2002 Volkswagen Golf Problems

WHILE DRIVING AT ABOUT 45 MILES PER HOUR, THE SIDE CURTAIN AND SEAT BOLSTER AIRBAGS DEPLOYED ON THEIR OWN. THERE WAS NO IMPACT TO THE VEHICLE THAT PRECEDED THIS INCIDENT. THE AIRBAGS SIMPLY DEPLOYED BY THEMSELVES. THIS SEEMS TO BE A RECURRING PROBLEM WITH THIS GENERATION OF VOLKSWAGENS: HTTP://WWW.CARCOMPLAINTS.COM/VOLKSWAGEN/GOLF/2002/SEAT_BELTS_AIR_BAGS/AIR_BAGS-SIDE_WINDOW.SHTML

ON SATURDAY AUG 7TH I WAS DRIVING MY 2002 VW GOLF ON THE HIGHWAY WHEN THE PASSENGER SIDE AIRBAG DEPLOYED. THE ROAD WAS SMOOTH WITH NO BUMPS OR POTHOLES, NOTHING HIT THE CAR, IT WAS TOTALLY SPONTANEOUS. LUCKILY THERE WERE NO PASSENGERS IN THE CAR. I HAVE CONTACTED MY LOCAL VW SERVICE SHOP AND WILL TAKE THE CAR IN SO THEY CAN IDENTIFY THE CAUSE OF THE DEPLOYMENT. *TR

TL* THE CONTACT OWNS A 2002 VOLKSWAGEN GOLF WITH A TDI ENGINE. THE CONTACT STATED THAT THE VEHICLE SUDDENLY ACCELERATED. THE CONTACT HAD TO POP THE CLUTCH AND KILL THE IGNITION, BUT THE ENGINE CONTINUE TO OPERATE UNTIL THE VEHICLE RAN OUT OF FUEL. THE CONTACTS MECHANIC INSPECTED THE VEHICLE AND STATED THAT THE TURBO CHARGER SEALS WERE NOT LEAKING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 53,000. *TR

HIGHWAY ON RAMP ENGINE REVVED UNCONTROLLABLY UNTIL FAILURE NEW ENGINE NEEDED. *TR

THERE WAS A BRAKE SWITCH SHORT THAT CAUSED THE CAR TO BE STUCK IN PARK. SO IT HAD TO BE DRAGGED OUT AND WAS SENT TO VOLKSWAGEN SERVICE. *TR

2002 VW GOLF WITH CRUISE CONTROL PROBLEM CUSTOMER STATES THAT THE CAR ACCELERATED INTO FIFTH GEAR WHEN SHE TOOK HER FOOT OFF THE BRAKE**CC THE CONSUMER DETERMINED THAT STEPPING ON THE BRAKE DID NOT DISENGAGE THE CRUISE CONTROL. THE CONSUMER STATED THE FOLLOWING DAY, WHEN HE BACKED HIS VEHICLE UP TO THE GARAGE DOOR, HE NOTICED THE BRAKE LIGHT/ STOP LIGHT DID NOT ILLUMINATED WHEN HE STEPPED ON THE BRAKE. THE CONSUMER BELIEVED THE FAILURE WAS THE ROOT CAUSE FOR THE CRUISE CONTROL'S FAILURE TO DISENGAGE. THE CONSUMER TOOK THE VEHICLE TO THE DEALER AND UPON INSPECTION IT WAS DETERMINED THAT THE REPLACEMENT BRAKE LIGHT SWITCH THAT HAD BEEN INSTALLED PREVIOUSLY UNDER RECALL WAS DEFECTIVE. *JB

TL* THE CONTACT OWNS 2002 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START IN RAINY WEATHER. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE IGNITION COIL WOULD NEED TO BE REPLACED. THE CONTACT LOCATED A VOLUNTARY MANUFACTURERS RECALL FOR THE FAILURE BUT WAS ADVISED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN THE VOLUNTARY RECALL. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 150,000.

MY 2002 VW GOLF HAS A DEFECT IN THE IMMOBILIZER THAT DEALERS CAN NOT DIAGNOSE OR REPAIR. ONCE THE KEY IS TURNED OFF, THE CAR SOMETIMES WILL NOT RESTART. IT HAS BEEN TOWED TO THE DEALER ON MULTIPLE OCCASIONS - BUT AFTER A VARIABLE TIME INTERVAL THE CAR STARTS AGAIN. SINCE IT STARTS - THREE DEALERS HAVE BEEN UNABLE TO DIAGNOSE WHY IT FAILS TO RECOGNIZE THE KEY. I AM FURIOUS THAT THE IMMOBILIZER CIRCUIT CAN NOT BE REPAIRED OR INACTIVATED. I LIVE IN THE COUNTRY AND AM AFRAID TO TURN THE CAR OFF IN A REMOTE LOCATION FOR FEAR IT WILL NOT RESTART - AND LEAVE ME STRANDED 20 MILES FROM NOWHERE. IT COULD STRAND MY WIFE AND INVALID DAUGHTER. THE CAR COULD NOT BE MOVED IN AN EMERGENCY, LIKE CLEARING THE WAY FOR EMERGENCY VEHICLES, OR GETTING OFF THE SIDE OF THE ROAD IF I PULL OVER AND STOP. VOLKSWAGEN IS UNRESPONSIVE TO THE PROBLEM - I HAVE SPOKEN TO USA HEADQUARTERS WHO HAS NOT RESPONDED. THE CAR IS NOT SAFE TO TAKE ON THE ROAD BECAUSE IT CAN UNPREDICTABLY FAIL TO DRIVE. THIS HAS HAPPENED 8 TIMES IN THE PAST 12 MONTHS, AND HAS BEEN TO SERVICE DEPARTMENT 3 TIMES WITH NO CURE. *TR

WHILE DRIVING MY WIFE WAS DRIVING OUR 2002 VW GOLF THE DRIVER SIDE WINDOW DROPPED. TURNS OUT ALL OVER THE INTERNET THERE ARE COMPLAINTS OF THE TABS HOLDING THE WINDOWS BREAKING. IN FACT WHEN I WAS AT THE DEALER I FELLOW OVERHEARD ME AND SAID HE HAD THE EXACT SAME PROBLEM ON HIS 2001 VW GTI. VW HAD A TSB AND EXTENDED THE WARRANTY BY A FEW YEARS ON THIS BUT IS SHOULD HAVE BEEN A RECALL. A WINDOW DROPPING IS A HUGE SAFETY FACTOR FOR A NUMBER OF REASONS. THE WINDOW IS A PROTECTION DEVICE TO SHIELD YOU IN AN ACCIDENT OR FROM DEBRIS AT 65MPH AND FOR YOUR OWN PERSONAL SAFETY IF ON THE WRONG SIDE OF TOWN. I CALLED THE VW DEALER TO SEE IF THEY WOULD FIX THIS PROBLEM THEY SAID YES THEY WOULD FIX IT FOR FREE YET UPON ARRIVING I WAS TOLD I WAS ONE MONTH OUT OF THE EXTENDED WARRANTY. THE DROPPING OF THIS WINDOW CAUSED MY WIFE TO HAVE TO PULL OVER ON A BUSY EXPRESSWAY BECAUSE SHE COULD NOT SEE IN THE RAIN WITH IT BLOWING IN HER WINDOW. ONCE A GAIN A FAULTY WINDOW HOLDING MECHANISM IS A SAFETY ISSUE AND SHOULD BE A RECALL ITEM. *TR

THE DRIVER'S SIDE WINDOW REGULATOR RECENTLY FAILED ON MY 2002 VW GOLF. THIS PART SECURES THE WINDOW TO THE POWER WINDOW MECHANISM, AND KEEPS THE WINDOW UP. THE FAILURE OCCURRED WHILE I WAS LEAVING A TOLL BOOTH. I PRESSED THE BUTTON TO RAISE THE WINDOW, HEARD A CRACK, AND THEN THE ENTIRE WINDOW VIOLENTLY CRASHED DOWN INTO THE INTERIOR OF THE DOOR, AND ATTEMPTS TO RAISE THE WINDOW FAILED. I WAS LUCKY THAT I WAS ONLY DRIVING ABOUT 20 MPH AT THE TIME, BUT UNFORTUNATELY I HAD TO DRIVE HOME FIVE HOURS WITH THE WINDOWS DOWN. IT WAS A VERY UNPLEASANT EXPERIENCE. WHEN I RETURNED HOME, UPON BRINGING THE CAR IN TO THE DEALERSHIP, I LEARNED THAT IT WAS THE WINDOW REGULATOR THAT HAD FAILED. I ALSO LEARNED THAT THIS PART HAS FAILED NUMEROUS TIMES ON GOLFS OF THIS MODEL YEAR (AND OTHER YEARS), AND THAT AN EXTENDED WARRANTY OF 7 YEARS WAS PLACED ON THE PART. I STRONGLY BELIEVE THAT A RECALL SHOULD HAVE BEEN PLACED ON THIS PART INSTEAD OF SIMPLY A WARRANTY EXTENSION. I HAVE HEARD NUMEROUS ANECDOTES OF PEOPLE HAVING THIS SAME PROBLEM. THE WINDOW CRASHES VIOLENTLY, AND HAD I BEEN DRIVING FAST OR IN TRAFFIC, THIS COULD HAVE CAUSED AN ACCIDENT VERY EASILY. WHAT'S MORE, ONE CANNOT PROTECT THE CAR FROM THEFT OR WATER DAMAGE WHEN THE WINDOW WON'T CLOSE. ACCORDING TO VW, A STURDIER REPLACEMENT PART WAS DESIGNED AROUND 2002, AND MY CAR IS NOW BEING FIXED WITH THIS PART. *TR

THE CAR HAS A TILT/TELESCOPE STEERING COLUMN, AFTER ADJUSTING THE COLUMN THE TURN SIGNALS QUIT WORKING. COULD NOT RESTART THE CAR AFTER TURNING IT OFF BECAUSE IMMOBILIZER WOULD NOT RECOGNIZE THE KEY. MULTIPLE FUSES WERE BLOWN OUT, INCLUDING THE ONE FOR THE HAZARD FLASHER. UPON INVESTIGATION THE FAILURE WAS FROM THE WIRING HARNESS FOR THE STEERING COLUMN, THE INSULATION ON MOST OF THE WIRES WAS CRACKED AND THE TURN SIGNAL WIRES SHORTED OUT. THE INSULATION FOR THE MAIN POWER WIRES RUNNING INTO THE IGNITION SWITCH ALSO WERE CRACKED, IF THESE SHORTED OUT IT COULD HAVE CAUSED A FIRE. MOST OF THE INSULATION IN THIS AREA HAS HARDENED AND IS NOT VERY FLEXIBLE, MAKING IT PRONE TO CRACKING. TEMPORARY REPAIR HAS BEEN TAPING UP ALL THE EXPOSED WIRES WITH ELECTRICAL TAPE. HAVE NOT YET CHECKED INTO THE AVAILABILITY OF A REPLACEMENT WIRING HARNESS. *JB

TURN SIGNAL/HAZARD RELAY ACTIVATES RANDOMLY. WHILE DRIVING DOWN THE ROAD I CAN HEAR THE TURN SIGNAL RELAY CLICKING AT A FASTER SPEED, LIKE WHEN YOU HAVE A BURNED OUT TURN SIGNAL BULB. BUT, WHEN YOU GO TO USE THE TURN SIGNAL/HAZARD SIGNAL, THEY STILL FUNCTION AS NORMALY. I BELIEVE THIS ISSUE IS RELATED TO RECAL 04V584000, YET VOLKSWAGEN OF AMERICA DOES NOT RECOGNIZE MY VEHICLE AS BEING PART OF THIS RECAL. *AK

DIESEL FUEL LEAK- WHEN FILLING TANK TO FULL, FUEL POURS OUT SOMEWHERE AT THE TOP OF THE TANK. *LA

MULTIPLE PROBLEMS INCLUDED: MALFUNCTION INDICATOR LAMP ON, VEHICLE CUT OFF, TRUNK SWITCH FELL OUT, DRIVER DOOR LOCK INOPERATIVE, FUEL GAUGE INOPERATIVE, ENGINE RATTLE. MULTIPLE REPLACEMENTS - CAMSHAFT SENSOR, TRUNK SWITCH, POWER DOOR LOCKS, FUEL LINES INSTALLED, FUEL SENDER UNIT, TIMING BELT AND TENSIONER. *TT *JB

2002 VOLKSWAGEN GOLF HAS HAD NUMEROUS PROBLEMS. THE MOST RECENT PROBLEM IS THAT THE COIL SPRING BROKE WHILE THE CONSUMER WAS DRIVING CAUSING DAMAGE TO THE STRUT. NOW THE CONSUMER HAS TO PAY TO GET THE VEHICLE FIXED. *KB THE CONSUMER STATED THE PROBLEMS STARTED AFTER THE WARRANTY ENDED. THE BATTERY DIED. 5 DAYS LATER, THE MIL APPEARED AND THE VEHICLE WAS MISFIRING. IN MARCH OF 2007 THE ENGINE LIGHT ILLUMINATED DUE TO A FAULTY COIL. IN APRIL OF 2007 THE BATTERY LIGHT ILLUMINATED DUE TO A FAILED ALTERNATOR. *JB THE RIGHT HEADLIGHT WAS INOPERATIVE, THE CATALYTIC CONVERTER WAS REPLACED. UPDATED 12/12/07

VW GOLF 2002 60K TURN SINGALS KEEP ON CLICKING. POSSIBLE LINK TO USING ARMORALL POLISH? *JB

Certain conditions cause the electrics door locks to not function. When this happens, it is not possible to exit the car from the inside as the door handles are not operative creating a trapped situation potentially leading to injury or death if the case of a fire.

WHILE DRIVING MY WIFE WAS DRIVING OUR 2002 VW GOLF THE DRIVER SIDE WINDOW DROPPED. TURNS OUT ALL OVER THE INTERNET THERE ARE COMPLAINTS OF THE TABS HOLDING THE WINDOWS BREAKING. IN FACT WHEN I WAS AT THE DEALER I FELLOW OVERHEARD ME AND SAID HE HAD THE EXACT SAME PROBLEM ON HIS 2001 VW GTI. VW HAD A TSB AND EXTENDED THE WARRANTY BY A FEW YEARS ON THIS BUT IS SHOULD HAVE BEEN A RECALL. A WINDOW DROPPING IS A HUGE SAFETY FACTOR FOR A NUMBER OF REASONS. THE WINDOW IS A PROTECTION DEVICE TO SHIELD YOU IN AN ACCIDENT OR FROM DEBRIS AT 65MPH AND FOR YOUR OWN PERSONAL SAFETY IF ON THE WRONG SIDE OF TOWN. I CALLED THE VW DEALER TO SEE IF THEY WOULD FIX THIS PROBLEM THEY SAID YES THEY WOULD FIX IT FOR FREE YET UPON ARRIVING I WAS TOLD I WAS ONE MONTH OUT OF THE EXTENDED WARRANTY. THE DROPPING OF THIS WINDOW CAUSED MY WIFE TO HAVE TO PULL OVER ON A BUSY EXPRESSWAY BECAUSE SHE COULD NOT SEE IN THE RAIN WITH IT BLOWING IN HER WINDOW. ONCE A GAIN A FAULTY WINDOW HOLDING MECHANISM IS A SAFETY ISSUE AND SHOULD BE A RECALL ITEM. *TR

AIR BAG LIGHT CAME ON. WHEN TAKEN IN FOR FIX IT WAS FOUND TO BE A FAULTY SWITCH IN THE DRIVER SIDE SEAT BELT BUCKLE. IT WAS JUST RECENTLY REPLACED AND SO FAR NO FURTHER PROBLEMS. *TR

