2010 Volkswagen Passat

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.

My 2010 Volkswagen CC became completely inoperable because of the active fuel pump control module recall (NHTSA 17V509). The vehicle stalled and nearly caused an accident. The check engine light came on just before I noticed a burning smell coming from the backseat of my car immediately after smelling that the car suddenly stalled out in the middle of a busy intersection and the engine would not start back up. I had to push it to a gas station parking lot across 3 lanes of traffic. I lifted up the backseat and found that the fuel control module was overheated and melting on top of the fuel pump so I carefully and properly disconnected it from the vehicle. The next day I had the vehicle towed to Lokey Volkswagen in Clearwater, FL. Today 3/14/2026 They did the recall repair and told me my vehicle is safe to drive. Today 3/14/2026 I drove the car 1 mile from the dealership when the exact same thing happened again the car stalled out, and I had to carefully maneuver to the shoulder of hwy us 19 s narrowly missing vehicles in the other lanes. The vehicle was then towed back to lokey Volkswagen. It is pretty clear that the issue was not resolved, and that this fuel control module failing may have affected other parts of the fuel system/wiring and or the fuel control module failed again. I have pictures of the fuel control module, and I gave the initial melted/failed fuel control module to the service department and they took it. The dealership service department is stating that this may be to do something other than the recall repair and that I may be liable for the diagnostic and towing charges. This is a very serious safety issue that almost cost me to get in accidents on the highway twice. I feel that they (Volkswagen) needs to be held responsible for rectification and to find out if there is a connection between this recall and the continuing failure of the vehicle to operate safely.

NHTSA ID

11724256

Incident

Mar 11, 2026

I purchased a used vehicle but have found out the oxygen sensor is feeding false error codes to the main OBC causing leaks into driver compartment causing engine to stall while auto in motion and most importantly causing steering wheel to lock, have spoken with VWoA but they have no direct influence with VW or dealerships even if a warranty issue because all parties are independent contractors and all they are able to do is try and help. My name has not been transferred to registration because of smog requirements so you may call me [XXX] my telephone number is [XXX] my case# with VWoA is [XXX], I myself have learned to deal with defects but should this matter be more widespread which I cannot find out because the last case regarding the sensors was sealed in an agreement made by the California ARB, EPA and VW and Audi through a settlement signed in December 2021. Once again my hands are tied from taking much more action but I believe your department whether is able to enforce this matter or not should at least investigate and issue warnings to advise people of what can happen so if they can even at own cost seek appropriate repairs before more damages accrued. Also if this sensor is effecting more models and manufacturers an appropriate temporary fix should be seeker since no long term solutions are available at this time INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11621633

Incident

Oct 13, 2024

The contact owns a 2010 Volkswagen Passat. The contact stated while driving at various speeds, there was a strong fuel odor inside and outside the vehicle. The contact stated that the failure persisted while the vehicle was parked and turned off. The check engine warning light was illuminated. The contact stated that the strong fuel odor had caused her to have headaches while driving. The vehicle was taken to an independent mechanic, where it was diagnosed that the fuel pump module had failed, causing the fuel pump to leak. Additionally, the contact stated that the vehicle had failed to start and was undrivable. The dealer was notified of the failure and advised the contact to bring the vehicle to their location for the repairs. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist because NHTSA Campaign Number: 17V509000 (Fuel System, Gasoline) had already been completed on the vehicle. The failure mileage was approximately 148,000.

NHTSA ID

11579270

Incident

Feb 25, 2024

Mileage

148,000 mi

The contact owns a 2010 Volkswagen Passat. The contact stated that while her son was driving at an undisclosed speed, the vehicle inadvertently lost motive power. The driver was able to coast to the shoulder of the roadway, where the vehicle was able to be restarted. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the thermostat. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 17V509000 (Fuel System, Gasoline) but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 61,000.

NHTSA ID

11567604

Incident

Jan 19, 2024

Mileage

61,000 mi

Replaced cracked fuel pump 3 times. Electrical problem to fuel pump ; also all were cracked from pressure. Thx !! Dr.

NHTSA ID

11535981

Incident

Jul 13, 2022

As the trunk hatch opens and closes, the wiring to the hatch wears down, frays, and then shorts or breaks. This killed our rear view camera, which is a safety issue. This also can cut off light to the license plate. The rear hatch also cannot then be opened from the rear of the car, as the handle is electrical and gets disconnected, possible causing another safety issue.

NHTSA ID

11535909

Incident

Aug 1, 2023

Drove the car to and from work that day with no problems. Also, went back to work a 2nd side job that evening with no issues. Got home, shut the car off and when my wife and I went out to go to work the next morning at 5 a.m., the car wouldn't start at all. Wouldn't even click. Did a lot of research because I had the starter replaced about 2 weeks before and knew it couldn't be the starter and also had bought a new battery when I had the starter replaced as well, so knew it wouldn't be the battery. After a lot, I mean a lot of research online, finally came to the decision it was the timing chain tensioner was faulty. When I went to replace the tensioner for the timing chain, I took my camera and put it in the cylinder heads and found out that there was 2 broken valves in the number 3 piston. One was broken and sideways in the piston and the other just broken. I'm not sure whether a rod has gone through the bottom of the head or not, couldn't get my camera to go that far down. So now I have no vehicle what-so-ever to drive back and forth to work. My wife had to resign from her job because she had no way to get there everyday and I have to pay someone gas money weekly to pick me up and bring me home from work so needless to say, we are currently struggling, can't pay our bills because my wife cannot get a job and now I have to figure out how to repair this damage that should have been made a recall for these volkswagens because by the looks of things, there are over 100 people that have had this same problem. An engine is going to be between $4,000 and $6,000 to repair and I have no way to fix this at that price. So now I am probably going to have to just junk the car.

NHTSA ID

11534164

Incident

Mar 17, 2022

I was in my car driving , as soon as I go for a turn my car stalled on me infront of everyone , almost causing a wreck.

NHTSA ID

11503514

Incident

Jan 18, 2023

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Lubricating engine components before reassembly.

Instruction, how to lubicate engine before initial start.

Inquiries

Volkswagen Engine Oil Standards