2012 Volkswagen Touareg Problems

While driving my family around, the car lost engine power and came to a stop on a busy roadway leaving us stranded until a tow truck could arrive. There were no warnings or indications that anything was wrong. One minute, it was driving fine and out of nowhere, the engine shut off in the middle of the road leaving us blocking a lane and creating a dangerous situation. The dealership is claiming that the high pressure fuel pump suffered a catastrophic failure and that the entire fuel system needs to be replaced, which is going to cost more than $13,000.

The contact owns a 2012 Volkswagen Touareg. The contact stated that there was an abnormal gasoline odor on the driver’s side of the vehicle. There were no warning lights illuminated. The contact looked underneath the vehicle at the gas tank and noticed that gasoline was leaking from the fuel tank onto the exhaust pipe. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The contact related the failure to NHTSA Campaign Number 17V151000 (Fuel System, Gasoline). The VIN was not included. The approximate failure mileage was 119,000.

The contact owns a 2012 Volkswagen Touareg. The contact stated while driving at an undisclosed speed, he smelled an oil odor and smoke odor in the interior of the vehicle. After a visual inspection, the contact observed oil leaking from underneath the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who determined the diesel particulate filter needed to be replaced but was unable to locate the part. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 124,000.

THE CATALYTIC CONVERTER COMPLETELY SEPARATED FROM ITS OWN FLANGE WHERE IT CONNECTS TO THE EXHAUST HEADER. ULTIMATELY CAUSING AN EXHAUST LEAK AND A CHECK ENGINE LIGHT. THIS OCCURRED WHILE DRIVING AND UNDER NORMAL OPERATING CONDITIONS. DRIVING ON A LOCAL HIGHWAY WITH A SPEED LIMIT OF 55 MPH, WHICH DOES NOT HAVE EXCESSIVE AMOUNT OF POT HOLES) .

After driving the car for approximately 30 minutes without any problems and turning it off, it would not turn the ignition back on, release the parking brake or shift out of „P“. Several towing companies were unable to tow the vehicle due to the manufacturer’s failure to provide instructions on how to release the shifter in case of a problem. Other vehicles have a release button somewhere, the 2012 VW Touareg doesn’t. On page 481 of the owners manual VW advises the owner that if „you want to have the vehicle towed, the gear shift selection lever must first be released with the emergency procedure. Get professional assistance.“ The manual doesn’t explain what this emergency procedure would be. We had to call 3 different towing companies with professionals who didn’t have any clue in regards to the question how to release the shifter. The fourth company came with special equipment which allowed to tow the vehicle with the shifter in „P“ The dealership found that the ESL module (electronic steering lock) was faulty, which could be a safety issue, especially if it actuates while driving the vehicle.

STEERING WHEEL SHAKES DURING HIGH WAY DRIVING. MOSTLY HAPPENS AROUND 80 MPH, HAVE DONE THE ROAD FORCE BALANCING AND 4 WHEEL ALIGNMENTS. THE POWER STEERING WHEEL ALSO HAS A WEAK ASSISTANT TO TURN BACK TO CENTER. HERE IS A YOUTUBE LINK OF DEMONSTRATION OF STEERING SHAKE. HTTPS://WWW.YOUTUBE.COM/WATCH?V=GQIK_KW7KGG

I was driving to church on the morning of 2/16/25 when I heard a very loud “Boom.” I thought something had hit the car. It sounded like a gun going off. When I pulled over to see what had happened I realized the right side mirror had exploded. The glass was completely gone with only the glue left on the back plate housing. Both mirrors were in the “off” position. Nothing hit the outside housing. The right side mirror simply exploded. Thank God the window was not down with a passenger in the right front seat. In cool weather I often drive with the window down. Someone could have been hurt. I have owned many cars but NEVER one with a side mirror that exploded. This design is DANGEROUS.

The contact owns a 2012 Volkswagen Touareg. The contact stated that the driver’s side seat belt unintendedly unlatched while driving at various speeds. Additionally, the contact stated that the clockspring was defective, causing several failures with the vehicle. The contact stated while tilting the steering wheel, the vehicle drifted away from the intended direction and the windshield wipers would activate to the fastest speed with windshield washer fluid spraying onto the windshield and the horn was blaring uncontrollably. The vehicle was taken to a dealer and the contact was provided an estimate for a diagnostic test. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 178,000.

THIS HAPPENED TO THIS MY 2012 TOUAREG. THE ENGINE RANDOMLY DIED, EVEN ON FREEWAY, WHICH IS TOO DANGEROUS. THE PREVIOUS TIME IN IN JAN,2018 AND THIS TIME WAS ON FEB, 5TH, 2018. I WENT TO VW DEALERSHIP, THEY COULDN'T FIND OUT ANYTHING. SAYING EVERYTHING IS NORMAL AND THEY COULDN'T SUGGEST ANYTHING. BUT IT IS EXTREME UNSAFE FOR ME TO DRIVE THIS CAR. THE ISSUE RANDOMLY HAPPENS. PER HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?4965979-CAR-RANDOMLY-DIES-WHILE-DRIVING-ON-FREEWAY, SEEMS THIS IS A COMMON ISSUE AMONG VW VEHICLES, AND PEOPLE THOUGHT IT IS HIGH PRESSURE FUEL PUMP PROBLEM OR OTHER RELEVANT PARTS. VW SHOULD TAKE IT SERIOUSLY AND FIND OUT THE ROOT CAUSE AND FIX IT. THANKS, LIANG

FOR MY SITUATION MY VEHICLE SHUT OFF BY ITSELF WHILE I WAS DRIVING ON THE HIGHWAY AT 60 MPH. IT HAS HAPPENED 3 TIMES ALREADY. THE FIRST COUPLE OF TIMES THE DEALER HAS REPLACED THE BATTERY. AFTER THEY REPLACED THE BATTERY THE DEALERSHIP TOLD ME THAT THE CAR LOOKS FINE. WHEN THIS HAPPENED AGAIN FOR THE 3RD TIME, IT REALLY SCARED ME BECAUSE I WAS DRIVING ON THE HIGHWAY. BEFORE THE VEHICLE SHUTS OFF BY ITSELF, ALL OF THE ELECTRONICS TURNED OFF ALSO. THE WEIRD THING ABOUT THIS ISSUE IS THAT AFTER THE VEHICLE IS SHUT OFF BY ITSELF, I AM ABLE TO RESTART MY VEHICLE. AT THIS TIME I BROUGHT MY CAR TO THE DEALER TO LET THEM CHECK OUT WHAT IS GOING ON. THEY TOLD ME THAT THEY COULDN'T FIND ANYTHING WRONG THAT EVERYTHING LOOKED RIGHT. THEY WILL RELEASE MY VEHICLE TO ME THIS SATURDAY. MY CONCERN IS I CAN TAKE THE VEHICLE BACK BUT I DON'T KNOW WHEN IS THIS PROBLEM GOING TO HAPPEN AGAIN. I GOT LUCKY THIS TIME BECAUSE THERE WASN'T ANY CARS BEHIND ME ON THE HIGHWAY. WHEN THE CAR SHUTS OFF BY ITSELF, IT CANNOT MOVE AT ALL AND I'M SITTING IN THE MIDDLE OF THE HIGHWAY. IF SOMETHING HAPPENS LIKE THIS WHO WILL TAKE THE RESPONSIBILITY? I ASKED VW OF AMERICA, THEY SAID IF THEY DIDN'T FIND ANYTHING WRONG THIS TIME THEN I NEED TO WAIT UNTIL THIS HAPPENS AGAIN OR IF THEY CAN FIND SOMETHING WRONG. THIS IS SOMETHING ABOUT SAFETY. WHEN THE MY VEHICLE SHUTS OFF THERE IS NO WARNING SIGN, IT JUST HAPPENS. PLEASE HELP ME TO SOLVE THIS ISSUE. I M NOT SURE IF THE DEALER REALLY CHECKS MY VEHICLE OR IF THEY ARE LYING? *TR

The contact owns a 2012 Volkswagen Touareg. The contact stated that the driver’s side seat belt unintendedly unlatched while driving at various speeds. Additionally, the contact stated that the clockspring was defective, causing several failures with the vehicle. The contact stated while tilting the steering wheel, the vehicle drifted away from the intended direction and the windshield wipers would activate to the fastest speed with windshield washer fluid spraying onto the windshield and the horn was blaring uncontrollably. The vehicle was taken to a dealer and the contact was provided an estimate for a diagnostic test. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 178,000.

WHILE TRAVELING ON HIGHWAY 24 AIRBAG SPONTANEOUSLY DEPLOYED AND I WAS INVOLVED IN MVA. FRONT END OF VW TOUREG SMASHED INTO CONCRETE CENTER POST. TRAVELING ABOUT 65 MPH.

I OWN A 2012 VW TOUAREG AND RECENTLY, I HAVE HAD AN ISSUE WITH THE BRAKES. WHEN I COME TO A COMPLETE STOP AT A LIGHT OR FOR A LONG TIME, AFTER 5 OR MORE SECONDS, THE BRAKE PEDAL STARTS TO GO DOWN AND THE CAR STARTS TO ROLL FORWARD. I CAN STOP THE ROLLING IF I PUSH THE BREAKS ALL THE WAY DOWN FURTHER, BUT THE DEALERSHIP SAYS THEY CANNOT REPRODUCE THE ISSUE AND THEREFORE CANNOT CHANGE ANY PARTS OR DO ANYTHING FOR ME. SINCE I AM UNWILLING TO GAMBLE WITH MY BRAKES, ESPECIALLY WITH MY SON IN THE VEHICLE, I HAVE LEFT THE VEHICLE AT THE DEALERSHIP UNTIL THEY CAN REPRODUCE THE ISSUE. I'M NOT SURE IF OTHER PEOPLE ARE HAVING THIS BREAK ISSUE, BUT I WANTED SOMEONE TO BE AWARE. *TR

TL* THE CONTACT OWNS A 2012 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT A KNOCKING SOUND WAS COMING FROM THE UNDER CARRIAGE OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE DEALER WAS ABLE TO IDENTIFY THE KNOCKING, BUT WAS UNABLE TO DIAGNOSE THE FAILURE. THE DEALER CONTACTED THE MANUFACTURER AND WAS TOLD THEY WERE AWARE OF THE PROBLEM, BUT DID NOT HAVE A SOLUTION AVAILABLE TO REMEDY THE ISSUE. THE CONTACT STATED THAT AFTER 9 DAYS, THE MANUFACTURER PROVIDED A SPECIAL SPRAY TO THE DEALER TO SPRAY BEHIND THE BRAKE PADS. THE CONTACT LEFT THE VEHICLE WITH THE DEALER FOR REPAIRS. THE FAILURE MILEAGE WAS 15 AND THE CURRENT MILEAGE 1,200.

THERE HAS BEEN A SUBSTANTIAL CHANGE/DECREASE IN THE PERFORMANCE OF MY 2012 TOUAREG TDI RESULTING IN SIGNIFICANTLY REDUCED FUEL ECONOMY: PREVIOUS AVG FUEL ECONOMY WAS APPROX 27MPG AND IS NOW BARELY AVERAGING 16 MPG. NOTICED CONTINUAL DECREASE IN CAR PERFORMANCE AFTER TAKING MY CAR IN FOR GENERAL MAINTENANCE TO GARCIA VW DEALERSHIP IN SANTA FE, NM ON THE FOLLOWING DATES: 3/6/18: GENERAL MAINTENANCE (AIR/CABIN/FUEL/ADBLUE MAINTENANCE/ AND TIRE CHANGE) 4/17/18: REPLACE A FAULTY RADIO WHICH SUDDENLY FAILED (DEALERSHIP HAD CAR FOR 8 DAYS) 6/7/18: CLEAN UP AD BLUE FUEL SPILL IN THE REAR SPARE TIRE COMPARTMENT THE ENGINE NOW RUNS SIGNIFICANTLY LOUDER AND IS REVVING UP AND SURGING AT INTERVALS. IN ADDITION TO THE SUBSTANTIAL DROP IN FUEL ECONOMY, THE AVERAGE SPEED/MPH HAS BEEN LOCKED AT 13MPH AND DROPPED TO 12MPH ON JUNE 1, 2018. CHANGE IN ENGINE BEHAVIOUR: -ENGINE RUNS LOUDER AND IS REVVING UP WHEN IDLING,ACCELERATING, BREAKING,DOWNSHIFTING -SOUNDS LIKE THE FUEL INJECTION IS SLUGGISH WHEN ACCELERATING -STEERING WHEEL FEELS SLUGGISH WHEN TURNING RIGHT AND ACCELERATING THROUGH TURNS. VIBRATING SOUND WHEN TURNING. -STARTING IGNITION: LONGER PAUSE FOR IGNITION TO START AFTER TURNING THE KEY AND FOOT IS ON BRAKE. -SUSPENSION: SUSPENSION OF THE CAR ROCKS BACK AND FORTH WHEN BRAKING AND SOUNDS LIKE THERE'S A TANK SLIDING/ SHIFTING IN THE REAR WHEN COMING TO A STOP. WHEN I INITIALLY HEARD THIS SOUND I OPENED THE TRUNK/CARGO AREA FOR THE SPARE TIRE AND FOUND DRIED AD BLUE SPILLED ALL OVER THE CARGO AREA INCLUDING DIRTY RAGS WHICH HAD BEEN USED TO WIPE UP ADBLUE AND STUFFED IN THE BOTTOM OF THE TRUNK. -AIR CONDITIONER IS EMITTING A VERY STRONG NAUSEATING YEAST ODOR THAT WILL NOT GO AWAY AND ISN'T COOLING EFFICIENTLY. I HAVENT AUTHORIZED OR APPROVED ANY UPDATES MODIFICATIONS TO THE VEHICLE RE: THE 3.0 LITER GEN EPA/CARB MODIFICATIONS: I SUSPECT VEHICLE TAMPERING.

FOR MY SITUATION MY VEHICLE SHUT OFF BY ITSELF WHILE I WAS DRIVING ON THE HIGHWAY AT 60 MPH. IT HAS HAPPENED 3 TIMES ALREADY. THE FIRST COUPLE OF TIMES THE DEALER HAS REPLACED THE BATTERY. AFTER THEY REPLACED THE BATTERY THE DEALERSHIP TOLD ME THAT THE CAR LOOKS FINE. WHEN THIS HAPPENED AGAIN FOR THE 3RD TIME, IT REALLY SCARED ME BECAUSE I WAS DRIVING ON THE HIGHWAY. BEFORE THE VEHICLE SHUTS OFF BY ITSELF, ALL OF THE ELECTRONICS TURNED OFF ALSO. THE WEIRD THING ABOUT THIS ISSUE IS THAT AFTER THE VEHICLE IS SHUT OFF BY ITSELF, I AM ABLE TO RESTART MY VEHICLE. AT THIS TIME I BROUGHT MY CAR TO THE DEALER TO LET THEM CHECK OUT WHAT IS GOING ON. THEY TOLD ME THAT THEY COULDN'T FIND ANYTHING WRONG THAT EVERYTHING LOOKED RIGHT. THEY WILL RELEASE MY VEHICLE TO ME THIS SATURDAY. MY CONCERN IS I CAN TAKE THE VEHICLE BACK BUT I DON'T KNOW WHEN IS THIS PROBLEM GOING TO HAPPEN AGAIN. I GOT LUCKY THIS TIME BECAUSE THERE WASN'T ANY CARS BEHIND ME ON THE HIGHWAY. WHEN THE CAR SHUTS OFF BY ITSELF, IT CANNOT MOVE AT ALL AND I'M SITTING IN THE MIDDLE OF THE HIGHWAY. IF SOMETHING HAPPENS LIKE THIS WHO WILL TAKE THE RESPONSIBILITY? I ASKED VW OF AMERICA, THEY SAID IF THEY DIDN'T FIND ANYTHING WRONG THIS TIME THEN I NEED TO WAIT UNTIL THIS HAPPENS AGAIN OR IF THEY CAN FIND SOMETHING WRONG. THIS IS SOMETHING ABOUT SAFETY. WHEN THE MY VEHICLE SHUTS OFF THERE IS NO WARNING SIGN, IT JUST HAPPENS. PLEASE HELP ME TO SOLVE THIS ISSUE. I M NOT SURE IF THE DEALER REALLY CHECKS MY VEHICLE OR IF THEY ARE LYING? *TR

The contact owns a 2012 Volkswagen Touareg. The contact stated that the driver’s side seat belt unintendedly unlatched while driving at various speeds. Additionally, the contact stated that the clockspring was defective, causing several failures with the vehicle. The contact stated while tilting the steering wheel, the vehicle drifted away from the intended direction and the windshield wipers would activate to the fastest speed with windshield washer fluid spraying onto the windshield and the horn was blaring uncontrollably. The vehicle was taken to a dealer and the contact was provided an estimate for a diagnostic test. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 178,000.

THE DRIVER SEAT BELT DOES NOT LATCH PROPERLY AND COMES OFF WHILE DRIVING. MULTIPLE ATTEMPTS ARE REQUIRED FOR THE SEAT BELT TO LATCH AND BE SECURE. THIS PROBLEM STARTED AROUND JULY 2020.

CAR FOLLOWING ME LIGHT ISSUE. LIGHTS ON LOW BEAM VERY BRIGHT (XENON) WITH NARROW BEAM PATTERN. SEEMED AS IF EVERY TIME THERE WAS A BUMP THEY WERE FLASHING ME BUT ITS JUST THE LIGHTS THEMSELVES. THIS CAR SHOULD BE RECALLED AND HEAD LIGHTS REPLACED. NOTICED THIS ON ALL TOURAGES..... *TR

THE POWER SEAT KNOB/SWITCH DESIGN CAUSES THE SEAT BACK TO RECLINE WHEN ENTERING AND EXITING THE VEHICLE. ON NUMEROUS OCCASIONS I HAVE FALLEN/SLID BACK INTO THE SEAT WHEN EXITING BECAUSE THE SEAT BACK WOULD RECLINE. ON SUCH OCCASIONS IT'S LIKE LOSING ONE'S BALANCE AS YOU TRY AND STAND UP BY USING ONE'S BODY TO PUSH OFF THE SEAT. ON NUMEROUS OCCASIONS THE HEAVY TOUAREG DOOR UNFORTUNATELY CLOSES AND HAS SLAMMED ON MY LEGS CAUSING BRUISING AND PAIN. WHEN MY PARTNER, WHO HAS A BAD BACK, TRIES TO ENTER AND EXIT THE TOUAREG, THE RECLINING SEAT BACK HAS CAUSED HER TO SLIDE ON THE SEAT AND TWEAKING HER BACK AND CAUSING UNPRECEDENTED HARM. MY CONTINUED FEAR IS WHEN TRYING TO EXIT THE VEHICLE ON BUSY STREETS BECAUSE WHEN I HAVE HAD TO NOT EXIT FULLY BECAUSE OF TRAFFIC, THE BACK SEAT SUPPORT IS GONE CAUSING ME TO ONCE AGAIN SLIDE INTO THE RECLINED SEAT BACK AND GETTING MY LEGS ONCE AGAIN CAUGHT BY A HEAVY DOOR. I HAD THIS ISSUE SINCE MY FIRST WEEK OF OWNERSHIP AND IT IS DOCUMENTED WITH THE DEALER. I RECENTLY FOUND OUT VW RECOGNIZES THE ISSUE AS THEY REENGINEERED THE SEAT KNOB AND BACKING BEZEL TO STOP THIS ISSUE BUT PRIOR TO THE FIX OWNERS ARE NOT ELIGIBLE BECAUSE THEY CONSIDER THIS REENGINEERED FIX TO BE JUST AN ACCESSORY. THE FIX STARTED TO APPEAR WITHIN THE 2013 MODEL YEAR. *TR

TPMS LIGHT INTERMITTENTLY STARTED BLINKING. I TOOK IT TO THE DEALER AND THEY "DIAGNOSED" IT AS THE BACK LEFT SENSOR. I WAS INITIALLY TOLD THAT THE RECOMMENDATION WAS TO NOT CHANGE IT UNTIL I REPLACED TIRES AND THEN I WAS TOLD IT WAS NOT COVERED UNDER MY WARRANTY. I CALLED THE WARRANTY COMPANY AND THEY SAID THAT IT WAS 100% COVERED.