2002 Volkswagen Golf Electrical Problems

TL* THE CONTACT OWNS 2002 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START IN RAINY WEATHER. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE IGNITION COIL WOULD NEED TO BE REPLACED. THE CONTACT LOCATED A VOLUNTARY MANUFACTURERS RECALL FOR THE FAILURE BUT WAS ADVISED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN THE VOLUNTARY RECALL. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 150,000.

NHTSA ID

10390105

Incident

Mar 8, 2011

Mileage

150,000 mi

MY 2002 VW GOLF HAS A DEFECT IN THE IMMOBILIZER THAT DEALERS CAN NOT DIAGNOSE OR REPAIR. ONCE THE KEY IS TURNED OFF, THE CAR SOMETIMES WILL NOT RESTART. IT HAS BEEN TOWED TO THE DEALER ON MULTIPLE OCCASIONS - BUT AFTER A VARIABLE TIME INTERVAL THE CAR STARTS AGAIN. SINCE IT STARTS - THREE DEALERS HAVE BEEN UNABLE TO DIAGNOSE WHY IT FAILS TO RECOGNIZE THE KEY. I AM FURIOUS THAT THE IMMOBILIZER CIRCUIT CAN NOT BE REPAIRED OR INACTIVATED. I LIVE IN THE COUNTRY AND AM AFRAID TO TURN THE CAR OFF IN A REMOTE LOCATION FOR FEAR IT WILL NOT RESTART - AND LEAVE ME STRANDED 20 MILES FROM NOWHERE. IT COULD STRAND MY WIFE AND INVALID DAUGHTER. THE CAR COULD NOT BE MOVED IN AN EMERGENCY, LIKE CLEARING THE WAY FOR EMERGENCY VEHICLES, OR GETTING OFF THE SIDE OF THE ROAD IF I PULL OVER AND STOP. VOLKSWAGEN IS UNRESPONSIVE TO THE PROBLEM - I HAVE SPOKEN TO USA HEADQUARTERS WHO HAS NOT RESPONDED. THE CAR IS NOT SAFE TO TAKE ON THE ROAD BECAUSE IT CAN UNPREDICTABLY FAIL TO DRIVE. THIS HAS HAPPENED 8 TIMES IN THE PAST 12 MONTHS, AND HAS BEEN TO SERVICE DEPARTMENT 3 TIMES WITH NO CURE. *TR

NHTSA ID

10229406

Incident

May 9, 2008

Mileage

130,000 mi

2002 VOLKSWAGEN GOLF HAS HAD NUMEROUS PROBLEMS. THE MOST RECENT PROBLEM IS THAT THE COIL SPRING BROKE WHILE THE CONSUMER WAS DRIVING CAUSING DAMAGE TO THE STRUT. NOW THE CONSUMER HAS TO PAY TO GET THE VEHICLE FIXED. *KB THE CONSUMER STATED THE PROBLEMS STARTED AFTER THE WARRANTY ENDED. THE BATTERY DIED. 5 DAYS LATER, THE MIL APPEARED AND THE VEHICLE WAS MISFIRING. IN MARCH OF 2007 THE ENGINE LIGHT ILLUMINATED DUE TO A FAULTY COIL. IN APRIL OF 2007 THE BATTERY LIGHT ILLUMINATED DUE TO A FAILED ALTERNATOR. *JB THE RIGHT HEADLIGHT WAS INOPERATIVE, THE CATALYTIC CONVERTER WAS REPLACED. UPDATED 12/12/07

NHTSA ID

10201525

Incident

Aug 11, 2007

Mileage

26,466 mi

THERE IS A FAULTY BRAKE SWITCH WHICH CAUSES THE CAR TO BE LOCKED IN PARK. IT HAD TO BE TOWED TO A DEALER FOR REPAIRS. OTHER MODELS OF THE 2002 GOLF HAVE A RECALL FOR THE SAME PROBLEM.

NHTSA ID

10177056

Incident

Dec 24, 2006

HELLO, MY WIFE HAS A VOLKSWAGEN GOLF. HER VOLKSWAGEN IS HAVING CERTAIN PROBLEMS WITH THE ELECTRICAL SYSTEM. THE SUNROOF IS OPERATING WHEN THE CAR IS ON OR OFF BY ITSELF. RAIN IS SOME HOW GETTING INTO THE CAR AND INTO THE OVERHEAD LIGHT. HER TAIL LIGHTS HAVE A MIND OF THERE OWN. SO DAYS THE TAILS WILL WORK AND OTHERS THEY WON'T. I HAVE PHYSICALLY CHECKED THE BULBS AND HAVE PUT NEW ONES IN AND STILL THEY DO NOT WORK. HER RADIO WILL NOT WORK. AND HER TRANSMISSION HAS BEEN LOOKED AT SEVERAL OF TIMES AND STILL CONTINUES TO HAVE THE SAME PROBLEM. IS THERE ANYWAY YOU CAN CHECK THESE PROBLEMS? *JB

NHTSA ID

10158000

Incident

May 22, 2006

THE CAR HAS A TILT/TELESCOPE STEERING COLUMN, AFTER ADJUSTING THE COLUMN THE TURN SIGNALS QUIT WORKING. COULD NOT RESTART THE CAR AFTER TURNING IT OFF BECAUSE IMMOBILIZER WOULD NOT RECOGNIZE THE KEY. MULTIPLE FUSES WERE BLOWN OUT, INCLUDING THE ONE FOR THE HAZARD FLASHER. UPON INVESTIGATION THE FAILURE WAS FROM THE WIRING HARNESS FOR THE STEERING COLUMN, THE INSULATION ON MOST OF THE WIRES WAS CRACKED AND THE TURN SIGNAL WIRES SHORTED OUT. THE INSULATION FOR THE MAIN POWER WIRES RUNNING INTO THE IGNITION SWITCH ALSO WERE CRACKED, IF THESE SHORTED OUT IT COULD HAVE CAUSED A FIRE. MOST OF THE INSULATION IN THIS AREA HAS HARDENED AND IS NOT VERY FLEXIBLE, MAKING IT PRONE TO CRACKING. TEMPORARY REPAIR HAS BEEN TAPING UP ALL THE EXPOSED WIRES WITH ELECTRICAL TAPE. HAVE NOT YET CHECKED INTO THE AVAILABILITY OF A REPLACEMENT WIRING HARNESS. *JB

NHTSA ID

10150674

Incident

Feb 18, 2006

Mileage

110,000 mi

MULTIPLE PROBLEMS INCLUDED: MALFUNCTION INDICATOR LAMP ON, VEHICLE CUT OFF, TRUNK SWITCH FELL OUT, DRIVER DOOR LOCK INOPERATIVE, FUEL GAUGE INOPERATIVE, ENGINE RATTLE. MULTIPLE REPLACEMENTS - CAMSHAFT SENSOR, TRUNK SWITCH, POWER DOOR LOCKS, FUEL LINES INSTALLED, FUEL SENDER UNIT, TIMING BELT AND TENSIONER. *TT *JB

NHTSA ID

10026474

Incident

Mar 25, 2003

Mileage

5,415 mi

THE COIL PACK WAS DAMAGED. *MR THE COIL PACK WAS REPLACED. THEN THE COIL PACK IN THE CYLINDER FAILED. THE CONSUMER REQUESTED FOR VW TO COMPENSATE HER FOR LOST TIME. THE ENGINE LIGHT HAD COME ON DUE TO THE EVAPORATIVE EMISSION SYSTEM EXPERIENCED AN INCORRECT PURGE FLOW. THE WINDSHIELD WASHER RESERVOIR LEAKED COOLANT. THE EXPANSION TANK WAS REPLACED. SCC *JB

NHTSA ID

10012216

Incident

Nov 7, 2002

INTERMITTENTLY VEHICLE WILL LOSE ALL POWER WITHOUT WARNING WHEN DRIVING. DEALERSHIP INDICATED THAT IT IS A RESULT OF A PROBLEM WITH IGNITION COIL.TS.*AK

NHTSA ID

10004216

Incident

Jun 2, 2002

Mileage

24 mi