2019 Volkswagen Tiguan Engine Problems

The car, a 2019 VW Tiguan, had a “check engine” light come on, and the resulting diagnosis and repairs - using VW’s specific engine fault codes - led to the replacement of both water pumps at 72,000 miles. An investigation of the water pump problem on such cars revealed that Volkswagon previously settled a major nationwide class-action lawsuit (apparently kept secret) covering certain 2014–2021 models with 1.8L and 2.0L engines. This resulted in an extended warranty covering the repair or replacement of failed water pumps. For some reason our car was not covered by the extended warranty, even though the engines in the 2017 Tiguans are all the same. Why weren't we, as the owners of a 2019 Tiguan, notified of the results of the class-action lawsuit, and given the extended warranty? I want to know the difference between the water pumps in the affected vehicles, and the one in our car. The water pump # in her Tiguan is identified as O6L 121 111 M. What differentiates her water pump from those covered by the settlement? Why are we forced to pay a good deal of money to correct a pretty disturbing VW design flaw (a plastic water pump), when others aren’t?

NHTSA ID

11755432

Incident

Jul 22, 2026

This vehicle is burning oil! I have stayed on top of getting the regular/required oil changes but inbetween we have had to constantly top off the oil. I also get all oil changes at the dealer. Last time when I complained about it the guy told me that it would be a lot of work to try to find out why and left it at that. My warranty expires in November and I don't want to get burned by this by needing a new engine!

NHTSA ID

11754140

Incident

Jun 8, 2026

The contact owns a 2019 Volkswagen Tiguan. The contact stated that while driving at an undisclosed speed, the vehicle drove over a pothole or an object on the roadway and the vehicle stalled. The failure had reoccurred on several occasions. No warning lights were illuminated. The vehicle was taken to a dealer to be diagnosed; however, the vehicle was not yet diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ID

11749983

Incident

Jul 13, 2026

Oil separator valve went out which caused the upper timing cover gasket, Cambridge assembly seal, oil pan and seal to fail. Could have caused the engine to fail whiling driving which could have resulted in an accident occurring. Confirmed by dealership. No other inspection has been done on it. Oil light came on whiling driving. I put in more oil. It goes in for regular oil changes and as not been noted prior to 6/19/26 that there was an issue with the vehicle.

NHTSA ID

11745493

Incident

Jun 19, 2026

My car jumps and lags due to fuel injector. It will be replaced by Volkswagen but only if there believe it’s Ana issue even though there are several reports of this issue

NHTSA ID

11742516

Incident

Jun 1, 2026

The car stopped at a light on a busy street in [XXX] (in the middle lane), then the engine stopped, and my wife could not restart it. I went as fast as possible and met her. I was eventually able to get it started. This is the third time we have had problems like this. I did the same thing for me and another time for my wife. I believe it is the stop-start capability, but I can't say for sure. We have also had bad engine oil burning problems and electrical problems. All of these (I now know, but did not before) are recurring problems for 2019 Tiguans. The cylinder head was rebuilt last year, associated with a similar instance. I am now fully aware that the 2019 Tiguans are known to experience all of these problems, but when I brought my car in on previous occasions, that never got mentioned. I am told XYZ is an issue, then billed for repairs. The car was originally leased, and when I purchased it at the end of the lease, I also purchased a full premium warranty. When the issue happened in May of 2025, the policy eventually covered this, but it took over a month of justifications and records before the third-party insurance company agreed to cover the repairs. All of this said, I am no longer comfortable that this car is safe for my wife to drive, as the issues that are repeating are known issues, and yet Volkswagen seems to sweep these under the rug from both a manufacturer and dealership perspective. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11738875

Incident

May 19, 2026

When it is really hot outside 90 and above my car does messes up. As I'm driving my car will throw the code pull over and Check starter system. Everything turns off, and then it takes minutes from my car to restart. It has happened multiple times when I'm in traffic at a stop light or driving and it throws the code as my car is moving. I have taken it to shops and still no auto shop can figure out the fix. Happened for the first time a year ago, and now its happening constantly

NHTSA ID

11737658

Incident

May 11, 2026

The vehicle will randomly shut off while driving. A message will appear stating "Check the Starting System" Attempts to restart the engine are unsuccessful. The engine will start, stall after about 2 seconds and the message "Check Starting System" will display. The first time it happened, I was turning a corner at a rather dangerous intersection and the vehicle stalled. It took about three attempts before the engine would remain running. When the engine would stall the dash would go dark and the engine would not remain running this happened about a month ago in hot weather. It occurred again on April 25th, 2026 way worse this time. The temperature in the area reached 91 Degrees Fahrenheit. My vehicle was sitting outside in the heat for at least 5 hours, same issue, The vehicle would then proceed to stall in the middle of the freeway, I was able to coast to the breakdown lane where the vehicle would remain unable to start and the message "Check Starter System" would display. Looking on NHTSA webpage before filing a complaint, it seems that this is a rather common issue. VW had a recall for other models (Campaign 28H7) for models such as the Jetta, Golf and other like models. This is a really dangerous issue and could end up getting someone seriously injured or worse killed in a collision if my vehicle stalls like this. The vehicle is scheduled for a service appointment in the near future (Local VW dealer is at least 2 weeks out before they can even look at my vehicle) After viewing this information, I can't help but believe it is possible the 28H7 recall is affecting more models than anticipated.

NHTSA ID

11734486

Incident

Apr 25, 2026

My car has delayed acceleration issues of between 3 - 6 seconds. The last one that was 6 seconds ore more was on June 29. In addition it's happened several times. I took the vehicle in for its last service and was told the issue was my battery. Battery was replaced and issue not resolved. The service before that I was told it was a carbon build up. Continues to happen sporadically.

NHTSA ID

11684296

Incident

Jun 29, 2025

Water pump leak/failure

NHTSA ID

11668280

Incident

Jun 19, 2025

High oil consumption

NHTSA ID

11667798

Incident

Jun 18, 2025

My vehicle will have a slow start when I start the car and also a delay when it is at a stoplight. I took it in for service twice and they told me it was because I had an after market battery. However - yesterday my car completely went dead at a stop light and I had to turn the engine off and in. It often lags or stops at a light. According to Reddit it seems it’s a crank start issue.

NHTSA ID

11664308

Incident

Jun 1, 2025

The contact owns a 2019 Volkswagen Tiguan. The contact stated that while driving at an undisclosed speed at night, the headlights unexpectedly failed to illuminate until the vehicle passed over a bump in the road, and shortly afterwards the headlights became illuminated again. Additionally, the engine oil and TPMS warning lights remained illuminated after the vehicle had an oil change and the tires were properly inflated. The vehicle was taken back to the dealer where the vehicle was purchased, but the dealer provided no assistance. The vehicle was not repaired. Upon investigation, the contact discovered that the VIN was included in NHTSA Campaign Number: 22V815000 (Tires). The manufacturer was not made aware of the failure. The failure mileage was approximately 103,000.

NHTSA ID

11664278

Incident

Nov 1, 2024

Mileage

103,000 mi

The car is burning a large amount of oil. I have taken it to the dealer for an oil consumption test 3 times. Every time, VW has indicated that the problem is normal. A tech stated that it is normal to burn a quart of oil every 1000 miles between oil changes. The engine has not ceased yet but it is a real fear of mine, especially since I drive my son in this car.

NHTSA ID

11618614

Incident

Sep 6, 2024

Me and my family were driving to Los Angeles on a freeway. All of a sudden the car showed a warning saying something like "Limited to 4,000 RPM", and we felt strong vibration under the hood. We decided to pull over at a first available gas station. While turning into the gas station, the car refused to go and refused to start, making a loud clicking sounds. We had to tow the car to the nearest VW dealership (Galpin VW). Later they informed us that they have to replace fuel injectors and harness and it will cost us approximately $2,600. After paying the amount, I found that VW issued a recall/bulletin for this very problem - VWP-23-03 for my model year (VW Tiguan 2019). I contacted VW but they refused to honor the warranty claiming that the warranty does not apply to my VIN. It seem obvious to me that this is the same exact problem as described in the bulletin VWP-23-03. I feel like VW has made a mistake by not applying this bulletin to my VIN number (and probably others) and is endangering motorists that would otherwise get this serious issue fixed during regular maintenance.

NHTSA ID

11608359

Incident

Aug 4, 2024

Starter system of the car, due to excess heat on days when the car is parked outside, it gives warning of starter system and the ignition turns off by itself

NHTSA ID

11607648

Incident

Aug 9, 2024

I was driving on a hot day and all of the instrument panel, air conditioning, all controllers, like signaling, windshield wipers, radio and all electronic gear turned off. Without the equipment and tools available, I could not change lanes or come to a stop safely. It would be difficult for me to say if other systems were affected. I was luckily not going very fast at the time and was able to navigate to the shoulder and stop my car without incident but it was a very stressful situation that I had never experienced in a vehicle before that time. Yes, my vehicle is available for inspection. This happened for the first time today so I have not tried to reproduce the issue. However, many others have complained about it on forums. Here is one of many examples: [XXX] A car's electronic systems should not completely turn off because of changes in the weather. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11604399

Incident

Jul 24, 2024

It’s happened twice in extreme heat; the first time I was driving not even 3 minutes after starting the car. All of a sudden there was a screen on the dash that popped up and said “ignition off, please stop the car safely”. The car was still able to drive but nothing else was working- gas gauge, speedometer, a/c, radio, etc. The second time happened when I had just started the car. Let it run for about 2-5 minutes and then the dash said “check starter system”. Is still fully capable of reversing, driving but just nothing else electrical working.

NHTSA ID

11601630

Incident

Jun 20, 2024

I have a 2019 VW Tiguan with 2.0 liter turbo 4 cylinder and auto trans. I am experiencing frequent delayed acceleration from standing start in duration of 2 - 6 seconds. This BW is equipped with Drive By Wire technology which means an electrical wire with a solenoid at each ends sends a signal to motor to rev up. If that signal is not perfect the car suffers from a delay in acceleration from stopped position. I have reported this twice to NHTSA since Aug 2019 when car was newly purchased. Within first week I experienced a “delayed acceleration” from stop and under 1800-2000 rpm’s and under 25mph so this is NOT turbo lag as service manager first suggested. This always occurs from a dead stop pulling into traffic whether left, right or straight away driving. The delay occurs about half the time 5 out of 10. Fortunately for me the six second delay event occurred in church parking lot. During these episodes the engine remains at idle with the accel pedal fully depressed to floor, and at end of the event motor races and car takes off. To repeat there is NOT a mechanical linkage for accel pedal to motor, with “Drive By Wire” technology. There are literally thousand of reports online about these failures and a cottage industry has sprung up to decrease these “delays” (Roar Pedal etc) but they are ineffective. I believe this “drive by wire technology “ is a means that an auto mfg attempts to meet EPA city CAFE fuel requirements. I have requested VE replace one or both solenoids but they refuse until they can replicate the issue and BE corporate isn’t listening and a new 2023 Tiguan I test drive for comparison suffered same issue but less frequent in short 30 minute drive. It is up to you to investigate and require auto manufacturers to correct this major problem in public confidence in auto mfgs and regulatory organizations tasked with protecting the public.

NHTSA ID

11574971

Incident

Sep 4, 2019

Road trip from VA to NJ approx 700 mi. Mid-trip, stopped for fuel and oil check. Thereafter, engine started to run rough. Check engine MIL on. Could not find any problem. Back on road. Received a low engine oil warning. Checked engine, oil all over back of engine compartment. Shut down engine and towed to nearest VW dealer. Found engine dipstick not completely seated. I checked and measured force needed to completely seat dipstick, at 30 lbs. Dipstick insert sleeve is plastic. Dipstick can be inserted to bottom w/o seating. Any leakage of vacuum from this engine causes extreme performance problems. Oil spewing in engine compartment is a significant fire hazard.

NHTSA ID

11558472

Incident

Sep 11, 2022

The contact owns a 2019 Volkswagen Tiguan. The contact stated that the vehicle experienced rough starts. Additionally, the vehicle drove rough and there was an oil odor present while driving. Upon inspection, it was discovered that there was no oil on the dip stick. The vehicle was taken to the local dealer who diagnosed that the turbo was faulty and needed to be replaced. The turbo was replaced but the failure persisted. The contact stated that the vehicle was experiencing excessive oil consumption. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 35,000.

NHTSA ID

11550752

Incident

Aug 19, 2020

Mileage

35,000 mi

When I turned the car on to leave work, the Check Engine and EPC lights came on, the car went into "Limp Home" mode and a warning came on the dash saying "Max Speed 4000 RPMs". Immediately, I could smell fuel, so I turned the vehicle off and exited. I noticed the ground under the car was wet. My husband came to check it out and the same thing happened. We saw that fuel was flooding out from underneath the engine. As he drove the vehicle to an adjacent lot to be able to be towed, fuel spewed out from underneath the engine. We had the vehicle towed to a VW Dealership in Grand Rapids who was able to diagnose a broken fuel rail bolt inside the intake manifold after they had the same experience with a massive fuel leak. Per the service advisor, this was not the first time they've seen something like this. Given the extreme flow of fuel from the engine, I'd say I'm very lucky that this didn't happen while driving through town or at speed on the highway where a vehicle fire would be possible with fuel pouring out of the manifold onto the hot engine.

NHTSA ID

11530340

Incident

Jun 8, 2023

My problem does not involve a crash but involves frequent DELAYED ACCELERATION in warm and cold weather, due to Drive-by-Wire technology or software. My VW service department does not acknowledge the problem and considers this delayed acceleration as turbo lag! Really, turbo lag at idle and no forward movement! Example sitting in parking lot at idle, auto trans in D drive. I stopped to let out my wife of car and I depressed accelerator pedal and nothing happened for six second delay, the motor continued at idle, 1000 rpm, than after approx., full six seconds (i was counting) then car raced off and I had to brake. This issue occurs from full stop warm or cold and from idle to 1800 rpm and up to 25mph and from first week of ownership beginning in October 2019. This had been reported up to eight times and only serviced by the selling VW dealership. The internet is full of remarks from VW owners of multiple VW models with same 4 cylinder turbo and many other European and Japanese manufacturers. I suggest these cars with 4 cylinder and turbo be investigated. I previously owned a 2016 GMC Terrain with drive by wire that never in three years displayed this similar issue.

NHTSA ID

11497122

Incident

Oct 4, 2019

Blind spot indicator went out dealer replaced under warranty (passenger side) warranty expired a few thousand miles later and now the driver side is faulty. Vehicle has a rough idle and oil leaks. Dealer will not diagnose problem and now that car is out of warranty they wont do anything unless paid for. Car has rough idle and miscellaneous oil leaks occasionally almost stalling. Independent shop ran a diagnostic and shows one cylinder misfiring and want to inspect pcv as most the time these fail on VW

NHTSA ID

11478844

Incident

Aug 8, 2020

The contact owns a 2019 Volkswagen Tiguan. The contact stated that while his wife was driving approximately 55 MPH, the vehicle lost motive power and stalled with several unknown warning lights illuminated. Since the initial failure, the failure occurred intermittently and the vehicle would restart soon after failure. The contact had taken the vehicle to a dealer however, the mechanic was unable to diagnose or duplicate the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 4,000.

NHTSA ID

11457583

Incident

May 1, 2020

Mileage

4,000 mi