2006 Volkswagen Passat

In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.

The contact owned a 2006 Volkswagen Passat . The contact received notification of NHTSA Campaign Number: 24V834000 (Air Bags) and would like to be removed from the recall distribution list. The local dealer and manufacturer were not contacted.

NHTSA ID

11692301

Incident

Oct 9, 2025

recalled airbag

NHTSA ID

11671216

Incident

Apr 1, 2018

The contact owns a 2006 Volkswagen Passat. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to be restarted. The vehicle was taken to the dealer, where it was diagnosed and determined that the fuel pump module had failed and needed to be replaced. The vehicle was repaired. The contact later received notification of NHTSA Campaign Number: 17V509000 (Fuel System, Gasoline). The manufacturer was made aware of the failure to obtain assistance with reimbursement. The failure mileage was not available. Parts distribution disconnect.

NHTSA ID

11660470

Incident

May 12, 2025

The contact owns a 2006 Volkswagen Passat. The contact received notification of NHTSA Campaign Number: 24V834000 (Air Bags) and would like to be removed from the recall distribution list. The local dealer was contacted however, the manufacturer was not.

NHTSA ID

11631089

Incident

Dec 16, 2024

My family and I have been VW owners for over 60 years. Unfortunately, the 2006 VW Passat has been layered with defects, negligent manufacturing issues, faulty wiring, electrical problems, computer glitches, to mention a few. There have been many recalls including an official recall by the NHTSA, for steering linkage problems and tie rod assembly which caused a loss of steering, crashes and deaths. Over 292 complaints are filed with Consumer Affairs, over 561 defects reported, and thousands of horror stories like mine about this car. It's considered a lemon by many car professionals. Many dealerships in the USA offered to inspect, and replace the electronic steering column lock free of charge and address any other concerns, which should be standard, reasonable behavior for all VW dealerships, mandated by this Federal agency. Shortly after this car almost killed me in 2013, VW put me through countless stressful hours of calls, emails and the like and still refused to be fully accountable. Shortly after my almost end of life, the notorious VW Emissions Scandal spoke volumes. VW was well aware of their defects including the electrical system in the steering column/immobilizer, (the system won’t recognize the key; a module in the car that connects the key and starts the engine is defective). In many cases, the entire steering column is defective and has to be completely replaced because the car’s pistons, internal combustion and engine are all subpar. Even the Sunroof and drains are defective and every time it rains, there is a flood in my car which has caused life threatening mold and mildew. I am respectfully asking for your help in having VW provide me, a near [XXX] woman, a safe, reliable, car without another defective sunroof and without defective water drains. It can be used as long as it's reliable and without deadly mold and mildew. I have photos. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11577635

Incident

Jan 10, 2024

Transmission clunks into gear and loses traction while shifting.

NHTSA ID

11523759

Incident

Mar 1, 2023

The contact owns a 2006 Volkswagen Passat. The contact stated that while approaching an off ramp while driving approximately 45 MPH, the vehicle stalled. There were no warning lights illuminated. The vehicle was towed to the local dealer where an unknown diagnostic test and repair was completed. Additionally, the dealer fractured an unknown part underneath the hood and water entered the vehicle near the sun visor and there was water accumulating on the rear passenger’s side door location. The manufacturer was contacted. The failure mileage was approximately 45,000.

NHTSA ID

11514628

Incident

Jan 1, 2015

Mileage

45,000 mi

We owned vehicle approx 8yrs and in late 2022 will driving/on highway 55mph or local roads like Broadway 15-20mph the vehicle goes into neutral. VErY dangerous it wil work as it should after a restart

NHTSA ID

11500131

Incident

Jan 4, 2023

Update to Volkswagen engine oil standards

Volkswagen Engine oil quality standards, update to attachments.

Engine oil quality standards, update to attachments.

In conjunction with the New Mexico DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 363 Volkswagen owners in the State of New Mexico on March 13, 2023.

In conjunction with the Massachusetts DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 1,498 Volkswagen owners in the State of Massachusetts on March 13, 2023.

In conjunction with the Colorado DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 1,414 Volkswagen owners in the State of Colorado on February 13, 2023.