2025 Volvo EX90 Driver assistance Problems

I was parked in a parking lot and when I released my foot from the break, the car accelerated on its own and crashed into the car in front of me. The automatic emergency braking did not deploy. It was most recently a safety risk and put others in the parking lot, particularly the driver in front me, in danger. I have reported this issue to Volvo and they instructed me to get the body of the car repaired and then the dealer will inspect it. I filed an insurance claim with my insurance company and the car is going to be repaired. There were no warning lamps or messages prior to the failure.

NHTSA ID

11756276

Incident

Aug 10, 2026

When in reverse, the infotainment system allows a user to swipe down from the top of the screen to open the notification window which overlays the backup camera, and upon closing the notification window, the backup camera is dismissed and is no longer visible.

NHTSA ID

11747111

Incident

Jun 27, 2026

DESCRIPTION OF DEFECT: I am reporting a recurring incident of unintended acceleration in my Volvo EX90. On multiple occasions, immediately upon shifting the vehicle into Drive — before I touched the accelerator pedal — the vehicle accelerated forward on its own without any input from me. This has happened more than once and is not an isolated event. The acceleration occurs at the moment of gear engagement, before I have made any contact with the accelerator pedal. I took the vehicle to my Volvo dealership on 2/12/26. The dealer was unable to reproduce the issue or identify a cause. This defect poses a serious and immediate safety risk, particularly in parking lots, driveways, and congested traffic, where unexpected acceleration could result in a collision, property damage, or injury to pedestrians or other drivers. I am requesting that NHTSA open a formal investigation into this issue.

NHTSA ID

11746581

Incident

Aug 20, 2025

Multiple times I have gotten a "Park assistance fault - book a service" message while driving and the parking sensors stop working. The issue temporarily resolves itself only to reoccurring several days later. Took to service and they replaced the car computer and said they could to replicate the issue after replacing the computer. Now a week later and the issue has re-occurred twice again.

NHTSA ID

11741674

Incident

Jun 2, 2026

My Volvo EX90 has recurring software reliability problems affecting safety-related detection systems and hands-free operation features. These failures involve inconsistent or incorrect detection of vehicles and pedestrians and unpredictable loss of hands-free phone functionality. These issues create increased distraction and reduce confidence in driver-assistance safety features.

NHTSA ID

11716524

Incident

Feb 1, 2026

The onboard charger (ghca) failed, destroying my evse and tripping the circut breaker in my electrical panel. It took 3.5 weeks for the replacement part to come in and be installed. On another occasion, the pilot assist adas presented an error and was unavailable until the computer was rebooted.

NHTSA ID

11715687

Incident

Dec 19, 2025

Ongoing Software Issues From shortly after delivery through now, the vehicle experiences frequent and recurring warning messages and system failures, including but not limited to: Suspension system warnings Driver assistance and self-driving feature failures One-pedal driving malfunctions Parking camera and sensor errors Other system warnings that appear to be software-related While the vehicle was often still technically drivable, these issues regularly caused the car to operate at reduced functionality, with key safety and convenience features disabled. Although software updates have reduced the frequency of these issues, they still occur intermittently and often require a vehicle reset or time to resolve. Because of these persistent and unpredictable warnings, my family and I have avoided taking this vehicle on long trips out of concern that the car may become unsafe or inoperable while traveling. The vehicle was brought in for service in December 2024 in an attempt to address these software-related issues; however, the service did not resolve the problem at that time. Hardware Failure #1 – GHCA In January 2025, the vehicle experienced a failure of the GHCA component, rendering the all-electric vehicle unable to charge. This occurred shortly after purchase. Service appointment booked: January 27, 2025 Vehicle in shop: aprox 30 days The vehicle was out of service for approximately one full month. During this time, I shared my experience on Reddit due to the severity of the issue and the vehicle’s newness. That post received over 350,000 views, and numerous Volvo EX90 owners reported experiencing the same GHCA failure—many stating they had required multiple replacements of the same component. This strongly suggests a widespread defect rather than an isolated incident. Hardware Failure #2 – GHCA (Repeat Failure) On February 3, 2026, the GHCA failed again, and the vehicle was returned to the dealership for service with no ETA on a fix.

NHTSA ID

11715573

Incident

Jan 27, 2025

On [XXX] around [XXX], while driving on [XXX] fro Santa Paula to Ojai, my car displayed a message on the dash that said "critical brake fault, pull over safely." When I applied the brakes they did not respond. I came to a stop only when the car lost momentum. When I exited the car to investigate, I shut the driver's door and was locked out. Neither my key card, nor phone key worked and the Volvo app indicated the reason was that the car was still driving it was not). I was just a mile away from descending a steep and winding road on the [XXX]. Had I been on that stretch of the road, the consequences I am certain there would have been a serious crash, as one side of the road has no shoulder and the other side is a steep cliff into a ravine. I had it towed that night to the dealership and it has been there at the dealership for almost three weeks. Both the dealership (Rusnak Volvo) and Volvo Customer Care have been uncommunicative, though on 12/7/22 Volvo Customer Care informed me I have a case number ([XXX]). When I called for an update today 12/12/25, I was told only that it had been assigned. No additional information has been provided. A simple internet search indicated that this brake issue has affected many Volvo cars in the past few years. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11704750

Incident

Nov 22, 2025

When leaving a downtown parking garage, I noted the following alert on the driver's screen: "Steering fault - Drive with caution. Book a service." The driver's screen also showed that there was a driver support system fault and that the lane keeping aid was not available. The center stack stated the following: "1 serious issue detected. Steering fault Drive with caution. Book a service." At the time that the fault came up, the car had been driven out of its parking spot (by turning left) approximately 50 feet. I had then stopped the car to talk to a friend. When I got back into the car, I noted the fault message on the driver's screen when I went to back the car up so that I could leave the parking garage. During my trip from downtown to the dealership, I did not note anything unusual other than the fact that the fault messages were displayed. The messages were displayed when I arrived at the dealership and stayed displayed until I exited the car. When I got back in the car to turn it on, the error messages had disappeared.

NHTSA ID

11698396

Incident

Nov 8, 2025

While driving, my car suddenly displayed the "Driver Support System Fault" icon (Picture 1). At that time, the only issue was the fault icon. I still had full navigation, lane departure warning and 360 camera functionality when I backed into my parking spot. The car was locked with my key card. I returned to 15 to 20 minutes later. The Driver Support System Fault Icon was lit in addition to the lane departure unavailability icon (Picture 2). The following functions and/or features did not work: - Lane Departure - 360 Camera - Front Camera - Tracking Lines for the Rear Camera - Park Sensor audible alerts (Forward or Backup) - Ambient Temperature (Reads "0 degrees Celsius") - Odometer in the central stack (Reads "-- km") - HVAC Functionality - Heated Seats - Heated Steering Wheel - Bluetooth - Wi-Fi - Google Assistant - Navigation, including map being frozen in one position - Glovebox access - Connectivity with Internet or Volvo App - Volume control for the radio did not function. - 4-way hazard button greyed out and non-functional on center stack Attempted reset/reboot of the Infotainment System did not resolve the issue and the car was taken to the local Volvo dealer. Summary of Pictures attached: Pic 3 - Quick Controls - Shows glove box, 4-way hazard icon and other control icons greyed out Pic 4 - Status - States "Everything is OK", but tire pressure button is not available and Total distance reads "--km". Additionally, as shown in Picture 3, the 4-way hazard icon is greyed out. Pic 5 - Similar shot as Picture 2 - Shows Driver Support System Fault and no Lane Departure Pic 6 - Car is in reverse. Shows rear back up camera without guidance lines. Does not show 360 camera. Pic 7 - HVAC Climate is off and cannot turn on. All controls were greyed out. I pressed "Manual" and "Auto" with no change. Pic 8 - Heated seats and heated steering wheel would not turn on even when I pressed the buttons.

NHTSA ID

11693995

Incident

Oct 5, 2025

On three occasions my car has initiated automatic emergency braking while I was driving across the same grated bridge deck (Montlake Bridge in Seattle). In each instance there was no potential for collision and my car slammed on brakes and jammed on my seatbelt with varying levels of discomfort and terror. This also created a safety risk because I could have been rear ended as there was so reason to suddenly stop and certainly was shocked to have my car brake urgently and restrain me suddenly with seatbelt. My best guess is that this related to boats traveling under the bridge as this happened three times during higher boat traffic. I reported incident to Volvo and was told a case would be opened and that I would be contacted. I was not contacted. I scheduled a service appointment to address this and other issues with the EX90 that are unrelated but for the third time my appointment was cancelled as the Volvo dealership is refusing to service the ex90s they have been selling.

NHTSA ID

11693952

Incident

Sep 16, 2025

The vehicle supports a feature to reset the display computer by holding the play/pause button for approximately 45 seconds. When executed the center console display as well as the speedometer display over the steering wheel reset and go blank for up to 1 minute. The safety issue is that this function can be performed while the vehicle is in motion. This leaves the speedometer inoperable until the reset completes. This poses an extreme safety hazard as the driver has no way to assess current speed. I'm able to reproduce this on the latest OTA software update 1.3.18.

NHTSA ID

11693256

Incident

Oct 13, 2025

I experienced a serious safety issue with my 2025 Volvo EX90 around 1:15 PM on October 7, 2025. It was drizzling at the time. I had stopped in front of an ATM to deposit and withdraw money. After finishing, when I released the brake pedal to leave, the vehicle suddenly accelerated forward on its own, much faster than normal creeping speed. I had to keep pressing the brake pedal to control the car. I used intermittent braking to steer it around and managed to park it safely. After shifting into Park (P), I restarted the vehicle’s system, but the issue did not go away. Only after I parked, locked the car, and came back later did it return to normal. I shared my experience on Reddit to see if other owners had similar incidents, and several reported the same issue. I am very concerned that this could happen again, as it poses a serious safety risk if it occurs in traffic or near pedestrians.

NHTSA ID

11692870

Incident

Oct 7, 2025

The vehicle has exhibited unexpected braking without any apparent external trigger, posing a safety risk. Most troubling, we have now had a third incident of the seatbelt pre-tensioning unexpectedly and forcefully, which caused my wife several days of lower abdominal discomfort. The most recent episode happened while parking at low speed. These experiences have undermined our trust in the vehicle’s safety systems.

NHTSA ID

11691630

Incident

Oct 3, 2025

The screen behind the steering wheel, which provides the car's speed, driver assist, warning lights, turn signals, and other driving information suddenly went blank. I was grateful that I was close to home and no longer on the interstate highway I had just exited. I drove home, reset the car, and the screen was back on. I was lucky. I could have been at the beginning on my drive, over a hundred miles from home and unable to easily exit the highway. The car is being towed today back to the dealer, again. This happened without warning. I was driving and the whole screen just went black.

NHTSA ID

11675323

Incident

Jul 19, 2025

Lane keeping sensors periodically fault and Volvo's solution is to reboot the vehicle

NHTSA ID

11673486

Incident

Jul 10, 2025

Drivers display with vehicle speed and ADAS state goes blank while driving resulting in inability to see current speed or ADAS speed set point. After rebooting the system as previously advised by Volvo, the ADAS speed set point showed "00" while maintaining a speed of 70mph

NHTSA ID

11673483

Incident

Jun 30, 2025

The vehicle gear selector had reverse (R) selected and pressing the accelerator pedal caused the vehicle to drive forwards. This appears to have been a result of enabling the "one pedal drive" function from the infotainment display while the gear selector was already in reverse. The mismatch of selected / indicated direction vs the resulting direction is a safety issue

NHTSA ID

11673479

Incident

Jul 14, 2025

Vehicle: 2024 Volvo EX90 VIN: [XXX] While driving on the highway, the entire digital instrument cluster and infotainment screen went completely black without warning. I could not see my speed, gear indicator, or use turn signals. This created an immediate and dangerous safety hazard, especially at high speed. The issue has occurred more than once, and despite taking the vehicle to the dealership, it has not been permanently resolved. I have filed a California Lemon Law claim with Volvo, and while Volvo acknowledged the defect and promised a buyback on March 18, 2025, they have failed to follow through or provide a resolution for over two weeks. I am submitting this complaint because the vehicle presents an active safety risk to myself and others, and I am concerned that this defect could result in a serious accident or injury if not addressed immediately. I also have video evidence of the blackout event. I am requesting that NHTSA open an investigation into this issue and hold the manufacturer accountable for failing to address a known safety defect in a timely manner. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11651941

Incident

Feb 20, 2025

I was on the 101 freeway on January 20, 2025. I was driving on the far left lane, driving 72-65 miles an hour. The 2025 Volvo EX90 suddenly wouldn't accelerate more than 36 mph. A turtle error came on the screen. "Driving Performance Reduced Drive with Caution Book a Service" message displayed. Due to the car suddenly slowing down, we almost were read ended by a truck. I have kids in the car. This car had multiple faults. I had the car serviced on 01/20/25 and received it back from the dealer on 01/28/25. After, receiving the car two days later, now the SOS fault System light turned on, and now the Air Bag Fault Light is on. I do have a video of the incident on the freeway when the car started slowing down and the error messages.

NHTSA ID

11640499

Incident

Jan 20, 2025

On Saturday, [XXX], I drove from Woodbridge, VA to Fairfax, VA without any issues or error messages. Car was parked and locked for approximately 2 1/4 hours. When I came back out to the car and opened the door, the display behind the steering wheel stated "System communication fault. Pilot Assist deactivated. Find a place to stop and select P to park. When parked, the system will reset." I followed the directions as specified in my parking spot without any change. I moved the car to another location in the parking lot and repeated the process as directed without any change. I then got out of the car, locked the car, walked away from the car so that I was well out of range of the car, and then came back to the car. Despite these efforts, when I unlocked the car with my Key Tag and got back in, I was not able to get the message to clear. This resulted in the following issues: (a) No speedometer on the display or in the HUD; (b) No green graphic for the turn signals to indicate that they were working; (c) No display of information concerning cruise control, headlight function or windshield wiper settings; (d) Speed limit sign reading in HUD was stuck on 25 mph even though I was driving on roads with higher speed limits (e.g., [XXX] - 45 mph and [XXX] - 55 mph); and (e) Center stack stated "1 serious issue detected - Emergency Call System fault - book a service". The car was driven this way from Fairfax, VA to the Service Department of the Volvo dealership with no change and when I left, the cluster behind the steering wheel and the center stack were still in the same condition. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11634197

Incident

Jan 4, 2025

At 164 miles on the odometer, I had the following issues: a. Received a message that the active high beam was not available and that it would be necessary to run the wipers to clean the front camera. I ran the wipers with washer fluid to clear the camera as instructed, but it did not clear the error message during the drive cycle; b. Car has Driver Support System Fault; and c. Car has Lane Keeping Aid Fault later in drive cycle which turned off the lane keeping aid function. Car was taken to dealership on 12/23/2024 and returned to me on 1/2/2025.

NHTSA ID

11634143

Incident

Dec 22, 2024