RoadVitals

1991 Volkswagen Passat Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
24
Latest Aug 28, 2003
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
9
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1991 Volkswagen Passat, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Engine621.4%
  • Visibility621.4%
  • Fuel system517.9%
  • Brakes310.7%
  • Seat belts310.7%
  • Electrical27.1%
  • Powertrain (other)13.6%
  • Transmission13.6%
  • Heating & air conditioning13.6%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

6
reports

From owner reports, verbatim

BURNING HOT ANTI-FREEZE AND STEAM CLOUDED THE CABIN OF MY VW PASSAT WHILE DRIVING DOWN THE HIGHWAY, CAUSING AN UNSAFE DRIVING SITUATION AND POTENTIAL HEALTH RISKS FROM BREATHING THE HOT FUMES.

NHTSA ID 10036771 · filed Aug 28, 2003

THE TIMMING BELT FAILED AT 152081 KM'S THIS IS IN CANADA. I WAS TOLD THAT I COULD CALL YOUR SITE AND REPORT THIS PROBLEM. THE TIMING BELT IS SUPPOSE TO BE GOOD FOR 100000 KM. THE TIMING BELT ONLY LASTED FOR 52 000 KM . I REPORTED IT TO VOLKSWAGEN NORTH AMERICA BUT THEY JUST GAVE ME THE RUN AROUND. IF THERE IS ANYTHING THAT YOU CAN DO OR I CAN DO PLEASE WRITE TO ME AT [email protected] OR CALL ME AT 403-212-1034 THANK YOU LEN.*AK

NHTSA ID 723561 · filed Jun 4, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Visibility

Reports naming windshields, glass, wipers, defrosters and mirrors.

6
reports

From owner reports, verbatim

THE POWER WINDOWS IN THE 1991 PASSAT SUDDENLY DIED. THERE IS STILL ELECTRICAL POWER TO THE MECHANISM INSIDE THE DOOR, BUT THE TRACK/GUIDE OR WHATEVER MAKES THE WINDOW SLIDE UP SMOOTHLY IS BROKEN. CURRENTLY THEY ARE STUCK IN THE UP,SEALED POSITION BECAUSE IF THEY GO DOWN, THEY DONT GO BACK UP COMPLETELY. THE CAR HAS SUSTAINED SOME WATER DAMAGE FROM WHEN THEY COULD NOT BE PUT UP.

NHTSA ID 700682 · filed Nov 17, 1998

INTERIOR HEATING CORE BROKE, CAUSING SMOKE TO FILL THE CAR WHILE DRIVING. ALSO, HEATER FAN MOTOR SWITCH FAILED.

NHTSA ID 534618 · filed Apr 18, 1998

Too few reports in this category for a page of its own — they appear in the full complaint list.

Fuel system

Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.

5
reports

From owner reports, verbatim

FUEL INJECTIN SYSTEM: ACCUMULATOR ( DELIVERY SYSTEM) WAS LEAKING GAS TO POINT IT WAS POURING OUT. GAS FUMES WERE STRONG FROM IN & OUTSIDE. VEHICLE WAS TOWED TO AN AUTO MOTOR GARAGE WHICH HAD SEEN A COMMON PROBLEM POSSIBLY DUE TO ROAD SALT ON STREET ADDED TO CORROSION. *AK FUMES POSSIBLY COULD HAVE IGNITED WHEN STOPPING AND COULD HAVE BEEN DANGEROUS. *YH

NHTSA ID 874912 · filed Nov 14, 2000

TEMPERATURE AND GAS GAUGE WERE FIXED ON MANY OCCASIONS BY THE DEALER BUT NEVER FULLY FIXED. WORK ONLY WHEN PUSHED ON THE DASH COVER. THERE IS A SERVICE BULL ON THIS BUT PROBLEM, BUT IT DIDN'T HELP FIX IT. *AK

NHTSA ID 720421 · filed Mar 21, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

3
reports

From owner reports, verbatim

CONSUMER WAS DRIVING ON HIGHWAY IN STOP AND GO TRAFFIC UNDER NORMAL ROAD CONDITIONS, SUDDENLY THE ABS LIGHT SENSOR CAME ON AND VEHICLE LOST BRAKES FOR APPROXIMATELY THREE HOURS. ABS SENOR LIGHT WENT OUT, AND ABS SYSTEM RESTORED BRAKES. DEALER NOTIFIED. *AK

NHTSA ID 824198 · filed Jun 11, 1998

MASTER CYLINDER HAS AN INTERNAL HYDRAULIC LEAK WHICH MAY LEAD TO A BRAKE FAILURE.

NHTSA ID 536716 · filed Jun 8, 1998

Too few reports in this category for a page of its own — they appear in the full complaint list.

Seat belts

Reports naming seat belts, buckles, retractors and pretensioners.

3
reports

From owner reports, verbatim

THE AUTOMATIC SEATBELT CONTROL MODULE WILL DRAIN THE CARS BATTERY IN A MATTER OF HOURS. TO USE THE CAR THE PASSIVE RESTRAINT SYSTEM MUST BE DISABLED. IT IS UNCLEAR IF THE BELTS EVEN WORK MANUALLY UNDER THESE CIRCUMSTANCES. *AK

NHTSA ID 701342 · filed Jan 12, 1999

MOTORIZED SEAT BELTS FAILED, OPENED WHILE DRIVING AND STAYED OPEN. *AK

NHTSA ID 517980 · filed Jul 2, 1997

Too few reports in this category for a page of its own — they appear in the full complaint list.

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

2
reports

From owner reports, verbatim

WHILE TRAVELING ON THE HIGHWAY THE VEHICLE LOST POWER, STARTED VIBRATING AND SHUT DOWN. PLEASE FILL IN ADDITIONAL INFORMATION, DEALER IS AWARE OF THE PROBLEM. PH

NHTSA ID 10004320 · filed Jan 21, 2003

FRONT/REAR POWER WINDOWS FAILED INTERMITTENTLY, CAUSING WINDOWS TO FALL DOWN. *SKD

NHTSA ID 489512 · filed Apr 21, 1995

Too few reports in this category for a page of its own — they appear in the full complaint list.

Powertrain (other)

Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.

1
report

From owner reports, verbatim

ODOMETER MILLAGE IS TURNED BACK. YH

NHTSA ID 552058 · filed May 3, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Transmission

Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.

1
report

From owner reports, verbatim

VEHICLE CAN BE PUT INTO GEAR FROM PARK WITHOUT KEY IN IGNITION DUE TO LACK OF INTERLOCK SYSTEM. *DSH

NHTSA ID 504028 · filed May 9, 1996

Too few reports in this category for a page of its own — they appear in the full complaint list.

Heating & air conditioning

Reports naming the heating, ventilation and air-conditioning system.

1
report

From owner reports, verbatim

TIMING BELT BROKE CAUSING DAMAGE TO VALVES ON TWO OCCASIONS.

NHTSA ID 539513 · filed Sep 1, 1998

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .