2010 Volkswagen Tiguan Problems

Vehicle sometimes displays red check engine light on dash with alarm sounding. Check engine light goes away after the vehicle is stopped briefly and restarted. Oil level is normal. Mechanic found no diagnostic codes when scanned with OBD scanner. Mechanic changed oil pressure sensor, replaced oil, checked oil pan. There is no leaking. But the check engine light still comes on with alarm. It does not seem to be related to miles driven, speed driven, road conditions, or external temperature. Consumer is afraid to drive the car, or sell car. Mileage is 61,000, one owner.

Timing chain/extensioner broke My car suddenly started jerking or jumping when I was idling. I pulled into a parking lot and ended up having to have it towed. It does not run now and I was told it needed a new engine. I was told that there was a known issue and class action lawsuit with the timing chain but that I had passed the extended warranty. My care only has 50,000 miles on it so a timing chain should not fail so soon. I am sure that there extended warranty left a lot of engine failures out.

The fusebox that was included in the NHTSA recall #13V569000 for lighting defects was never resolved correctly on this car and many other VW Tiquans like this. I am a 45 year ASE licensed professional automotive technician. I am an ASE Master tech with current L1-L9 licensing. I am also an ex GM mastertech as well. Part time automotive instructor too. I've seen the multiple cases filed with the NHTSA regarding this melting fuse box that causes multiple issues whether they be with lighting, causes the engine & whole electrical system to shut down, same with several computers. I've scanned the system using VAG-COM and have two different sets of scan data to show clearly the issue. The car will load a multitude of erroneous codes because the central electrical, ABS, engine computer & other modules lose power causing a VERY dangerous situation for the operator of the vehicle. Not to mention a fire danger. I have pictures of the before and after repair I did on this vehicle. It still needs the fuse box replaced. I replaced the melted #6 wire that attaches to the fuse box (VW part# 1K0 937 125D) which was included in the original NHTSA recall I mentioned at the beginning of this essay. The vehicle & component is available for inspection at any time. This vehicle stalled & left my wife & kids stranded several times making it incredibly unsafe to drive. The car has been ok now for 2 weeks after my temporary repair. Prior NHTSA complaints from other owners with similar issues were 10551509, 10552308, 10553122, 10553811, & 10776567.

POWERSTEERING FAILS INTERMITTENTLY, STEERING WHEEL WOBBLES WITHOUT USER INTERVENTION OCCASIONALLY (AT RED LIGHT). ISSUE SEEMS RELEASED TO ELECTRICAL POWER STEERING RACK OR CONTROL BOX, BUT VW DOES NOT SEEM TO ACKNOWLEDGE THIS IS A FREQUENTLY REPORTED PROBLEM. WHEN DOES IT HAPPEN: 1. AFTER PARKING CAR, POWER STEERING IS COMPLETELY OFF, SLOWLY DRIVING FOR 20-30 SEC SO FAR BROUGHT IT BACK. HOWEVER, STEERING IS NOT ACCURATE (SOMETIMES VERY LIGHT AND WOBBLE STARTS). AFTER OVERNIGHT PARKING THINGS SEEM FINE 2. ON HIGHWAY, AFTER 20 MINS DRIVE STEERING BECAME RATHER ERRATIC WITH DIFFICULTIES TO KEEP CAR ON THE LANE, AFTER EXIT AND STOP ENGINE AND RESTART THINGS WERE FINE AGAIN. HAPPENED SEVERAL TIMES. CAN SEND VIDEO SHOWING WOBBLING OF STEERING WHEEL...

I DROVE TO A FRIENDS HOUSE AND ABOUT TWO HOURS LATER GOT IN THE CAR AND STARTED TO DRIVE THEN 10 OF MY EXTERIOR LIGHTS ALL WENT OUT THE SAME TIME. MY FOOTWELL LIGHTS I CANNOT DIM OR BRIGHTEN THROUGH THE CONTROLS AND BACK UP SENSOR STOPPED WORKING. I HAD NO HEADLIGHTS WHILE I WAS DRIVING AT NIGHT AT AROUND 11PM. ALL THIS HAPPENED AT ONCE AT THE SAME TIME. ALL OF THE BULBS WERE FINE. I REPLACED THEM. THEY WEREN'T EVEN BLOWN. FUSES WERE FINE. THIS IS A REAL SAFETY HAZARD AND CAN LEAD TO CRASH IF NOT LOOKED INTO.

I HAVE BEEN HAVING THIS TRUCK FOR 13 MONTHS NOW I HAVE MORE THAN 20 PAYMENTS STILL TO MAKE ON THIS TRUCK EVERY TIME IT RAINS THE TRUCK GETS FILLED WITH WATER IN THE PASSENGER SIDE FILLS MORE THAN 5 GALLONS OF WATER DEPENDING ON HOW BAD IT RAINS MY HEATED SEATS DON'T WORK AM ASSUMING IT'S DUE TO THE WATER DAMAGE AND MY BACK LIGHTS CONTINUE TO BLOW OUT I AM ACTUALLY FIGHTING A TICKET DUE TO THIS MATTER THERE IS WATER DAMAGE ON TOP OF THE ROOF TOP AND FEEL I GOT RIP OFF WITH THIS JUNK

We own a 2010 VW Tiguan and it has many problems, but the biggest one is that the Steering Wheel just randomly will turn off and loose all power steering, I believe these models use electric power steering (EPS) system, which don't use like a traditional power steering hydraulic pump but uses electricity and maybe magnets... to induce the steering. the steering wheel is a big deal and should not just randomly stop working and there is tons of these models and others have have this problems, I seen people on youtube have the same problem with the 2017 models Tiguan and this part is consistently out of stock, because so many of them break.. this should be a nationwide recall and a major safety recall as well.

The contact owns a 2010 Volkswagen Tiguan. The contact stated while driving approximately 65 MPH, the vehicle lost power steering functionality. The contact stated that the forward momentum allowed her to pull off the roadway. The contact stated that the steering wheel started shaking violently. The contact stated an unknown red warning light was illuminated. The vehicle was turned off and restarted and the power steering functionality returned. The contact stated that the failure was intermittent, however the failure had reoccurred several times. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that the power steering assist, and rack and pinion gear needed to be replaced. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was 125,068.

PURCHASED OCTOBER 2017 AND IN JANUARY STARTED TO HEAR RATTLING SOUNDS. TOOK BACK TO SUBARU SERVICE WHERE PURCHASED AND THEY DID NOT FIND ANYTHING WRONG WITH VEHICLE. IN JUNE 2018 CAR STARTED TO SPUTTER AND MAKE SOUNDS WHILE DRIVING AND WOULD NOT ADJUST RPMS WHEN DRIVING. COULD NOT GO FASTER WHEN STEPPING ON THE GAS PEDAL ON THE HIGHWAY. THREE DAYS LATER, CAR WOULD START BUT WOULD NOT GO INTO GEAR AND HAD TO BE TOWED FROM A RESTAURANT PARKING LOT. MECHANIC GAVE AN ESTIMATE OF OVER $6,000 BECAUSE TIMING CHAIN BROKE AND ENGINE FAILED. ENGINE LIGHT HAD NOT GONE ON BEFORE THAT INCIDENT. POSSIBLE DEFECT BY VOLKSWAGEN WHEN LEARNING ABOUT CLASS ACTION LAWSUIT AND MY CAR IS SAME YEAR MAKE AND MODEL OF ONES IN LAWSUIT.

DEALERSHIP INFORMED US TIMING CHAIN NEEDED TO BE REPLACED AND MANIFOLD WOULD BE REPLACED UNDER WARRANTY. AFTER REPLACING TIMING CHAIN, THEY NOTIFIED US MANIFOLD WAS ALREADY REPLACED ON VEHICLE AND IT ALSO NEEDED NEW VALVES DUE TO BEING BENT FROM BAD TIMING CHAIN. MANY OTHER VW OWNERS HAVE EXPERIENCED TIMING CHAIN ISSUES. THESE ISSUES STARTED WHILE THE VEHICLE WAS IN MOTION AND WHILE DRIVING LED TO EXTREME SHAKING AND NOISE AT LOW SPEEDS. VEHICLE FELT VERY UNSAFE TO DRIVE AND WAS PROMPTLY TAKEN TO DEALER.

THIS MODEL HAS A PUSH TO ACTIVATE EMERGENCY BRAKE. THE EMERGENCY BRAKE WILL ENGAGE WITHOUT TOUCHING IT WHENEVER IT WANTS. IT HAS HAPPENED A FEW TIMES WHILE I WAS GOING IN REVERSE WITH NO NOTICE NOR DOES THE LIGHT INDICATOR GO ON. I HAVE TOOK IT TO MOHEGAN VW DEALER AND THEY DID FIND ANY PROBLEM WITH THE VEHICLE . I TRIED TO EXPLAIN TO THEM THAT IT ENGAGES AT ANY GIVEN TIME BUT THEY INFORMED ME THAT WITHOUT A BRAKE INDICATOR ON THERE WAS NOTHING THEY CAN DO. I NEED HELP WITH THIS ISSUE BEFORE IT ENGAGES WHILE I'M DRIVING AND KILLS ME OR ANYONE ON THE ROAD.

WAS WAITING AT A RED LIGHT, ON AN INCLINE, CAR STOPPED, WITH MULTIPLE CARS AHEAD. KNEW I WOULD BE WAITING FOR A WHILE FOR THE LIGHT TO CHANGE, SO GENTLY RELEASED SOME PRESSURE ON THE BRAKE. CAR LUNGED FORWARD HITTING CAR AHEAD OF ME AND EACH TIME I DEPRESSED THE BRAKE THE CAR LUNGED, HITTING THE CAR IN FRONT OF ME THREE TIMES. STOPPED THE FRIGHTENING ORDEAL BY DEPRESSING THE BRAKE AND TURNING OFF THE IGNITION. CAUSED NECK AND BACK INJURY, (REPORTED BY THE INJURED, BUT NOT CONFIRMED) OF SHERYL BROWN, DRIVER OF CAR I HIT. GOOGLED SEARCHED THIS PROBLEM AND APPARENTLY OTHERS HAVE REPORTED LUNGING AFTER BRAKING IN BOTH TIGUAN AND TOUREG.

BACKGROUND: 2015 (70,733 MI), ENGINE LIGHT WENT ON & I BROUGHT IT TO VWHARTFORD. THEY FOUND FAULT FOR SYSTEM TO LEAN FOUND REAR MAIN SELA IS LEAKING OIL WHICH IS CAUSING FUEL TRIM FAULTS. OIL CAP IS LEAKING OIL & THE UPPER TIME CHAIN COVER IS LEAKING OIL BUT THE MAIN OIL LEAK IS COMING FROM THE REAR SEAL. THEY REMOVED THE TRANS & REPLACED THE MAIN SEAL & OIL CAP ($877). IN 2016 (94,999 MI), CAR FAILED EMISSIONS DUE TO INTAKE MANIFOLD. VW REPLACED THIS AND IT WAS COVERED UNDER WARRANTY. SUGGESTION - TO GET A CARBON CLEANING FOR THE VALVES DUE TO BUILD UP ($290). JUNE '18 (118,239 MI): MY COOLANT LIGHT WENT ON. VW SAID MY COOLANT WAS NOT LOW - WATER PUMP WAS LEAKING. THEY RESEALED VALVE COVER & UPPER TIMING CHAIN DUE TO OIL LEAKS. THEY R AND R VALVE COVER CLEANING & RESEALED, INSTALLED UPPER TIMING CHAIN SEALS AND SIDE OF ENGINE BLOCK OF OIL & INSTALLED NEW WATER PUMP. I ASKED IF THIS WAS COVERED UNDER THE WARRANTY OR PREVIOUS WORK & WAS TOLD NO. I ASKED IF THIS WOULD PROLONG THE LONGEVITY & WAS TOLD YES ($1800). 8/19/19 (133,449 MI): ENGINE LIGHT WAS ON - COULD NOT LOOK AT FOR A COUPLE DAYS, BUT OK TO DRIVE AS LONG AS THE ENGINE LIGHT WAS NOT BLINKING. RESULT: SYSTEM LEAN AT IDLE, BREATHER IS LEAKING AIR CAUSING HESITATION. THEY INSTALLED NEW BREATHER. ASKED IF IT WAS COVERED THEY SAID NO. ASKED IF IT WOULD IMPROVE THE LONGEVITY OF MY CAR, I WAS TOLD YES ($480). ISSUE 9/4/19: ENGINE LIGHT WENT ON. THIS WAS AFTER TRAVELING FOR LABOR DAY (360 MILES). ON MAIN ST. IN WHART, THE CAR STARTED TO SHAKE & BOUNCE AT 2 STOP LIGHTS. WENT 2 BLOCKS HOME. TOWED IT - WAS TOLD TIMING CHAIN WENT & IT'S NOT COVERED UNDER THE TC RECALL. QUOTE - USED ENGINE $6500+. TOLD IT WAS WORTHLESS & NOT WORTH FIXING ($125 FOR DIAG) TOWED THE CAR TO ANOTHER PLACE - THEY FIXED IT FOR LESS THAN $3400. I HAVE TOLD VW AND VWHART THAT THERE IS SOMETHING WRONG WITH THIS MAKE/MODEL, BUT I AM IGNORED.

LEAKAGE OF FLUID AROUND TRANSFER CASE NECESSITATING REPLACEMENT . MILEAGE ONLY 43000

While driving down the road the steering wheel began to wobble and shake really bad and the power steering light came on and then power steering locked up, I was barely able to get out of the way of oncoming traffic which was very difficult for me because I have Lupus and not very much strength in my arms. Had to turn car off and restart several times before getting the light to stay off long enough to get home but it was still wobbling, this was a very scary situation for me.

TL-CONTACT OWNS A 2010 VOLKSWAGON RUATUAN ----VEHICLE DOES HAVE RECALL BUT CONTACT STATED VOLKSWAGON STATED VIN NUMBER IS NOT INCLUDED IN RECALL... CONTACT CALLED DEALERSHIP AND DEALERSHIP STATED EVEN THOUGH VEHICLE HAS SAME PROBLEMS THERE IS NOTHING THEY CAN DO ... ENGINE TURNS OFF WITH KEY IN IGNITION AND IGNITION BECOMES LOOSE KEY TURNS TO OFF POSITION AND CAR SHUTS OFF WHILE DRIVING..CONTACT GIVEN NUMBER TO VOLKSWAGON. CB .0RECALLSASSOCIATED WITH THIS VIN

EARLY MONDAY MORNING ON 12/17/18 WHILE DRIVING FROM ORLANDO,FL TO CLEARWATER,FL ON A MAJOR HIGHWAY MY WIFE HAD TURNED ON THE PASSENGER SEAT HEATER. NOTHING WAS OUT OF THE ORDINARY UNTIL WE SMELLED SOMETHING BURNING, THINKING IT WAS PROBABLY COMING FROM THE OUTSIDE. THE SMELL DIDN'T GO AWAY SO WE TURNED OFF THE A/C AND BOTH DRIVER AND PASSENGER SEAT HEATER UNTIL THE SMELL OF SMOKE WHEN AWAY. WE LEFT THE SEAT HEATERS OFF AND LEFT ON THE AC. WHEN WE GOT HOME WE STILL DIDN'T NOTICE ANYTHING UNTIL LATER ON IN THE MORNING WHEN MY SWEATER HAD A BLACK BURN MARK. I WENT OUT TO THE CAR AND NOTICED THAT THE PASSENGER SEAT HAD A BURN HOLE CLOSE TO THE BACK. WHEN I TURNED ON THE CAR AND TURNED THE PASSENGER SEAT HEATER ON I NOTICED SMOKE COMING UP AND THEN A SPARK AS IF IT WHERE A LIGHTER.

MY HUSBAND WAS DRIVING MY VEHICLE AND I SAT IN THE PASSENGER SEAT TURNED ON THE HEATED SEATING AND AFTER ABOUT 2 MIN I STARTED TO SMELL PLASTIC BURNING MY LEG WAS BURNING AND WE SEEN SMOKE IN THE CAR AND PULLED OVER. WHEN I GOT OUT THE CAR MY SEAT HAD A HOLE IN IT WITH SMOKE BILLOWING OUT.

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN TIGUAN. WHILE DRIVING 30 MPH, ANOTHER VEHICLE FAILED TO YIELD AND CRASHED INTO THE FRONT DRIVER'S SIDE OF THE CONTACT'S VEHICLE. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO WARNING INDICATORS ILLUMINATED. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DAMAGED, BUT NOT DESTROYED. THE VEHICLE WAS TOWED TO A SHOP. THE CONTACT CALLED FREMONT VOLKSWAGEN CASPER AT (307) 462-5509 (6001 E 2ND ST, CASPER, WY 82609). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED A CASE NUMBER. THE FAILURE MILEAGE WAS APPROXIMATELY 76,000.

STEERING WHEEL ELECTRONIC CONTROLS STOPPED WORKING FOR A FEW MINUTES. NEXT TIME THE CAR WAS STARTED, THE AIR BAG ERROR LIGHT CAME ON. THERE IS A LOUDER THAN NORMAL "BRUSHING" FRICTION NOISE DURING STEERING, AND A METALLIC PING UPON THE FIRST TURN OF THE STEERING WHEEL AFTER STARTUP THAT WAS REPORTED TO TWO VW DEALERS MULTIPLE TIMES OVER THE LAST TWO YEARS. DEALERS CLAIMED NOT TO HEAR ANYTHING. ISSUES WERE NOT ADDRESSED. READING THE SYMPTOMS DESCRIBED BY THE CLOCK SPRING/AIRBAG RECALL, I BELIEVE THERE IS A CONNECTION TO THE ISSUES I'VE BEEN HAVING, THAT HAVE NOW RESULTED IN A PERMANENT AIRBAG MALFUNCTION WARNING.

THE SUNROOF OF THE CAR LEAKS WHEN IT RAINS OR SNOWS. ANY PRECIPITATION WILL GET INTO THE VEHICLE. THE DRAINS ARE CLEARED AND VOLKSWAGEN HAS SAID THE SUNROOF DRAIN TUBS DETERIORATE AND WATER DOES NOT MAKE IT OUTSIDE THE VEHICLE. INSTEAD, ALL THE WATER LEAKS INTO THE FOOT WELL OF THE VEHICLE AND HAS CAUSED MOLD AND OTHER ELECTRICAL ISSUES. THE DEALERSHIP QUOTED US $3,650 TO FIX THE ISSUE OF PUTTING IN NEW TUBES AND REPLACING THE CARPETS. HOWEVER, NOT THE ENTIRE CAR HAS MOLD AND NEEDS THE SEATS REPLACED AS WELL.

MY 2010 TIGUAN HAS EXPERIENCED A COUPLE OF SIGNIFICANT ISSUES DUE TO DESIGN - ONE A BURNED FUSE BOX AND TWO A MAJOR WATER LEAK INSIDE THE RIGHT FRONT PASSENGER FLOORBOARD. BOTH ISSUES STEM FROM DESIGN AND NOT WEAR AND TEAR. BOTH REPAIRS WERE COSTLY - $561 AND $753. I HAVE RECEIVED A SAFETY RECALL 97Z9 FROM VW FOR A FUSE ISSUE AND WILL BE WAITING ON A RESPONSE. I'VE ALSO SUBMITTED AN INQUIRY TO VW ASKING ABOUT PLANS TO REVIEW THE DRAIN HOSE ISSUE. HAD I NOT INVESTIGATED THE STRONG DAMP SMELL IN THE INTERIOR OF THE VEHICLE I WOULD NOT HAVE FOUND THE SATURATED FLOORBOARD AND I DO MEAN SOAKING WET. BOTH DRAIN HOSES WERE FOUND TO HAVE SMALL LEAKS AND THE ROUTE OF THE HOSES DUMPS RIGHT INTO THE CABIN - AGAIN THIS IS NOT A WEAR AND TEAR ISSUE - IT'S A DESIGN/PRODUCT ISSUE. AS A PRECAUTION THE DEALER RECOMMENDED THAT I HAVE ALL OF THE HOSES REPLACED TO PREVENT FUTURE WATER DAMAGE. I'VE SEEN NUMEROUS COMPLAINTS FROM OTHER VW OWNERS ABOUT THE DRAIN HOSES BEING DEFECTIVE SO THIS APPEARS TO BE A LARGER ISSUE THAN JUST A FEW VEHICLES. THANK YOU. *TR

PASSENGER SIDE FLOORBOARD AND RIGHT FRONT HEADLINER COMPLETELY DRENCHED IN WATER AFTER RAIN. THERE WAS SO MUCH WATER IT COULD HAVE CAUSED A SHORT AND COULD POTENTIALLY LEAD TO MOLD ISSUES. DESIGN ISSUE WITH SUNROOF DRAIN HOSES. *JS

2010 VW LE TIGUAN PURCHASED NEW AND IMMEDIATELY THE BACK-UP CAMERA COMES ON WHILE DRIVING STATING THAT YOU CAN'T USE THE BACK-UP CAMERA WHILE DRIVING. WHILE SERVICE TRIED TO FIX SEVERAL TIMES, IT CONTINUES TO DATE. WATER PUMP FAILED WHILE DRIVING, TRUNK HATCH MECHANISM FAILED AND HAD TO BE REPLACED AND DRIVERS DOOR LOCK AND WINDOW LOCK FAILED AND NEW DOOR REPLACED. ELECTRICAL BOX FUSES MELTED AND HAD TO BE REPLACED AND THE FRONT PASSENGER SEAT WARMER OVERHEATED AND MELTED THE SEAT CAUSING FULL REPLACEMENT OF SEAT (FROM THE FACTORY IN GERMANY). ENGINE MANIFOLD FLAP FAILED AND HAD TO BE REPLACED. INTEGRATED IPOD JACK HAS NEVER WORKED CORRECTLY. MOON ROOF DRAIN FAILED CAUSING THE INSIDE OF THE VEHICLE TO HAVE ICE ON THE WINDOWS AND WINDSHIELD CAUSING THE WHOLE MECHANISM TO BE REPLACED. *TR N UPDATED 9/19/13 *CN THE INTAKE MANIFOLD MALFUNCTIONED AND HAD TO BE REPLACED. THE HIGH PRESSURE FUEL PIP FROM THE FUEL PUMP FAIL AS IT WAS LEAKING

Reversing out drive way and coil rear suspension spring snaped

DRIVING APPROXIMATELY 30-35 MPH ON DRY, FLAT PAVEMENT...NO POTHOLES OR ROAD HAZARDS. HEARD THUMP FROM REAR TIRE ON PASSENGER SIDE (THOUGHT SOMETHING FELL OVER IN TRUNK). DROVE APPROXIMATELY 1/2 MILE TO HOME AND WHEN EXITING VEHICLE HEARD HISSING NOISE FROM TIRE. THE TIRE HAS A SLIT IN THE TREAD/SIDEWALL OF APPROXIMATELY ONE-INCH IN LENGTH. *TR