2013 Volkswagen Passat

In August 2015, VW launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clock spring. VW’s recall indicated that debris entry into the steering wheel hub can result in the contamination and ultimately failure of the clock spring in 2010-2014 MY CC, Eos, GTI, Golf, Jetta, Jetta Sportwagen, Passat, and Tiguan models. The contamination of the clock spring by debris, such as human hair, can cause the flat ribbon cable to tear. This results in the loss of the electrical connection to the front driver air bag and any steering wheel mounted controls. The clock spring is designed so that the flat cable inside will break with minimum force to prevent it from impeding movement of the steering wheel. The loss of the electrical connection to the front driver air bag results in the immediate illumination of the air bag warning light and prevents the deployment of the front driver air bag in a collision of sufficient severity. A torn clock spring also causes audible grinding noises from the area of the steering wheel/driver air bag or steering column while steering. The failure of the clock spring does not impair vehicle control or drivability (steering, brakes, acceleration). In November 2017, the Office of Defects Investigation (ODI) opened Recall Query RQ17009 after receiving complaints that alleged the failure of the clock spring in the subject models. While the majority of these complaints involved vehicles excluded from the original recall, several complaints involved vehicles that had received the remedy for Recall 15V-483. On April 18, 2018, ODI upgraded the investigation to Engineering Analysis EA18003 after receiving additional complaints concerning the recall remedy and scope of Recall 15V-483. During the investigation, VW identified certain 2015-2018 MY vehicles that share a common steering wheel clock spring with the vehicles covered under Recall 15V-483.  VW began using a different clock spring design starting with the 2019 MY Jetta. This new part is not compatible with previous model years due to the communication properties between the clock spring and the vehicle, including the air bag control module. In October 2018, VW released Warranty Extensions AWA-18-18 and VWP-18-11, which established a 15-year, unlimited mileage coverage for the Steering Wheel Clock Spring for vehicles included in the scope of Recall 15V-483. For certain 2010-2018 MY vehicles outside of the recall scope, a 10-year, 120,000-mile coverage was given. Vehicles repaired under these warranty extensions receive replacement clock springs at no charge to the consumer. In early 2023, VW updated AWA-18-18 (now AWA-23-01) and VWP-18-11 to upgrade certain vehicles and model years from the 10-year, 120,000-mile coverage to the 15-year, unlimited mileage coverage option. These warranty extensions cover vehicles with recall remedy failures as well as vehicles outside of the Recall 15V-483 scope that exhibited similar failures. In view of the circumstances, including the high detectability of the subject failure and warranty extensions issued by VW, ODI is closing this Engineering Analysis. NHTSA reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.

The vehicle was brought to Bill Jacobs Volkswagen in Naperville, IL to have three open, mandatory federal campaigns and emissions modifications completed. The dealership is actively practicing illegal 'recall steering' by holding the vehicle hostage. The service department refuses to perform the free federal campaigns unless the owner first authorizes between $2,500 and $3,000 in unrelated diagnostic and repair fees out of pocket. The dealership falsely claims that the vehicle must be 'brough to specification' at the owners expense before a federal safety or emissions campaign can be completed, which directly violates federal regulations prohibiting dealerships from conditioning or delaying mandatory factory campaign work based on customer-paid services. Furthermore, dealership staff ignored explicit, repeated verbal warnings regarding an active Adblue countdown, shut the vehicle off, bricked the car via a 'No-Start' lockout inside their active service lane, and are now refusing to release the vehicle or keys without unapproved fees. The active check engine lights on the vehicle are directly tied to the faulty emissions and NOx sensor components that the open campaigns are legally mandated to replace. Addition customer-pay repairs have been explicitly declined, and the dealer is refusing to execute the safety and emissions campaigns.

NHTSA ID

11772209

Incident

Oct 15, 2026

The contact owns a 2013 Volkswagen Passat. The contact received notification of NHTSA Campaign Number: 24V834000 (Air Bags). The contact called the three closest dealers but no assistance with transporting the vehicle or offering an alternative option for repair was provided. The manufacturer was also notified of the failure and refused to help. While requesting to speak with a manager, the contact was informed that a supervisor would provide the same response. The contact feared for her safety while driving the vehicle. The vehicle was not repaired.

NHTSA ID

11755868

Incident

Jun 1, 2026

Passenger side headlight went out. The problem was not the bulb or fuse. This issue seems to perfectly match Safety Recall 94G8, but for some reason my car is not covered in that recall notice, even though safety recall 94G8 is for "some" 2012-2013 VW Passats, which is what I drive.

NHTSA ID

11736609

Incident

May 3, 2026

My airbag light is on, steering wheel controls don’t work, and my horn doesn’t work. Safety is put at risk because the airbag won’t deploy if needed, won’t be able to think in case someone can’t see me.

NHTSA ID

11693057

Incident

Oct 13, 2025

The contact owns a 2013 Volkswagen Passat. The contact received notification of NHTSA Campaign Number: 24V834000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted several times. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11692331

Incident

Oct 9, 2025

My vehicle has an open Takata airbag recall with recall number 69E6. I have been placed on a waiting list at nearby dealerships for over 6 months. Each time I contact the dealerships, I am told to wait and call back in another month. No proactive communication has been provided and no remedy has been scheduled despite repeated follow-ups. The vehicle continues to display an airbag error light indicating an active safety hazard. The manufacturer has not provided a repair appointment, loaner vehicle, or any timeline for when the safety recall remedy will be available. This extended delay poses a serious risk given the known dangers of defective Takata airbags.

NHTSA ID

11691269

Incident

Sep 7, 2025

The contact owns a 2013 Volkswagen Passat. The contact stated while at a red light ,the vehicle intermittently stalled. No warning lights were illuminated. The failure had occurred on several occasions. The vehicle was taken to a dealer to be diagnosed; however, the cause of the failure was undetermined. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 100,000.

NHTSA ID

11690973

Incident

Jun 30, 2025

Mileage

100,000 mi

The contact owns a 2013 Volkswagen Passat. The contact stated that the vehicle was purchased in 2024 from a Used Car Dealer. The contact stated that the check engine warning light illuminated after the vehicle was driven off the dealer lot. The contact drove to the destination and restarted the vehicle and the message "Distressed Vehicle Start" was illuminated. The contact drove the vehicle back to the dealer and the vehicle was taken to an independent mechanic and the contact was advised that there was an issue with the engine. The dealer advised the contact that parts had been ordered and she would be contacted to bring the vehicle in for the repair. The contact was not contacted, and calls were not returned. The contact contacted the warranty company for assistance with the repair. The contact stated that the timing belt was replaced, the vehicle was repaired; however, the vehicle had developed other failures. The contact stated that the vehicle lost motive power and was shaking abnormally while shifting gear. The contact stated that the failure recurred with several unknown warning lights illuminated. The warranty company was contacted, and the contact was advised to take the vehicle to an authorized dealer for assistance. The vehicle was towed to a dealer; however, a full diagnostic test was not completed, and the vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 134,000.

NHTSA ID

11689520

Incident

Dec 27, 2024

Mileage

134,000 mi

Prevent Sporatic Misfire Faults.

Reprogramming Control Module process

Identifying and Mixing Volkswagen Engine Coolants

Engine missfire diagnostic aid

Adhesive to bond sensor to Radiator.

Safety Related Inquiry and Reporting