2007 Volvo S40 Owner Complaints

ON OR ABOUT 12/04/2019 DURING A FLASH RAIN STORM LAST WINTER, MY HUSBAND AND I WAS HEADED HOME ON THE 215 FWY NORTHBOUND IN SAN BERNARDINO, CA WHEN THE CENTER DOME AREA AND THE ELECTRIC SUNROOF INSIDE OUR CAR BEGIN POURING IN HUGE AMOUNTS OF VERY COLD RAIN WATER ON US AND ON THE DASHBOARD, STEREO CONSOLE, GEAR SHIFTER, FLOOR AND SEATS. UNTIL IT WAS SAFE TO EXIT THE FREEWAY, MY HUSBAND TRIED TO SOAK UP AS MUCH OF THE LEAKING RAINWATER AS HE COULD WITH HIS COAT BUT THE WATER CONTINUED TO POURING INTO THE CAR. ONCE IT WAS SAFE TO EXIT THE FREEWAY, WE PULLED INTO A GAS STATION AND EXAMINE THE SUNROOF TO MAKE SURE IT WAS SHUT PROPERLY, WHICH IT WAS, NOT UNDERSTANDING WHY THIS WAS HAPPENING, HE AND I USED AS MANY PIECES OF NAPKINS AND CLOTH THAT WE COULD FIND TO SOP UP AS MUCH WATER AS WE COULD AND AS BEST AS WE COULD. WE DROVE ON THE STREETS THE REMAINING FEW MILES TO GET HOME BECAUSE IT WAS MUCH SAFER TO DO SO AT THIS POINT. LATER, WE RESEARCHED AS MUCH AS WE COULD FIND OUT ABOUT THE PROBLEM VIA ONLINE COMPLAINTS AND REVIEWS FROM OTHER VOLVO OWNERS. WE THEN TRIED ONE OF THE FIXES OFFERED: CLEARING POTENTIAL DEBRIS FROM THE SUNROOF DRAIN HOSES. HOWEVER, WHEN WE TOOK THE CAR TO A DRIVE-THRU CARWASH SHORTLY AFTERWARDS, THE EXACT SAME THING HAPPEN. WE ARE LOOKING FORWARD TO SELLING THE VOLVO, BUT DUE TO THE LEAKY CENTER DOME AND SUNROOF, THERE IS NO WAY WE WILL CONSIDER SELLING THE CAR WITHOUT DISCLOSING THIS SAFETY ISSUE TO THE NEXT BUYER, EVEN THOUGH WHEN WE PURCHASED THE CAR IN 2013, THE DEALER WHO SOLD IT TO US DID NOT TELL US ABOUT THE SAFETY DEFECT. UNDOUBTEDLY, IF CAUGHT OFF GUARD WHILE DRIVING (I.E. WITHOUT A PASSENGER'S HELPING HAND), NOT KNOWING ABOUT THE DEFECT MAY RESULT IN A MAJOR ACCIDENT OR FATALITY. PLEASE HELP!!!

NHTSA ID

11360366

Incident

Dec 2, 2019

Mileage

99,000 mi

I WAS DRIVING AND THE ENGINE SHUT OFF CAUSING ME TO LOSE CONTROL OF MY VEHICLE AS THE POWER STEERING SHUT DOWN. I WAS ABLE TO STEER MY VEHICLE WITH DIFFICULTY TO THE SIDE OF THE ROAD WHERE IT STOPPED. ABOUT ONE WEEK LATER THIS HAPPENED AGAIN. THIS TIME I WAS COMING OUT OF A PARKING LOT AND HAD TO AIM MY VEHICLE IN A WAY TO AVOID HITTING OTHER VEHICLES. BOTH TIME, AFTER A FEW MINUTES THE CAR STARTED RIGHT UP AND I WAS ABLE TO DRIVE AGAIN. LAST FRIDAY, MAY 3, I PULLED MY VEHICLE OVER AND WHEN I STOPPED THE VEHICLE SHUT DOWN. THIS TIME IT DID NOT RESTART. THE ERROR MESSAGE DISPLAYED ON THE DASH WAS THAT THE "STEERING WAS LOCKED, TRY AGAIN." AFTER SEVERAL ATTEMPTS INCLUDING JUMP STARTING THE VEHICLE, WHICH WAS UNNECESSARY, THE VEHICLE WOULD NOT START. I HAD MY VEHICLE TOWED TO THE NEAREST VOLVO DEALERSHIP AND WAS TOLD THAT THE "STEERING COLUMN LOCK" HAD FAILED. THE PART NEEDED TO BE REPLACED AT A COST OF OVER $830.

NHTSA ID

11205749

Incident

May 3, 2019

Mileage

124,000 mi

TL* THE CONTACT OWNED A 2007 VOLVO S40. THE CONTACT CALLED ON BEHALF OF THE DRIVER. THE CONTACT STATED THAT THE VEHICLE WAS STRUCK ON THE FRONT PASSENGER SIDE BY ANOTHER VEHICLE. THE SPEED WAS UNKNOWN. THE AIR BAG FAILED TO DEPLOY AND THE SEAT BELT DETACHED. THE DRIVER SUSTAINED LEG, BACK, AND SHOULDER INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED TO A TOW LOT. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

NHTSA ID

11141465

Incident

Oct 11, 2016

Mileage

60,000 mi

AFTER PARKING CAR AND TURNING CAR OFF, AIRBAG, BRAKE, AND INFORMATION WARNING LIGHTS STAY ON, AS DOES VENTILATION SYSTEM. PASSENGER SEAT HAS EXCESS WATER UNDERNEATH. NOW CAR WILL NOT START.

NHTSA ID

11098954

Incident

May 31, 2018

Mileage

104,000 mi

VEHICLE LOSES POWER DUE TO ACCELERATOR PEDAL LOW VOLTAGE/SIGNAL. THIS OCCURS IN MULTIPLE SITUATIONS. SAFEST IS SHORTLY AFTER STARTING THE CAR AN ENGINE LIGHT STATING 'ENGINE SYSTEM URGENT' APPEARS. UNSAFE OCCURRENCE INCLUDES POWER LOSS WHILE PEDAL IS DEPRESSES SUCH AS ON THE HIGHWAY WITH CONSTANT PRESSURE OR MOST SEVERE WHEN TURNING LEFT THROUGH AN INTERSECTION POWER IS REDUCED TO IDLE. IF THE VENT OCCURS WITH THE PEDAL REPRESSED, POWER IS REDUCED TO IDLE MOMENTARILY (2-3 SECONDS) AND AFTER 'PUMPING' THE PEDAL SEVERAL TIMES IT RETURNS TO NORMAL. I HAVE BROUGHT THIS VEHICLE SEVERAL TIMES TO REPAIR. DEAL CHANGED PEDAL, CHANGED WIRING CONNECTORS (ALSO CLEANED SEVERAL TIMES) AND ULTIMATELY REPLACED ENGINE COMPUTER. PROBLEM STILL OCCURS AND DEALER DOES NOT KNOW WHAT ELSE TO DO. MOST RECENT OCCURRENCE WAS 27 JAN BUT THIS ISSUES APPEARS ABOUT EVERY TWO MONTHS AFTER REPAIR AND OCCURS DAILY ONCE TO PROBLEM RETURNS.

NHTSA ID

10949021

Incident

Jan 30, 2017

Mileage

10 mi

SAFETY CONCERN: 2007 VOLVO S40 ELECTRONIC THROTTLE MODULE FAILURE - CAUSING "REDUCED ENGINE PERFORMANCE" MESSAGE AND VEHICLE (2007 VOLVO S40) SUDDENLY SLOWS DOWN WHILE IN MOTION, LIMPS AND CANNOT GO HIGHER SPEED. HAD BARELY EXITED THE FREEWAY ON 1/24/2017 AND THIS HAPPENED AS I WAS ON RAMP. COULD BE EXTREMELY DANGEROUS IF IT HAPPENED 1 MINUTE BEFORE WHEN ON FREEWAY. TURNED VEHICLE IN RIGHT AWAY TO LOCAL VOLVO DEALERSHIP (WHICH WAS LUCKILY WITHIN 15 MINUTES) AND THEY DIAGNOSED IT TO BE FAULTY ELECTRONIC THROTTLE MODULE NEEDING REPLACEMENT. MILEAGE ON CAR 129,000 MILES. WANTED TO REPORT SO THIS ISSUE CAN BE LOOKED INTO FOR SAFETY CONCERN AND IF THE HUGE COST OF REPLACEMENT CAN BE OFFSET SO OWNERS CAN HAVE PEACE OF MIND REPLACING IT TIMELY IF THERE IS A RECOMMENDATION OR BULLETIN (SIMILAR TO TIMING BELTS ETC. - WHICH I DON'T BELIEVE THERE IS CURRENTLY FOR ELECTRONIC THROTTLE MODULE).

NHTSA ID

10947597

Incident

Jan 24, 2017

Mileage

129,401 mi

TAKATA RECALL SOMETHING IS WRONG WITH THE AIRBAGS. I T IS SHOWING ME THAT IT NEEDS TO BE REPAIRED.

NHTSA ID

10887948

Incident

Jun 1, 2016

TL* THE CONTACT OWNS A 2007 VOLVO S40. WHILE DRIVING, THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE PVC VALVE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 117,000.

NHTSA ID

10758733

Incident

Aug 17, 2015

Mileage

117,000 mi

MY CAR WOULD NOT START BECAUSE THERE WAS A MESSAGE INDICATING THE STEERING WHEEL WAS LOCKED, BUT, IT WAS NOT LOCKED. I HAD TO TOW THE CAR TO THE SHOP. THEY REPORTED A DEFECTIVE STEERING COLUMN LOCK MODULE. I FOUND THIS IS A COMMON PROBLEM FOR THIS CARS WHICH IS TOTALLY UNSAFE AND UNACCEPTABLE.

NHTSA ID

10745158

Incident

Jul 15, 2015

Mileage

51,104 mi

THE COOLING SYSTEM AND DEFROST SHUT DOWN AFTER DRIVING FOR A WHILE. TURNS OUT THE CLUTCH WENT BAD ON THE COMPRESSOR. AFTER RESEARCHING FURTHER ONLINE, THERE ARE MANY COMPLAINTS ABOUT THIS FAILURE. UNFORTUNATELY, THIS IS A VERY EXPENSIVE REPAIR THAT I CANNOT AFFORD. *TR

NHTSA ID

10662337

Incident

Mar 13, 2012

TL* THE CONTACT OWNS A 2007 VOLVO S40. THE CONTACT STATED THAT THE BRAKE SENSOR ILLUMINATED INDICATING LOW BRAKE FLUID. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE TECHNICIAN REPLENISHED THE BRAKE FLUID AND RESET THE BRAKE SENSOR. THE CONTACT INDICATED THAT SHORTLY AFTER THE BRAKE SENSOR WAS RESET BY THE DEALER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHO WAS NOT ABLE TO REPLICATE OR DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V101000 (BRAKES). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

NHTSA ID

10648903

Incident

May 9, 2014

Mileage

65,000 mi

SUNROOF DRAIN BECAME CLOGGED. THIS CAUSED THE POORLY DESIGNED DRAINS TO LEAK AT A JUNCTION INSIDE THE VEHICLE ALONG THE DOOR PILLAR AND BEHIND THE INSTRUMENT PANEL. THE WATER COLLECTS ON THE REAR PASSENGER FLOORBOARDS AND AROUND THE DRIVERS SEAT. THE CAR OWNER IS UNAWARE OF THE LEAK UNTIL A LARGE AMOUNT OF WATER HAS ACCUMULATED. I AM VERY CONCERNED ABOUT THE POTENTIAL FOR AN ELECTRICAL FAULT OR SHORT CIRCUIT THAT COULD POTENTIALLY RESULT IN A FIRE, MALFUNCTION OR COULD LEAD TO AN ACCIDENT. VOLVO SHOULD MAKE CHECKING THESE DRAINS A REGULAR PART OF IT'S SERVICE PROCEDURES OR CONSIDER A REDESIGN OR RECALL. THIS ISSUE IS WIDESPREAD. *TR

NHTSA ID

10648861

Incident

Oct 1, 2014

Mileage

54,000 mi

MICHELIN PRIMACY MXV4 TIRES - DRY ROT ON ALL 4 TIRES AFTER ONLY 20,000 MILES. THE WARRANTY IS FOR 60,000 MILES. THIS DRY ROT IS A HUGE SAFETY CONCERN. *TR

NHTSA ID

10551644

Incident

Nov 9, 2013

Mileage

55,000 mi

12/9/2011 WHILE ON AN INCLINE DRIVING AT APPROXIMATELY 25 MPH BRAKES FAILED, EVEN AFTER PRESSING PEDAL ALL THE WAY TO THE FLOOR, CAR FAILED TO STOP CAUSING COLLISION WITH VEHICLE IN FRONT DESPITE MORE THAN NECESSARY BRAKING DISTANCE MAINTAINED BETWEEN TWO VEHICLES AND UNDER CLEAR, SUNNY CONDITIONS. NOTE: DEALER HAD COMPLETED 10-POINT INSPECTION DURING OIL CHANGE 14 DAYS BEFORE OCCURRENCE. 8/2011 CAR FLOODED WITH WATER INTERNALLY AND ON FLOOR/CARPET. SECOND OCCURRENCE. SUNROOF DRAIN PIPES REPLACED AND CAR SEATS, CARPETS, FOAM PADDING REMOVED AND DRIED. OWNER REQUIRED TO PAY 50% OF COST OF LABOR AND PARTS, EVEN THOUGH WAS TO HAVE BEEN REPAIRED IN 2/2011.2/2011 FIRST INCIDENT OF CAR FLOOD WITH WATER INTERNALLY AND ON FLOOR/CARPET. SUNROOF REPLACED AND CAR SEATS, CARPETS, FOAM PADDING REMOVED AND DRIED. SUNROOF REPLACED BY VOLVO, OWNER INCURRED LABOR COSTS. WARRANTY EXPIRED 2 MONTHS AND 1 WEEK BEFORE TAKEN IN. CAR HAD UNDERGONE 22500 MILE CHECK WITH NOTHING NOTICED BY VOLVO WHILE UNDER WARRANTY! REGULAR MAINTENANCE WAS DONE AT DEALERS AT RECOMMENDED SCHEDULE AND DEALER PERFORMED STATE-REQUIRED SAFETY AND EMISSION INSPECTIONS. *TR

NHTSA ID

10439260

Incident

Dec 9, 2011

Mileage

23,000 mi

I OWN A '07 VOLVO S40 WITH 78,000 MILES. IT BEGAN MAKING A LOUD WHISTLING NOISE COMING FROM THE OIL DIPSTICK. AFTER RESEARCHING ONLINE I FOUND THAT IT WAS A KNOWN PROBLEM BY VOLVO AND THE DEFECTIVE PART IS COVERED UNDER AN EXTENDED WARRANTY, HOWEVER THIS DEFECTIVE PART CAUSES EXCESSIVE DAMAGE TO THE ENGINE THAT IS NOT COVERED BY VOLVO. IT IS NOW UP TO THE CONSUMER TO PAY FOR THE ENGINE DAMAGE OR IT WILL CAUSE THE TIMING BELT TO SNAP AND THE ENGINE TO EXPLODE. AN UNSUSPECTING CONSUMER CAN BE FATALLY INJURED BY THIS PROBLEM AND SOMETHING MUST BE DONE ABOUT IT! *KB

NHTSA ID

10437709

Incident

Nov 14, 2011

Mileage

78,000 mi

TL* THE CONTACT OWNS A 2007 VOLVO S40. THE CONTACT STATED WHILE DRIVING 30 MPH, SHE APPLIED THE BRAKES AND A BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS LEAKING BRAKE FLUID. BRAKE FLUID WAS ADDED TO THE VEHICLE AS A TEMPORARY REMEDY. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED NHTSA CAMPAIGN ID NUMBER 08V101000 (SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 76,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10430628

Incident

Oct 14, 2011

Mileage

76,000 mi

2007 VOLVO S-40. CONSUMER WRITES REGARDING A SEAT BELT DEFECT AFTER SUFFERING AN INJURY TO THE EYE DUE TO A REAR END COLLISION *TGW THE CONSUMER STATED HE WAS STRUCK FROM THE REAR WHILE STOPPED YIELDING TO TRAFFIC. THE CONSUMER STATED HE AND HIS WIFE WERE HIT WITH SUCH FORCE THAT THE VEHICLE ROLLED APPROXIMATELY 25 FEET FROM WHERE THEY WERE ORIGINALLY STOPPED. THE DRIVER'S SIDE SEAT BELT DID NOT RETRAIN THE CONSUMERS UPPER BODY WHICH ALLOWED HIS TORSO TO GO FORWARD; CONSEQUENTLY, HIS HEAD STRUCK THE LEFT WINDSHIELD PILLAR. FROM THE IMPACT OF HIS HEAD STRIKING THE WINDSHIELD PILLAR, HIS UPPER EYE LID WAS LACERATED BY THE FRAME OF HIS EYEGLASSES AND SEVERELY BRUISED HIS EYE AS A RESULT. THE CONSUMERS WIFE SUSTAINED WHIPLASH. *JB

NHTSA ID

10381951

Incident

Dec 1, 2010

TL*THE CONTACT OWNS A 2007 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH THE BRAKES FAILED CAUSING HER TO CRASH INTO THE REAR OF A VEHICLE. THE DRIVER SUSTAINED MINOR INJURIES, WHIPLASH AND WAS NOT TRANSPORTED TO THE HOSPITAL. A POLICE REPORT WAS FILED. THE VEHICLE WAS INSPECTED BY AN INSURANCE ADJUSTER WHO CONFIRMED THAT IT WAS DESTROYED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 63,000.

NHTSA ID

10378807

Incident

Jan 18, 2011

Mileage

63,000 mi

I PARKED THE 2007 S40 VOLVO AND CAN'T REMOVE THE KEY FROM THE IGNITION SWITCH. THE CAR IS IN PARK, BRAKE ON, ALL NECESSARY CHECKS ARE CHECKED. STILL CAN'T GET THE KEY TO RELEASE, HAD TO TURN IT SEVERAL TIMES (30 MINUTES) RIGHT TO LEFT UNTIL I HEARD A CLICK AND THE KEY CAME OUT. I HAVE SEEM POST ON THE INTERNET ABOUT THIS AND THAT IS HOW I FIGURED OUT HOW TO GET MY KEY AND LOCK THE DOORS. I CALLED VOLVO AND THE RESPONSE WAS GO TO THE DEALER AND YOU ARE OUT OF WARRANTY?! THE KEY WILL NOT GO PAST THE I POSITION. I DON'T MIND PAYING TO GET IT FIXED BUT ACCORDING TO THE VOLVO MAKERS IT IS ISOLATED AND NOT KNOWN HOW TO FIX. I BEG TO DIFFER BASED ON TALKING TO OTHER OWNERS AND THE INFO ON THE WEB. PLEASE ASSIST AS MUCH AS POSSIBLE OR A DIRECTION TO GET RESOLUTION. *TR

NHTSA ID

10312587

Incident

Feb 16, 2010

Mileage

70,004 mi

I DROVE INTO A HOTEL PARKING GARAGE , CAME INTO MY SPOT AND THE CAR ACCELERATED AND WENT INTO A WALL. I SHUT THE ENGINE OFF TO PREVENT MY WHOLE CAR GOING THRU THE WALL. JUST THE FRONT OF THE CAR WENT INTO THE WALL. *TR

NHTSA ID

10312385

Incident

Jan 29, 2010

Mileage

35,000 mi

ON JUNE 28, 2008, MY GARAGE DOOR CAME DOWN ON MY 2007 VOLVO S40 SEDAN, WITHOUT WARNING, CAUSING DAMAGE TO THE ROOF OF THE CAR (EST. $2000.00) AS WELL AS IRREPARABLE DAMAGE TO THE GARAGE DOOR (REPLACED AT A COST OF $1150.00). A TECHNICIAN FROM GENIE (MFG OF GARAGE DOOR OPENER) THOROUGHLY INSPECTED AND TESTED THE OPENER ON JUNE 30, 2008, AND FOUND THE UNIT TO BE WORKING PROPERLY. IT WAS DISCOVERED THAT THE ACTION OF UNLOCKING AND LOCKING THE CAR DOORS WITH THE REMOTE AS WELL AS STARTING THE IGNITION OF THE CAR CAUSED THE GARAGE DOOR TO OPEN AND CLOSE WITHOUT WARNING. EACH TIME THE CAR REMOTE WAS PRESSED, IT TRANSMITTED TO THE GARAGE DOOR OPENER. AFTER DE PROGRAMMING THE HOMELINK IN THE CAR, THE SITUATION NO LONGER OCCURRED. I NO LONGER FELT SAFE HAVING THE HOMELINK ACTIVE, AS I DID NOT WANT TO CHANCE FURTHER VEHICLE DAMAGE OR BODILY HARM. THE PROBLEM WAS CLEARLY A TRANSMITTER/ELECTRICAL PROBLEM WITH THE CAR REMOTE/HOMELINK. I CONTACTED VOLVO ON JUNE 30, WHO ASSIGNED A FIELD REPRESENTATIVE TO INSPECT THE CAR AT A LOCAL VOLVO DEALERSHIP ON JULY 9, 2008. I HAD REQUESTED THEY COME TO MY HOME TO WITNESS THE PROBLEM, BUT THAT REQUEST WAS DENIED. ON JULY 10, 2008 THE PRODUCT INVESTIGATION COORDINATOR FROM VOLVO INFORMED ME THAT THE FINDINGS OF THE FIELD REPRESENTATIVE SHOWED NO OPERATIONAL ISSUES, THEREFORE, IT WAS NOT A VOLVO PROBLEM. I HAVE TRIED CONTACTING HOMELINK, TO NO AVAIL. NOTHING HAS BEEN DONE TO CORRECT THE MALFUNCTION, NOR HAVE I RECEIVED ANY COMPENSATION FOR DAMAGE CAUSED BY THIS MALFUNCTION. *TR

NHTSA ID

10233973

Incident

Jun 28, 2008

Mileage

9,500 mi

TL*THE CONTACT OWNS A 2007 VOLVO S40. THE CONTACT STATED THAT HER VEHICLE FEELS AS IF IT WERE DOWNSHIFTING; HOWEVER, IT HAS AN AUTOMATIC TRANSMISSION. WHEN SHE BEGINS TO ACCELERATE, THE REDUCED ENGINE PERFORMANCE LIGHT ILLUMINATES WHEN THE DOWNSHIFTING OCCURS. THE DEALER REPLACED THE ACCELERATOR PEDAL AND CLEANED THE COMPUTER AFTER THE FIRST FAILURE. AFTER THE SECOND FAILURE, THEY REPLACED THE COMPUTER. THE FAILURES STILL PERSIST AND THE CONTACT IS SCHEDULED TO TAKE THE VEHICLE TO THE DEALER NEXT WEEK. THE SPEED WAS UNKNOWN. THE FAILURE MILEAGE WAS 3,000.

NHTSA ID

10226473

Incident

Feb 1, 2007

Mileage

3,000 mi

THE REAR BRAKES ON THIS VEHICLE CAUGHT ON FIRE AFTER A SHORT DRIVE (1 MILE) HAVING TO BE EXTINGUISHED WITH A FIRE EXTINGUISHER. THE REAR BRAKE ASSEMBLY (LEFT REAR) COMPLETELY FAILED AND OVERHEATED TO THE POINT OF CAUSING FLAMES TO APPEAR NEEDING TO BE EXTINGUISHED. THIS CAR HAD 2939 MILES ON IT AS A NEW VOLVO S40. THIS CATASTROPHIC FAILURE WAS UNEXPLAINED AND WITHOUT AN APPARENT ERROR BY DRIVER AS THIS VEHICLE IS USED BY A COLLEGE STUDENT FOR VERY SHORT DISTANCES. THE EMERGENCY BRAKE WAS NOT LEFT ON. *TR

NHTSA ID

10208681

Incident

Oct 12, 2007

Mileage

2,939 mi

TL*THE CONTACT OWNS A 2007 VOLVO S40. THE CONTACT HAS RECENTLY RENTED THREE ZIP-CARS WITHIN THE PAST FEW MONTHS AND HAS DETECTED AN UNUSUAL SCENT COMING FROM THE VENTS. THE PANTS HE HAD HANGING INSIDE THE VEHICLE HAD A FAINT SMELL TO THEM ONCE HE ARRIVED HOME. HE BELIEVES THERE COULD BE ASBESTOS INSIDE THE VEHICLES. THE DEALER AND MANUFACTURER HAVE NOT BEEN NOTIFIED. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 40.

NHTSA ID

10196172

Incident

Jun 1, 2007

Mileage

40 mi

ON MY BRAND NEW S-40 VOLVO WITH A MANUAL 5 SPEED TRANSMISSION OPERATING THE CLUTCH PEDAL TO BE FULLY DEPRESSED TO THE FLOOR CAN BE OBSTRUCTED EASILY BY AN ADJACENT PROTRUDING PANEL ON THE FLOOR BOARD. WHEN MY LEFT FOOT IS BLOCKED BY THIS PROTRUDING PANEL, I AM INHIBITED FROM SHIFTING GEARS. THIS CONDITION IS VERY DANGEROUS IN HEAVY TRAFFIC. VOLVO CUSTOMER SERVICE HAS BEEN ADVISED OF THIS PROBLEM AND HAS REFUSED TO ACKNOWLEDGE IT AS A DEFECT. VOLVO HAS REFUSED TO PROVIDE A SIMPLE SOLUTION TO THE PROBLEM BY SUPPLYING A PROPERLY FORMED CLUTCH LEVER THAT POSITIONS THE CLUTCH PEDAL FAR ENOUGH AWAY FROM THE PROTRUDING PANEL FOR CONSISTENTLY PROPER DEPRESSION OF THE CLUTCH DURING SHIFTING. *JB

NHTSA ID

10178369

Incident

Jan 3, 2007

Mileage

400 mi