AIR BAG LIGHT IS ON IN VEHICLE BECAUSE OF A POOR ELECTRICAL CONNECTION IN THE DRIVER'S SIDE SEAT BELT CLASP, WHICH WAS ALREADY REPLACED ONCE WHILE VEHICLE WAS STILL UNDER FACTORY WARRANTY, ABOUT 2YRS AND 30K MILES AGO. THE LOCKING MECHANISM OF THE SEAT BELT CLASP ITSELF STILL WORKS, HOWEVER, WHILE THE AIR BAG LIGHT IS ON BECAUSE OF THE FAILED ELECTRICAL CONNECTION IN THE CLASP, AIR BAGS WILL NOT DEPLOY, WHICH RISKS MY AND MY PASSENGERS' LIFE AND SAFETY. TO REPLACE THE PART, I INCURRED A $75 DIAGNOSTIC FEE FROM A LOCAL MECHANIC AND PURCHASED A NEW PART FOR $161, WHICH I WILL INSTALL MYSELF TO SAVE ANOTHER $75 INSTALLATION FEE. TOTAL ECONOMIC LOSS TO ME WAS $236, BUT COULD HAVE BEEN $311 IF I DIDN'T HAVE THE TOOLS AND TIME TO DO IT MYSELF. THE OLD SEAT BELT CLASP WILL BE AVAILABLE FOR INSPECTION. *TR

THE CAR HAS A TILT/TELESCOPE STEERING COLUMN, AFTER ADJUSTING THE COLUMN THE TURN SIGNALS QUIT WORKING. COULD NOT RESTART THE CAR AFTER TURNING IT OFF BECAUSE IMMOBILIZER WOULD NOT RECOGNIZE THE KEY. MULTIPLE FUSES WERE BLOWN OUT, INCLUDING THE ONE FOR THE HAZARD FLASHER. UPON INVESTIGATION THE FAILURE WAS FROM THE WIRING HARNESS FOR THE STEERING COLUMN, THE INSULATION ON MOST OF THE WIRES WAS CRACKED AND THE TURN SIGNAL WIRES SHORTED OUT. THE INSULATION FOR THE MAIN POWER WIRES RUNNING INTO THE IGNITION SWITCH ALSO WERE CRACKED, IF THESE SHORTED OUT IT COULD HAVE CAUSED A FIRE. MOST OF THE INSULATION IN THIS AREA HAS HARDENED AND IS NOT VERY FLEXIBLE, MAKING IT PRONE TO CRACKING. TEMPORARY REPAIR HAS BEEN TAPING UP ALL THE EXPOSED WIRES WITH ELECTRICAL TAPE. HAVE NOT YET CHECKED INTO THE AVAILABILITY OF A REPLACEMENT WIRING HARNESS. *JB

CONSTANT NOISE FROM THE STEERING COLUMN. AIR BAG SPRING CHANGED TWICE. STEERING COLUMN STILL MAKING NOISE. *JB

VEHICLE SLOWED DRAMATICALLY AT HIGHWAY SPEED DOWN TO 35 MPH, I HAD TO USE THE EMERGENCY BLINKERS TO GET TO THE SLOW LANE, A VERY DANGEROUS SITUATION ON A CONGESTED HIGHWAY. CLUTCH AND FLYWHEEL REPLACED, AND THE SAME FAILURE HAPPENED AGAIN WITH OEM PARTS ONLY 3 WEEKS LATER. *AK

1. TRANSMISSION CONTROL MODULE FAILURE. CAR WAS NOT ABLE TO START. WAS TOWED FOR REPAIR. THIS CHIP HAS BEEN REPLACED TWICE. 2. CAR BEGAN MAKING SEVERE JERKING MOVEMENTS, RANDOMLY. USUALLY THESE JUMPS OCCUR WITHIN THE FIRST 10 MINUTES OF DRIVING THE VEHICLE BUT CAN OCCUR LATER. THE SEVERITY OF THE JERKS IS ALSO VARIABLE. 3. THE CAR WAS IN THE SHOP FOR OVER A MONTH. THE PROBLEM WAS NOT CORRECTED. 4. THE CAR CONSUMES AN UNUSUAL HIGH AMOUNT OF MOTOR OIL (MORE THAN A QUART APPROXIMATELY EVERY 1,000 MILES). 5. VW WAS RUNNING A OIL CONSUMPTION TEST BUT THEY INSISTED THE CONSUMPTION LEVEL WAS NORMAL FOR THIS TYPE OF ENGINE. THE PROBLEM STILL EXISTS. I HAVE BEEN EXPERIENCING NUMEROUS MECHANICAL PROBLEMS WITH THE VEHICLE SOON AFTER PURCHASE IN 2002. I HAVE ALWAYS TRIED TO NEGOTIATE WITH VW. I HAVE WRITTEN LETTERS AND THEY HAVE BEEN RELUCTANT TO SOLVE THE PROBLEM IN A SATISFACTORY WAY. I HAVE READ ABOUT THE LEMON LAW BUT MY TIME ALLOWANCE HAS EXPIRED. THE CAR IS STILL UNDER WARRANTY UNTIL JANUARY 2006. IN ADDITION TO THE ENGINE/ TRANSMISSION PROBLEMS, I HAVE HAD PROBLEMS WITH ALL MY WINDOWS ROLLING DOWN AUTOMATICALLY AS I TRY TO CLOSE THEM. THERE WAS A RECALL ON THIS. THIS HAS BEEN EXAMINED OVER 5 TIMES. THE PANELS WERE REPLACED. THE PROBLEM STILL PERSISTS. I AM NOT ABLE TO GIVE AN EXACT DATE OF AN INCIDENT BECAUSE THERE ARE MANY. ALL OF THESE DATES HAVE BEEN DOCUMENTED. I AM GIVING A DATE OF JANUARY 2002 AS THE INCIDENT DATE (WHEN THE CAR WAS PURCHASED). I FEEL VW HAS EVADED RESPONSIBILITY IN CORRECTING THE PROBLEMS AND HAS CREATED AN UNSAFE VEHICLE. THE NUMBER OF FAILURES AND THE INABILITY TO CORRECT THEM IS UNACCEPTABLE. I FEEL MY PROBLEMS WERE NOT ADDRESSED SERIOUSLY AND WERE DISMISSED WITHOUT CONCERN FOR MY SAFETY AND PUBLIC SAFETY IN GENERAL. *JB

ROLL PIN THAT RETAINS DIFFERENTIAL SPIDER GEAR PIN BACKED OUT CAUSING LARGER PIN TO CONTACT INSIDE OF CASE. THE FAILURE INCLUDED A LARGE HOLE IN TRANSMISSION/ DIFFERENTIAL CASE, GEAR AND BEARING DAMAGE. *NM

CONSTANT KNOCKING SOUND COMING FROM THE PASSENGER SIDE FRONT END OF VEHICLE. *JB

BURNING SMELL OCCURRED ON OFF-HIGHWAY ROAD, TRAVELING AT SPEEDS UNDER 5 MPH. HOT SENSATION ON THIGH PROMPTED QUICK ACTION TO TURN OFF VEHICLE / SEAT HEATER WHILE GETTING OUT OF THE VEHICLE A 1/4" HOLE WAS FOUND ON THE LEFT SIDE OF THE DRIVERS SEAT. HARNESS WAS DISCONNECTED AND SERVICE WAS SCHEDULED. *NM

2002 VOLKSWAGEN GOLF HAS HAD NUMEROUS PROBLEMS. THE MOST RECENT PROBLEM IS THAT THE COIL SPRING BROKE WHILE THE CONSUMER WAS DRIVING CAUSING DAMAGE TO THE STRUT. NOW THE CONSUMER HAS TO PAY TO GET THE VEHICLE FIXED. *KB THE CONSUMER STATED THE PROBLEMS STARTED AFTER THE WARRANTY ENDED. THE BATTERY DIED. 5 DAYS LATER, THE MIL APPEARED AND THE VEHICLE WAS MISFIRING. IN MARCH OF 2007 THE ENGINE LIGHT ILLUMINATED DUE TO A FAULTY COIL. IN APRIL OF 2007 THE BATTERY LIGHT ILLUMINATED DUE TO A FAILED ALTERNATOR. *JB THE RIGHT HEADLIGHT WAS INOPERATIVE, THE CATALYTIC CONVERTER WAS REPLACED. UPDATED 12/12/07

SIDEWALLS OF MY DAUGHTER'S VOLKSWAGEN SEPARATED. THE TIRES WERE CONTINENTAL CONTITOURING CONTRACT, 19565R15-91H CH95. *LA

THE VEHICLE HAD A DAMAGED MOTOR. *TT *SCC *JB