1999 Volvo S80 Engine Problems

The ETM is acting up for no reason available

NHTSA ID

11427306

Incident

Jul 23, 2021

WHILE WE WERE TRY I G TO REPAIR THIS VEHICLE WE WERE TEST DRIVING IT A D CAME TO A FULL STOP AT A STOPLIGHT SIGNAL AND COULD NOT DOWNSHIFT VEHICLE INTO 1ST GEAR FROM A STOP AFTER THE VEHICLE WAS AT NORMAL RUNNING TEMPERATURE. CAUSING IT TO GO I TO A LIMP HOME MODE. SO WHILE WE WERE DRIVING WE NOTICED THAT THE FLOOR WAS SATURATED WITH ANTIFREEZE AND A SWEET ODOR FROM THE VENTS WAS NOTICED WITH A SMOKE . WE SERVICED THE TRANSMISSION WITHOUT SUCCESS . ALSO NOTICED AN NO OIL PRESSURE READ ON DASH ONLY WHEN WE WERE NOT IN ACCELERATION. THIS DISAPPEAR WHEN UPON ACCELERATION AND RETURNED WHEN IDLING. WE SERVICED THE OIL FILTER THE FLUIDS PERFORMED A MOTOR FLUSH FIRST AND REPLACED THE OIL PRESSURE SWITCH. WITHOUT SUCCESSFUL REPAIRS AND CONTINUE OF THE CODE RETURNS AFTER PERFORMING A DRIVE CYCLE NUMEROUS TIMES. WE ARE CONVINCED THIS IS CAUSED BY THE RECALL #R155. THANK YOU FOR HELP IN REPAIRING THIS ISSUE UNDER THE NHTSA RECALL#06V441000. *TR

NHTSA ID

10823300

Incident

Jan 19, 2016

Mileage

143,000 mi

TL* THE CONTACT OWNS A 1999 VOLVO S80. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30 MPH, THE VEHICLE BEGAN TO OPERATE ROUGHLY AND THE ENGINE STALLED WITHOUT WARNING. AFTER FIFTEEN MINUTES, THE VEHICLE RESTARTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN 2007, THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 06V441000 (VEHICLE SPEED CONTROL) HOWEVER, THE FAILURE RECURRED EIGHT YEARS LATER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ID

10820242

Incident

Jun 3, 2014

I'VE HAD THIS PROBLEM FOR MONTHS NOW. THE CAR SHUTS DOWN AND WON'T RESTART! I BEEN TAKING OFF THE BATTERY AND LETTING IT SIT OVER NIGHT, THEN PUTTING CABLES BACK ON TO GET IT TO RESTART! TODAY I DROVE IT FOR A MILE AND PARKED IT AND WHILE IT WAS RUNNING IT SHUT DOWN AGAIN! MOST OF THE TIME IT SHUTS DOWN WHEN I'M DRIVING AND I LOSE BRAKE CONTROL! *TR

NHTSA ID

10558799

Incident

Jan 6, 2014

Mileage

97,000 mi

TL* THE CONTACT OWNS A 1999 VOLVO S80. THE CONTACT STATED THAT AS THE VEHICLE WAS BEING STARTED, A STRONG BURNING ODOR BEGAN TO CIRCULATE INSIDE OF THE VEHICLE. IMMEDIATELY, THE CONTACT EXITED THE VEHICLE AND NOTICED FLAMES EMITTING FROM THE EXHAUST PIPE. THE CONTACT THEN EXTINGUISHED THE FLAMES. THE VEHICLE HAD BEEN REPAIRED FOUR TIMES PRIOR TO THE RECENT FIRE FOR A SEVERE OIL LEAK. THE TURBO OIL TRAP PCV WAS REPLACED EACH TIME. THE REPAIRS WERE PERFORMED BY AN AUTHORIZED DEALER. THE CONTACT ALSO REPLACED THE PART HIMSELF. THE VEHICLE HAD NOT BEEN REPAIRED FOR THE MOST RECENT FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

NHTSA ID

10473816

Incident

Aug 14, 2003

Mileage

65,000 mi

TL* THE CONTACT OWNS A 1999 VOLVO S80. THE CONTACT STATED THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS FOR THE FAILURE. THE DEALER REPLACED THE BATTERY AND THE WIRING HARNESS BUT TO NO AVAIL. THE FAILURE MILEAGE WAS 186,585 AND THE CURRENT MILEAGE WAS 187, 642.

NHTSA ID

10411937

Incident

Jun 6, 2011

Mileage

186,585 mi

TL*THE CONTACT OWNS A 1999 VOLVO S80. WHILE ACCELERATING FROM A STOP, THE CONTACT FELT A THUMP FROM THE DRIVER SIDE WHEEL. THE FAILURE OCCURRED WHENEVER SHE ACCELERATED FROM A STOP OR DECELERATED. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE INSULATION SURROUNDING THE WIRES IN THE ENGINE COMPARTMENT WERE DEGRADED. THE VEHICLE ALSO DISPLAYED DIFFICULTY WHEN SHIFTING INTO FOURTH GEAR. WHILE DRIVING APPROXIMATELY 70 MPH, THE CONTACT COULD NOT SHIFT OUT OF THIRD GEAR AFTER ATTEMPTING TO ACCELERATE FROM 40 MPH. THE FAILURE OCCURRED INTERMITTENTLY AND THE CHECK ENGINE LIGHT BEGAN TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN RECALLS 00V238000 (SUSPENSION: FRONT: CONTROL ARM: UPPER BALL JOINT), 02V096000 (ENGINE AND ENGINE COOLING: COOLING SYSTEM: FAN), AND 06V441000 (VEHICLE SPEED CONTROL). THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 78,600 AND THE CURRENT MILEAGE WAS APPROXIMATELY 79,100.

NHTSA ID

10366607

Incident

Nov 1, 2010

Mileage

78,600 mi

I JUST PURCHASED A USED 99 VOLVO, I AM A MOM OF 4 AND HAD HEARD VOLVO TO BE VERY SAFE RELIABLE CAR. THE CAR RAN GREAT FOR ABOUT 2 DAYS, THEN THE LIGHTS STARTED COMING ON, ENGINE SYSTEM SERVICE REQUIRED, AND THE VEHICLE WOULD ALSO STALL FOR NO REASON. I TOOK IT TO LOCAL VOLVO DEALER, THEY SAY THERE WAS A RECALL ON THE MESSAGE BOARD, BUT IF THE LIGHT CAME ON AGAIN IT WOULD NEED A NEW THROTTLE MODULE, COST OF 1100. I LEFT AND CAME HOME AND DID SOME RESEARCH, I HAVE SINCE FOUND THAT THE ETM HAS BEEN RECALLED ON THAT YEAR VEHICLE AND THEY EXTENDED THE WARRANTY TO 200,000 MILES. I AM VERY DISAPPOINTED IN THE DEALERSHIP THAT THEY WOULD NOT INFORM ME FIRST HAND AND TRY TO CHARGE ME. I HAVE SINCE CONTACTED VOLVO LLC AND AM AWAITING A RESPONSE. I HAVE ALSO LEARNED THAT THE STALLING IS CONSIDERED "LIMP HOME MODE", WHICH IS SUPPOSE TO BE A SAFETY FEATURE, HOWEVER I DID NOT FEEL SAFE WHEN THE VEHICLE DID IT TODAY DRIVING ON I285, IN THE CENTER LANE AT 65 MPH WITH MY 2 YEAR OLD IN THE CAR. AFTER THAT EXPERIENCE I DO NOT THINK I WOULD EVER RECOMMEND A VOLVO TO ANYONE. *TR

NHTSA ID

10286770

Incident

Oct 8, 2009

Mileage

127,500 mi

I WAS DRIVING ON THE HIGHWAY AND I FELT A LOSS OF POWER. I PULLED OVER AND THE CAR SHUT DOWN. I TRIED STARTING IT BUT IT BACKFIRED AND STALLED. IT TOOK ME A WHILE TO FIND OUT WHAT WAS GOING WRONG. FINALLY I UNPLUGGED THE MAF (MASS AIR FLOW SENSOR) AND DROVE BACK HOME WITH AN EXTREMELY WEAK AND DANGEROUS CAR. I DROVE IT LIKE THAT FOR A FEW DAYS. I HAD NO CHOICE BECAUSE I HAD NO OTHER WAY TO GO TO SCHOOL. I CHANGED THE MAF SENSOR BUT IT DIDN'T DO MUCH. I WENT TO A LOCAL SHOP AND HAD THE THROTTLE BODY CLEANED. I COULD NOW DRIVE WITH MY MAF PLUGGED IN BUT IT WOULDN'T DRIVE PROPERLY AND WOULD OCCASIONALLY STALL. I LEARNED THAT VOLVO HAD ALOT OF ETM (ELECTRONIC THROTTLE MODULE/BODY) FAILURES ON THEIR S80'S. SO THEY ISSUED A RECALL THAT THEY APPARENTLY HAVE A HARD TIME RESPECTING. I WENT TO A VOLVO DEALERSHIP (VOLVO LAVAL) ONE OF THE WORST DEALERSHIPS I'VE BEEN THROUGH, BY THE WAY. THE SERVICE MANAGER DIDN'T WANT TO KNOW NOTHING ABOUT MY CAR AND SIMPLY TOLD ME MY WARRANTY WAS OVER (ALTHOUGH IT WAS SUPPOSED TO EXPIRE MAY 26TH, IT WAS ACTUALLY MAY 19TH THAT DAY, SO I HAD A WEEK LEFT). HE DIDN'T WANT TO KNOW NOTHING ABOUT MY SITUATION AND CUT SHORT AND ASKED ME AND MY FRIEND TO LEAVE AFTER INSULTING US. NOW MY CAR STALLS OCCASIONALLY AND HAS A ROUGH IDLE. THE DEALERSHIP DIDN'T EVEN WANT TO DIAGNOSE THE CAR FOR FREE ALTHOUGH IT IS A DESIGN MISTAKE BY VOLVO. I NOW HAVE THE CHOICE OF EITHER SPENDING 1600$+ ON A THROTTLE MODULE OR JUST DRIVE MY CAR AND DEAL WITH THE STALLING. *TR

NHTSA ID

10275217

Incident

Apr 26, 2009

Mileage

178,000 mi

VOLVO 1999 S80 - CAR WENT FROM 60 MPH TO 20 MPH ON FREEWAY. TOLD IT WAS THE ELECTRONIC THROTTLE BODY. ALSO TOLD IT WAS A MONTH OUT OF THE EXTENDED WARRANTY. *TR

NHTSA ID

10268790

Incident

Apr 15, 2009

Mileage

95,000 mi

I OWN AN 1999 VOLVO S80 (T6 TURBO) SEVERAL MONTHS AGO THE CAR DEVELOPED A ROUGH IDLE AND ENGINE SURGE WHEN THE RPMS WERE BELOW ABOUT 1200. I HAVE HAD THE CAR LOOKED AT BY A VOLVO DEALER AND INDEPENDENT MECHANICS. NO ONE HAS FOUND THE PROBLEM. THE ERROR CODES THAT ARE BEING GENERATED ARE INACCURATE. REPLACING THE INDICATED PARTS DOES NOT SOLVE THE PROBLEM. THE MOST DANGEROUS ASPECT OF THIS PROBLEM IS THAT WHEN IN REVERSE THERE IS A SIGNIFICANT ENGINE SURGE AT TIMES. THIS CREATES A VERY UNSAFE SITUATION BECAUSE THE SURGE IS NOT PREDICTABLE. SIGNIFICANTLY INCREASED PRESSURE ON THE BRAKE PEDAL IS REQUIRED TO KEEP THE CAR UNDER CONTROL WHILE IN REVERSE WHEN THIS SURGE OCCURS. I STRONGLY URGE YOU TO INVESTIGATE THIS DEFECT IN THE VOLVO S80 AND TAKE ACTION TO REQUIRE A RECALL OF THESE VEHICLES. *TR

NHTSA ID

10263901

Incident

Mar 24, 2009

TL*THE CONTACT OWNS A 1999 VOLVO S80. WHILE DRIVING 40 MPH, THE VEHICLE BEGAN TO SLOW DOWN AND THE ABS AND ENGINE INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE TROLLIS SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED TWO WEEKS LATER. THE VEHICLE WAS TAKEN TO THE DEALER AGAIN AND THEY STATED THAT THE CENTRAL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER STATED THAT THE VEHICLE NEEDED TO BE TAKEN BACK TO THE DEALER FOR FURTHER INSPECTION. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 97,000. UPDATED 1/8/09 *CN THE BALL JOINT NEEDED TO BE REPLACED, THE HEATING SYSTEM, THROTTLE SYSTEMS, ENGINE COOLING FAN AND THE MASTER CYLINDER ALL FAILED. THE VEHICLE WOULD ACCELERATED ON ITS OWN. THE VEHICLE STALLED ON SEVERAL OCCASIONS. THE STEERING MADE A NOISE WHEN IT WAS TURNED. THE DEALER LUBRICATED THE STEERING. THE DEALER STATED THE VEHICLE NEEDED AN O2 SENSOR. THE IGNITION SWITCH WAS REPLACED. THE INNER TIE RODS WERE REPLACED. 01/14/09. *JB

NHTSA ID

10251514

Incident

Dec 4, 2004

Mileage

60,000 mi

TWIN TURBO HAD TO BE REPLACED IN FEBRUARY 2008. NOT CHEAP. BUT EVER SINCE THEN, THERE HAS BEEN A LACK OF POWER AND VERY SLUGGISH ON TAKE OFF AND WHEN TRYING TO PASS ON THE HIGHWAY. HAD THE CONTROL VALVE REPLACED JUST RECENTLY, HELPED SOME, BUT STILL VERY SLUGGISH. THINK THE VOLVO DEALER HERE HAVE MORONS FOR SERVICE TECH'S. *TR

NHTSA ID

10238674

Incident

Feb 1, 2008

Mileage

103,000 mi

1999 S80 STALLED/SURGED AT 20,000 MILES AT THE TIME. *TS THE CONSUMER STATED WHENEVER THE STALLING OCCURRED, THE CRUISE CONTROL WOULD GO OUT, AND AT HIGHWAY SPEEDS THE ENGINE WOULD START TO RUN IN AN UNEVEN/HESITATION MODE. THE PROBLEM WAS MUCH WORSE AT LOWER SPEEDS. THE DEALER INSTALLED TWO SOFTWARE UPDATES AT DIFFERENT TIMES WHICH DID NOT FIX THE PROBLEM. FINALLY, THE PROBLEM WAS FIXED WHEN THE AIRFLOW SENSOR AND THE ABS CONTROL UNIT WAS REPLACED. *JB

NHTSA ID

10177479

Incident

Dec 1, 2006

DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS (15-75 MPH) ON NORMAL ROAD CONDITIONS WITH THE CRUISE CONTROL ENGAGED AND AFTER AN EXTENDED RIDE FROM 45 TO 90 MINUTES, ALL WARNING LIGHTS ILLUMINATED. THE CRUISE CONTROL DISENGAGED BY IT SELF AND THE ENGINE HESITATED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP TWICE, WHO PERFORMED A NHTSA RECALL #06V41000 WHICH ENTAILED UPGRADING THE CURRENT SOFTWARE. HOWEVER, THE PROBLEM WAS NOT CORRECTED EITHER TIME, THE LURCH/STALL PROBLEM CONTINUED. THE DEALERSHIP AND THE MANUFACTURER COINCIDED THE REPLACEMENT OF THE AIR FLOW CONTROL AND THE ABS CONTROL UNIT WAS NOT COVERED BY THE VEHICLE'S EXTENDED WARRANTY, EVENTHOUGH THOSE REPLACEMENT CORRECTED THE PROBLEM. THE CONTACT WAS VERY CONCERNED BECAUSE THE RECALL DID NOT SOLVE THE DANGEROUS PROBLEM. UPDATED 12/28/2006 - *NM

NHTSA ID

10174461

Incident

Oct 1, 2006

Mileage

20,499 mi

FOR THE PAST YEAR MY CHECK ENGINE AND URGENT LIGHT HAVE BEEN POPPING ON. I HAVE TO GO TO MY MACHANIC (WHO IS VOLVO CERTIFIED) TO HAVE THEM TURN OFF. BUT THE CHECK ENGINE LIGHT COMES ON MORE FREQUENT NOW. FOR THE PAST 6 MONTHS, WHEN I START THE CAR, IT HESITATES AND RUNS ROUGH, LIKE IT IS GOING TO STALL. THE FIRST TIME THIS HAPPENED MY MACHANIC SAID IT NEEDED A TUNE UP. TODAY 10/19/06 I BROUGHT IT TO MY MACANIC AGAIN, AND THEY TOLD ME IT WAS THE THROTTLE MODULE AND THE 1999 S80 'S ARE HAVING ALL THE SAME PROBLEMS, AND THAT I NEED TO TAKE IT TO AN AUTHORIZED DEALER, BEFORE IT GETS WORSE. *NM

NHTSA ID

10171355

Incident

May 14, 2006

TRANSMISSION PROBLEMS CAUSING DANGEROUS DRIVING CONDITIONS. THE TRANSMISSION SLIPS WHEN GOING BETWEEN 2ND AND 3RD. ALSO HAD ISSUES WITH THE ENGINE GOING TO 700 RPMS WHEN GOING 65 MPH. THIS IS JUST ONE OF THE MANY PROBLEMS. THE SOLENOID WENT OUT IN THE TRANSMISSION ABOUT 13000 MILES AGO. CURRENTLY I HAVE THREE DIFFERENT ERROR CODES "TRANSMISSION SERVICE URGENT", LOW OIL PRESSURE STOP ENGINE ASAP", AND "EMISSION SERVICE REQUIRED". I HAVE READ MANY OTHER PEOPLE HAVE THE SAME PROBLEMS I HAVE HAD. NM

NHTSA ID

10158043

Incident

Jan 10, 2006

Mileage

75,000 mi

1999 VOLVO S80 T6 3/08/06 REPLACED TRANSMISSION ( 75,000 MILES) ( $4,800) 08/05 REPLACE RADIATOR 08/05 REPLACED ETM 04 - REPLACED FRONT SUSPENSION / SWAY BARS / STRUTS/ ETC.. VOLVO UNDER ENGINEERED THE FRONT END OF THIS CAR AND IF YOU GO TO WEB BLOGS IT IS IN ALMOST EVERY 1999 - 2000 S-80 VEHICLE... ITS DISGUSTING THAT THIS CAR IS ALLOWED TO CONTINUE OR FORD/ VOLVO ISN'T HELD LIABLE...*JB

NHTSA ID

10152819

Incident

Mar 13, 2006

DT*: THE CONTACT STATED THE ABS, TRACTION CONTROL, CHECK ENGINE, AND TOTAL BRAKE FAILURE LIGHTS ILLUMINATE AT DIFFERENT TIMES. THERE IS A NOISE THAT SOUNDS AS IF THE ABS IS ACTIVATING. THE VEHICLE HAS NOT BEEN SEEN BY THE DEALERSHIP OR AN INDEPENDENT REPAIR SHOP. *NM

NHTSA ID

10147731

Incident

Jan 13, 2006

Mileage

70,000 mi

ENGINE MISS FIRING AND EMISSION LIGHT ON. LATER ENGINE RUNNING GOOD BUT CRUISE CONTROL WOULD NOT WORK AND TEXT MESSAGE 'ENGINE SYSTEM FIX NEXT SERVICE' WITH ORANGE WARNING LIGHT ON. TOOK TO VOLVO DEALER AND THEY REPLACED THE ETM FOR NO CHARGE. THEY KEPT THE OLD PART BECAUSE THEY HAD REPLACED THE ORIGINAL ONE. *NM

NHTSA ID

10141529

Incident

Sep 29, 2005

Mileage

64,000 mi

DT:THE CONTACT OWNS A VOLVO S80 VEHICLE. IT INTERMITTENTLY STALLED/ DIED, AND LOST POWER. THE ELECTRONIC THROTTLE MODULE FAILED AND WAS CLEANED THREE TIMES. *AK THE LINE SEAL AND GASKET WERE REPLACED DUE TO AN OIL LEAK. THE TOP ENGINE TORQUE ARM WAS CRACKED. *JB

NHTSA ID

10132993

Incident

Feb 14, 2003

Mileage

53,000 mi

ON SEPTEMBER 10, 2005 AT APPROXIMATELY 2:30 PM, MY ENGINE ABRUPTLY STALLED WHILE TRAVELING AT HIGHWAY SPEEDS WITH CRUISE CONTROL ENGAGED. I PULLED THE CAR OFF TO THE SIDE OF THE ROAD. IT WOULD NOT RESTART. UPON EACH ATTEMPT TO RESTART, THE ENGINE WOULD ACTUALLY RUN ROUGHLY FOR 1-2 SECONDS AND THEN STALL. I HAD THE CAR TOWED ABOUT 35 MILES TO MY VOLVO DEALER. WHEN IT ARRIVED, IT STARTED. THIS IS THE SECOND TIME THIS HAS HAPPENED. THE LAST TIME, THE DEALER FOUND NO PROBLEM. I AM AWARE THAT VOLVO SUSPECTS THE THROTTLE BODY IN THESE MATTERS. MINE HAS ALREADY BEEN REPLACED! *NM

NHTSA ID

10136123

Incident

Sep 9, 2005

Mileage

75,700 mi

DT: CONTACT STATES: ON 7-8-05 WHILE DRIVING AT 25 MPH THE CONSUMER HEARD A SPUTTERING, AND ALL OF A SUDDEN THERE WAS A BURST OF BLACK SMOKE COMING FROM THE FUEL PIPE. HAD VEHICLE TOWED TO THE DEALER., WHO COULD NOT DUPLICATE THE PROBLEM. *AK

NHTSA ID

10133792

Incident

Jul 8, 2005

Mileage

142,000 mi

DT;VEHICLE STALLED/LOST POWER, AND OPERATED ON REDUCED SPEED. PCV FAILED AND WAS REPLACED. *AK

NHTSA ID

10131256

Incident

Jul 29, 2005

Mileage

51,928 mi

I OWN A 1999 VOLVO S80 WHICH I DRIVE FOR BUSINESS PURPOSES. ON AUGUST 17, 2004 THE VEHICLE STALLED AT HIGHWAY SPEED. WOULD BARELY RUN, EVEN WITH FULL THROTTLE. HAD VEHICLE TOWED TO NEAREST VOLVO DEALER, VOLVO OF LOUISVILLE, KY. THEY REPLACED THROTTLE BODY . APPROX. 2 WEEKS LATER, HAD SAME OCCURRENCE. CAR STALLED AT HIGHWAY SPEED. HAD VEHICLE TOWED TO LOCAL DEALER, CENTURY VOLVO HUNTSVILLE, AL. THEY EXAMINED IT AND COULD NOT FIND ANY PROBLEM. IT WAS NOT MALFUNCTIONING FOR THEM. THEY KEPT VEHICLE FOR SEVERAL DAYS TRYING TO DUPLICATE PROBLEM. I HAD A SIMILAR OCCURRENCE AGAIN APPROX. 5 DAYS LATER. INSTEAD OF HAVING VEHICLE TOWED AGAIN, THE SERVICE REP SUGGESTED THAT THE CAR MIGHT "RESET" IF LEFT FOR 2-3 HOURS. I LEFT CAR ON ROADSIDE OVERNIGHT AND HAD MY WIFE COME PICK ME UP. THE NEXT DAY I WENT BACK AND THE CAR DROVE FINE. I HAD ANOTHER OCCURRENCE AT HIGHWAY SPEEDS ON OCTOBER 26, 2004. VEHICLE TOWED TO ROYAL VOLVO IN BIRMINGHAM. BY THE TIME THEY EXAMINED IT, VEHICLE WAS NO LONGER MALFUNCTIONING. THEY KEPT IT RUNNING UNDER LOAD FOR SEVERAL HOURS. THERE WERE NO COMPUTER FAULT CODES FOUND THAT COULD HAVE CONTRIBUTED TO THE PROBLEM. THIS IS THE SAME INFORMATION THAT CENTRURY VOLVO HAD FOUND AND ADVISED ME OF EARLIER. I CONTINUED TO DRIVE THE CAR WITH A LOT OF CONCERN THROUGH THE WINTER. IT WENT SEVERAL MONTHS WITH NO PROBLEMS. I HAD ANOTHER OCCURRENCE IN MAY 2005. I WAS ABLE TO MAKE IT HOME BY ALLOWING THE CAR TO SIT FOR 20-30 MINUTES AND THEN IT WOULD DRIVE FOR A SHORT DISTANCE BEFORE GOING BAD AGAIN. AT THIS TIME I PARKED THE CAR AND BEGAN DRIVING MY SECONDARY VEHICLE (A 94 VOLVO 960). UNFORTUNATELY, I WAS INVOLVED IN AN ACCIDENT WITH THIS VEHICLE ON JULY 29, 2005 WHICH FORCED ME TO DRIVE THE 99 S80 AGAIN. IT STALLED OUT AGAIN TODAY (SECOND DAY DRIVEN). I'VE HAD IT TOWED TO CENTURY VOLVO IN HUNTSVILLE AGAIN. MY SALESMAN SHOWED ME AN ARTICLE IN TODAY'S NEWSPAPER REGARDING THIS PROBLEM. *JB

NHTSA ID

10131203

Incident

Aug 17, 2004

Mileage

169,836 mi