2006 Volkswagen Jetta Fuel system Problems

THERE HAS BEEN TAMPERING DONE TO MY VEHICLE HOW DO I ASSURE SAFETY AND HAVE IT INVESTIGATED AND HAVE A REPAIR MAN LOOK OVER THE VEHICLE AFTER THE THEFT?

NHTSA ID

11383094

Incident

May 1, 2020

THERE ARE SOME MOUNTING BRACKETS, SUSPENSION BRACKETS, NUTS AND BOLTS ASSOCIATED TO THE OPERATION OF THE VEHICLE THAT HAVE BROKE MORE THAN ONCE PLEASE CONTACT ME AND I WILL GIVE U FURTHER DETAIL.[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).. *TR

NHTSA ID

11383092

Incident

Jan 1, 2020

Mileage

150,000 mi

CAR CAN SPUTTER ON FREEWAY AT TIMES AND CAN STALL OUT WHEN DECELERATING FROM FREEWAY CRUISING SPEED. FUEL LINES ARE EMPTY DESPITE HAVING REPLACED FUEL PUMP AND FILTER, AS WELL AS WIRING HARNESS.

NHTSA ID

11209408

Incident

Apr 17, 2019

Mileage

115,000 mi

VW JETTA TDI 2.5L 2006 - PLASTIC ENGINE COVER TAPPED A HOLE INTO FUEL RAIL. DIESEL FUEL LEAKED ALL OVER ENGINE AND ENGINE STARTED SMOKING. FIRE WAS IMMANENT HAD I CONTINUED TO DRIVE. LOST FUEL ON ROAD AND GROUND. VW CUSTOMER SERVICE LINE SAYS MY VIN DOES NOT SHOW A RECALL FOR THIS BUT THE LEAK ISSUE IS POSTED ALL OVER INTERNET AND TDI FORUM SITES AND YOUTUBE. VW SHOULD RECALL THIS BEFORE SOMEONE GETS HURT. HOLE LOOKS LIKE A LESION OR A SORE THAT HIS BEEN RUBBED BY THE PLASTIC COVER ON THE WEAK METAL TUBE FUEL RAIL. NOW, NEW JETTAS ARE MADE WITH RUBBER FUEL TUBES. THEY HAVE DEFINITELY KNOWN ABOUT THIS FOR MANY YEARS (SINCE 2007 AT LEAST).

NHTSA ID

11057927

Incident

Jan 1, 2018

Mileage

170,000 mi

THE VEHICLE HAS A LONG HISTORY OF THE THROTTLE BECOMING INOPERATIVE RESULTING IN NO-POWER (IDLE POWER STRICTLY SPEAKING) CONDITIONS. THAT CONDITION IS CLEARED WHEN THE CLUTCH PEDAL IS DEPRESSED AND RELEASED. RECENTLY THERE WAS AN INSTANCE OF UNCOMMANDED ACCELERATION: INSTEAD OF NO POWER, FULL POWER WAS APPLIED BY THE ENGINE. AGAIN CYCLING THE CLUTCH CLEARED THE CONDITION. THE NO-POWER CASES APPEARED MORE LIKELY IN URBAN DRIVING AND SOON AFTER A TRANSMISSION SHIFT BUT DID OCCUR UNDER ALMOST ANY CONDITIONS. THE FULL-POWER CASE OCCURRED ONCE, CLIMBING A HILL AT ~2800' ALTITUDE. THE POWER FAIL OCCURRED AS EARLY AS 34K MILES, AND CONTINUED WITH VW'S KNOWLEDGE UNTIL ~72K MILES, WHEN VW OF AMERICA TECHNICIANS FINALLY DID SOMETHING TO END IT. THOSE SYMPTOMS STARTED RECURRING AT ~270K MILES. THE ACCELERATION INCIDENT OCCURRED AT ABOUT 275K MILES. THE VEHICLE HAS BEEN TAKEN OUT OF SERVICE; IT WILL BE SENT TO A SALVAGE YARD IF THE NTSB IS NOT INTERESTED IN THE VEHICLE. *TR

NHTSA ID

10939638

Incident

Nov 12, 2016

Mileage

276,000 mi

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING AT VARIOUS SPEEDS, THE PARKING WARNING LIGHT ILLUMINATED INTERMITTENTLY. IN ADDITION, THE AIR BAG WARNING LIGHT ILLUMINATED AND THE FUEL TANK LEAKED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT PROVIDED.

NHTSA ID

10837147

Incident

Jul 5, 2013

Mileage

120,000 mi

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 20 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS PULLED OVER AND RESTARTED, BUT BEGAN TO JOLT AND MOVE SLOWLY. THE DEALER DIAGNOSED THAT THE FAILURE WAS CAUSED BY "GEORGIA FUEL" AND THAT THE FUEL LINE NEEDED TO BE REPAIRED. ALSO, THE PASSENGER SIDE AIR BAR WARNING INDICATOR REMAINED ILLUMINATED. THE DEALER DIAGNOSED THAT THE AIR BAG NEEDED TO BE REWIRED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 155,000.

NHTSA ID

10732809

Incident

Jun 8, 2015

Mileage

155,000 mi

DRIVING ALONG THE ROAD AND COOLANT SUDDENLY FLUSHED OUT OF CAR. WATER PUMP HAD TO BE REPLACED ALONG WITH TIMING BELT. OIL LEAKS IN MULTIPLE PLACES ARE STARTING TO APPEAR. I WONDERED WHY I WAS GOING THROUGH SO MUCH OIL. MECHANIC ALERTED ME TO THE POOR DESIGN AND BUILD AND TOLD ME TO CHECK OF OPEN RECALLS AND SIMILAR PROBLEMS. *TR

NHTSA ID

10641422

Incident

Sep 15, 2014

Mileage

120,000 mi

AT APPROX 80-90K I STARTED HEARING A CLATTERING NOISE FROM THE ENGINE AND EXTRA NOISE WHEN IDLING. ALSO, THE CAR HAS A HARD TIME SHIFTING (AUTOMATIC TRANS). AFTER TAKING THE CAR TO A MECHANIC, I WAS TOLD THAT IT'S THE DSG DMF COMING APART AND RATTLING. AFTER DOING SOME RESEARCH, I FIND IT'S A COMMON PROBLEM. IT STARTED HAPPENING SHORTLY AFTER MY CAR WENT OUT OF CPO WARRANTY, WHICH EXPIRED AT 74K. I DIDN'T REALLY PAY THAT MUCH ATTENTION TO IT UNTIL IT GOT WORSE. THIS IS A 06 TDI MKV WITH AUTO DSG, BRM ENGINE. ALSO EXPERIENCING DIFFICULTIES WITH SOOT IN FUEL FILTER, LIKELY DUE TO FAULTY SEAL IN FUEL INJECTORS UNDER CAM SHAFT. ONCE AGAIN, COMMON PROBLEM ACCORDING TO MECHANICS AND ONLINE FORUMS ON THIS MODEL. THERE'S A RECALL ON THE DMF FOR THIS MODEL IN AUSTRALIA, NEEDS TO HAVE ONE FOR US. *TR

NHTSA ID

10565642

Incident

Sep 22, 2013

Mileage

80,000 mi

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, SHE BEGAN TO SMELL GASOLINE INSIDE THE VEHICLE. THE CONTACT OPENED THE HOOD AND SAW THAT GASOLINE WAS LEAKING ONTO THE ENGINE. THE CONTACT WAS INFORMED OF A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN NUMBER: 10V621000 (FUEL SYSTEM, GASOLINE) BUT WAS INFORMED THAT HER VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 90,000.

NHTSA ID

10538093

Incident

Aug 29, 2013

Mileage

90,000 mi

MY WIFE AND I WERE DRIVING HOME AND SUDDENLY MY CAR STARTED JERKING AND MADE A "KNOCKING" SOUND, WITHOUT ANY WARNING (I.E. CHECK ENGINE LIGHT). WE WERE CLOSE TO HOME AND DECIDED TO CONTINUE ON; HOWEVER, IN THE NEXT COUPLE OF MILES, THE PROBLEMS PERSISTED, STILL WITH NO CHECK ENGINE LIGHT OR ANY INDICATION OF WHAT WAS WRONG WITH THE VEHICLE. OVER THE NEXT SEVERAL DAYS, WHILE PARKED ON A SECURED PREMISE, I STARTED THE CAR UP AND IT HAD AN ERRATIC LOPING SOUND. I PROCEEDED TO CALL A NEARBY VOLKSWAGEN DEALER AND SPOKE TO TWO CERTIFIED VW MECHANICS, WHO FAILED TO ACKNOWLEDGE THE ISSUE THAT THERE WAS NO WARNING INDICATION BEFORE THE CAR STARTED TO ACT UP AND SAID TO BRING IT IN TO SWAP OUT THE ENGINE AT APPROX. $7500; THEY DISMISSED THE PROBLEM AS "NORMAL WEAR AND TEAR". I RESEARCHED THE PROBLEM ON THE INTERNET AND IT LEAD ME TO BELIEVE THAT IT WAS A PROBLEM WITH THE CAM, WHICH I HAD CONFIRMED BY AN AUTO-MECHANIC AFTER TOWING THE CAR IN. HE TOLD ME THE ENTIRE ENGINE WAS WARPED DUE TO THE CAM GOING OUT. OTHER 2006 VW JETTA TDI OWNERS HAVE COMMENTED ON THE SAME ISSUES, WHICH AT THIS POINT LEADS ME TO BELIEVE THAT IT IS NOT "NORMAL WEAR AND TEAR", BUT A MANUFACTURE DEFECT. *TR

NHTSA ID

10496238

Incident

Dec 30, 2012

Mileage

149,000 mi

BOUGHT NEW VW JETTA SEDAN ON 08/17/06. ON 05/13/10 TOOK THE CAR TO THE DEALER BECAUSE OF CAR DECELERATING WHILE DRIVING I.E. DROPPING IN SECONDS FROM 60 MILES TO 20 MILES. IT WAS TAKEN TO THE DEALER MULTIPLE TIMES FOR THE SAME PROBLEM. DEALER ANSWER "UNABLE TO REPLICATE PROBLEM" UNTIL WARRANTY OF FOUR YEARS EXPIRED. THE PROBLEM CONTINUES EVEN AFTER THE CARBON ACCUMULATED ON THE THROTTLE WAS CLEANED AND THE FUEL PUMP WAS REPLACED. DUE TO UNSAFE TO DRIVE, REQUESTED FOR THE DEALER TO BUY THE CAR BACK AS A LEMON. THE DEALER REFUSES BECAUSE THE FOUR YR WARRANTY IS OVER. OTHER PROBLEMS EXPERIENCED WITH THIS VEHICLE DURING THIS PERIOD: AIR BAGS LIGHTS GOING OFF, AIR BAG COVER FALLING OFF, TRUNK OPENING ON ITS OWN WHILE DRIVING, RAIN WATER LEAKING INSIDE THE LINING OF THE CAR, SCREWS COMING OFF A DOOR PANEL, DOORS FALLING OFF THE HINGES, EMERGENCY SWITCH FALLING INSIDE PANEL, FUEL CAP NOT LOCKING, RECALLS. DEALER RECOMMENDING TO REPLACE THE STEERING WHEEL COLUMN FOR 2,340.

NHTSA ID

10440788

Incident

May 13, 2010

Mileage

24,406 mi

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA DIESEL. THE CONTACT STATED THAT THE HIGH PRESSURE FUEL PUMP WAS MALFUNCTIONING AND CAUSING THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC, WHO STATED THAT THE FUEL PUMP HAD METAL SHAVINGS INSIDE OF IT THAT WERE CLOGGING THE FUEL INJECTOR. THE MECHANIC ALSO STATED THAT THE ENTIRE FUEL SYSTEM NEEDED TO BE CLEANED AND THE HIGH PRESSURE FUEL PUMP AND INJECTORS NEEDED TO BE REPLACED. THE CONTACT NOTIFIED THE MANUFACTURER AND FILED A COMPLAINT. THE MANUFACTURER INFORMED THE CONTACT THAT THERE WERE NO RECALLS, BUT THEY WERE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE STALLING COULD LEAD TO A CRASH. THE FAILURE MILEAGE WAS 55,000.

NHTSA ID

10418015

Incident

Aug 8, 2010

Mileage

55,000 mi

VW HAS CHANGED THE DIESEL ENGINES (TDI) STARTING WITH APPROXIMATE YEAR 2004 UNTIL 2007, WHEN THEY STOPPED SELLING TDI TO MEET EMISSION REQUIREMENTS. TO SAVE MONEY AND LICENSING FEES TO BOSCH THEY HAVE CHANGED FROM COMMON RAIL SYSTEM MADE BY BOSCH (FEEDS THE DIESEL FUEL TO ENGINE WITH VERY HIGH PRESSURE) TO VW SYSTEM CALLED TDI PD: PUMP DUSE (OR PUMP-NOZZLE INJECTION). TO ACCOMMODATE THE INJECTORS INSIDE THE ENGINE, THEY HAVE CHANGED THE SPECS AND DIMENSIONS OF MANY PARTS, INCLUDING THE CAMSHAFT. THE CAMSHAFT INSIDE THIS ENGINE HAS THE ADDED ROLE TO DRIVE THE PD LIFTERS, APART FROM VALVE LIFTING AND CLOSING. I OWN THIS TYPE OF CAR VW JETTA 2006 TDI, AND THE CAMSHAFT WORE OFF AT 80,000 MILES, AND YES IT WAS OUT OF WARRANTY AND IT COSTS $3000. APART FROM THE COSTS, WHICH ACCRUES TO APROX $3000 PER 50,000 TO 80,000 MILES RENDERING THIS CAR A LIABILITY COST TO THE OWNERS (A LONG TERM OWNER WILL HAVE THE PRICE OF CAR DOUBLED BY ADDED BILLS TO CHANGE THE CAMSHAFTS MANY TIMES. THIS IMPACTS DRASTICALLY FINANCIALLY MANY FAMILIES DEPENDING ON THIS CAR), WITHOUT THE POSSIBILITY TO FIX IT PERMANENTLY AND FOR ONCE . I HAVE CHANGED THE CAMSHAFT AND NOW AT 115000 MILES IT STARTS TO SHOWS SIGNS OF WEAR, LIKE LAST TIME. NOT CHANGING GEARS IN TIME, CAR IS SHAKING. THE EFFECT GETS WORSE, UNTIL WHEN THE CAMSHAFT LOBES WEARS OFF MORE, AND RESULTS IN VALVES NOT OPENING AND CLOSING IN RIGHT SEQUENCE AND TIME, AND ENGINE WILL STALL, LIKE MINE DID ON MY STREET. AS WELL I WAS ON HIGHWAY AND CAR WILL NOT OPERATE AND RESPOND TO ACCELERATION PEDAL INPUT, MAXIMUM PEDAL INPUT WAS GIVING ONLY 40MPH, EXPOSING ME TO A STAMPEDE OF CARS FROM BEHIND IN A DANGEROUS SITUATION UNABLE TO CONTROL THE CAR. I HAVE EXPLAINED THE SITUATION TO VW AND THEY DENY ANY: WRONGDOING, DESIGN FLAW, FAULT OR LIABILITY. ACCORDING TO TDICLUB.COM THERE IS UP TO 20% FAILURE OF THE ENGINES VIA CAMSHAFT WEAR OF LOBES. I TRUST YOU WILL INVESTIGATE AND REQUEST VW TO ADDRESS:SAFETY+FINANCIAL IMPACT TO TDI PD OWNERS. *TR

NHTSA ID

10395387

Incident

Feb 19, 2010

Mileage

80,000 mi

SUDDEN DECELERATION OR LOSS OF POWER MAINLY AT HIGHWAY SPEEDS BUT OCCASIONALLY IN TOWN. THIS LASTED FOR ONLY A FEW SECONDS AND THE CAR REGAINED POWER. THERE WERE SCARY SITUATIONS ON THE INTERSTATE HIGHWAYS BUT NO ACCIDENTS OR INJURIES OCCURRED. THIS OCCURRED INTERMITTENTLY OVER SEVERAL MONTHS BUT THE DEALER WAS NOT ABLE TO EITHER DUPLICATE THE PROBLEM OR IDENTIFY ANY COMPONENTS THAT WERE FAULTY. AFTER MUCH PERSISTENCE AND FRUSTRATION ON MY PART, THE DEALER EVENTUALLY IDENTIFIED A FAULTY 'TANDEM FUEL PUMP' AND A FAULTY COMPONENT OF THE TRANSMISSION (MECHATRON). BOTH COMPONENTS WERE PLACED ON FEBRUARY 17, 2010 AND I HAVE HAD ANY PROBLEMS SINCE THAT TIME. JETTA TDI. *TR

NHTSA ID

10382563

Incident

Feb 17, 2010

Mileage

57,000 mi

CHECK ENGINE LIGHT CODES P0302/P2293 INTAKE CAMSHAFT, CAM FOLLOWER, HIGH PRESSURE FUEL PUMP, LOW PRESSURE FUEL SENSOR, AIR INTAKE HOSE, SPARKS PLUGS. *TR

NHTSA ID

10371100

Incident

Nov 22, 2010

Mileage

84,000 mi

WE HAVE HAD SEVERAL INCIDENTS WITH OUR 2006 VOLKSWAGEN JETTA 2.5 WHERE WE WOULD LOSE POWER AND THE VEHICLE STALLS OUT. OUR 2006 JETTA IS A GASOLINE 5-CYLINDER WITH AUTOMATIC TRANSMISSION AND HAS ONLY 45,000 MILES. IN JUNE OF 2010 WE FIRST NOTICED THE STALLING ISSUE WHEN DRIVING HOME AND IT STALLED OUT WHILE PULLING INTO THE DRIVEWAY. AFTER SITTING FOR ABOUT 10 MINUTES WE WERE ABLE TO PULL IT INTO THE GARAGE. THE SECOND INCIDENT OCCURRED ON FRIDAY 7/30/2010, WHILE DRIVING HOME FROM WORK (30 MILE COMMUTE) AT 45-55 MPH THE JETTA STARTED TO INTERMITTENTLY LOSE POWER BEFORE THE ENGINE COMPLETELY STALLED. NOTE: I WAS STILL TRAVELING AT 55 MPH WHEN THE ENGINE STALLED. IT WOULD RESTART AND BEGAN EXPERIENCING THE SAME ISSUE MULTIPLE TIMES. WE TOWED THE CAR TO OUR LOCAL VOLKSWAGEN DEALERSHIP. THEY RAN DIAGNOSTICS AND DID NOT FIND ANY ERROR CODES FROM THE CAR'S COMPUTER. THEY REPLACED THE BATTERY THINKING THAT IT MIGHT HAVE BEEN AN ELECTRICAL ISSUE. WE PICKED UP THE CAR ON TUESDAY 8/3/2010 IN THE MORNING. WHILE DRIVING HOME FROM WORK THAT SAME DAY (30 MILE COMMUTE) THE ENGINE BEGAN EXPERIENCING THE SAME ISSUE, INTERMITTENTLY LOSING POWER WHILE TRAVELING ON THE INTERSTATE AT 70-80 MPH. AFTER EXITING THE INTERSTATE THE SYMPTOMS CONTINUED TO GET WORSE AND THE ENGINE COMPLETELY STALLED IN THE MIDDLE OF AN INTERSECTION ALMOST CAUSING A MULTI-CAR ACCIDENT. AFTER MULTIPLE ATTEMPTS TO RESTART AND REPEATED ENGINE STALLS I WAS ABLE TO GET THE VEHICLE TO GAS STATION WHERE IT WAS TOWED TO THE VOLKSWAGEN DEALER FOR A 2ND TIME. ONLY GOOD NEWS OF THIS STORY, THE VW MECHANIC WAS ABLE TO REPRODUCE THE ENGINE STALL ISSUE AFTER TEST DRIVING THE JETTA FOR ABOUT 45 MINUTES. VW DEALER REPORTED THE RESULT TO VW MANUFACTURER TECH SUPPORT. VW DEALER KEPT THE CAR FOR MORE THAN 1 WEEK TO RUN MORE TESTS PER VW TECH SUPPORT. ULTIMATELY REPLACED THE FUEL PUMP AND FUEL FILTER. NO MORE OCCURRENCES IN THE LAST TWO WEEKS...BUT AM LITERALLY HOLDING MY BREATH WHILE DRIVING. *TR

NHTSA ID

10352980

Incident

Aug 13, 2010

Mileage

45,000 mi

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE VEHICLE EXPERIENCED VARIOUS RECURRING FAILURES SINCE THE DATE IT WAS PURCHASED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON NUMEROUS OCCASIONS WHERE THE BATTERY WAS REPLACED, THROTTLE VALVES WERE CLEANED, THE RECIRCULATION VALVE WAS REPLACED, THE ENGINE FAN CONTROL MODULE WAS REPLACED, THE FUEL PRESSURE SENSOR WAS REPLACED, THE CRANK CASE BREEDER VALVE WAS REPLACED, THE HIGH PRESSURE FUEL PUMP WAS REPLACED, AND THE CAM SHAFT FOLLOWER WAS REPLACED. THE VEHICLE WAS ALSO REPAIRED UNDER THE RECALL 09V164000, POWER TRAIN DRIVELINE, DRIVESHAFT AND HAD THE SUNROOF DRAINED DUE TO WATER LEAKAGE. THE FAILURE MILEAGE WAS 16,257 AND THE CURRENT MILEAGE WAS 47,000.

NHTSA ID

10348971

Incident

Aug 22, 2007

Mileage

16,257 mi

2006 JETTA TDI 58,229 MILES TODAY / PURCHASED FROM 2ND OWNER AT 53K MILES 34MPG IN TOWN / 42.5MPG HIGHWAY WIFE DRIVEN WITH LIGHT FOOT. OIL CHANGE AND FUEL FILTER REPLACED AT 53K MILES BACKGROUND: CAR WAS PURCHASED EARLY DEC 2009, WITH IN 2 WEEKS IT WAS AT THE DEALER FOR A NON START ISSUE. CAR WAS GARAGED OVER A 3 DAY WEEKEND AND NOT DRIVEN AT ALL. MONDAY MY WIFE GOES TO START IT AND IT WILL NOT START, AFTER TELLING ME I TRY FOR 3 MINUTES TO GET IT STARTED AND IT FINALLY STARTS. TAKEN TO DEALERSHIP AND THEY FIND NO ISSUES, THEY BLAME COLD START AS THE CULPRIT. THIS IS A BS CALL AS THE CAR WAS AND IS ALWAYS GARAGED AT 50+ DEGREES F. ROUGHLY 3 WEEKS LATER THE SAME SITUATION HAPPENS AND THE CAR GOES BACK TO THE DEALER. TO NO AVAIL THEY STILL COULD NOT REPLICATE THE ISSUE NOR FIND A SOLUTION. THE NO START ISSUE/ HARD START ISSUE SEEMED TO PROGRESS FROM SITTING FOR 3 DAYS AND NOT STARTING TO RANDOMLY MULTIPLE TIMES A WEEK NOT STARTING. THEY STILL CANNOT FIND A SOLUTION. I FIRMLY BELIEVE THIS IS A FUEL ISSUE. ON TO TODAY'S ISSUE: FIRST NOTICED 3 WEEKS AGO WHILE ATTEMPTING TO PASS A CAR ON THE INTERSTATE AT 70MPH (AROUND 4K RPM), THE CAR DOWN SHIFTED AND STUTTERED RATHER THEN INCREASING SPEED. I THOUGHT IT WAS A 1 TIME ISSUE UNTIL I STARTED NOTICING IT MORE AND MORE. NOW IT HAPPENS FREQUENTLY AND MORE PRONOUNCED STARTING AT EVEN 35MPH/3400 RPM IN 3RD GEAR. FROM 10AM TUESDAY TO 5PM FRIDAY OUR JETTA WAS BACK AT THE DEALERSHIP BECAUSE OF A STUTTER/POWER LOSS ISSUE. THEY DID REPLACE THE FUEL FILTER TODAY AS WELL AS TEST THE FUEL (WHICH TESTED FINE), THE EGR VALVE WAS CLEANED WITH A CARB CLEANER. THE SERVICE MANAGER DROVE THE CAR OFTEN AND HAS BEEN ABLE TO REPLICATE THE POWER LOSS / STUTTER, HOWEVER THEY CANNOT FIND ANYTHING WRONG. THEY CALLED THE VW TECH LINE MULTIPLE TIMES AND STILL NO FIX ONCE AGAIN. CAR DIED SEVERAL TIMES TODAY. TURNING ONTO THE HIGHWAY THE CAR STUTTERED AND THEN .5 MILES LATER IT DIED AT 45MPH IN TRAFFIC. PULLED OVER AND CRANKED FOR 3 MINUTES. *TR

NHTSA ID

10331889

Incident

May 22, 2010

Mileage

58,500 mi

MY 2006 JETTA 2.5 HAS AN INTERMITTENT ACCELERATOR HESITATION. IT CAN OCCUR WHEN THE ENGINE IS COLD OR HOT. IT SEEMS TO OCCUR WHEN IT IS ROLLING FREE AT NEAR 5 TO 10 MPH, AND WHEN THE ACCELERATOR IS PRESSED NOTHING HAPPENS FOR A SECOND OR TWO. THEN IT CATCHES AND GOES. *TR

NHTSA ID

10238352

Incident

Aug 8, 2008

Mileage

41,000 mi

AT 15F DEGREES OR LOWER TEMPERATURES THE VOLKSWAGEN DSG TRANSMISSION WILL IMPEDE THE DIESEL ENGINES ABILITY TO START, LEAVING THE VEHICLE INOPERABLE. VWAG AND VWOA HAS KNOWLEDGE OF THIS SYSTEM DEFECT PROVIDING NO SOLUTION. VWOA CONTINUES TO SELL THESE DEFECTIVE VEHICLES. *TR

NHTSA ID

10227204

Incident

Dec 27, 2006

Mileage

3,300 mi

ENGINE FAILURE ON MY 2006 VOLKSWAGEN DIESEL JETTA. THE ELECTRONIC CONTROL FUEL INJECTOR OVER FUELED THE CYLINDERS AND CAUSED THE PULL RODS TO BEND AND DAMAGED THE ENGINE, COSTS ARE $7,500 TO REPAIR THE ENGINE. CAR IS ONLY 2 AND HALF YEARS OLD WITH 85,0000 MILES. *TR

NHTSA ID

10227184

Incident

Mar 9, 2008

Mileage

85,486 mi

FILLED UP MY 2006 JETTA TDI AND DIESEL FUEL CAME OUT ALL OVER THE CAR AND THE GROUND. THE FUEL FILLER DESIGN WILL NOT ACCOMMODATE THE LARGER DIAMETER TRUCK DIESEL NOZZLE, BUT THAT'S ALL THERE WAS AVAILABLE AT THE SERVICE STATION (AND AT MOST SERVICE STATIONS ALONG THE INTERSTATE). THE PREVIOUS GENERATION FUEL FILLER DID ACCOMMODATE THE LARGER DIAMETER DIESEL NOZZLES SO I DON'T KNOW WHAT VW WAS THINKING. VW NEEDS TO ISSUE A RECALL AND FIX THIS ASAP. IT IS A SAFETY ISSUE DUE TO SPILLED DIESEL FUEL. *JB

NHTSA ID

10167317

Incident

Sep 1, 2006

Mileage

8,800 mi