2000 Volvo S80 Brakes Problems

I WANT TO MAKE YOU AWARE OF A VERY SERIOUS CAR ACCIDENT THAT MY MOTHER HAD ON 9-5-18. SHE WAS DRIVING HER 2000 VOLVO S80 WHEN HER CAR BEGAN TO ACCELERATE ON ITS OWN. SHE WAS NOT ABLE TO CONTROL THE CAR. MY MOM HAD HER FOOT ON THE BRAKE BUT THAT DID NOT STOP THE VEHICLE. UNFORTUNATELY, AT THAT POINT THE CAR WAS OUT OF CONTROL HITTING AND BANGING UP ALL THE CARS AROUND IT. THEN THE CAR FINALLY SMASHED INTO ANOTHER CAR STOPPING THE OUT OF CONTROL CAR. MY MOM WAS SERIOUSLY HURT AND TAKEN TO THE HOSPITAL. SHE HAD EMERGENCY SURGERY TO REPAIR HER AORTA THAT TORE FROM THE CRASH. SHE ALSO BROKE HER STERNUM. I AM DEVASTATED BY WHAT HAPPENED TO MY MOM. I FEEL THAT IT IS EXTREMELY IMPORTANT THAT YOU AND VOLVO ARE MADE AWARE OF THIS TRAGIC SITUATION THAT OCCURRED BY THIS VOLVO S80.

NHTSA ID

11128657

Incident

Sep 5, 2018

WHILE STOPPING OR TURNING AT LOW SPEEDS THE CARS IDLE SPEED WILL FLUCTUATE FROM A COMPLETE STOP UP TO 1100 RPMS. MOST OF THE TIME BETWEEN 500 & 1100 RPMS ! WHEN THE CAR STOPS RUNNING WHILE I AM TRYING TO TURN A CORNER , THE POWER STEERING OF COARSE DOES NOT WORK AND ITS HARD TO STEER IT. I DID TAKE IT TO A VOLVO DEALER, & THEY SAID IT NEEDED A NEW THROTTLE SENSOR & COMPUTER SOFTWARE CHANGE, & IT WOULD COST ME $2400. I CAN'T FIND OUT IF ANY OF THE RECALLS HAVE EVER BEEN DONE #R155, R146, NHTSA I.D. #626114 & I.D. #10018801. THE PREVIOUS OWNER HAD THE CAR FOR THREE YEARS & DID NOT RECEIVE AND RECALLS NOTICES. MOST OF THE TIME THE CAR RUNS FINE, I HAVE DRIVEN IT OVER 40,000 MILES NOW WITH THE CHECK ENG. LIGHT ON & OFF. THE CHECK ENGINE LIGHT WILL STAY ON FOR A DAY OR TOO & GO OFF FOR THREE OR FOUR DAYS AT A TIME. I WOULD REALLY LIKE TO KNOW IF ANY OF THE RECALLS HAVE EVER BEEN DONE TO THIS CAR. *TR

NHTSA ID

10627132

Incident

Jul 1, 2009

Mileage

106,987 mi

DRIVING IN THE CITY AND WHEN TRYING TO STOP ON A TRAFFIC LIGHT THE BRAKES BECAME HARD AND ENGINE WAS NOT RUNNING WELL. WHEN I TRIED TO DRIVE OFF IN THE GREEN LIGHT THE SPEED CONTROL OF THE GAS PEDAL WAS VERY CHAOTIC. I GOT A MESSAGE OF ENGINE SYSTEM SERVICE REQUIRED. I TOOK THE CAR TO THE LOCAL VOLVO DEALER AND HE DIAGNOSED A FAULTY THROTTLE ETM ASKING 2000 $ TO REPLACE. AFTER RESEARCHING I FOUND THAT THERE WAS ALREADY A RECALL ON THAT BY VOLVO AND WHEN I ASKED THE DEALER HE SAID THAT THIS WAS TRUE BUT MY CAR WAS MORE THAN 10 YEARS OLD ( ALTHOUGH HE COULD HAVE INFORMED ME ABOUT THAT IN THE FIRST PLACE). HE INFORMED ME THAT A SOFTWARE SERVICE ON THE ETM OF MY CAR WAS DONE IN 2006 ( AFTER THE RECALL?) BUT THIS DID NOT FIX THE PROBLEM AS APPARENTLY THE PROBLEM IS WITH THE ETM DESIGN ( FALTERING POTENTIOMETER). THIS CAR IS VERY DANGEROUS AND IT WILL PROBABLY GO TO THE JUNKYARD, BUT WE SHOULD BE CONCERNED BY ALL VOLVOS REMAINING ON THE STREET WITH FAULTY ETM'S, WHICH THE NUMEROUS COMPLAINTS FILED AT NHTSA SHOW. *TR

NHTSA ID

10433515

Incident

Oct 8, 2011

Mileage

144,400 mi

I WAS DRIVING ALONG A BUSY STREET, WHEN I CAME TO A STOP SIGN THE BRAKES WHERE HARD TO PUSH, WHEN I FINALLY STOPPED THE CAR, YOU COULD STILL FILL THE CAR TRYING TO MOVE FORWARD I TOOK MY FOOT OF THE BRAKES AND THE CAR SPED UP ON IT'S ON REACHING CLOSE TO 40 MPH AGAIN I WAS BARELY ABLE TO STOP THE CAR DO TO A STIFF BRAKE PEDAL. I PUT THE CAR IN PARK AND SHUT IT OFF, ONCE I RESTARTED THE CAR IT WAS SPUTTERING AND WOULDN'T IDLE CORRECTLY EVERY TIME I PUT THE CAR IN GEAR IT WOULD SHUT OFF NOW I'M GETTING AN ERROR MESSAGE THAT SAYS SERVICE ENGINE SYSTEM URGENT. *TR

NHTSA ID

10423220

Incident

Sep 3, 2011

Mileage

131,329 mi

I PURCHASED A 2000 VOLVO S80 IN DEC 2010. SEVERAL MONTHS AFTER PURCHASE I NOTICED A HISSING SOUND COMING FROM UNDER THE DASH NEAR THE FIRE WALL. THE SOUND IS COMING FROM THE BRAKE BOOSTER. THIS HAS CAUSED WEAK BRAKES. SOMETIMES WHEN YOU PUSH THE BRAKE PEDAL IT GOES TO THE FLOOR AND THE BRAKES HAVE TO BE PUMPED TO STOP THE CAR. *TR

NHTSA ID

10375405

Incident

Feb 1, 2010

Mileage

230,000 mi

I WAS DRIVING MY 2000 VOLVO S80 ON 5/19/10 AND HAD EXITED I-405, ONTO HWY 169, HEADING HOME TOWARDS MAPLE VALLEY, WHEN ALL OF A SUDDEN I HEARD A VERY LOUD BANG, RESULTING IN SUDDEN STEERING LOSS, HEARD LOUD SQUEALING, AND SAW LOTS OF WHITE SMOKE. THE SMOKE WAS FROM THE FRONT PASSENGER TIRE, WHICH HAD TURNED OUTWARD, COMPLETELY SIDEWAYS AT A 90 DEGREE ANGLE. THE CAR IS NOW IN NO CONDITION TO BE DRIVEN. THE WHEEL DAMAGED THE FRAME, WARP/DENTED THE QUARTER PANEL, BROKE OFF THE MOLDING, RIPPED OUT THE CV DRIVE OR WHATEVER THAT THING IS THAT MAKES THE WHEEL TURN IN A NORMAL, FORWARD DIRECTION, BROKE THE LOWER CONTROL ARM, MESSED UP THE BRAKE LINE, STRUTS, AND WHO KNOWS WHAT ELSE? I'M GUESSING THAT THE REPAIR COSTS ARE GOING TO BE TOWARDS THE THOUSANDS, BEING THAT VOLVO PARTS ARE SO EXPENSIVE. *TR

