1994 Volvo 850 Problems

I HAVE A 1994 VOLVO 850. I HAVE A LEAK WHERE THE HEAT SHIELD IS ATTACHED TO THE GAS TANK. VOLVO IS WELL AWARE OF THIS PROBLEM BUT MY VIN DOES NOT SHOW THE RECALL. THE LEAK OF GAS IS 100% FROM THE RECALLED SPOT HEATSHIELD SIDE OF THE GAS TANK. THIS IS A SAFETY ISSUE BECAUSE IT COULD BLOW BACK ON THE EXHAUST AND CAUSE A FIRE.

WE SMELL GAS. WHEN STOP NOTICE FUEL LEAKING FROM FUEL ENTRY PIPE. WHEN GOT CLOSER LOOK IT WAS LEAKING FROM FUEL ENTRY PIPE THAT CONNECTED TO FUEL TANK. *TR

I BELIEVE IT'S THE ELECTRONIC THROTTLE CONTROL. I'VE HAD THE PART REPLACED AND YET THE CAR STILL RUNS POORLY. IT STALLS, LOOSES SPEED, AND QUITS RUNNING ALL TOGETHER. IT IS A VERY SERIOUS AND DANGEROUS SITUATION. *JB

I AM HAVING PROBLEMS WITH MY CAR CUTTING OFF WHILE DRIVING. STRANGELY, FIRST IT STARTED OUT CUTTING OFF WHENEVER I WOULD MAKE A RIGHT TURN. THE CAR WOULD JUST CUT OFF, ALL THE LIGHTS IN THE DASH WOULD COME ON. I HAVE HAD THREE AUTO REPAIR PLACES LOOK AT IT. OF COURSE I WAS ADVISED TO DO SEVERAL THINGS WHICH THEY THOUGHT WOULD FIX THE PROBLEM. IT DID NOT. WELL THE LASTEST AND WORST HAPPENED ON 8/6 WHEN THE CAR CUT OFF WHILE DRIVING AND ON A BUSY STREET. FORTUNATELY, I WAS ABLE TO COAST TO THE FAR SIDE AND SWITCH THE CAR OFF AND IT STARTED RIGHT BACK UP. PLEASE I NEED HELP. I AM SCARED TO GET ON THE INTERSTATE IN FEAR THAT IT WILL SHUT DOWN ON ME.

TL* THE CONTACT OWNS A 1994 VOLVO 850. THE CONTACT STATED THAT THE RADIATOR FOR THE HEATING CORE WAS LEAKING AND EMITTING CHEMICAL FUMES INTO THE VEHICLE. AS A RESULT, THE CONTACT SUFFERED A SEVERE RESPIRATORY PROBLEM. THE CONTACT WAS TAKEN TO THE HOSPITAL ON VARIOUS OCCASIONS FOR TREATMENT. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

STALLS ALL THE TIME MECHANIC CAN'T FIND PROBLEM THIS HAS BEEN GOING ON FOR ABOUT TWO YEARS. IT STALLS AT 60MPH AND IT STALLS WHILE IDLING. IT STALLED 7 TIMES GOING A TOTAL OF 4.5 MILES. HELP *TR

THE CONSOLE AND STEERING WHEEL WERE WET FROM RAIN. THE SRS DASH WARNING LIGHT CAME ON. ABOUT 5 MILES AFTER THAT, THE DRIVER'S SIDE AIR BAG DEPLOYED. THE BAG WAS THE ORIGINAL BAG. THE SRS LIGHT HAD GONE ON ONCE 20 MONTHS BEFORE WHEN THE CONSOLE GOT WET. THE DEALERSHIP RAN A TEST FOR ABOUT $115 EACH ON BOTH OCCASIONS AND SAID THE CAUSE OF THE SRS LIGHT COMING ON WAS INDETERMINATE. TWENTY MONTHS AGO A TOP, LONGTIME VOLVO DEALERSHIP SERVICE MANAGER ASSURED ME THAT AIR BAGS NEVER GO OFF WITHOUT AN IMPACT. HE SAID THERE HAD NOT BEEN A SINGLE OCCASION OF THAT EVER HAPPENING. I SHOULD HAVE GOOGLED THE TOPIC. I WOULD HAVE SEEN RIGHT AWAY THAT HE DIDN'T KNOW WHAT HE WAS TALKING ABOUT. TWO BONES IN MY FOREARM WERE BROKEN AND HEAVY BRUISES THAT ARE STILL VISIBLE 5 WEEKS LATER WERE LEFT ON MY STOMACH AND THIGHS. CORPORATE OFFICES AND THE DEALERSHIP SAY THE BAG WAS OUT OF WARRANTY; A REPLACEMENT STEERING WHEEL TO INSTALL A NEW BAG IS NOT AVAILABLE; AND THAT THEY WILL NOT DISCONNECT THE PASSENGER BAG, THOUGH I CONSIDER IT A TIME BOMB. BEFORE WRITING AN EMAIL ATTEMPTING TO PLACE THE BLAME ON ME, ERICA AT "THE EXECUTIVE OFFICES OF VOLVO" LEFT AN APPARENTLY INANE VOICE MAIL THAT I HAVE SAVED FOR NOW SAYING "THIS IS NOT EXACTLY A SPONTANEOUS DEPLOYMENT. WE DO KNOW WHY THE BAG DEPLOYED IN YOUR VEHICLE." I EMAILED BACK THAT HER CLAIM THAT "WE" KNOW WHAT CAUSED THE BAG TO DEPLOY "STRUCK ME AS ODD BECAUSE NO ONE AT THE VOLVO [DEALERSHIP] THIS PAST WEEK SAID THAT THEY KNEW." EVEN AFTER RUNNING A CHECK ON THE SRS SYSTEM, AND CHARGING ME $115 TO DO SO, THEY STILL SAID THEY DID NOT KNOW. IN FACT A FEW WEEKS AGO TWO LONG TIME SERVICE MANAGERS WERE SAYING MY EXPERIENCE WAS UNPRECEDENTED OR IMPOSSIBLE. I SUGGESTED IN ANOTHER EMAIL TO ERICA THAT THE CORPORATION HAD A MORAL OBLIGATION TO INFORM THEIR SERVICE MANAGERS OF DOCUMENTED CASES OF SPONTANEOUS DEPLOYMENT. *TR

I OWN A 1994 VOLVO 850 SEDAN. I WAS PARKED ON A BUSY DOWNTOWN PORTLAND ST. AND GOT IN MY CAR, TURNED ON THE IGNITION AND MY AIRBAG DEPLOYED. IT WAS SO LOUD I THOUGHT I HAD BEEN SHOT. (AS DID PASSERSBY) MY CAR FILLED WITH WHAT I THOUGHT WAS SMOKE (DUE TO GUNPOWDER SMELL) AND GOT OUT QUICKLY. I WAS VERY DISTRAUGHT AND IN SHOCK...MY ARMS AND CHEST HAD BURNS AND CUTS AND BRUISES INSTANTLY. I WENT TO THE ER..THANKFULLY NOTHING BROKEN BUT NOW MY INSURANCE COMPANY (FARMER'S) IS SAYING IT'S NOT COVERED SINCE IT IS "SO RARE" AND THEY FEEL "DEFECTIVE EQUIPMENT". I THEN CONTACTED VOLVO HEADQUARTERS AND THEY ARE SAYING THAT SINCE THE CAR IS 14 YRS. OLD THERE COULDN'T POSSIBLY BE A "FACTORY DEFECT". AT THIS POINT I'M NOT SURE WHAT'S GOING TO HAPPEN BUT NOBODY SEEMS TO BE ABLE TO HELP ME WITH THIS. I FEEL LIKE I AM SUCH AN INNOCENT VICTIM IN ALL THIS. ALL I DID WAS TRY TO START MY CAR........... *TR

DT: THE CONTACT STATED VEHICLE WAS LEAKING OIL BUT HE WAS UNSURE WHERE IT WAS COMING FROM. THE DEALERSHIP SUGGESTED CHANGING THE MASTER CYLINDER AND IT WAS CHANGED AT A LOCAL SERVICE STATION, HOWEVER THE LEAK CONTINUED. THE CONTACT CLAIMED THE LEAK WAS COMING FROM THE ABS. THE MODULE WAS CHANGED, THE LEAK STOPPED AND THE BRAKES WORKED PROPERLY. HE THEN RECEIVED NHTSA RECALL 04V368000 CONCERNING THE FUEL SYSTEM. RECALL REPAIR WAS PERFORMED BUT THERE WAS STILL A SMELL OF FUEL. THIS HAPPENED WITH THE WINDOWS UP OR DOWN. THE CHECK ENGINE LIGHT WAS CAME ON. UPON INSPECTION AT THE DEALERSHIP THE COMPUTER FOUND THE AIR MASS FLOW METER WAS NOT WORKING PROPERLY. THIS CAUSED THE VEHICLE TO IDLE ROUGHER AND NOT RUN SMOOTHLY. THE AIR MASS FLOW METER HAS BEEN REPLACED FOUR TIMES BY THE DEALERSHIP. THE CHECK ENGINE LIGHT WAS STILL ON. *AK UPDATED 12/27/2005. *NM

WHILE THE VEHICLE WAS PARKED AND THE EMERGENCY PARKING BRAKE ENGAGED. THE VEHICLE COMMENCED TO ROLL INTO THE CONSUMER. THE CONSUMER JUMP INTO THE TRUNK WHILE THE VEHICLE CONTINUED TO ROLL DOWN THE STREET UNTIL IT RAN INTO ANOTHER VEHICLE. THE CONSUMER SUSTAINED INJURIES TO HER NECK AND MINOR CUTS AND BRUISES. THE VEHICLE WAS ON AN INCLINE. *JB

DT: WHILE HE WAS IN A PARKING LOT THE FRONT PASSENGER WHEEL FELL OFF. THE BOLTS THAT HELD THE FRONT ASSEMBLY BROKE OFF, AND THE AXLE BROKE. DEALER SAID HE SAW THIS PROBLEM BEFORE. ANOTHER DEALER SAID THEY NEVER HEARD OF THIS PROBLEM, AND GAVE HIM THEIR PHONE NUMBER. MANUFACTURER HAS NOT BEEN CONTACTED YET. *AK

AFTER HITTING POTHOLE, WHEEL BROKE. ALSO, REAR TIRE DEVELOPED A LEAK. *AK

DRIVERS SIDE WIPER DOES NOT CLEAR WINDSHIELD. THEY SAY TO TIGHTEN NUT BUT IT NO LONGER WORKS. I WOULD HAVE TO REPLACE TOTAL ASSEMBLY. I WAS TOLD THIS IS A PERSISTENT PROBLEM WITH THE 850. SHOULDN'T THIS BE FIXED BY VOLVO? *JB

THE NUT THAT LOCKS DOWN THE WIPER ON THE DRIVER'S SIDE COMES LOOSE OVER AND OVER CONSTITUTING A VERY HAZARDOUS SITUATION. I HAVE TIGHTENED IT NEARLY TO THE POINT OF BENDING THE WIPER ASSSEMBLY. THNX. *AK

DEALER SAID NO RECALL ON TIRES OR RIMS I BOUGHT NEW ONES COMSUMER REPORT SAID THERE WAS A RECALL. *AK

AFTER HITTING POTHOLE, WHEEL BROKE. ALSO, REAR TIRE DEVELOPED A LEAK. *AK

1994 850 GLT VOLVO WAS TOTAL DESTROYED BY FIRE. *MR THE CONSUMER WAS DRIVING THE VEHICLE WHEN THE SEAT FELT HOT, THEN IT BEGUN TO SMOKE AND SMELLED BURNING. THE DEALER DISCONNECTED THE SEAT HEATER CIRCUITS. SHORTLY AFTER THAT, THE VEHICLE WAS TURNED ON AND BEGUN TO SMOKE AGAIN. FLAMES WERE SHOOTING OUT FROM UNDERNEATH THE DRIVER'S SEAT. *SC

1. SEATS FELT VERY HOT TO THE POINT OF BURNING. HAD TO TURN HEATER OFF. . BURNED HOLES IN BOTH SEATS AND IN COAT OF PASSENGER. 3. SEAT HEATERS REPLACED. ONE ABOUT TWO YEARS AGO BY VOLVO DEALER. PART WAS NOT RETURNED. OTHER HEATER REPLACED LAST MONTH BY LOCAL GARAGE. I HAVE OLD HEATER, WHICH HAS A BARE WIRE STICKING OUT FROM BURNED HOLE IN HEATER PAD.*AK

THE TRANSMISSION FAILED CAUSING IT NOT TO SHIFT OUT OF FIRST GEAR. NLM

WHEN FIRST STARTED, THE CAR WILL NOT AUTOMATICALLY SHIFT. MANUALLY MOVED TO 2ND GEAR WILL SOMETIMES SHIFT AND THEN BACK TO DRIVE. IF PUT INTO LOW GEAR THE UPSHIFT LIGHT ILLUMINATES AND THE CAR ACTS LIKE IT IS RUNNING IN THE WRONG GEAR REGARDLESS OF THE POSTION OF THE AUTO GEAR SHIFTER. *AK

DT:THE CONTACT OWNS A 1994 VOLVO 850. THE VEHICLE WILL STALL WHILE DRIVING HE HAS HAD THE VEHICLE SERVICED NUMEROUS TIMES AND THE MECHANIC CANNOT DUPLICATE THE PROBLEM. THIS HAPPENS WHILE DRIVING AT ACCELERATING, DECELERATING, STARTUP, AND OTHER TIMES. THERE IS NO WARNING TO THIS FAIKURE.THERE IS NO AVERAGE SPEED FOR THIS OCCURRENCE. IF AN A BACKROADTAKE FOOT OF TO GO AROUND THE CURVE THE VEHICLE WILL STALL. WITHIN KAST YEAR IT HAPPENED ON CHRISTMAS DAY. THEN TWO WEEKS KATER, AND THEN THREE AND A HALF MONTHS LATER, AND TODAY AUGUST 10,2005 IT HAS HAPPENED FOUR TIMES. THE ENGINE WILL RESTART ABOUT FOUR OR FIVE MINUTES AFTER THEN STALLING. THE TRANSMISSION IS AUTOMATIC.*AK

DT: THE OWNER NOTICED AFTER DELIVERY OF VEHICLE THAT THERE WAS NO CHANGE IN THE MILEAGE. THE GAUGE WOULD READ HOW FAST THE OWNER WAS TRAVELING, BUT NOT HOW FAR THE VEHICLE WAS TRAVELING. THE OWNER NOTICED THIS WITHIN THE FIRST 10 MILES OF DRIVING. THE VEHICLE WAS PURCHASED ON THE PHONE AFTER VIEWING A WEBSITE. THE DEALERSHIP WHO SOLD THE VEHICLE DID NOT INDICATE THAT THERE WAS A DISCREPANCY. ALSO, CERTAIN FIELDS IN THE VEHICLE INFORMATION THAT COULD HAVE BEEN CHECKED TO INDICATE AN ODOMETER PROBLEM, AND THESE FIELDS WERE NOT CHECKED. WHEN THE OWNER ASKED ABOUT THE MILEAGE ON THE VEHICLE THE OWNER WAS TOLD BY SALESMAN THAT THERE WERE 131,889 MILES. THIS WAS THE SAME MILEAGE THAT WAS ON THE TITLE AND ON THE WEB SITE. THIS WAS THE MILEAGE THAT THE ODOMETER SHOWED BECAUSE THE ODOMETER WILL NOT ADVANCE AS THE MILEAGE INCREASED. THE OWNER GOT THE TITLE ON AUGUST 9 2005, AND THE TITLE STATED AS OF MARCH 2003 THERE WERE 122,042 MILES. ON VEHICLE. THE MILEAGE ADVANCED ABOUT 10,000 MILES SINCE 2003. THE OWNER CONTACTED THE DEALERSHIP ON AUGUST 5 2005 ABOUT THE ODOMETER PROBLEM, AS WELL AS A ENGINE PROBLEM. THE DEALERSHIP CLAIMED THEY DID NOT KNOW ABOUT THE MILEAGE PROBLEM, AND WAS UNCONCERNED ABOUT IT. THE OWNER TOOK THE CAR TO A VOLVO DEALERSHIP FOR REPAIRS, BUT VOVLO HAS NEVER SEEN THIS PROBLEM WITH THE SPEEDOMETER WORKING BUT NOT THE ODOMETER. *AK

STEERING WHEEL DIFFICULT/DANGEROUS WHILE MAKING SHARP TURNS. *AK

ENGINE WILL STALL, TEMPORARY LOSS OF STEERING WHILE DRIVING . TT

IF THE CRASH SENSOR LOCATED IN THE CENTER CONSOLE UNDER THE ORIGINAL EQUIPMENT CUP HOLDER BETWEEN THE TWO FRONT SEATS GETS WET IT WILL DISABLE THE AIR BAGS, AND THE SEAT BELT WILL NOT WORK. THE DEALER WANTS THE OWNER TO PAY 1158 TO CORRECT THE PROBLEM THAT HE IS HAVING WITH THE ELECTRICAL SYSTEM, CAUSING THE AIR BAG AND THE SEAT BELT NOT TO WORK IF EITHER FUNCTION GETS WET. *AK VEHICLE ALSO EXPERIENCED FLASHING LIGHTS AND DEALER STATED THIS WAS DUE TO A FAULTY REGULATOR, CONSUMER FEELS THAT THE CRASH SENSOR DID NOT GET WET DUE TO IT HAD NOT BEEN OPENED FOR INSPECTION, CONSUMER FEELS THAT THERE IS AN ELECRICAL PROBLEM THAT IS CAUSING LIGHTS TO FLASH AND POTENTIAL PROBLEMS WITH THE AIR BAGS. *SLC

SEAT BELT DOES NOT FASTEN THE CENTURY CHILD SAFETY SEAT SECURELY. *SD

BECAUSE OF FAILURE OF INTERNAL LATCHING MECHANISMS, THE DOORS OF THE 1994 VOLVO 850 (AND POSSIBLY OTHER MODELS) AFTER BEING CLOSED CAN SUDDENLY AND WITHOUT WARNING BE RENDERED PERMANENTLY CLOSED AND UNABLE TO BE OPENED FROM EITHER INSIDE OR OUTSIDE THE VEHICLE. USE OF THE VEHICLE KEY, DOOR LOCKS OR DOOR HANDLES ARE INEFFECTIVE AT ALLOWING AN AFFECTED DOOR TO BE OPENED, EVEN THOUGH UNAFFECTED DOORS WILL CONTINUE TO UNLOCK, LOCK, CLOSE AND OPEN NORMALLY. THE ISSUE OCCURRED ON MY VEHICLE ON BOTH REAR DOORS, ALTHOUGH AT DIFFERENT TIMES. OCCUPANTS CAN BECOME ENTRAPPED INSIDE THE VEHICLE, MAKING TIMELY EGRESS IN THE EVENT OF AN EMERGENCY IMPOSSIBLE, ESPECIALLY FOR ELDERLY, DISABLED OR INFANT PASSENGERS, WHO MAY HAVE TO CLIMB OR BE PULLED OVER SEATBACKS IN ORDER TO EXIT VIA A DOOR THAT IS STILL OPERATIONAL. EXITING VIA A REAR WINDOW OF THIS VEHICLE WITHOUT PERSONAL INJURY WOULD BE EXTREMELY UNLIKELY OR IMPOSSIBLE FOR MOST PEOPLE. *TR

TL*THE CONTACT OWNS A 1994 VOLVO 850. THE VEHICLE CHECK STRAP HAS FAILED AND IS CAUSING THE METAL TO WEAR OUT AND DAMAGE THE HINGES. THE FAILURE IS CREATING A HOLE IN THE DOOR. THE DEALER STATED THAT THE PILLARS NEED TO BE REPLACED. THE COST FOR THE REPAIR IS $947. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 18,700.

DT: WHILE HE WAS IN A PARKING LOT THE FRONT PASSENGER WHEEL FELL OFF. THE BOLTS THAT HELD THE FRONT ASSEMBLY BROKE OFF, AND THE AXLE BROKE. DEALER SAID HE SAW THIS PROBLEM BEFORE. ANOTHER DEALER SAID THEY NEVER HEARD OF THIS PROBLEM, AND GAVE HIM THEIR PHONE NUMBER. MANUFACTURER HAS NOT BEEN CONTACTED YET. *AK

THE VEHICLE CAME WITH 16 INCH WHEEL, REPEATED BLOWOUTS WITHOUT TIRE GOING FLAT,VOLVO SUGGESTED TO SWITCH TO 15 INCH WHEEL, WHEEL CRACKED AROUND THE MIDDLE. DEALER CLAIMS WHEEL BEARING ON 2 FRONT WHEELS PITTED. *AK

REAR DELTA LINKS MALFUNCTIONED.

FRONT PASSENGER REPLACEMENTS AND ORIGINAL RIM CRACKED THREE TIMES WITHIN THIRTY DAYS, RESULTING IN FLAT TIRES, REPLACE RIMS THREE TIMES. TT FIRST OCCASION, HIT A POT HOLE AND TIRE BUSTED AND WHEEL CRACKED, SECOND OCCASTION, HIT A BUMP AND TIRE WENT FLAT AND WHEEL CRACKED, ON THIRD OCCASION, HIT A HOLE AND WHEEL CRACKED AGAIN, CONSUMER STATES CRAKED WHEELS ONLY OCCUR ON THE FRONT PASSENGER SIDE. RIGHT REAR SEAT BACK NOT OPERATING PROPERLY. WEATHER STIP DEFECTIVE, KEPT FALLING OFF. JACK BROKE PRIOR TO RECALL. BATTERY WAS REPLACED. ENGINE TORQUE ARM BROKE AND WAS REPLACED. *SLC