1995 Volkswagen Passat Problems

HEATER CORE "DOORS " MELTED FROM THE R TYPE ANTIFREEZE BREAKING DOWN TO AN ACID. THIS CAUSE THE HEATERCORE TO BREAK, ANTIFREEZE ENTERED THE CAR THROUGH THE VENTS AND ALSO ODDLY ENOUGH FILLED THE GAUGE CLUSTER WITH STEAM FOGGING THE CLUSTER. IT'S $800 FOR A REPLACEMENT SO I BOUGHT A FITTING AND SOME HOSE CLAMPS AND BYPASSES THE HEATER CORE SO I COULD STILL OPERATE THE VEHICLE WHEN IT WASN'T TOO COLD. HOWEVER WHEN OPERATING THE VEHICLE IN COLD WEATHER ALL THE WINDOWS HAD TO BE DOWN DUE TO YOUR BODY HEAT CAUSING ALL GLASS IN THE VEHICLE TO FOG. REPLACED THE HEATER CORE IN JANUARY, FLUSHED THE RADIATOR AND INSTALLED REGULAR TYPE 50/50 ANTIFREEZE AND NOT THE VW R-TYPE FLUID TO PREVENT BREAK DOWN INTO ACID AGAIN. *TR

95 PASSAT HEATER CORE RUPTURE FILLING THE VEHICLE CABIN WITH HOT RADIATOR FLUID AND STEAM. WINDSHIELD BECAME COATED WITH ANTI-FREEZE SOLUTION THAT JUST SMEARED AND COULD NOT BE WIPED OFF. VEHICLE LEFT THE ROAD INTO THE DITCH. I WILL BYPASS THE HEATER CORE FOR I CAN'T AFFORD TO HAVE IT REPAIRED AT THIS TIME. CONTACTED VWOA AND NO SPECIFIC RECALLS HAVE BEEN ISSUED.*JB

THE HEATER CORE FAILED ON OUR 1995 VW PASSAT WHILE MY SON WAS DRIVING IT. WITHOUT WARNING IT FAILED AND POURED 190 DEGREE ANTIFREEZE OVER HIS ANKLES. FORTUNATELY HE WASN'T SEVERELY BURNED OR CRASHED THE CAR, BUT IT WAS SERIOUS ISSUE. WE SPOKE TO VW BUT THEY WOULDN'T REPLACE THE HEATER CORE. MANY CUSTOMERS HAVE HAD THE CORE REPLACED UNDER WARRANTY, BUT IT SEEMS TO BE RANDOMLY SELECTED. I HAVE READ ON THE FORUMS OF THIS HAPPENING OFTEN AND WOULD LIKE TO KNOW IF THERE IS RECALL THAT VW NEEDS TO ADDRESS. THANK YOU FOR YOUR HELP. *TR

DT*: THE CONTACT STATED THE VEHICLE VIBRATES AND IS WORSE WHEN IN HIGH GEAR. PART OF THE FAN FRACTURED CAUSING THE VEHICLE TO OVERHEAT. THERE IS AN NHTSA RECALL, # 95V178000, REGARDING THE ENGINE AND ENGINE COOLING: COOLING SYSTEM: FAN. THE VEHICLE VIN WAS NOT INCLUDED IN THE RECALL.

5SP VRG PASSAT. EMERGENCY/PARKING BRAKE WHEN APPLIED UNDER 40 DEGREES STICKS ON CAUSING THE REAR WHEEL TO DRAG DOWN THE ROAD FOR UP TO A MILE BEFORE THEY BREAK LOOSE AGAIN AND MOVE FREELY. *TR

BACKUP LIGHTS DIDN'T TURN ON, WHEN THE BRAKES WERE DEPRESSED THE ACCENT LIGHTS (LIGHTS THAT ILLUMINATE THE GAUGES, WINDOW, A/C & HEATER CONTROLS AND LOCK BUTTONS ETC.) WOULD TURN ON. ALSO IF THE CAR IF THE KEYS WERE TURNED TO THE FIRST NOTCH (STEERING WHEEL UNLOCK) AND THE HEATER VENTS TURNED TO THE ON POSITION BUT NOT BLOWING (DUE TO NO POWER) WHEN YOU PRESSED THE BRAKE PEDAL THE AIR WOULD START BLOWING... I TRACED IT DOWN TO AN IGNORANT ELECTRICAL ENGINEER DESIGNING THE CAR. THE REVERSE LIGHTS WERE LOOMED ON TO THE TRUNK ARM, EVERYTIME THE TRUNK WAS CLOSED IT BENT THE WIRE CAUSING THE WIRE TO BREAK AND SHORT OUT OVER TIME, I FIXED THE WIRE AND REROUTED IT LOW AND BEHOLD THE REVERSE LIGHTS ARE APPARENTLY TIED INTO THE ACCENT LIGHTS AND THE A/C & HEATER CONTROLS CAUSING THOSE TO MALFUNCTION IF THE REVERSE WAS SHORTED, MY GUESS IS THEY MUST ALL SHARE A COMMON GROUND. *TR

BACKUP LIGHTS DIDN'T TURN ON, WHEN THE BRAKES WERE DEPRESSED THE ACCENT LIGHTS (LIGHTS THAT ILLUMINATE THE GAUGES, WINDOW, A/C & HEATER CONTROLS AND LOCK BUTTONS ETC.) WOULD TURN ON. ALSO IF THE CAR IF THE KEYS WERE TURNED TO THE FIRST NOTCH (STEERING WHEEL UNLOCK) AND THE HEATER VENTS TURNED TO THE ON POSITION BUT NOT BLOWING (DUE TO NO POWER) WHEN YOU PRESSED THE BRAKE PEDAL THE AIR WOULD START BLOWING... I TRACED IT DOWN TO AN IGNORANT ELECTRICAL ENGINEER DESIGNING THE CAR. THE REVERSE LIGHTS WERE LOOMED ON TO THE TRUNK ARM, EVERYTIME THE TRUNK WAS CLOSED IT BENT THE WIRE CAUSING THE WIRE TO BREAK AND SHORT OUT OVER TIME, I FIXED THE WIRE AND REROUTED IT LOW AND BEHOLD THE REVERSE LIGHTS ARE APPARENTLY TIED INTO THE ACCENT LIGHTS AND THE A/C & HEATER CONTROLS CAUSING THOSE TO MALFUNCTION IF THE REVERSE WAS SHORTED, MY GUESS IS THEY MUST ALL SHARE A COMMON GROUND. *TR

I WAS STARTING MY 1995 VOLKSWAGEN PASSAT VR6 (MANUAL), AND IT STARTED UP JUST FINE, BUT AS I STARTED TO GET GOING, THE CAR DIED. I LOST ALL ELECTRICAL FUNCTIONS OF THE CAR INITIATED BY THE IGNITION SWITCH, INCLUDING POWER BRAKES, POWER STEERING, AND HEADLIGHTS. I FOUND OUT THAT MY IGNITION SWITCH HAD MALFUNCTIONED. I CALLED VW OF AMERICA (1-800-822-8987), AND THEY TOLD ME THAT A RECALL WAS OUT FOR THE 1996 AND 1997 MODELS. THE ONLY DIFFERENCE BETWEEN THESE TWO MODEL YEARS AND MY MODEL YEAR IS THE SWITCH IN THE ON BOARD DIAGNOSTIC SYSTEM FROM OBD 1 TO OBD 2. I KNEW FROM EXPERIENCE THAT THE IGNITION SWITCH WAS THE SAME FOR ALL 1995 TO 1997 PASSATS, BUT JUST TO BE SURE, I CALLED STEVENS CREEK VOLKSWAGEN PARTS DEPARTMENT (1-408-492-1200). THE GUY THERE TOLD ME THAT PART NUMBERS MATCHED THROUGH ALL 3 YEARS, AND THAT THE IGNITION SWITCH MALFUNTCIONS AN ALL 3 MODEL YEARS INCLUDING 1995. SO, I CALLED VW OF AMERICA AGAIN, AN ASKED THEM WHY THEY DIDN'T RECALL MY MODEL YEAR. THEY STATED THAT "VW COULD HAVE RECTIFIED THE PROBLEM" WHICH IS IMPOSSIBLE WHEN ALL 3 PART NUMBERS ARE THE SAME. THEY THEN SAID THAT THEY WOULD LAUNCH THEIR OWN INVESTIGATION INTO IT, AND TOLD ME TO CALL NHTSA. MY FINAL SAY ON THIS MATTER IS THAT IT DEFINITELY IS LIFE THREATENING, BECAUSE THE IGNITION SWITCH IS ELECTRICAL, AND CAN MALFUNTCION AT AND TIME, CAUSING YOU TO LOSE POWER STEERING, BRAKES, AND LIGHTING ON THE ROAD. I WAS LUCK BECAUSE I JUST GOT GOING, AND WAS ABLE TO PUSH THE CAR BACK BY MY HOUSE. MEANWHILE, VOLKSWAGEN OF AMERICA IS CUTTING CORNERS TO SAVE MONEY BY ONLY RECALLING THE MODEL YEARS THAT YOU HAVE TESTED, EVEN THOUGH THE MALFUNCTIONING PART IS THE SAME INALL 3 MODEL YEARS: 1995, 1996, AND 1997. AS A MEMBER OF A VW VORTEX FORUM, I WILL TELL OTHERS WITH THIS SAME PROBLEM TO WRITE IN TO YOU. *AK

DRIVER SIDE DOOR FAILS TO OPEN 75% OF THE TIME, YOU HAVE TO YANK THE HANDLE MULTIPLE TIMES FOR IT TO OPEN, THE REAR DRIVER SIDE DOOR DOESN'T OPEN FROM THE OUTSIDE ANYMORE, THE OTHER DOORS ARE STARTING TO HAVE THE SAME PROBLEM, WHEN YOU LOCK THE CAR THE REAR PASSENGER DOORS LOCK MECHANISM SLOWLY RISES TO THE UNLOCKED POSITION. DRIVERS SIDE DOOR AND PASSENGER SIDE DOOR MANY TIMES FAIL TO CLOSE. WHEN YOU CLOSE THE DOORS THEY FLY BACK OPEN EITHER IMMEDIATELY AFTER CLOSING OR WHILE OPERATING THE VEHICLE. **THERE IS A SIMILAR COMPLAINT MISPLACED INTO THE AIR CONDITIONER SECTION BY ANOTHER INDIVIDUAL.** *TR

REAR DOOR LATCH IS MALFUNCTIONING. LATCH RELEASES WHEN DRIVING

CONSUMER STATES WITHOUT WARNING THE TRANSMISSION DOES NOT WORK ANYMORE. CONSUMER CAN NOT SHIFT THE CAR OUT OF PARK. TS

TRANSMISSION COOLANT IS LEAKING OUT ON TO GROUND, AND COOLANT IS RUNNING INTO CYLINDER BLOCK. DEALERSHIP IS AWARE OF PROBLEM.*AK

DT: CALLER CAN NOT OPEN DOOR FROM THE OUTSIDE. SHE HAS TO USE THE HANDLE ON THE INSIDE OF ALL THE DOORS EXCEPT THE REAR PASSENGER DOOR. DEALER SAID THEY NEVER HEARD OF THIS. MANUFACTURER SAID THEY COULD NOT DO ANYTHING TO HELP HER.*AK

ALL FOUR DOOR HANDLES OUTSIDE HAVE BROKEN OFF, THE PASSENGER INDOOR HANDLE HAS BROKEN OFF AND THE SAFEY CHECK WAS FAILED BECAUSE OF THIS. VW SAYS THIS IS JUST "WEAR AND TEAR" BUT WE BELIEVE THIS HAS TO BE A DESIGN FAULT - AND NOW IT'S A SAFEY ISSUE TOO.*AK

RACK AND PINION STEERING FAILED. AS RESULT STEERING MALFUNCTIONED. HOWEVER TCONSUMER WAS ABLE TO GAIN CONTROL. *AK

THE CONSUMER BELIEVES THERE ARE A NUMBER OF ELECTRICAL FAILURES WITH THE VEHICLE INCLUDING, 5 BATTERIES IN FIVE YEARS, RIGHT AND LEFT FRONT WINDOWS WILL NOT ROLL DOWN, TRUNK LIGHT ILLUMINATES FOR NO APPARENT REASON AND THE DOOR LOCKS ARE INOPERATIVE. NLM

AFTER REPLACING BATTERY IN CAR, THE SUNROOF, PASSENGER AND BOTH REAR WINDOWS CEASED TO FUNCTION. *AK

FRONT WHEEL BEARINGS FAILED/REPLACED. *AK

WHILE TRAVELING ON THE HIGHWAY THE PLASTIC LENS THAT COVER THE HEADLIGHT CAUSED THE HEADLIGHT TO BECOME DARK SO NO LIGHT COME THROUGH DIM AND DARK. PLEASE FILL IN ADDITIONAL INFORMATION DEALER IS AWARE OF THE PROBLEM. TS *TR

THE IGNITION AND HEADLIGHT SWITCH WAS DEFECTIVE.TS *JB

THE CONSUMER BELIEVES THERE ARE A NUMBER OF ELECTRICAL FAILURES WITH THE VEHICLE INCLUDING, 5 BATTERIES IN FIVE YEARS, RIGHT AND LEFT FRONT WINDOWS WILL NOT ROLL DOWN, TRUNK LIGHT ILLUMINATES FOR NO APPARENT REASON AND THE DOOR LOCKS ARE INOPERATIVE. NLM

INTERMITTENT STALLING AFTER VEHICLE IS WARMED UP AND IT IS SLOWED DOWN TO FIRST GEAR/REVERSE GEAR OR STOPPED AND AT IDLE SPEED. *AK

TIMING CHAIN STRETCHED AND VALVES WENT AGAINST PISTONS. ENGINE LIGHT GOES ON AND OFF ALL THE TIME. IGNITION SWITCH FAIL AND LIGHTS GO OFF. RIGHT WINDOW DOESN'T WORK. IGNITION COIL IS DEFECTIVE.

WHILE DRIVING AT NORMAL SPEED CONSUMER FELT THAT VEHICLE SUDDENLY WENT FROM DRIVE TO NEUTRAL, THEN BACK TO DRIVE. TOOK VEHICLE TO DEALER ,AND THEY REPLACED A PART. CONSUMER IS NOT AWARE OF WHICH PART WAS REPLACED PROBLEM STOPPED. CURRENTLY, SUNROOF AND REAR SEAT BELTS ARE NOT WORKING. CONSUMER OWNS A 1996 NOT IN THE DIMS SYSTEM. PLEASE PROVIDE ANY FURTHER INFORMATION. TS

RECEIVED A SAFETY ADVISORY LETTER FROM VOLKSWAGEN REGARDING FUEL TANK SYSTEM AND RIGHT REAR TIRE. CONSUMER ALSO STATED THE LETTER SHOULD BE CALLED A RECALL. PEOPLE MIGHT IGNORE IT BY BEING CALLED A SAFETY ADVISORY. PLEASE ADD VIN #*AK

SEAT BELT INOPERATIVE.

TIMING CHAIN STRETCHED AND VALVES WENT AGAINST PISTONS. ENGINE LIGHT GOES ON AND OFF ALL THE TIME. IGNITION SWITCH FAIL AND LIGHTS GO OFF. RIGHT WINDOW DOESN'T WORK. IGNITION COIL IS DEFECTIVE.

NO SUMMARY

1995 PASSAT SIDEWALL BLEW OUT WHILE DRIVING 65 MPH. *TS THE TECHNICIAN WHO PERFORMED THE INSPECTION POINTED TO CRACKS WHICH WERE NEAR THE RIM LINE. *JB

RECEIVED A SAFETY ADVISORY LETTER FROM VOLKSWAGEN REGARDING FUEL TANK SYSTEM AND RIGHT REAR TIRE. CONSUMER ALSO STATED THE LETTER SHOULD BE CALLED A RECALL. PEOPLE MIGHT IGNORE IT BY BEING CALLED A SAFETY ADVISORY. PLEASE ADD VIN #*AK

WHILE IN PARKED GEAR THE VEHICLE CONTINUES TO ROLL BACKWARD.

HEATER CORE IS DEAD CARE SMELLS LIKE ANTIFREEZE. DRIVER'S DOOR NO LONGER OPENS FROM OUTSIDE, AND OTHER DOORS ARE STARTING TO DO THE THE SAME. CAR CAN'T BE SHUT OFF FOR SHORT STOP OR IT WILL NOT START AGAIN. A/C WENT OUT 2 YEARS AGO CONTACTED VW OF AMERICAN NO HELP.