RoadVitals

2010 Volkswagen Tiguan Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Jul 21, 2014
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
1
2 investigations on file

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

14V441000

FUEL SYSTEM, GASOLINE

Jul 21, 2014
151,389 units potentially affected
The defect: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2014 Tiguan vehicles manufactured July 2007 to June 2014. When using winterized fuel, in certain conditions bubbles may form in the fuel system which could result in the vehicle stalling.
The risk: A vehicle stall increases the risk of a crash.
The remedy: Volkswagen will notify owners, and dealers will update the vehicle's software to increase the fuel pump pressure, free of charge. The recall is expected to begin August 19, 2014. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 24AV/2W.
Volkswagen of America, Inc.Manufacturer number 24AV/2WView on NHTSA.gov
13V569000

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS; EXTERIOR LIGHTING

Nov 22, 2013
62,155 units potentially affected
The defect: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2011 Tiguan vehicles manufactured July 2007 through June 2011. Due to a problem with the fuse for the exterior lights, the holder for the fuse that controls the vehicle's exterior lights circuit may melt.
The risk: If the holder melts, there may be a partial loss of exterior lighting. Reduced vehicle illumination diminishes the vehicle's visibility, increasing the risk of a crash.
The remedy: Volkswagen will notify owners, and dealers will replace the fuse, free of charge. Owners may contact Volkswagen at 1-800-893-5298. Volkswagen's recall number is 97Z9/2V.
Volkswagen of America, Inc.Manufacturer number 97Z9/2VView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EA18003OpenEngineering Analysis

Air Bag Clockspring Failure

Opened Apr 18, 2018

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

AIR BAGS:FRONTAL:DRIVER CLOCKSPRING/SPIRAL CASSETTE
PE13036ClosedPreliminary Evaluation

Partial Loss of Exterior Lights

Opened Nov 4, 2013
Closed Feb 28, 2014

Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.

ELECTRICAL SYSTEMLed to recall 13V569000

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .