2012 Volvo S80 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2012 Volvo S80, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Airbags111.1%
- Body & structure111.1%
- Driver assistance111.1%
- Interior & seats111.1%
- Other / unspecified111.1%
- Powertrain (other)111.1%
- Steering111.1%
- Suspension111.1%
- Tires & wheels111.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
See attached document for complaint.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
THE PASSENGER DOOR CONTINUES TO OPEN AT HIGHWAY SPEEDS. I HAVE THE OPTION FOR DOORS TO LOCK WHEN CAR BEGINS TO MOVE. THE LOCK REMAINS "LOCKED" HOWEVER DOOR OPENS WITH INTERIOR LIGHTS AND DASHBOARD WARNING. I HAVE CONTACTED VOLVO TO NO END... I SEE A MULTITUDE OF DOOR OPENING ISSUES ON VOLVO FORUM SITES, AND MECHANIC STATES COMMON PROBLEM WITH VOLVO.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
See attached document for complaint.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
See attached document for complaint.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2012 VOLVO S80. WHILE DRIVING 35 MPH, THE CONTACT STATED THAT THE WHEEL STUDS FRACTURED FROM THE TIRE. AS A RESULT, THE VEHICLE SLID ONTO THE ROAD SHOULDER AND THE FENDER WAS RIPPED OFF. THERE WAS NO CRASH. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND THEN TAKEN TO DEMONDTROND VOLVO (VOLVO BUILDING, 14101 NORTH FWY, HOUSTON, TX 77090, (281) 607-0382). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 138,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2012 VOLVO S80. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE VEHICLE WOULD JERK VIOLENTLY WHEN ACCELERATING TO A HIGH SPEED. IN ADDITION, THE TACHOMETER FLUCTUATED CAUSING THE VEHICLE TO JERK VIOLENTLY. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V317000 (POWER TRAIN). THE APPROXIMATE FAILURE MILEAGE WAS 45,800.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
A batch of metal used for the steering wheel trim prematurely wears down at the base of the steering wheel in 2 locations out of sight with normal use and becomes razor sharp. When turning the wheel, the spinning razor edge can cause the driver to lose control due to sudden pain due to slicing into the fingers. The metal slices into the skin drawing blood much like that of a papercut. I have experienced sudden cuts in turning on 2 separate occasions recently having to re-grab the steering wheel due to involuntary pain reflex release to prevent total loss of control and the problem has not been confirmed by the dealer. There is no prior warning when this issue suddenly occurs.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
DRIVERS SIDE REAR SUSPENSION LINK ARM FAILURE. VEHICLE TRAVELING STRAIGHT AHEAD ON EXPRESSWAY AT POSTED SPEED, 70MPH, ROAD CONDITIONS DRY AND CLEAR. NO IMPACTS OR SUDDEN MANEUVERS PRIOR TO FAILURE, I.E. CHUCK HOLE OR DEBRIS. NO TIRE OR WHEEL DAMAGE SUSTAINED PRIOR TO OR AFTER SUSPENSION FAILURE. NO IMPACT EVIDENCED UNDERNEATH VEHICLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS 21 JUL 2013 - SUNDAY EVENING THE TIRE LOW PRESSURE WARNING LIGHT CAME ON WHEN I PARKED MY CAR IN THE GARAGE. I LOOKED AT ALL FOUR TIRES AND FOUND NOTHING WRONG. 22 JUL 2013 - MONDAY AS SAFETY PRECAUTION I TOOK THE VEHICLE IN FOR SERVICE AND HAD THE SENSOR CHECKED. THE VOLVO SERVICE DEPARTMENT STATED; THEY CHECK THE PRESSURE IN ALL TIRES FOR LEAKS, PROPER INFLATION AND THE LIGHT WENT OUT. 23 JUL 2013 - TUESDAY MORNING ON MY WAY TO WORK THE LIGHT CAME BACK ON. AGAIN; I LOOKED AT ALL FOUR TIRES AND FOUND NOTHING WRONG. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .