Owner-reported complaints naming the engine system, filed with NHTSA
Data refreshed
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components. Every record below is an owner-reported complaint about the 2023 Volkswagen Taos submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 42 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 42, in the owner's own words
head gasket well known issue with no campaign or warranty coverage Volkswagen issued an official TSB 15-23-01 (Head Gasket Leakage) acknowledging that the original factory head gasket design on early Taos models allows coolant to leak. The production line was eventually updated with a redesigned gasket. They denied coverage or even partial reduction in labor.
On April 27, 2025, in [XXX] , the vehicle displayed a low coolant warning in the morning. The owner replenished the coolant as instructed, the warning cleared, and the vehicle was driven to work without incident. Later that day, while traveling southbound on [XXX] at approximately 60 mph, the engine overheat warning activated, forcing the driver to stop and pull over. The vehicle required two separate tows — first to the residence, then to the dealership the following day. On April 30, 2025, the dealership completed a full warranty repair replacing the engine head gasket and seals under TSB 2071245/1, a Volkswagen-issued Technical Service Bulletin acknowledging a known manufacturing defect in the 2022–2023 Taos cooling system, for which there is no recall issued. A formal case was opened with VW Customer Care prior to the repair visit and is on record. This incident occurred just before the vehicle’s warranty expiration at 30,000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
This vehicle has a known design flaw which causes the cylinder gasket to leak and require replacement. VW has only issued a Technical Service Notice which was no provided to owners regarding the part that needed replacement. They are correcting the problem with a differently designed part in order to try to cure the design flaw. This can cause catastrophic engine failure. It should have been a recall. I should have been notified and the car should have been repaired at VW’s expense. They have explained since your agency didn’t issue a recall, they dot need to inform the public. Now they are expecting me to pay $3000 to correct their design error and also pay for rental car while it is under repair. This is a major violation of the lemon law, and yet there are numerous verified complaints. Issue a recall on the 2023 Taos, they are clearly scamming owners and leaving them in danger with a vehicle that has a faulty engine part. Owners like me, should have their car repaired by the responsible party, VW
Cylinder head gaskets) replaced - Cylinder head serviced/repaired - Timing belt replaced
Started driving, engine light comes on and it shows error code “start/stop error” Car won’t go past 30pmh.
I took the vehicle in to the VW dealership for service on 06/30/25 and they found that the head gasket had failed after only 26500 miles. A failed head gasket could lead to engine failure during operation which would create a significant safety issue.
I was told there was a leak in my coolant system that has happened to many other with the 22 and 23 taos. If out of warranty the claim would be almost 5k even though my car is only 2 years old. The work needed to be done is labor intensive and also a issues with the cylinder head gasket.
head gasket is leaking - dealer won't acknowlege the problem - coolant leaking into oil- low coolant light comes on
Head gasket failure, car loses combustion, u safe to drive. Engine light has been on for 5 months so far. Dealer has not been able to fix it.
The vehicle begins to feel like it is skipping while driving. The EPC light comes on, the dashboard beeps and indicates lane assist is unavailable, check engine sign illuminates. The vehicle will drive for a short time but then jerks and just stops. This has happened at least 3 times. Dealer has already replaced the fuel pump, electrical wiring and some switch that wasn't readying properly. After the fuel pump was replaced, the tank was filled, continue to track down miles and gallons. When the vehicle got to 135 travel miles left and one notch above the gas tank, it jerked and stopped immediately at an unsafe spot on the road. The sensor was not properly reading the gas and the tank was empty! This last incident was the same evening after an inspection and 60K service. This vehicle is unsafe and VW should be making this right. Warranty has expired and now they want to charge me for the same issue. This has been going on for months and I believe the vehicle is unsafe and is putting me in danger of having or creating a bad accident.
2023 Taos SE shuts off completely at red lights/when I’m stopped more than 60 seconds. It prompts me to shift into park, put the key to steering column and restart, then shift back into drive and go. Dealer scanned it on two separate occasions and has no explanation. Couldn’t reproduce. Very dangerous as increases risk of crashes and rear ended when a car needs to be restarted mid roadway. The 2022 model had a recall for this exact stalling issue and they claimed to have fixed it but doesn’t appear so. Last occurred to me 9/6/2025 around 7:13pm.
2023 VW Taos leased in June 2023 - needed to replace brakes 2 years (June 2025) into owning the car. Inspection would not pass without them. This is an excessively quick wear that cost me over $600 for a leased vehicle that should be just basic ownership during 3 year lease. August 2025 - Brought in for an oil change and a coolant yellow light on dashboard. Our local mechanic would not touch the coolant issue as he said it seems to be related to a head gasket leak. The 2022 model had many issues with this problem, however no issues are reported on the 2023 Taos. I have had to find another vehicle to drive and wait 5 days to get it into our local VW dealership, who told us it was OK to drive without even looking at the vehicle. No thank you! We called VW and if in fact this is a head gasket, it would be covered under warranty. These are each pretty serious safety concerns and needs to be reported for future owners of this vehicle. Not interested in another VW after these incidents. We are a first time leaser of them - thank goodness it wasn't a purchase.
The contact owns a 2023 Volkswagen Taos. The contact stated that while operating the vehicle, the check engine warning light illuminated. The vehicle was taken to the local dealer, who diagnosed that there was coolant intrusion into the head gasket. The head gasket was replaced, and the vehicle was repaired. Later, while driving 55 MPH, the message "Transmission Failure" was displayed and the transmission shifted to D2, causing the vehicle to decelerate to 25 MPH. The vehicle was parked, and after restarting the vehicle, the vehicle operated normally. The vehicle was later taken to the local dealer, who diagnosed that the Medtronic transmission had failed and needed to be replaced; however, parts were on back order. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 10,185.
The contact owns a 2023 Volkswagen Taos. The contact stated while driving 45 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The ETC (Electronic Throttle Control) warning light illuminated. In addition, the engine revved independently. The vehicle was taken to the dealer where it was diagnosed that the cam shaft timing had failed. The timing belt and cam magnet were replaced. The contact stated that on a separate occasion, while driving 45 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal and the engine revved independently. The ETC warning light illuminated. The vehicle was taken back to the dealer and was diagnosed that the cam shaft sensor had failed. The vehicle was repaired. The contact stated that recently the vehicle failed to accelerate as intended while depressing the accelerator pedal. The vehicle was taken back to the dealer to be diagnosed and the contact was informed that the air hose had failed. The vehicle was repaired. The contact stated that several unknown warning lights were illuminated intermittently. The manufacturer was not made aware of the failure. The failure mileage was approximately 11,000.
unknown head gasket, went out at 22,000 miles Low coolant light High engine temperatures Overheating Empty coolant reservoir Smell of coolant Coolant residue on the engine block Most of the head gasket failures also occurred at relatively low miles.
Car only has 16,000 miles on it. Started smelling antifreeze when the car was started. Took to dealer- faulty, failing head gasket. Bad since manufactured. Also, brakes had sounded loud since purchased. Told this was just the type of brakes. Upon inspection of the vehicle for the head gasket it was noted that the rear brake pads need replaced!! Again, this car only has 16,000 miles on it. From research it appears the head gasket and rear brakes are an issue for the 2023 Taos. Dealer/shop has had the car for 6 days and I was told if I needed a loaner it would now cost me $ out of pocket....for a manufactured failure.
Accelerating Transmission Shifting When accelerating from a full stop, using same force of pressure on foot to accelerate the vehicles behaves differently every time. Vehicle will rev and have a 1-3 second delay to move the wheels/tires, or have no delay. There is no common variable to know how the vehicle will accelerate from stop to stop. Have tried to narrow down anything unique to identify when this happens but it is sporadic and unknowing how the vehicle will behave. Specifically, have noted if the occurrences are unique to: Slope or incline, humid weather versus dry, fuel type (have always used same), cold temperatures versus warmer or cool, or any unique non-ordinary operating conditions. Safety risk- anytime vehicle is supposed to accelerate. Daily safety risks- We enter a roundabout and attempt to accelerate, and vehicle hesitates for 3 seconds causing us to not enter or risk hitting vehicle oncoming. Vehicle behind attempts ot accelerate as well usually resulting in. honking at us- daily. Left hand turn. Apply pressure to accelerator, and cannot make turn or get hit by oncoming vehicle. Parking lot. Accelerate over speedbump, vehicle lags/rev's, and then rapid acceleration causes vehicle to jolt almost hitting people/animals. Window will go up when switch is in position to lower and vice versa. Issue from day one. Our dog was in vehicle. Window down about 4 inches. At intersection. Went to accelerate which hesitated while holding switch to lower window, and window went up with our dogs nose still between car interior and exterior. Focus was on driving if we could make through intersection and could only imagine if we had a child with their hand out. The above is noted when vehicle has been in for service. Vehicle is currently at dealer and we will not accept vehicle until Volkswagen identifies issues. Known issues with this year and model AWD model.
3 times in the past year including today, the car has completely turned off while in drive at a red light or stop sign. It is not the auto start/stop, it simply completely shuts off the car and when I take my foot off the break the car says “shift gear into park and manually restart car” this has almost caused an accident every time and is a safety issue. I reported to dealer, they’ve heard of this before but can’t replicate or find issue. It is not safe for the cars engine to shut off while in drive and have to stop in the middle of road and shift gears and manually restart car. Major safety issue
Hazard warning light came on for low coolant on 1/18/2025. Almost empty of coolant. Bought VW coolant and filled. Brought in to dealer I bought the car from, told it was the head gasket leaking (after $170 charge). Quoted me an estimate of almost $4000. Told me it was not under warranty- my car has a little over 56,000. Warranty ends at 50,000. Dealer told me this is a known issue.
12,000 mile VW Taos coolent light went off. Faulty Engine coolant gasket failed. Took it into the dealership they also needed to replace the back brakes! Entertainment/radio screen randomly goes off as well. This is the second time it's been taken in because of an issue. Will not bee keeping this car.
While driving Dec 10, 2024 my VW Taos failed to accelerate after slowing at an intersection. If this happens when I’m turning, on coming traffic has to slow down unexpectedly. The EPC light and check engine light came on. Car would not go above 15-20 mph. Called dealer and cautiously drove car to dealer. The mechanic said a popped fuse was reason the lights came on and car wouldn’t accelerate. They replaced 10A fuse and said codes/lights corrected. Now on 12/23/24 same exact issue has occurred. This is a huge safety concern. Taos 2022 models had a safety recall for a fuel delivery module that was causing that exact same issues and EPC and check engine light to come on. I am waiting for the dealer to call me back now to discuss how serious this really is and to get them to acknowledge they didn’t truly diagnose the vehicle the first time (given the 2022 Taos safety recall). Please investigate, I believe the 2023 models have the exact same problem. Not being able to accelerate is dangerous in multiple scenarios.
Vehicle displayed instances of overheating but was told by dealership it wasn't a big issue and the vehicle was safe to drive. I took the vehicle to the dealership for scheduled maintenance and when I returned to pick up the vehicle I was told that coolant was leaking into the oil and the head gasket was defective. The service desk representative stated the head gasket is a known issue in the 2022-23 models. The engine will need to be taken out of the vehicle, taken apart, and a new gasket installed. I was also told this issue would most likely happen again due to the design of the gasket. Parts are on order and the dealership has the vehicle as it's not safe to drive prior to repairs being made.
Haven’t owned the vehicle for 2 years and I’ve already had to have brake lines replaced, windshield and now the head gasket has crapped out. Which apparently is a huge issue with this vehicle. It’s really the worst buy I’ve ever made. Trade in value, at just 2 years old, is only 19,000…when I paid 30….it’s really awful. Now I have to wait for, God only knows how long, because the parts are on back order, to have it fixed! Volkswagen has ruined me for ever loving their name.
On August 4th, 2024 Volkswagen Taos coolant reservoir at 17,348 miles was nearly empty. Went to closest dealership, which could not set appointment to look at until October 21. Every couple hundred of miles, I have had to refill the coolant level. The VW Taos was finally able to be diagnosed with a head gasket failure on October 21, 2024 with 22,359 miles. The parts and fix are a couple of months out, with no current ETA. Was given back vehicle to drive in the meantime. This is a major safety issue, as the gasket could completely fail at any time. This is also causing premature wear on the engine, as coolant will be leaking into the oil. The manufacture, Volkswagen, was contacted and unable to offer any assistance and told to keep driving in the meantime, since the dealer gave me back the vehicle.
a low coolant light went on . Brought car in and head gasket and rear brake pads need to be replaced. the car has 16000 miles on it. This is unacceptable. !!!!!!!!!!!! I would like to know if the car will be replaced with the same faulty brake pads and the same faulty head gasket. These are know issues so why hasn't VW fixed both these parts and why would I want to same ones in my car that are known to be faulty.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .