2019 Volvo S90 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2019 Volvo S90, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical266.7%
- Driver assistance133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
Component: Electrical / Instrument Cluster The vehicle experienced a failure of the digital instrument cluster while driving. The instrument panel intermittently malfunctioned, including going blank, freezing, or failing to display critical information such as vehicle speed, warning indicators, and system alerts. This issue occurred without warning and created a safety concern because the driver was unable to reliably monitor essential driving information. At times, the display did not function properly, which impacted the driver’s ability to safely operate the vehicle, especially while in motion. The problem was not consistent and occurred intermittently, making it difficult to anticipate or manage. Restarting the vehicle sometimes temporarily restored functionality. The instrument cluster was later identified as defective and required replacement by Volvo. The failure of this component raises safety concerns due to the loss of critical driver information while operating the vehicle.
The car caught fire while parked in my driveway I had just had the hybrid system serviced at the dealership
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
On July 13, 2025, as I was entering a small parking lot, my car suddenly accelerated on its own and crashed through a metal gate at the far end of the lot and then hit a large docked tourist boat. I had just turned right into the parking lot and was going approximately 5-6 miles per hour. I had not yet started to turn the wheel to park as the two available spaces were about midway in the lot. The car suddenly and unexpectedly accelerated. I had no time to react. The car was totaled. The airbags deployed. It was caused by faulty acceleration. The vehicle was towed, inspected by the insurance company adjustor There were no warning lamps or indications of any problems The car had undergone a software update on or about June 25,2025.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .