2006 Volkswagen Passat Problems

The contact owned a 2006 Volkswagen Passat . The contact received notification of NHTSA Campaign Number: 24V834000 (Air Bags) and would like to be removed from the recall distribution list. The local dealer and manufacturer were not contacted.

recalled airbag

The contact owns a 2006 Volkswagen Passat. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to be restarted. The vehicle was taken to the dealer, where it was diagnosed and determined that the fuel pump module had failed and needed to be replaced. The vehicle was repaired. The contact later received notification of NHTSA Campaign Number: 17V509000 (Fuel System, Gasoline). The manufacturer was made aware of the failure to obtain assistance with reimbursement. The failure mileage was not available. Parts distribution disconnect.

My family and I have been VW owners for over 60 years. Unfortunately, the 2006 VW Passat has been layered with defects, negligent manufacturing issues, faulty wiring, electrical problems, computer glitches, to mention a few. There have been many recalls including an official recall by the NHTSA, for steering linkage problems and tie rod assembly which caused a loss of steering, crashes and deaths. Over 292 complaints are filed with Consumer Affairs, over 561 defects reported, and thousands of horror stories like mine about this car. It's considered a lemon by many car professionals. Many dealerships in the USA offered to inspect, and replace the electronic steering column lock free of charge and address any other concerns, which should be standard, reasonable behavior for all VW dealerships, mandated by this Federal agency. Shortly after this car almost killed me in 2013, VW put me through countless stressful hours of calls, emails and the like and still refused to be fully accountable. Shortly after my almost end of life, the notorious VW Emissions Scandal spoke volumes. VW was well aware of their defects including the electrical system in the steering column/immobilizer, (the system won’t recognize the key; a module in the car that connects the key and starts the engine is defective). In many cases, the entire steering column is defective and has to be completely replaced because the car’s pistons, internal combustion and engine are all subpar. Even the Sunroof and drains are defective and every time it rains, there is a flood in my car which has caused life threatening mold and mildew. I am respectfully asking for your help in having VW provide me, a near [XXX] woman, a safe, reliable, car without another defective sunroof and without defective water drains. It can be used as long as it's reliable and without deadly mold and mildew. I have photos. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

TRYING TO START CAR AND WON'T TURN ON WITH KEY ALL MY KEYS DON'T WORK SAYS STEERING WHEEL LOCK DEFECTIVE CAN'T GET MY CAR TO TURN MY RADIO ON I AM PARKED IN MY DRIVE WAY AND CAN'T EVEN TOW IT TO DEALER NOW BECAUSE IT WON'T GO INTO NEUTRAL. *TR

MY VW HAS BEEN HARD TO START AND GETTING THE STEERING LOCK FAULT WARNING. I UNDERSTAND THERE WAS A VOLUNTARY RECALL, BUT I WAS THE ORIGINAL OWNER AND DO NOT REMEMBER GETTING THE RECALL NOTICE.

My family and I have been VW owners for over 60 years. Unfortunately, the 2006 VW Passat has been layered with defects, negligent manufacturing issues, faulty wiring, electrical problems, computer glitches, to mention a few. There have been many recalls including an official recall by the NHTSA, for steering linkage problems and tie rod assembly which caused a loss of steering, crashes and deaths. Over 292 complaints are filed with Consumer Affairs, over 561 defects reported, and thousands of horror stories like mine about this car. It's considered a lemon by many car professionals. Many dealerships in the USA offered to inspect, and replace the electronic steering column lock free of charge and address any other concerns, which should be standard, reasonable behavior for all VW dealerships, mandated by this Federal agency. Shortly after this car almost killed me in 2013, VW put me through countless stressful hours of calls, emails and the like and still refused to be fully accountable. Shortly after my almost end of life, the notorious VW Emissions Scandal spoke volumes. VW was well aware of their defects including the electrical system in the steering column/immobilizer, (the system won’t recognize the key; a module in the car that connects the key and starts the engine is defective). In many cases, the entire steering column is defective and has to be completely replaced because the car’s pistons, internal combustion and engine are all subpar. Even the Sunroof and drains are defective and every time it rains, there is a flood in my car which has caused life threatening mold and mildew. I am respectfully asking for your help in having VW provide me, a near [XXX] woman, a safe, reliable, car without another defective sunroof and without defective water drains. It can be used as long as it's reliable and without deadly mold and mildew. I have photos. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

TRYING TO START CAR AND WON'T TURN ON WITH KEY ALL MY KEYS DON'T WORK SAYS STEERING WHEEL LOCK DEFECTIVE CAN'T GET MY CAR TO TURN MY RADIO ON I AM PARKED IN MY DRIVE WAY AND CAN'T EVEN TOW IT TO DEALER NOW BECAUSE IT WON'T GO INTO NEUTRAL. *TR

The contact owns a 2006 Volkswagen Passat. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to be restarted. The vehicle was taken to the dealer, where it was diagnosed and determined that the fuel pump module had failed and needed to be replaced. The vehicle was repaired. The contact later received notification of NHTSA Campaign Number: 17V509000 (Fuel System, Gasoline). The manufacturer was made aware of the failure to obtain assistance with reimbursement. The failure mileage was not available. Parts distribution disconnect.

I HAVE A GAS LEAK COMING FROM THE TOP OF THE GAS TANK. VERY HEAVY FUMES COMING IN THE CAR AND AROUND THE CAR. WHEN THE CAR IS IN MOTION AND STATIONARY.

I PURCHASED THIS CAR 2 YEARS AGO AND HAVE HAVE THE PARKING BRAKE FAIL AND BREAK THREE TIMES. THE FIRST TIME WAS SHORTLY AFTER THE PURCHASE AND THE CAR CAME OUT OF GEAR IN MY DRIVEWAY AND BEGAN ROLLING. MY 65 YO MOM HAD TO STOP IT AND PUSH IT UP AS SHE WAS HOME ALONE. IT TURNED ON ANOTHER TIME WHILE I WAS CROSSING AN INTERSECTION AND I WAS ALMOST T-BONED. I HAD IT REPLACED AFTER THIS INCIDENT. IN MAY 2020 THE PARKING BRAKE WOULD NOT DISENGAGE AND I NEEDED TO HAVE IT TOWED TO MY MECHANIC. THE BRAKE WAS STUCK ON AND THE COMPUTER CONTROL UNIT BROKE. I PAID $2500 TO HAVE THE UNIT REPLACED. IN DEC 2020 (ONLY 7 MONTHS LATER) THE EXACT THING HAPPENED AGAIN. I WAS UNABLE TO DISENGAGE THE PARKING BRAKE AND NEEDED TO TOW IT TO MY MECHANIC. THE CALIPER AND COMPUTER BROKE AGAIN. THE COST IS SIMILAR. THIS IS A SAFETY ISSUE. IF YOU LOOK AT ANY VW FORUMS YOU WILL SEE THIS IS A KNOWN ISSUE WITH MANY PEOPLE HAVING THEIR BRAKE STUCK AND UNABLE TO ENGAGE/DISENGAGE THE UNIT. I REACHED OUT TO VW AND HAD NO RESOLUTION. I REQUEST THE PARKING BRAKE BE RECALLED AND EVERYONE WHO HAD WORK DONE ON IT, INCLUDING MYSELF, RECEIVED A FULL REFUND.

HAVE REPLACED NUMEROUS PARTS ...THE EPX LIGHT KEEPS COMING ON WHICH MAY REFERENCE TO THE OIL PUMP BOLT FAILING...CRANKSHAFT AND CAM SHAFTS CODES KEEP COMING ON EVEN THOUGH THEY WERE REPLACED...TRANSMISSION SHIFTING SLIGHTLY HARD.. OVERHEATING EVEN THOUGH NEW PARTS WERE INSTALLED...AIR BAG LIGHT STAYS ON..BRAKES HAVE BEEN BLEED OVER 10 TIMES AND ARE STILL TOO SOFT CAUSE ME TO BRAKE AT A FURTHER DISTANCE TO AVOID A WRECK....I AM ON A FIXED INCOME AND CANT AFFORD A MASSAGE BILL TO FIX IT AND VW IS AWARE OVER THESE YEARS OF THE ISSUES AND WONT RECALL TO REPAIR ANY OF THE ISSUES...I HAVE ALL RECEIPTS FOR THE PARTS REPLACED... *TR

I WAS BACKING OUT OF A PARKING SPACE WITH THE CAR IN REVERSE. I LIFTED MY FOOT FROM THE BRAKE AND STARTED TO APPLY THE ACCELERATOR AT WHICH POINT THE VEHICLE ACCELERATED TO FULL SPEED AND HIT A STAIRCASE RAIL BEHIND ME. I THEN SLAMMED THE BRAKE AND PUT THE CAR INTO DRIVE TO AVOID REVERSING INTO ANYONE. I APPLIED THE ACCELERATOR AND ONCE AGAIN IT ACCELERATED FORWARD AT FULL SPEED, THIS TIME HITTING A CONCRETE COLUMN WHICH DISABLED THE VEHICLE.

THE ENGINE LOST IT'S POWER, GAS CONSUPTION IS SO HIGH, ENGINE IS SHAKING AND NOISY AND WLECTRICAL CONTROLE IS DOWN RANDOMLY. AM SCARED OF DRIVING IT.

Transmission clunks into gear and loses traction while shifting.

We owned vehicle approx 8yrs and in late 2022 will driving/on highway 55mph or local roads like Broadway 15-20mph the vehicle goes into neutral. VErY dangerous it wil work as it should after a restart

2006 VOLKSWAGEN PASSAT. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO EMERGENCY/ SIGNAL LIGHTS MALFUNCTION, SUNROOF PROBLEMS AND OTHER VEHICLE ISSUES. *SMD THE CONSUMER STATED THE VEHICLE INTERMITTENTLY FAILS TO RECOGNIZE THE ELECTRONIC KEY WHEN ATTEMPTING TO START THE VEHICLE. THE BLINKER/TURN SIGNALS FAIL TO TURN OFF WHEN PROMPTED. THE CONSUMER WAS ADVISED THAT THE SIGNALS WOULD NOT TURN OFF UNLESS THE STEERING WHEEL WAS TURNED COMPLETELY STRAIGHT. THE SUNROOF OPENS UNPROMPTED. THE DEALER AND MANUFACTURER COULD NOT DUPLICATE THE FAILURE. THE VEHICLE WAS ROTTED UNDERNEATH. THE EMERGENCY BRAKE LIGHTS FLASHED INCESSANTLY. *JS

TAKATA RECALL

CHECK ENGINE (MIL) LIGHT TURNED ON, CAR ALL OF A SUDDEN IDLES AT A HIGHER RPM WHILE WE WERE DRIVING!!! VEHICLE WAS TAKEN INTO THE DEALERSHIP. CAR IS ONLY UNDER WARRANTY FOR 36,000 MILES OR 3 YEARS! DEALERSHIP RAN DIAGNOSTIC, CAME UP WITH: CODE P0123 (THROTTLE HIGH INPUT), P0299 (TURBO UNDER BOOST), P0456 (EVAP LEAK), P1098 (INTAKE TURNING VALVE SHORT TO B+), CODE P2004 (INTAKE RUNNER STUCK), CODE P3237 (INTAKE RUNNER BASIC SETTINGS). DEALER RECOMMENDED INTAKE RUNNER MOTOR REPLACEMENT & REPLACEMENT OF TURBO & N80 VALVE, ALSO CV BOOT NEEDS REPLACEMENT. TOTAL COST OF REPAIRS OVER $1200!!! WE ALWAYS TAKE CARE OF OUR VEHICLES AND HAVE THEM SERVICED AT THE DEALERSHIP. VEHICLE HAS ALSO HAD DEFECTIVE INTERIOR PARTS. INTERIOR TRIM (ALL SWITCHES - LOCK, WINDOW & RADIO ARE BUBBLING AND CHIPPING). DOOR PANEL TRIM (RUBBER IS PEELING). SHIFT KNOB - METALLIC PIECE ON SHIFT KNOB, PEELED AND DUG INTO SKIN AND CAUSED INJURY. CARBON FIBER DASH IS PEELING APART. CONTACTED VW OF AMERICA, PER THEIR CUSTOMER SERVICE REP, THEY ARE UNABLE TO MAKE ANY REPAIRS DUE TO THE AGE AND MILEAGE OF THE VEHICLE. CAR IS A 2006 - 67,000 MILES. LESS THAN 5 YEARS OLD. I WOULD HAVE NEVER PURCHASED A VOLKSWAGEN HAD I KNOWN THEY WERE NOT RELIABLE VEHICLES. UNKNOWLEDGABLE SALES REPS, OR JUST AFTER CUSTOMERS TO MAKE A BUCK. SELLING PEOPLE UNRELIABLE VEHICLES AND VOLKSWAGEN CLEARLY DOES NOT TAKE CARE OF THEIR CUSTOMERS NOR DO THEY CARE ABOUT CUSTOMER LOYALTY OR SAFETY. *TR

VW, 2006 PASSAT, NOW HAS A "STEERING COLUMN DEFECT" WARNING, AND THE CAR DOESN'T START. THE CAR HAS 60,000 MILES ON IT, AND THIS STARTED JUST AFTER THE 50,000 MILE WARRANTY EXPIRED. THE CAR ALSO STALLS AT HIGH SPEED WHEN THIS LIGHT COMES ON WITHOUT WARNING, AND CAN CAUSE A SERIOUS ACCIDENT. THE CAR ALSO HAS A PROBLEM WITH DOWNSHIFTING WHEN ON THE HIGHWAY, AND SLAMS INTO LOW GEAR AS THOUGH THE CAR HIT SOMETHING. THE DEALER CANNOT FIND THE PROBLEM WHEN THE CAR IS PUT ON THE DIAGNOSTIC COMPUTER. I HAVE READ MANY OTHER COMPLAINTS ON THE INTERNET ABOUT THESE SAME ISSUES WITH THE 2006 PASSAT, AND FOUND THAT THE FIX FOR THE STEERING COLUMN ALONE COSTS BETWEEN $1400 AND $2000. BECAUSE THIS APPEARS TO BE A FACTORY DEFECT, AND IT IS A SAFETY ISSUE, I WANTED TO REPORT IT AS SUCH. ALTHOUGH THERE HASN'T BEEN AN ACCIDENT CAUSED IN MY CASE, THE POTENTIAL FOR DISASTER IS HUGE. I'M AFRAID TO DRIVE THE CAR, BECAUSE THIS IS A RECURRING PROBLEM, AND CAN HAPPEN AT ANY TIME. *TR

TAKATA RECALL I WENT IN TO GET THE REPAIR A WEEK LATER AN AIRBAG FAULT CAME ON AND STILL ON. THEN TWICE WHILE I WAS DRIVEING ON HIGHWAY CAR CUTS OFF COMPLETELY THEN I HAVE TO PULL OVER WITH IT JUST ROLLING. THE STEERING SOMETIMES COMES ON AND SAYS DEFECTIVE THEN THE SUN ROOF OPEN CLOSES BY ITSELF. ALOT OF ELECTRICAL PROBLEMS ALWAYS HAVE TO GET SOMETHING FIX JUST PRAY THAT I DONT GET INTO AN ACCIDENT. THE HEATED SEATS DONT WORK NOMORE FOR SOME REASON ON DAY THEY WAS GOOD NOW NO AND ITS NOT THE FUSE.

I HAVE AN AIR BAG LIGHT ON AND I GET A WARNING SIGN THAT IT SHOULD BE SERVICED. WIPERS ARE NOT THAT EFFECTIVE AND I KEEP ON HAVING FOGY WINDOWS SO I HAVE TO KEEP ON ADJUSTING THE HEAT.

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. WHILE DRIVING VARIOUS SPEEDS AT NIGHT, THE DRIVER SIDE HEADLIGHT FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HEADLIGHT WIRES WERE FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 121,000.

WE BOUGHT THIS CAR FOR MY 17 YEAR OLD DAUGHTER. THE LIGHTS ARE SO BAD THAT IT IS A DANGER DRIVING AT NIGHT. WE TOOK IT BACK TO THE DEALER WHO REPLACED THE REGULAR LIGHTS WITH LED LIGHTS, SLIGHT BETTER BUT STILL DANGEROUS. AFTER RESEARCHING WE FOUND THAT THIS IS A DEFECT AND THE ARE MANY COMPLAINTS. WE TOOK IT TO THE VW DEALER WHO CONFIRMED THIS IS AN ISSUE WITH THIS CAR AND THERE IS NOT MUCH WE CAN DO ABOUT IT BUT REPLACE THE ENTIRE LIGHTING SYSTEM WHICH WOULD BE VERY COSTLY. I AM WORRIED ABOUT MY TEENAGE DAUGHTER DRIVING THIS CAR AT NIGHT.

2006 VOLKSWAGEN PASSAT. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO EMERGENCY/ SIGNAL LIGHTS MALFUNCTION, SUNROOF PROBLEMS AND OTHER VEHICLE ISSUES. *SMD THE CONSUMER STATED THE VEHICLE INTERMITTENTLY FAILS TO RECOGNIZE THE ELECTRONIC KEY WHEN ATTEMPTING TO START THE VEHICLE. THE BLINKER/TURN SIGNALS FAIL TO TURN OFF WHEN PROMPTED. THE CONSUMER WAS ADVISED THAT THE SIGNALS WOULD NOT TURN OFF UNLESS THE STEERING WHEEL WAS TURNED COMPLETELY STRAIGHT. THE SUNROOF OPENS UNPROMPTED. THE DEALER AND MANUFACTURER COULD NOT DUPLICATE THE FAILURE. THE VEHICLE WAS ROTTED UNDERNEATH. THE EMERGENCY BRAKE LIGHTS FLASHED INCESSANTLY. *JS

DRIVING SOUTH ON THE 57 FREEWAY AT APPROXIMATELY 2:45 P.M. WITH MY GRANDDAUGHTER WHEN SUDDENLY FOR NO REASON THE SUNROOF POPPED OFF ONTO THE FREEWAY, WE DID NOT HAVE THE SUNROOF OPEN. WE ARE LUCKY IT DID HIT ANYONE AND CAUSE AN ACCIDENT. WE CALLED VOLKSWAGEN OF AMERICA & WAS TOLD TO TAKE CAR TO A VOLKSWAGEN DEALER, THE DEALER DETERMINED THAT IT WAS A MANUFACTURER DEFECT. SPOKE WITH [XXX] THE REGIONAL CARE MANAGER AND HE SAID THAT HE COULD ONLY OFFER $2000.00 TOWARDS A NEW CAR AND WOULD NOT OFFER ANYTHING TOWARDS A REPAIR. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ELECTRONIC EMERGENCY BRAKE FAULT; WAS DRIVING ON JANUARY 18,2014. MY DAUGHTER WAS DRIVING ABOUT 35 MPH WHEN THIS EMERGENCY BRAKE LIGHT STARTED FLASHING YELLOW. ALSO THERE WAS A RED BRAKE LIGHT THAT WAS FLASHING AND BEEPING THREE TIMES. SHE GOT THE CAR UNDER CONTROL MIND YOU SHE IS ONLY 17 AND SHE JUST BOUGHT THIS CAR FROM CAMPUS AUTO HERE IN FORT DODGE, IA ON THE 10TH AND HE TOLD HER NOTHING WAS WRONG WITH THE CAR. EVERYTHING HAS WENT WRONG WITH THIS CAR THAT CAN GO WRONG. SHE PULLED OVER AND READ IN HER MANUAL THAT WITH THE BEEPING 3 TIMES AND THE RED LIGHT INDICATOR SAID THAT SHE WAS SUPPOSE TO GET IT TO A TRUSTED MECHANIC RIGHT AWAY. SO SHE DID THE SMART THING AND CALLED ME TO HAVE THE CAR TAKEN TO A MECHANIC. BUT WHAT IF SHE WOULD HAVE BEEN ON THE HIGHWAY AND THIS WOULD HAVE HAPPENED. SHE WOULD HAVE LOST CONTROL OF THIS CAR ON A HIGHWAY. PLEASE LOOK INTO THESE PASSAT. THERE IS SOMETHING SERIOUSLY WRONG WITH THEM. WHEEL BEARINGS ARE BAD IN THE REAR. FUEL PUMP WENT BAD. COILS BURN. THESE ARE ALL DANGEROUS THINGS. PLEASE HELP. *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE STEERING COLUMN LOCKS UP ON HER VEHICLE AND PREVENTS IT FROM BEING DRIVEN. SHE ATTEMPTED TO START THE ENGINE AND AN INDICATOR ILLUMINATED, WHICH STATED THAT THE STEERING COLUMN WAS LOCKED. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE STEERING COLUMN WAS DEFECTIVE AND NEEDED A MODULE. THE REPAIR WOULD COST $1,300. THE FAILURE MILEAGE WAS 63,000. UPDATED 05/27/09 *BF UPDATED 06/08/09 *BF UPDATED 6/16/09 *NJ THE LEFT REAR CALIPER NEEDED TO BE REPLACED,THE CHECK ENGINE LIGHT ILLUMINATED, THE TRANSMISSION WAS MAKING A LOUD NOISE, THE TIRE PRESSURE LIGHT ILLUMINATED, THE LEFT TURN SIGNAL DID NOT WORK, THE LEFT WHEEL BEARING NEEDED TO BE REPLACED, THE HOOD RELEASE LEVER INSIDE THE VEHICLE WAS INOPERATIVE. UPDATED 06/17/09.*JB

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT AND SEAT BELT WARNING LIGHT WERE CONSTANTLY ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SEAT BELT ASSEMBLY, PISTON, AND SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS APPROXIMATELY 65,562....UPDATED 06/30/16 *BF THE CONSUMER STATED THE DRIVER SEAT BELT WAS FROZEN AND GIVING AN AIR BAG MALFUNCTION WARNING. UPDATED 07/13/16.*JB

BROKEN SEATBELT SENSOR CAUSES AIRBAG FAULT. I AM NOT SURE NOW IF AIRBAG WILL WORK. ONLINE SEARCH INDICATES MANY PEOPLE HAVE SAME PROBLEM. AIRBAG FAULT SHOULD BE COVERED BY RECALL BECAUSE SEATBELTS SHOULD NOT FAIL UNDER NORMAL USE AFTER 105000 MILES. *TR

CHECK ENGINE (MIL) LIGHT TURNED ON, CAR ALL OF A SUDDEN IDLES AT A HIGHER RPM WHILE WE WERE DRIVING!!! VEHICLE WAS TAKEN INTO THE DEALERSHIP. CAR IS ONLY UNDER WARRANTY FOR 36,000 MILES OR 3 YEARS! DEALERSHIP RAN DIAGNOSTIC, CAME UP WITH: CODE P0123 (THROTTLE HIGH INPUT), P0299 (TURBO UNDER BOOST), P0456 (EVAP LEAK), P1098 (INTAKE TURNING VALVE SHORT TO B+), CODE P2004 (INTAKE RUNNER STUCK), CODE P3237 (INTAKE RUNNER BASIC SETTINGS). DEALER RECOMMENDED INTAKE RUNNER MOTOR REPLACEMENT & REPLACEMENT OF TURBO & N80 VALVE, ALSO CV BOOT NEEDS REPLACEMENT. TOTAL COST OF REPAIRS OVER $1200!!! WE ALWAYS TAKE CARE OF OUR VEHICLES AND HAVE THEM SERVICED AT THE DEALERSHIP. VEHICLE HAS ALSO HAD DEFECTIVE INTERIOR PARTS. INTERIOR TRIM (ALL SWITCHES - LOCK, WINDOW & RADIO ARE BUBBLING AND CHIPPING). DOOR PANEL TRIM (RUBBER IS PEELING). SHIFT KNOB - METALLIC PIECE ON SHIFT KNOB, PEELED AND DUG INTO SKIN AND CAUSED INJURY. CARBON FIBER DASH IS PEELING APART. CONTACTED VW OF AMERICA, PER THEIR CUSTOMER SERVICE REP, THEY ARE UNABLE TO MAKE ANY REPAIRS DUE TO THE AGE AND MILEAGE OF THE VEHICLE. CAR IS A 2006 - 67,000 MILES. LESS THAN 5 YEARS OLD. I WOULD HAVE NEVER PURCHASED A VOLKSWAGEN HAD I KNOWN THEY WERE NOT RELIABLE VEHICLES. UNKNOWLEDGABLE SALES REPS, OR JUST AFTER CUSTOMERS TO MAKE A BUCK. SELLING PEOPLE UNRELIABLE VEHICLES AND VOLKSWAGEN CLEARLY DOES NOT TAKE CARE OF THEIR CUSTOMERS NOR DO THEY CARE ABOUT CUSTOMER LOYALTY OR SAFETY. *TR

THERE ARE SEVERE TOXIC ODOR'S (VOC'S) COMING FROM THE BOTTOM OF THE CARPET INSULATION OF THE INTERIOR IF THE CAR. IT IS SO POTENT THAT I HAVE SORE THROATS , HEADACHES AND FEEL LIGHT HEADED DURING AND AFTER I DRIVE THE 2006 VOLKSWAGEN PASSAT. THIS ODOR/VOC HAS ALMOST CAUSED ME TO FAINT DUE TO THE SEVERE ALLERGIC REACTION I HAVE TO IT. I HAVE TO HAVE ALL WINDOWS OPEN TO EVEN DRIVE THE AUTOMOBILE. AFTER SEARCHING THE INTERNET UNDER "VOLKSWAGEN CRAYON SMELL" THERE ARE HUNDREDS ARE SIMILAR COMPLAINTS ABOUT VOLKSWAGEN CARS WHERE THEY HAVE FOUND THE INTERIOR SOUND INSULATION MAT UNDER THE CARPER FLOOR TO BE THE CAUSE. I NEED MY CAR AND I CAN'T DRIVE IT LIKE THIS AS IT IS UNSAFE FOR MY HEALTH AND I FEAR THIS "CRAYON ODOR" COULD CAUSE ME TO HAVE A CAR ACCIDENT. I HAVE TRIED TO ENLIST VW AMERICA AND THEY STATE THEY ARE NOT AWARE OF THE ISSUE , HOWEVER, THERE ARE HUNDREDS, IF NOT THOUSAND COMPLAINTS THAT THEY HAVE RECEIVED FROM THIS TOXIC ODOR THAT IS COMING INTO THE PASSENGER CABIN OF THEIR CARS ESPECIALLY THE 2006 PASSAT. THIS TOXIC CRAYON ODOR IS PRESENT AT ALL TIMES , IT IS NOT DEPENDENT ON THE CAR RUNNING (BEING ON) WHAT SO EVER.. PLEASE HELP!!! *TR

20 AFTER I PURCHASED MY CAR AT CARMAX IN LAUREL, MD IN JUNE 2009 I HAD TO TAKE IT BACK BECAUSE MY AC WAS BLOWING HOT AIR, AFTER A DIAGNOSIS CARMAX SENT MY CAR TO A FITZGERALD VOLKSWAGEN DEALERSHIP IN ANNAPOLIS, MD WHERE THEY DIAGNOSED IT FOR THE SAME PROBLEM AND IN TURN HAD TO REPLACE MY AC COMPRESSOR, CONDENSOR AND CLUTCH. I RAN THE AC FOR APPROXIMATELY 2 MONTHS (JULY & AUG 2009) THAT YEAR, SINCE WE WERE ALREADY HALF WAY THROUGH THE SUMMER. IN MAY 2010 WHEN I TURNED MY AC ON AGAIN IT BLEW HOT AIR, I SENT IT BACK TO CARMAX WHO DIAGNOSED IT AGAIN AND SAID THE AC COMPRESSOR AND PRESSURE SWITCH SHOULD BE REPLACE, LESS THAN A YEAR SINCE THE INITIAL AC WAS REPLACED THE FIRST TIME. AT THIS POINT, I CALLED FITZGERALD AND WAS TOLD I WAS PAST MY 12,000 MILES PER THE REPLACEMENT WARRANTY AND THAT I WOULD HAVE TO PAY FOR THE WORK WHICH WAS QUOTED AT $2300 AND $1700. AFTER I COMPLAINED TO THE ATTORNEY GENERAL OFFICE, THE DEALER OFFERED A GOOD WILL ONE TIME OFFER DECREASING THE ESTIMATED COST TO $900. I DECLINED THE OFFER SINCE I DON'T BELIEVE I SHOULD HAVE TO PAY FOR SOMETHING THAT CLEARLY WAS NOT DONE CORRECTLY THE FIRST TIME. AFTER PURCHASING AN EXTENDED WARRANTY FOR ANOTHER ISSUE, I TOOK THE CAR BACK TO THE DEALER, THEY DIAGNOSED WITH THE SAME PROBLEM I AGREED TO HAVE THEM FIX IT BASED ON MY WARRANTY COVERAGE HOWEVER, I WAS DENIED COVERAGE BY THE WARRANTY COMPANY BECAUSE VOLKSWAGEN PREVIOUSLY ISSUED A TSB REGARDING AC ISSUES IN 2006 VW PASSAT. THIS TSB WAS ISSUED IN 2007, MY CAR WAS PURCHASED IN 2009. SO AS OF TODAY 7/20/2011 I AM STILL WITHOUT A WORKING AC SYSTEM AND I AM CURRENTLY DRIVING AROUND IN HEAT ADVISORY WEATHER WITH NO AC. I AM FORCED TO MAKE ALTERNATE ARRANGEMENTS FOR TRANSPORTATION AS A RESULT, SINCE THE EXCESSIVE HEAT EXPOSURE CAUSES ME HEADACHES & DIZZINESS. *KB

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE COMPRESSOR CREATED METAL PARTICLES THAT TRAVEL THROUGH THE AIR CONDITIONING SYSTEM CAUSING THE AIR CONDITIONER TO FAIL. THE DEALER ADVISED THE CONTACT THAT IN ORDER TO CORRECT THE COMPRESSOR DEFECT THE REPAIR REQUIRED THE REMOVAL OF THE ENTIRE AIR CONDITIONING UNIT. THE MANUFACTURER WAS CONTACTED AND A REPORT WAS FILED; HOWEVER, NO ASSISTANCE WAS OFFERED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 60,000.

2006 VOLKSWAGEN PASSAT. CONSUMER WRITES IN REGARDS TO DEFECTIVE VEHICLE TIRES. *SMD THE CONSUMER STATED THE VEHICLE WAS DRIVING ROUGH AND THE STEERING WAS VIBRATING DUE TO THE VEHICLE HAVING 3 BAD TIRES. THE CONSUMER RECEIVED 4 NEW TIRES. *JS

I AM A PHD COMPUTER SCIENTIST AND MY VW'S COMPUTER CONTROL MODULE SPONTANEOUSLY CHANGED ITS SETTING. A VW DEALER TECHNICIAN DOCUMENTED THE CHANGE, AND RESET THE PARAMETER TO FACTORY SETTINGS. I REPLACED ALL 4 TIRES ON MY CAR AT COSTCO. WHEN I STARTED MY CAR, THE "LOW TIRE PRESSURE" WARNING LIGHT LIT. I REPORTED THIS TO THE COSTCO EMPLOYEE WHO HAD DONE THE WORK. HE CHECKED THE FACTORY SETTINGS BY THE DRIVER'S DOOR, AND MADE SURE ALL TIRES WERE SET TO THAT PRESSURE, 35 LBS. THE WARNING LIGHT WENT ON EVERY TIME I DROVE. I SCHEDULED A REGULAR SERVICE APPOINTMENT WITH A VW DEALER. THE TECHNICAL FOUND THAT THE CONTROL UNIT'S SETTING HAD CHANGED TO 100101 FROM 100100. HE RESET THE PARAMETER, AND THE START-UP WARNING STOPPED. *TR