NHTSA ID

10332047

Incident

May 19, 2010

Mileage

124,000 mi

2000 VOLVO S80 T6, 152,000 MILES, MAINTAINED REGULARLY. DRIVING IN SNOWY WEATHER; VEHICLE HAD BEEN PARKED EARLIER IN THE DAY AND BEEN DRIVING FINE. AT 40 MILES PER HOUR, THE LEFT REAR BRAKE LOCKED UP THE WHEEL AND REMAINED STUCK. ABS AND TRACTION CONTROL LIGHTS CAME ON AND SYSTEMS CAME DISABLED. LOCK-UP WAS THE RESULT OF A PARKING BRAKE SHOE SEPARATING FROM ITS BACKING, SIMILAR TO HTTP://FORUMS.SWEDESPEED.COM/ZEROTHREAD?ID=97350 .*CW

NHTSA ID

10302464

Incident

Jan 27, 2010

Mileage

152,300 mi

TL*THE CONTACT OWNS A 2000 VOLVO S80. THE CONTACT STATED THAT THE TRANS SIGNAL (ALERT TO THE ABS AND SPEED SENSOR) WOULD ALTER THE ABS AND ALL OF THE INSTRUMENT PANEL LIGHTS WOULD ILLUMINATE. HE HAD NOT NOTICED ANY PERFORMANCE ISSUES WITH THE VEHICLE DUE TO THE FAILURE. HE TOOK THE VEHICLE TO A REPAIR SHOP FOR DIAGNOSTIC TESTING. THE RESULTS PRODUCED SIX CODES AND INDICATED THAT THE SPEED SENSOR WAS ALSO A PART OF THE FAILURE. THE MANUFACTURER STATED THAT THE VEHICLE WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 06V441000. THE CURRENT MILEAGE WAS 122,944 AND FAILURE MILEAGE WAS APPROXIMATELY 122,000.

NHTSA ID

10269938

Incident

Feb 15, 2009

Mileage

122,000 mi

I AM HAVING AN ISSUE WITH MY BRAKE WARNING LIGHT/ENGINE LIGHT. I HAVE NOT HAD THE CAR A MONTH. THE WARNING MESSAGE SAYS BRAKE FAILURE STOP IMMEDIATELY. I TOOK BACK TO DEALERSHIP AND THEY SAID THAT I HAD NO FLUID. BUT IT IS STILL HAPPENING. I NOTICED THE RECALL ON THE 2000 VOLVO S-80. NOT SURE IF IS THE SAME THING, BUT IF IT IS SHOULD THE VOLVO DEALERSHIP FIX FOR FREE. THE RECALL WAS SENT OUT MARCH OF 07. *TR

NHTSA ID

10244220

Incident

Sep 16, 2008

Mileage

140,000 mi

2000 VOLVO S80 2.9L HAD ABS MODULE FAILED TWICE AT 25K MILES (2006) AND 50K (8/2008) MILES. GOTTEN CLOSE TO ACCIDENTS ESPECIALLY DURING RAIN, SNOW, OR HUMID WEATHER. COMPLAINED TO AUTHORIZED DEALER/MECHANIC AT LEAST OVER THE LAST 4 YEARS WITHOUT ANY HELP UNTIL IT REQUIRES REPAIR. *TR

NHTSA ID

10238348

Incident

Aug 1, 2008

Mileage

50,000 mi

TL*THE CONTACT OWNS A 2000 VOLVO S80. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD SPONTANEOUSLY DECELERATE. PRIOR TO THE FAILURE, THE ENGINE AND BRAKE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE DEALER STATED THAT THE ABS MODULE NEEDED TO BE REPLACED AT THE COST OF $1,500. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER DID NOT PROVIDE ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 107,000. UPDATED 09/23/08. *LJ UPDATED 09/24/08. *JB

NHTSA ID

10234702

Incident

Jul 17, 2008

Mileage

107,000 mi

MY WIFE LEFT FOR WORK & GOT TO THE END OF THE DRIVEWAY & HAD NO BRAKE ASSIST IE VERY HARD PEDAL. THIS OCCURRED WITHOUT WARNING(NO WARNING LIGHTS,ETC).SHE PARKED THE VEHICLE&TOOK ANOTHER TO GET TO WORK(RN).I LATER DROVE THE CAR,BRAKES WORKED FINE. THE NEXT DAY I DROVE IT AGAIN & NO POWER BRAKES. *TR

NHTSA ID

10234275

Incident

Jul 12, 2008

Mileage

57,479 mi

SRS AIRBAG FAILURE AND ABS BRAKE WARNING LIGHTS AND ALERTS POSTED ON DASHBOARD DISPLAY. TURNS OUT THE PROBLEM WAS DEFECTIVE SOFTWARE AND WAS RESOLVED WITH A SOFTWARE UPDATE. THIS IS A CRITICAL SAFETY ISSUE SINCE THE FAILURE RESULTS IN THE DISABLING OF THE SYSTEMS. THE PROBLEM WAS DIAGNOSED AND FIXED IN ABOUT AN HOUR. VOLVO CLEARLY NEW ABOUT THIS PROBLEMS SINCE THE SOFTWARE UPGRADE (AKA A FIX) WAS ALREADY COMPLETED AND AVAILABLE - VOLVO HAD TO PAY SOMEONE TO FIX THE SOFTWARE, WHY PAY THEM IF THERE WAS NO DEFECT. I BELIEVE THIS SAFETY ISSUE SHOULD BE AT LEAST ADVISED IF NOT MANDATORY FOR ALL OWNERS OF THESE VEHICLES. IT IS A SIMPLE EASY WAY TO AVOID A TRAGEDY IF THESE SYSTEMS ARE DISABLED BY DEFECTIVE SOFTWARE. *TR

NHTSA ID

10214883

Incident

Dec 26, 2007

Mileage

148,900 mi

1) ENGINE IDLES ROUGH, PROBLEM BECAME SO BAD THAT CAR STALLS AT LOW SPEEDS, LOST POWER STEERING & "ENGINE DIES" AT LOW SPEEDS (UNSAFE!). LOCAL MECH REFERRED TO ETM WARRANTY PROGRAM TO RE-PROGRAM FAULTY ETM MODULE. TOOK CAR TO DLR, RE-PROGRAMMED ETM CAR DIED AGAIN! TURNS OUT BAD BATTERY AS WELL: SEVERAL HUNDRED $$$ TO REPLACE BATTERY. CAR DOES NOT ACCELERATE SMOOTHLY, LARGE "SHUDDERS" PRESENT WHEN MERGING ONTO HWY, DURING TRANSMISSION/GEAR SHIFT. NOT GOOD! 2) AIRBAG "SRS-URGENT SERVICE" WARNING INDICATOR LIGHT IS ON. GOOD LOCAL MECH. STATES THIS IS A $1000 REPAIR. 3) "CHECK BRAKE LIGHT" WARNING INDICATOR LIGHT TURNS ON WHEN DEPRESSING ON BRAKE PEDAL: GOOD LOCAL MECH. STATES THAT THIS IS "NORMAL" REQUIRES EXACT MATCHING ELECTRICAL RESISTANCE OF ALL BRAKE LAMPS TO ENSURE THAT "CHECK BRAKE LIGHT" WARNING DOES NOT OCCUR (IN ACTUALITY THE BRAKE LIGHTS WORK FINE, THE BUILT-IN-TEST IS FAULTY). 4) "CHECK ENGINE LIGHT" COMES ON 2-3 TIMES IN LAST 3 MONTHS. MAJOR SERVICE WAS REQUIRED. ONE FAULT WAS ISOLATED TO FUEL TANK GAS CAP: IF NOT SECURED PROPERLY "ECM-4308 (LEAK DIAGNOSTIC) LARGE LEAK" OCCURS...REMEDIED BY TWISTING FUEL CAP 3 FULL ROTATIONS, AFTER RE-FUELING GAS TANK. GOOD LOCAL MECH. DIAGNOSED THE LOOSE GAS CAP PROBLEM, WARNED ME ABOUT IT, AND DIDN'T CHARGE ME (NICE!). 5) BODY PAINT IS VERY SUSCEPTIBLE TO CHIPPING & SCRATCHES. PAINT OR EXTERIOR PANELS ARE VERY SOFT AND EASILY DAMAGED. ANOTHER SHAME, THIS CAR LOOKS GREAT BUT DOES NOT HOLD UP VERY WELL UNDER TYPICAL PARKING LOT CONDITIONS (I.E. SOMEONE PARKED NEXT TO YOU OPENS THEIR CAR DOOR INTO THE SIDE OF YOUR CAR RESULTING IN A LARGE SCRATCH). SOLUTION: PURCHASE A FANCY CAR COVER AND PROTECT THE BODY PAINT, IF YOU CAN! 6) PARKING BRAKE "SEEMS LOOSE", UPON PARKING CAR AND ENGAGING PARKING BRAKE THE VEHICLE ROLLS ALMOST 30 CM BWDS OR FWD DEPENDING ON LEVEL OR INCLINED SURFACE. *TR

NHTSA ID

10213987

Incident

Oct 19, 2006

Mileage

119,500 mi

A HISSING SOUND COMING FROM THE BRAKE PEDAL AREA BEGAN OCCURING AND I TOOK TO THE CAR TO THE DEALER AND WAS INFORMED THAT IT WAS A DEFECTIVE "BRAKE BOOSTER" AND THAT IT IS A VERY DANGEROUS SITUATION THAT IF NOT CORRECTED COULD LEAD TO TOTAL BRAKE FAILURE. THE CAR IS USED TWICE A WEEK AND THE BRAKE BOOSTER HAS NOT BEEN REPLACED AND IS AVAILABLE FOR INSPECTION. *TR

NHTSA ID

10200049

Incident

Aug 1, 2006

Mileage

125,000 mi

I HAVE BEEN HAVING PROBLEMS WITH MY 2000 VOLVO S80 HESITATING AS IF IT'S NOT GETTING ANY GAS WHEN FIRST BEGINNING TO DRIVE IT EVERYDAY. I HAVE COMPLAINED ABOUT THIS PROBLEM SINCE PURCHASING THIS VEHICLE BUT THE VOLVO REPAIR SHOP HAVE NOT BEEN ABLE TO FIX THE PROBLEM AND THEY SAY THEY DO NOT KNOW WHAT THE PROBLEM IS. ALSO MY CHECK ENGINE LIGHT, STC LIGHT, AND ABS LIGHT KEEPS COMING ON. I HAVE ALSO NOTICED THAT WHEN THESE LIGHTS COME ON MY CAR BECOMES HARD TO STEER SOMETIMES. AFTER CHECKING INTO THIS PROBLEM I HAVE FOUND THAT MANY OTHER VOLVO S80 'S BUILT AROUND THE SAME TIME AS MINE ARE HAVING THE SAME PROBLEMS. I HAVE COMPLAINED ABOUT MY CAR SUSPENSION MAKING WEIRD NOISES SINCE HAVING THIS VEHICLE AND THE VOLVO REPAIR SHOP SAYS THEY CAN NOT FIND ANY THING WRONG BUT WHEN ENQUIRING WITH OTHERS WHO OWN VOLVO S80'S, BUILT AROUND THE SAME TIME AS MINE, MANY ARE SAYING THEY ARE HAVING THIS PROBLEM ALSO. THE BELOW INFORMATION ASKS FOR AN INCIDENT DATE BUT THE PROBLEM WITH MY 2000 VOLVO S80 HESITATING AND BEING HARD TO STEER OCCUR OFTEN PROBABLY OVER 100 TIMES. *NM

NHTSA ID

10152747

Incident

Jan 3, 2006

Mileage

48,000 mi

IN OCTOBER 2001 WHILE DRIVING AT NIGHT HEADLIGHTS WENT OFF. THE FOLLOWING DAY WHILE CROSSING THE STREET THE CAR STALLED. APPROXIMATELY TEN MINUTES LATER WAS ABLE TO START THE CAR, AND AT THE SAME TIME HEADLIGHTS CAME ON. CAR WAS UNDER WARRANTY, AND THE MECHANIC REPAIRED THE THROTTLE BODY & GASKET. IN JUNE 2004 CAR STALLED AGAIN. REPLACED SWAY LINKS AND PROGRAM DOWN LOAD $338.19. IN DECEMBER 2004, CAR STALED ON THE ROAD AGAIN. IT WAS TOWED TO THE REPAIR SHOP, THEY REPLACED THE THROTTLE BODY, MASS AIR FLOW, MFI MODULE- AT COST OF 2098.96. THE CONTACT DID NOT TAKE THIS CAR ON ANY LONGER TRIP. DUE TO STALLING ON THE ROAD, FREQUENT LOSS OF HEADLIGHTS AND NUMEROUS OTHER MECHANICAL PROBLEMS THE CONTACT BELIEVED THIS CAR WAS UNSAFE TO BE ON THE ROAD. 11-16 E-MAIL ; FIRST TIME THE CAR WOULD NOT RESPOND TO THE ACCELERATOR PEDAL. STOPPED TURN THE CAR OFF AND TRIED TO RESTART IT AGAIN. AFTER FEW ATTEMPTS THE CONTACT WAS ABLE TO RESTART THE CAR. *AK THE RIGHT DOOR MIRROR FAILED AND THE ABS CONTROL MODULE WAS REPLACED. UPDATED 02/07/06. *JB

NHTSA ID

10143211

Incident

Nov 19, 2001

Mileage

22,815 mi

2000 VOLVO S80 T6 ON NUMEROUS OCCASIONS THE VEHICLE WOULD STALL, EVEN WHEN DRIVING AT HIGHWAY SPEEDS. ON SEVERAL OCCASIONS WHILE DRIVING MY CHILDREN TO SCHOOL ON THE HIGHWAY THE VEHICLE STALLED FORCING ME TO CROSS 3-4 LANES OF HEAVY TRAFFIC WITHOUT THE USE OF POWER STEERING OR POWER BRAKES. THE ELECTRONIC THROTTLE MODULE WAS DETERMINED TO BE DEFECTIVE. THIS IS A KNOWN DEFECTIVE PART ON 1999-2001 VOLVO S80'S. THERE ARE EVEN DOCUMENTED REPORTS THAT THE ETM WILL FAIL ON OVER 90% OF ALL VOLVO S80'S WITHIN THIS YEAR RANGE ('99-01). I HAVE SPENT $900 TO HAVE THIS REPLACED. THE STATE OF CALIFORNIA IS FILING A LAWSUIT AGAINST VOLVO OVER THIS PART. I LIVE IN KY; THEREFORE I DON'T BELIEVE THAT LAWSUIT WILL HELP ME. I AM ASKING VOLVO FOR FULL REIMBURSEMENT TO REPLACE THIS PART. IT NOT ONLY WAS A FAULTY DESIGN, BUT ALSO POTENTIALLY DEADLY PART. THERE SHOULD HAVE BEEN A FULL RECALL ON THIS PART AND VOLVO KNEW ABOUT THIS PROBLEM EVEN BEFORE THE RELEASE OF THE VEHICLE IN '99. THERE IS ANOTHER KNOW DEFECTIVE PART ON THE SAME YEAR VOLVO THAT IS THE ABS MODULE. I HAD TO HAVE THAT REPLACED FOR A COST OF $1000. DOCUMENTED REPORTS SAY THE ABS MODULE WILL FAIL ON 60% OF THOSE VOLVOS. *JB

NHTSA ID

10140296

Incident

Oct 19, 2005

Mileage

80,000 mi

THE ABS CONTROL MODULE FUNCTIONS INTERMITTENTLY AND IS USUALLY IN THE FAILURE MODE. ABS BRAKES DO NOT FUNCTION PROPERLY. A NEW MODULE IS REQUIRED AT A QUOTED PRICE OF $950 FROM VOLVO DEALER. THIS IS A CONTINUOUS AND ONGOING PROBLEM.

NHTSA ID

10137392

Incident

Apr 2, 2004

Mileage

55,000 mi

OVER THE COURSE OF OWNERSHIP OF A 2000 VOLVO S80 (I.E., FOUR YEARS), I HAVE THE TRANSMISSION OVERHAULED AT 67,000 MILES;HAD THE THROTTLE REPLACED WHEN MY CAR CHOKED ( LUCKILY ON A SIDE STREET); HAD A BAR ON THE SUNROOF DROP OFF; ENGINE MOUNTS BROKEN; WHEEL STOPS BROKEN; AND, MOST RECENTLY REPLACED AN ABS PANEL. NOT WITHSTANDING IN ANY OF THESE INCIDENTS IS THE COOLING FAN AND BALL JOINT REPLACED DUE TO RECALL. TRULY THIS CAR HAS BEEN MORE EXPENSIVE THAN ANY OTHER KNOWN TO BE DRIVEN. EVERY TRIP TO THE DEALERSHIP IS EASILY $1000 PLUS. AT THE TIME OF PURCHASE, THE RESEARCH WAS SCANT IN TERMS OF PROBLEMS. I HAVE TRULY BEEN DISMAYED BY VOLVO'S COMMITMENT TO ITS PRODUCT AND IS DESIGN FLAWS AND/OR DEFECTS. AFTER, THE TRANSMISSION WAS CORRECTED AT THE DEALERSHIP, I WENT TO TRADE THE CAR IN---TO PURCHASE ANOTHER CAR. THE DEALERSHIP WHERE I PURCHASED THE CAR BASICALLY WOULD NOT GIVE MONEY ON ITS TRADE. AFTER SEVERAL THOUSAND DOLLARS LATER IN REPAIRS, I AM STILL FUMING OVER A CAR THAT WAS PURCHASED SOLELY FOR THE "HISTORICAL" VOLVO STANDARD AND ITS COMMITMENT TO SAFETY. *JB

NHTSA ID

10130850

Incident

Jul 14, 2003

Mileage

67,000 mi

WHILE DRIVING THE VEHICLE GOES INTO "LIMP" MODE AND A ERROR MESSAGE SAYING "SAFELY PULL OVER AND RESTART VEHICLE" GOES ON. THE VEHICLE WOULDN'T EXCEED 5 MPH WITH TRAFFIC BEHIND ME. IT IS A POTENTIALLY DANGEROUS SITUATION, WHICH HAS HAPPENED SEVERAL TIMES. BUT I'VE FINALLY BROUGHT THE CAR TO THE DEALERSHIP AND APPARENTLY THE ELECTRONIC THROTTLE BODY MODULE, AND THE ANTI-LOCK BRAKE MODULE BOTH HAVE TO BE REPLACED. THEN AFTER CHECKING SEVERAL FORUMS THIS SEEMS TO BE AN EPIDEMIC FOR THE VOLVO S80.

NHTSA ID

10116054

Incident

Mar 14, 2005

WHILE DRIVING 50 MPH BRAKES FAILED WITHOUT WARNING, RESULTING IN A COLLISION. *AK

NHTSA ID

10049801

Incident

Oct 10, 2003

Mileage

35,000 mi

THE VEHICLE EXPERIENCED PROBLEM WITH THE BRAKE SYSTEM. THE DEALER STATED NOTHING WAS WRONG WITH THE BRAKES . PLEASE PROVIDE ANY ADDITION INFORMATION. *NLM

NHTSA ID

10048671

Incident

Nov 25, 2003

THERE IS AN OVERALL PROBLEM WITH THE S80 CARS. I HAVE BEEN TO THE DEALER ON MANY OCCASIONS FOR OTHER REPAIRS SUCH AS THE ROOF TOP COVER, BRAKE LIGHTS...BECAUSE OF THE BALL JOINTS AND THE ON AND OFF HUMING NOISE, I AM UNCOMFORTABLE DRIVING THE CAR BEYOND THE AREA. THE DEALER AND THE MANUFACTURER WERE CONTACTED. WE ONLY REQUESTED THE OTPIONS OF EITHER CANCELLING THE LEASE OR ANOTHER CAR SINCE MINE IS A LEMON...I WAS NOT SUCCESSFUL WHICH MADE ME WONDER IF THIS IS A SERIOUS ISSUE AND OTHERS ARE COMING FORWARD. I FELT THE NEED TO HIGHLIGHT THIS TO THE NTSB TO FOLLOW-UP WITH THE MANUFACTURER AND GET DATA ACCROSS THE COUNTRY.*AK

NHTSA ID

748653

Incident

May 10, 2001

WHILE BACKING AFTER THE CAR HAS BEEN SITTING FOR AWHILE (COLD ENGINE), THE BRAKES FAIL TO STOP THE CAR FOR SEVERAL SECONDS (FEET).

NHTSA ID

713015

Incident

Sep 1, 1999