I FOUND THIS TO BE A FREQUENT PROBLEM WITH THIS MANUFACTURE. I ALSO FOUND THAT THERE WAS ALREADY A CLASS ACTION LAWSUIT BUT MY VEHICLE WASN'T IN THE PERAMITERS BECAUSE OF THE MILEAGE (ENDS AT 100K). I NEVER RECEIVED NOTICE OF THE RECALL OR I WOULD HAVE TAKEN IT IN TO GET LOOKED AT BEFORE THE 100K MIKE CUTOFF. BECAUSE THEY SAID THIS WASN'T COVERED IN THE WARRANTY, I LOOKED INTO BUYING ANOTHER CAR FROM THEM. THEY INFORMED ME THAT THEY COULD GIVE ME $250 FOR MY VEHICLE. NOW I KNOW VOLKSWAGEN IS TRYING TO AVOID PAYING FOR THIS BECAUSE THEY KNOW THEY CAN MAKE MONEY.

NHTSA ID

11191490

Incident

Mar 16, 2019

Mileage

108 mi

VEHICLE KEEPS MISFIRING. CHECK ENGINE LIGHT REMAINS ON. EPC LIGHT COMES ON PERIODICALLY AFTER FUEL PUMP WAS REPLACED. WHILE DRIVING CAR JERKS AND CHECK ENGINE LIGHT BEGINS TO FLASH. LOTS OF WEAR TO TIRES WITHIN A FEW THOUSAND MILES. BREAKS MUST BE PUSH ON HARD TO STOP. THE DEALERSHIP SAID THE ONLY THING THAT WAS WRONG WAS A CODE FOR CARBON BUILDUP. DEALERSHIP WOULD NOT PROVIDE CODE JUST A PRICE OF $1000. SPARK PLUGS AND COILS WERE CHANGED BEFORE PURCHASING VEHICLE. I'M CERTAIN THE FUEL PUMP WAS NOT CHANGED. THE VEHICLE USES 1/8 OF A TANK TO WARM UP.

NHTSA ID

11190388

Incident

Aug 25, 2018

Mileage

103,000 mi

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN CC. THE CONTACT STATED THAT THE ENGINE WOULD NOT START. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO OURISMAN HONDA OF LAUREL (3371 LAUREL FORT MEADE RD, LAUREL, MD 20724, (301) 498-7400) WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPAIRED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

NHTSA ID

11189946

Incident

Sep 1, 2018

Mileage

60,000 mi

BOUGHT THE CAR USED AND TOOK IT TO A MECHANIC TO GET IT CHECKED OUT. LOW AND BEHOLD THEY INFORMED ME I HAVE A FAILING POWER STEERING MODULE, REAR MAIN SEAL, CARBON BUILD UP ON THE INTAKE, AS WELL AS CRACKS IN BOTH FRONT CONTROL ARMS. TOOK IT TO A DEALER WHO CONFIRMED THIS DIAGNOSIS AND GAVE ME A $6250 QUOTE FOR THE WORK. CAR WAS DRIVING FINE AND FELT GREAT. AFTER TAKING IT TO THE SHOP THE CHECK ENGINE LIGHT WAS ON. CAR HAS 90K ON IT AND WAS UNDER WARRANTY UNTIL THEN. ALL THESE ITEMS WERE NEGLECTED BY THE DEALER.

NHTSA ID

11181382

Incident

Feb 17, 2019

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Instruction, how to lubicate engine before initial start.

Lubricating engine components before reassembly.

Inquiries

Volkswagen Engine Oil Standards