Owner-reported complaints naming the interior system, filed with NHTSA
Data refreshed
Reports naming seats, latches, locks, linkages and interior fittings. Every record below is an owner-reported complaint about the 2002 Volkswagen Jetta submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 24 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
WHILE DRIVING OUR JETTA AT APPROXIMATELY 30 MPH THE DRIVERS SIDE CURTAIN AIRBAG AND SIDE SEAT AIRBAG SPONTANEOUSLY DEPLOYED. THERE WAS NO IMPACT. THERE WAS NO POTHOLE. IT WAS THE ONLY CAR ON THE ROAD. GOING STRAIGHT.
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. WHILE DRIVING 60 MPH, SMOKE STARTED TO EMIT FROM THE FRONT PASSENGER SEAT. THE FRONT PASSENGER WAS NOT INJURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 217,000.
BOTH FRONT SEAT HEATERS ON ANY SETTING ARC AND HAVE BURNED MULTIPLE HOLES ON THE OUTER LOWER SEAT UPHOLSTERY. *TR
WHILE DRIVING WITH SEAT HEATER ON SEAT BURNED THRU FOAM AND SEAT COVER ALSO BURNED PANTS LEG AND WIFE'S FINGER TRYING TO PUT OUT THE EMBERS. *TR
TURNED THE DRIVERS SIDE HEATED SEAT WARMER ON TO 2. RANGE BEING 0-5. I SMELLED SMOKE AND TURNED IT OFF AFTER ONLY 10-15MIN OF BEING ON. I NOTICED WHEN I GOT OUT OF THE CAR, THAT I HAD A HUGE QUARTER SIZE HOLE IN MY SEAT AND MY DOWN COAT WAS BURNED THROUGH IN 2 LARGE SPOTS. THIS IS UNSAFE. IT COULD HAVE BEEN A HUGE FIRE IF I HAD NOT TURNED OFF THE WARMER AS SOON AS I SMELLED SOMETHING BURNING. *TR
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE DRIVER'S SIDE HEATED SEAT OVERHEATED AND BURNED THROUGH THE SEAT, CAUSING BURNS TO THE CONTACT'S LEGS. THE CONTACT STATED THAT THE FAILURE HAD BEEN EXPERIENCED BEFORE, BUT WAS NEVER SO SEVER THAT IT CAUSED INJURIES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGES WERE 70,000.
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE HEATED SEATS BEGAN TO SPARK AND BURNED A WHOLE IN THE SEAT. THE SEATS WERE REPAIRED UNDER A PREVIOUS MANUFACTURER'S RECALL, BUT THE FAILURE RECURRED. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT THE CONTACT WAS DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 145,000.
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE HEATED SEAT WARMER BURNED THROUGH THE SEAT AND THE PANTS OF THE CONTACT. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 125,000.
DRIVER SIDE LOCK SWITCH, UNABLE TO LOCK MY 02 JETTA WITH REMOTE KEY. INTERIOR LIGHT ON THE DRIVER DOOR CONSTANTLY STAYS ON. *KB
WHILE DRIVING HOME AT NIGHT, MY SON AND I SMELLED SMOKE. WE EXITED THE VEHICLE, CHECKED UNDER THE HOOD, BUT FOUND NOTHING. WE CONTINUED HOME AND PARKED IN THE GARAGE. STILL SMELLING SMOKE, WE RE-INSPECTED THE VEHICLE, BUT WERE UNABLE TO DETERMINE AN ORIGIN OR ANY VISIBLE EVIDENCE. BOTH SEAT HEATERS WERE ON DURING THE DRIVE HOME, BUT THE SEATS SHOWED NO VISUAL SIGNS OF DAMAGE AFTER PARKING. NEXT MORNING WE OPENED THE VEHICLE TO DISCOVER THE CABIN WAS FILLED WITH SMOKE WITH AN APPROXIMATE 1?HOLE BURNED UP THRU THE PASSENGER SEAT ON THE LOWER RIGHT BOLSTER. APPARENTLY THE SEAT HEATER INITIATED A THERMAL EVENT WHICH ERUPTED IN A SEAT FIRE AFTER WE TURNED OFF THE IGNITION AND PARKED THE CAR IN THE GARAGE. FORTUNATELY, THE FIRE DID NOT ENGULF THE VEHICLE OR IT COULD HAVE CAUGHT OUR HOME ON FIRE, RESULTING IN POSSIBLE INJURY OR DEATH TO MY FAMILY. I BELIEVE WE DODGED A BULLET BECAUSE THE SEAT FIRE DID NOT SUSTAIN ITSELF AND ENGULF THE VEHICLE. VW HAS AGREED TO REPAIR THE BURNED SEAT AT THEIR EXPENSE AND MAKE A MITIGATION REPAIR. HOWEVER, VW HAS DECLINED MY REQUEST TO COVER ANY SIMILAR MITIGATION REPAIR TO THE OTHER SEAT. IN OCTOBER 2004, THE NHTSA ODI CONCLUDED THAT ?DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE? BUT ?SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.? THE ODI STATED THE INVESTIGATION DID NOT CONCLUDE THAT A SAFETY-RELATED DEFECT DOES NOT EXIST AND THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. (EA04010) EVIDENCE AND REPORTS INDICATE THAT SEAT HEATER CAUSED THERMAL EVENTS IN BOTH DRIVER AND PASSENGER SEATS IN THE VW JETTA HAVE BEEN AN ISSUE FOR NEARLY 10 YEARS NOW. NEAR MISSES CONTINUE TO OCCUR. I BELIEVE THAT A SEAT FIRE IS A SIGNIFICANT SAFETY CONCERN. I WOULD ENCOURAGE THE NHTSA TO RE-EXAMINE THE CIRCUMSTANCES TO DETERMINE IF FURTHER ACTION IS WARRANTED. *TR
I TURNED ON MY SEAT WARMER ON THE DRIVER SIDE AND AFTER A WHILE A BURNT SMELL WAS NOTICE. I COULD NOT FIND THE ORIGIN UNTIL I WENT TO A STORE AND TRIED TO PAID. I TOOK MY WALLET OUT AND IT WAS STUCK TO MY PANTS. THE WALLET HAD THE MYSTERIOUS SMELL. I WENT BACK TO THE CAR AND THE SEAT HAD A BIG BURNT HOLE ON THE LEATHER SEAT. IF I HAD NOT HAD MY COAT AND WALLET ON THE LEFT SIDE I COULD HAVE BEEN ELECTROCUTED OR CAUGHT FIRE. *TR
PASSENGER LEATHER SEAT CAUGHT FIRE WHILE HEATED SEAT WAS ON. BURNED A HOLE IN THE SEAT AND ELECTRICAL SMOKE WAS PLUMING OUT OF THE HOLE. THIS HAS ONLY OCCURRED ONCE BECAUSE IT HAS NOT BEEN USED SINCE. THE FAILURE HAS NOT BEEN CORRECTED. *TR
I WAS RIDING DOWN THE ROAD COMING FROM WORK WHEN I NOTICED A BURNING SMELL. I DIDN'T SEE ANY SMOKE,SO I THOUGHT IT MIGHT BE COMING FROM OUTSIDE. AFTER A WHILE, THE SMELL GOT STRONGER. THAT'S WHEN I LOOKED OVER AND NOTICED FLAMES COMING FROM THE PASSENGER SEAT. I PULLED OVER IMMEDIATELY AND SMOTHERED IT. IT TURNED OUT THAT THE HEATED SEAT ON THE PASSENGER SIDE HAD BEEN ON FROM WHERE MY MOTHER WAS RIDING THE NIGHT BEFORE. THIS IS NOT THE FIRST ISSUE THAT I'VE HAD WITH MY 2002 VOLKSWAGEN JETTA,BUT IT'S THE FIRST THAT MADE ME FEEL THAT IT WAS UNSAFE TO DRIVE. I HAVE A FOUR YEAR OLD SON AND I AM NOW IN FEAR THAT SOMETHING COULD POSSIBLY HAPPEN AGAIN. I'VE DONE SOME RESEARCH AND APPARENTLY THIS IS A COMMON OCCURRENCE IN THIS MODEL. I'VE REPORTED THE INCIDENT TO VWOA, BUT HAVE NOT HEARD BACK FROM THEM. FORTUNATELY NO ONE WAS INJURED. BUT SOMEONE ELSE MIGHT NOT BE SO LUCKY. I HOPE THIS ISSUE CAN BE RESOLVED. THANK YOU. *TR
MY 2002 VW JETTA TDI HAS MANY ELECTRICAL PROBLEMS. THE ONE THAT MIGHT BE A SAFETY FACTOR IS THE MICRO SWITCHES IN THE DOOR LATCHES. THE DOORS WITH FAULTY SWITCHES DON'T KNOW IF THERE OPEN OR CLOSED. WHEN OPEN THE SAFETY LIGHT ON THE DOOR DOES NOT COME ON TO ALERT ONCOMING VEHICLES THAT A DOOR IS OPEN. IF THE SWITCH STAYS ON WHEN THE DOOR IS CLOSED, THE DOME LIGHTS STAY ON UNTIL THE BATTERY IS DEAD. THE VW DEALER JUST "JERKED" ME AROUND UNTIL THE WARRANTY HAD EXPIRED. (FREDERICTON VW). SINCE THE PART(S) FOR THIS REPAIR ARE EXPENSIVE, I FEEL THAT VW SHOULD RECALL ALL VEHICLES TO REPLACE THE SWITCHES AND DOOR LATCHES. MEL MOIR *TR
WHILE DRIVING WITH THE SEAT HEATER ON IN 2002 VW JETTA THE SEAT HEATER OVERHEATED AND BURNED THROUGH THE LEATHER SEAT AND BURNED THE DRIVER. SMOKE WAS PRESENT IN THE VEHICLE. *TR
CHECK ENGINE LIGHT CONTINUOUSLY COMES ON, COMPLETED RECALL FOR BRAKE SWITCH, EPC LIGHT CONTINUES TO COME ON, CAR STALLS WHILE WAITING FOR A LIGHT TO CHANGE VERY DANGEROUS. AFTER A NIGHT OF RAIN, LEAK IN PASSENGER SIDE FLOOR MOLD GROWING CAR WILL HAVE A VERY HARD START OR NO START AT ALL IN THE MORNING, REPLACED BATTERY 3 TIMES. CHANGED O2 SENSOR 2X, CAR BURNS OIL CONTINUOUSLY, INTERIOR LIGHTS GO OUT WHEN THEY FEEL LIKE IT, BRAKE LIGHTS DIE OUT FAST, CHANGED BRAKE LIGHTS AND SIGNAL LIGHTS AT LEAST 5X. *TR
THE DRIVER'S SIDE DOOR CAME LOOSE WHILE DRIVING AND EVEN THOUGH IT WAS SEEMINGLY SHUT PROPERLY WHEN AT A STOP. ASIDE FROM THE LOUD ROAD NOISE, THE "DOOR'S AJAR" DING WOULD STARTLE ME, PARTICULARLY WHEN AT HIGH SPEED ON THE (RELATIVELY SMOOTH) HIGHWAYS. I HAVE TO SLAM THE DOOR SEVERAL TIMES IN ORDER TO GET THE DINGING TO STOP. WHENEVER THE DOOR RATTLED LOOSE ON THE HIGHWAY (WHICH WAS UNPREDICTABLE), I WAS WORRIED THAT IT WAS GOING TO FLY OPEN. I HAD TO PULL OVER TO ATTEMPT TO CLOSE IT. I PAID $550 TO HAVE THE DOOR LOCK REPLACED (IT WAS THE HARDWARE, NOT THE ELECTRONIC LOCKS, WHICH FUNCTIONED NORMALLY THROUGHOUT THE ORDEAL). NOW, ONLY 2 YEARS LATER, I'M HAVING THE SAME PROBLEM, AND THE DEALER SAYS THAT NEITHER THEIR REPAIRS NOR THE REPLACEMENT PARTS ARE UNDER WARRANTY. *TR
WHILE DRIVING HOME FROM WORK, I HEARD A VERY LARGE "CRACK" SOUND AND FELT MY SEAT SHUDDER. THE SOUND AND IMPACT MADE ME THINK THAT SOMETHING HAD STRUCK THE CAR UNDER MY SEAT. HOWEVER, WHEN I RETURNED HOME, I DISCOVERED THAT A SPRING ATTACHED TO MY SEAT HAD DISLODGE. FURTHER INSPECTION REVEALED THAT ONE OF THE PLACES WHERE THE SPRING CONNECTED HAD BROKEN OFF - APPARENTLY METAL FATIGUE. THIS STRUCK ME ODD BECAUSE WHILE CLEANING MY CAR EARLIER IN THE SUMMER, I HAD NOTICED THAT A SPRING WAS LOOSE UNDER THE PASSENGER SIDE FRONT SEAT AND ALSO FOUND THE NUB OF WHERE IT ATTACHED. I HAVE KEPT BOTH PIECES AND THE SPRINGS. I THINK THERE IS A STRUCTURAL DEFECT WITH THE PART. I AM NOT A VERY HEAVY PERSON - 180 LBS - SO I DOUBT I PUT THAT MUCH STRESS ON THE SEAT. I THINK THIS IS A POTENTIALLY DANGEROUS ISSUE AND THAT IS WHY I AM REPORTING IT. WHEN THE SYSTEM FAILED I SWERVED WHILE DRIVING ON THE HIGHWAY AS THE SOUND WAS INCREDIBLY UNNERVING. I ALSO NOW WONDER ABOUT THE SEATS STRUCTURAL INTEGRITY IF IT WERE INVOLVED IN A COLLISION.
PURCHASED USED 2002 VW JETTA 1.8 TURBO (5 SPEED) WITH 34,000 MILES STILL UNDER WARRANTY. TAKEN TO DEALERSHIP FOR BLOWN FUSES (CIGARETTE LIGHTER), TRUNK LATCH, CENTER CONSOLE, AND TRANSMISSION REPAIRS. FUSE PROBLEM WAS ONGOING. WITHIN A FEW MONTHS, A LOCAL MECHANIC INSTALLED A SMALL BOOST GAUGE ON THE DASH, WHICH WAS WIRED INTO A 10 AMP FUSE. WITHIN FIVE DAYS, THE CAR WAS BEING BACKED OUT OF THE DRIVEWAY WHEN SMOKE BEGAN POURING FROM ALL THE DASH VENTS. THE WIRE HARNESS, FUSE BLOCK, AND CONTROLLER COMPONENTS LOCATED BEHIND THE DASH WERE DESTROYED BY FIRE. VW OF AMERICA PREPARED TO SEND INVESTIGATORS TO NM, BUT WHEN THEY DISCOVERED GAUGE WIRING MAY HAVE CONTRIBUTED, THEY DID NOT INVESTIGATE. HAVE READ OF OTHER ELECTRICAL FIRES BEHIND INSTRUMENT PANEL, DASH, SINCE THIS TIME. OUR SON WAS DRIVING THE CAR AT THE TIME OF THE FIRE, BUT WAS ABLE TO GET OUT. *TR
2002 JETTA WITH A SAFETY RECALL- REPLACED BRAKE LIGHT SWITCH CUSTOMER STATES THAT THE DEALERSHIP REFUSED TO FIXED THE RECALL**CC THE VW SERVICE CENTER AND CUSTOMER CARE INFORMED THE CONSUMER THE VEHICLE WAS OUT OF WARRANTY AND THEY HAD NO OBLIGATIONS TO PAY FOR TOWING OR ANY OTHER COST ASSOCIATED WITH THE VEHICLE, INCLUDING THE LAST RECALL REGARDING THE BRAKE LIGHT SWITCH THAT THE CONSUMER HAS REPLACED ON 3 SEPARATE OCCASIONS. THE CONSUMERS DAUGHTER HAD EXPERIENCED THE VEHICLE LOCKING UP AS A RESULT OF THE DEFECTIVE BRAKE SWITCH. THE INSTRUMENT PANEL FAILED AND THE CONSUMERS DAUGHTER WAS UNABLE TO READ THE PANEL. THE CONSUMER STATED IN THE PAST, THE TRUNK LATCH FAILED AS WELL AS A BROKEN BOLT ON THE TRANSMISSION, THE DRIVERS SIDE SEAT BELT AND THE EGR ALL HAD TO BE REPLACED. THE DOOR LATCH FAILED BECAUSE THE LOCK SIGNAL WAS NOT WORKING. *JB THE CONSUMER STATED THAT HE RECEIVED A RECALL FOR HIS DAUGHTER'S VEHICLE, THIS IS THE 3RD BRAKE SWITCH NOT TO MENTION OVER $800 IN UNWARRANTED CHARGES FROM THE DEALERSHIP. THE CONSUMER STATED HE WAS HOPING THAT THIS CLASSIFIES THE VEHICLE AS A LEMON. THE CONSUMER STATED WOULD LIKE DEALERSHIP TO REVIEW THE OVER CHARGES OR BUYING THE VEHICLE BACK. *TR
WAY TO MANY TO LIST HERE. I HAVE HAD PROBLEMS FROM THE START. MORE THAN $7000 WORTH OF REPAIR (PLUS MORE THAT WAS COVERED BY WARR) THE FINAL ITEM THAT CAUSED ME TO SAY I WOULD NEVER CONSIDER ANOTHER VW PRODUCT WAS THE ENGINE DAMAGE CAUSED BY A TIMING BELT FAILURE. ALL SERVICES WERE PERFORMED AT THE DEALERSHIP. THE USERS MANUAL STATES INSPECTION OF THE BELT AT SERVICES (THAT I PAID FOR) AND REPLACEMENT AT 120,000 MILES. I ONLY HAD 92,000 MILES. IT WILL COST $5,000 TO REPAIR THE ENGINE. IT IS NOT COST EFFECTIVE TO REPAIR THIS CAR. IT WAS A GREAT CAR TO DRIVE BUT QUALITY CONTROL IS POOR AT BEST. *NM
I BOUGHT THE CAR 3 DAYS LATER THE PROBLEM(S) STARTED. AND THEY HAVE BEEN GOING EVER SINCE. SHIFTING HARD, DISPLAY LIGHTS, WOULD NOT START, WONDOWS WOULD NOT ROLL DOWN, OR IFF THEY DID, THEY MADE A LOUD THUD. *AK
FRONT LEFT (DRIVER'S SIDE) SEAT MATERIAL SPLIT ON THE SEAM HOLDING THE FRONT MATERIAL TO THE SIDE MATERIAL. DIRECTLY UNDER THE SPLIT IS A METAL BRACKET THAT IS NOT PADDED. THIS BRACKET LIKELY CAUSED THE SEAM TO SEPARATE. VOLKSWAGEN OF AMERICA (VOA) HAD ME BRING THE VEHICLE IN TO ONE ONTO VOLKSWAGEN FOR INSPECTION. REPAIR OR REPLACEMENT WAS DENIED BY THE SERVICE MANAGER (CARL SCHIDZICK) DENIED THE CLAIM BECAUSE I WAS BEYOND THE 12,000 MILE WARRANTY. THE VOA REGIONAL SERVICE MANAGER WHOSE NAME WAS REFUSED TO ME BACKED UP THE DEALER AND REFUSED REPAIR/REPLACEMENT. VOA WOULD NOT PROVIDE A COPY OF THEIR REPORT, WOULD NOT PROVIDE CONTACT INFORMATION FOR THE REGIONAL SERVICE MANAGER AND WOULD NOT ALLOW ANY APPEAL. THEY SAID THEY HAVE RECEIVED NO COMPLAINTS REGARDING SEAT MATERIAL FAILURE ON JETTAS. IF THE SEPARATION HAD OCCURRED BEFORE 12,000 MILES THEY SAID THEY WOULD HAVE REPAIRED OR REPLACED THE ITEM. MY NEW CAR SEAT COVER BLOCKS DEPLOYMENT OF THE SIDE AIRBAG. *LA
SEAT'S MATERIAL IS DETERIORATING, AND IF USING A SEAT COVER IT WILL BE COVERING SIDE AIR BAGS.*AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .