2001 Volvo V70 Owner Complaints

The contact owns a 2001 Volvo V70. The contact stated that while the vehicle was idling, the engine caught fire. The air bag warning light was illuminated. There was damage to the garage. There were no reported injuries. The fire department extinguished the fire and confirmed the origin of the fire was the engine. A police report was filed. The vehicle was towed to an independent mechanic. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 178,000.

NHTSA ID

11451932

Incident

Jan 30, 2022

Mileage

178,000 mi

Been trying to get the airbags serviced and replace since I received the notice from Volvo on Dec.14 2021. I have made several appointments in my area to get this matter fixed, Dealers in my area either don't have replacement in stock or don't know of the recall contract Volvo CarUSA LLC they could not help me, now I am receiving text message on dash saying SRS Airbag service Urgent. Any help would be appreciated. Sincerely [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11451736

Incident

Dec 14, 2021

Received an airbag recall. There is no local dealer but there are authorized non-dealer service shops that do replace airbags. Under the recall a Volvo dealer must do the replacement. The nearest Volvo dealer is 300 miles away. Volvo will only reimburse for 25 miles of towing. The recall states "If you are unable to have this procedure performed without charge....". Towing cost would be approximately $800.00. How do I, and several others in my area, resolve this issue?

NHTSA ID

11447515

Incident

Jan 10, 2022

I was notified of the recall. Because I live 300 miles away from the nearest volvo dealership, there is no option for me to replace the airbag free of charge. Additionally, there is no plan in place to provide me with a safe vehicle until such a time that my volvo can be repaired. Until I undertake a great risk by traveling 300 miles at great inconvenience and expense, to have this problem resolved, I am expected to take a daily risk by driving this unsafe vehicle.

NHTSA ID

11444282

Incident

Dec 18, 2021

Heater core burst causing severe burn on drivers right foot. An inch and a half deep puddle of boiling hot antifreeze poured out with no warning from center console over gas pedal. Passenger floor area also had boiling antifreeze. Daughter was driving and taken to hospital treated for second degree burns.

NHTSA ID

11419842

Incident

Jun 5, 2021

THE DRIVER'S SIDE SEATBELT DOES NOT ROLL SMOOTHLY EITHER BEING PULLED OUT OR ALLOWED TO RETRACT.WHEN YOU PULL OUT ' OR RELEASE TO RETURN THE DRIVER'S SIDE SEATBELT, IT CATCHES IN THE BOTTOM OF THE SLOT IN THE SIDE POST WHERE IT CURVES FORWARD SO THAT IT EITHER WON'T COME OUT FAR ENOUGH TO LATCH, OR IF YOU CAN PULL IT OUT AND INSERT IT IN THE LATCH, IT STICKS WHEN YOU LET IT GO SO THAT IT STAYS SLACK AND DOES NOT RETRACT TO KEEP THE BELT TIGHT. EVEN IF YOU MANAGE TO GET IT OUT AND PROPERLY INSERTED, IT WILL NOT RETRACT WHEN RELEASED. . THE BELT HAS TO BE KEPT UP IN THE HIGHEST PART PF THE SLOT IN THE POST THAT IT COMES OUT OF, OR IS RETRACTED BACK INTO, WITH MY LEFT HAND WHILE BEING PULLED OUT OR ALLOWED TO RETRACT, OR ELSE IT GETS STUCK IN THE BOTTOM OF THE SLOT.. IT IS NOT SAFE. EVEN IF PROPERLY CLICKED IN, YOU COULD NOT COUNT ON IT TO RETRACT TIGHTLY IF THERE IS A COLLISION OR SUDDEN STOP.

NHTSA ID

11331366

Incident

Jun 1, 2020

Mileage

82,000 mi

TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT NOTICED A FUEL ODOR AROUND AND INSIDE THE VEHICLE. THE CONTACT ALSO NOTICED FUEL LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 69,000.

NHTSA ID

11280896

Incident

Apr 1, 2019

Mileage

69,000 mi

TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE FRONT DRIVER AND PASSENGER SEATS WERE MELTING AND BLACK SMOKE WAS EMERGING FROM THE SEATS. ADDITIONALLY, THERE WAS AN ABNORMAL BURNING SMELL EMERGING FROM THE VEHICLE. THE CONTACT STATED THAT THE BATTERY WAS REPLACED IN THE VEHICLE PRIOR TO THE FAILURE. THE CONTACT DISCONNECTED THE CIRCUITS TO THE SEATS. THERE WERE NO WARNING LIGHTS ILLUMINATED. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE FAILURE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000. THE VIN WAS INVALID.

NHTSA ID

11217130

Incident

Sep 1, 2017

Mileage

105,000 mi

TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT THE REAR BRAKE LIGHTS INTERMITTENTLY FAILED TO FUNCTION. THE BRAKE WARNING LIGHT ILLUMINATED STATING CHECK REAR BRAKE LIGHTS. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC TESTING OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT COVERED UNDER THE CAMPAIGN NUMBER: 04V051000 (EXTERIOR LIGHTING) AND DID NOT OFFER FURTHER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 206,000.

NHTSA ID

11144519

Incident

Oct 5, 2018

Mileage

206,000 mi

WHEN I AM DRIVING IN 5TH GEAR THE TRANSMISSION WILL DROP INTO 4TH GEAR, AT THAT TIME I LOOSE 1ST, 3RD AND 5TH GEARS I CAN SHIFT BETWEEN 4TH AND 2ND. THE SHIFT IS VERY HARD AND CAUSES A JERK AND CLUNKING NOISE. I HAVE TO STOP AND SHUT OFF THE VEHICLE. I TURN THE CAR IMMEDIATELY BACK ON AND ALL THE GEARS ARE FUNCTIONAL. I'M NOT SURE WHY THERE'S SO MANY COMPLAINTS ABOUT THIS ISSUE YET NO ACTION HAS BEEN TAKEN TO FIX THIS PROBLEM

NHTSA ID

11093551

Incident

Jan 10, 2018

Mileage

190,000 mi

TL* THE CONTACT OWNS A 2001 VOLVO V70. WHILE OPERATING THE VEHICLE, THE ODOR OF FUEL WAS PRESENT INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TOP OF THE FUEL TANK WAS LEAKING AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND LOCAL DEALER (MAPLE HILL VOLVO IN KALAMAZOO, MI) WERE NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED BY THE DEALER THAT THE VEHICLE WAS PREVIOUSLY INSPECTED PER NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE), BUT THE FAILURE STILL OCCURRED. THE FAILURE MILEAGE WAS 160,000.

NHTSA ID

11088688

Incident

Apr 1, 2017

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT THE KEY FOB WOULD NOT FUNCTION INTERMITTENTLY, THE DOOR LOCKS WORKED INTERMITTENTLY, AND THE TURN SIGNALS WORKED INDEPENDENTLY. ALSO, VARIOUS OTHER ELECTRICAL SYSTEMS BEGAN EXPERIENCING ISSUES. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.

NHTSA ID

11005928

Incident

Jul 1, 2017

Mileage

135,000 mi

1.) TIRE #1 WAS PUNCTURED BY A PIECE OF GRAVEL AT ABOUT 25,000 MILES 2.) TIRE #2 MECHANIC REFUSED TO ROTATE TIRES BECAUSE BELT WAS SEPARATING FROM TIRE. TIRES WERE BOUGHT NEW AUGUST 2014. TIRES HAVE LESS THAN 34000 MILES

NHTSA ID

10885148

Incident

Jul 15, 2016

Mileage

25,000 mi

TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT DISCOVERED THAT FLUID WAS LEAKING FROM THE VEHICLE WHEN ANTI FREEZE WAS ADDED. IN ADDITION, WHEN THE AIR CONDITIONER WAS ACTIVATED, WARM AIR EMITTED FROM THE VENTS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE COOLING FAN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY SERVICED PER NHTSA CAMPAIGN NUMBER: 04V451000 (ENGINE AND ENGINE COOLING) YEARS AGO. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000. THE VIN WAS NOT PROVIDED. UPDATED 09/22/16*LJ CONSUMER STATED "RECALLED PART COOLANT FAN MODULE" AGAIN BECAME DEFECTIVE. IT CAUSED DAMAGED TO THE VEHICLE, INCLUDING A RADIATOR AND COOLANT RESERVE TANK, IN ADDITION TO REPLACEMENT OF THE DEFECTIVE MODULAR/ COOLANT FAN ASSEMBLY. UPDATED 6/19/18*JB

NHTSA ID

10877072

Incident

May 23, 2016

Mileage

190,000 mi

THERE IS A KNOWN SAFETY ISSUE WITH THIS 2001 VOLVO V70 XC AWD TRANSMISSION AND IT NEEDS TO BE ADDRESSED ASAP. VOLVO AND THE NHTSA BOTH KNOW ABOUT THIS ONGOING PROBLEM AND REFUSE TO FIX THE PROBLEM. THE TRANSMISTION SLIPS BAD AND STOPS WORKING AND LOSES POWER AND THE DEALERS STATES THE COMPUTER UPDATES WILL FIX THE PROBLEM AS EVEN TOLD BYE THE DEALER ITS A KNOWN ISSUE THAT VOLVO REFUSES TO RECTIFY UNFORTUNATELY. BUT THIS IS A SAFTY ISSUE AT THIS POINT THERE ARE SO MANY COMPLAINTS AND I WANT TO KNOW WHY NOTHING IS BEING DONE AFTER ALL THESE YEARS ? I WANT A REBUILT OR NEW SAFE TRANSMISSION INSTALLED AT THE COST OF VOLVO FOR NOT FIXING THE ONGOING PROBLEMS THEY KNEW ABOUT BACK IN 2001 AND THERE COMPLETE WRONG MAINTENANCE ON THE TRANSMISSION STATING NOT TO CHANGE THE FLUID UNTIL 90K. I BELIEVE THE NHTSA HAS MANY COMPLAINTS IN REFRANCE TO THIS SAME ISSUE WHY IS NOTHING BEING DONE ?

NHTSA ID

10820848

Incident

Nov 2, 2015

Mileage

183 mi

TL* THE CONTACT OWNS A 2001 VOLVO V70. WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR ROUTINE INSPECTION, IT WAS DISCOVERED THAT THE FUEL PUMP WAS FRACTURED AND LEAKING DUE TO DEFECTIVE MATERIAL. THE FUEL PUMP WAS REPLACED. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 106,000.

NHTSA ID

10724316

Incident

Jun 5, 2015

Mileage

106,000 mi

TRANSMISSION HAS HAD PROBLEMS FOR ABOUT THREE YEARS. WE WERE TRAVELING ON THE HWY AND THE CAR STARTED SHAKING, THEN STOPPED. WE HAD TO HAVE IT TOWED TO OUR MECHANIC. NEEDS NEW TRANSMISSION AND ALTERNATOR WHICH WOULD COST MORE THAN IT IS WORTH. OUR MECHANIC HAS SEEN A NUMBER OF 2001S WITH PROBLEMATIC TRANSMISSIONS. WE ARE VERY DISAPPOINTED IN VOLVO FOR NOT FIXING THIS PROBLEM. NOW THIS BEAUTIFUL CAR IS SITTING IN OUR DRIVEWAY UNUSED.

NHTSA ID

10721930

Incident

May 17, 2013

Mileage

113,000 mi

FIRST TIME, WAS IN A DRIVE THROUGH & JUST TOOK OFF, HOPPED THE CURB, AND HIT TALK BOX. NEXT 2 TIMES WERE STOPPED QUICKLY BY ME PUTTING IN NEUTRAL. LAST TIME WAS JUST LEAVING PARKING SPACE, AND CAR JUMPED CURB AND I STOPPED 4 FT. FROM BRICK WALL. HAVE HAD IT TESTED 2-3 TIMES BY MECHANICS W/O SUCCESS. *TR

NHTSA ID

10713148

Incident

Dec 19, 2014

Mileage

170,000 mi

I NOTICED THE TAIL LIGHT BRAKE BULBS WERE BURNING OUT QUICKLY. AFTER GETTING A TICKET I STOPPED DRIVING IT UNTIL I COULD DETERMINE THE CAUSE. VOLVO LISTS A BRAKE RELAY RECALL. BRAKE LIGHT FUSES AND RELAYS ARE IN 4 LOCATIONS IN THE CAR. THEY ARE: 1. UNDER THE HOOD IN THE ENGINE CONTROL UNIT ECU, 2.THE PASSENGER COMPARTMENT A. CENTRAL CONTROL UNIT CCU AND B. FUSE PANEL BY DRIVERS SIDE DOOR POST 3. REAR CONTROL UNIT IN THE CARGO COMPARTMENT. THE PROBLEM WAS AN ELECTRICAL ENGINEERING DESIGN WHERE A STEEL RACE THAT SURROUNDS THE TAILLIGHT BULBS TRANSFERS THE ELECTRICAL CURRENT IS DESIGNED TO FAIL. AS THE BULB HEATS UP IT TRANSFERS THE HEAT TO THE PLATE AND PLASTIC PINS THAT HOLD IT IN PLACE UNDER PRESSURE FROM THE SPRING STEEL PARTS OF THE REMOVABLE BULB SOCKET UNIT. AS THE PLASTIC PINS WEAKEN AND MOVE AWAY UNDER PRESSURE AND HEAT FROM THE BULB SOCKET SPRING STEEL KEEPERS, AND CONDUCTORS OF VOLTAGE AND CURRENT, THE CURRENT IS THROTTLED DOWN TO A PIN POINT AS THE PLATE MOVES AWAY FROM THE BULB CREATING MORE HEAT AND ARCING TO MELT THE STEEL RACE SURROUND THE BULBS THAT SUPPLY THE CURRENT. THE REPLACED BULBS SEEM TO WORK FOR A SHORT TIME AS THE CONNECTION IS REESTABLISHED WHEN THE BULB SOCKET IS REMOVED AND REPLACED, AND THE CONNECTION IS REESTABLISHED FOR A TIME, BUT IT WILL SOON OVER HEAT AND FAIL FROM THE WEAKENED AND MELTED PLASTIC LENS. BRAKE LIGHT FAILURE RESULTS NOT FROM A FAILED PART, RELAY, FUSE OR WIRE, BUT FROM AN ENGINEERING DESIGN FLAW THAT WAS RECOGNIZED AND ELIMINATED IN THE 2005 MODELS. FORD AND VOLVO NEVER MENTION THIS. A RECALL COULD AMOUNT TO SIX HUNDRED TO A THOUSAND DOLLARS PER CAR FOR THE 4 LENSES WITH LABOR. THE ARCING IN THE WIRING MAY ALSO CAUSE OTHER COMPUTER FAILURES AS THE TRANSMISSION ALSO HAS AN ELECTRICAL PROBLEM IN THE KICKDOWN PROCESS THAT CAUSES AN ABNORMAL DELAY IN NEUTRAL GEAR AND HARD ENGAGEMENT OF THE LOWER GEAR. *TR

NHTSA ID

10667711

Incident

Apr 2, 2014

Mileage

128,000 mi

THE IGNITION IS SHUT OFF MOMENTARILY AS THE TRANSMISSION ATTEMPTS TO DOWNSHIFT CAUSING IT TO SLIP INTO NEUTRAL THEN ENGAGE THE LOWER GEAR HARD AS THE TRANSMISSIONS COMPUTER REESTABLISHES CONTROL. THIS ACTION IS RECORDED ON A VIDEO CAR CAMERA OPERATED BY THE IGNITIONS ON AND OFF POSITION. THE HARD SHIFTING PROBLEM THOUGHT TO BE FIXED BY SOFTWARE UPDATE MAY BE ADDRESSING THE SYMPTOM NOT THE CAUSE. ACCELERATION IS ALSO AFFECTED AT OTHER TIMES WHERE THE FOOT PEDAL IS INOPERABLE, BUT REESTABLISHED WHEN SHUTTING THE IGNITION OFF AND ON. THE DRIVE TRAIN BECOMES WOBBLY AFTER A SHORT PERIOD OF TIME AT HIGHWAY SPEEDS MAKING TRAVEL BETWEEN CITIES UNSAFE. A CLUNKING SOUND FROM THE REAR, AS BROKEN SPRING OR LOOSE BOWLING BALL MAKES, IS HEARD AT TIMES OF MILD ACCELERATION AT LOWER SPEEDS. PERHAPS A GROUNDING STRAP MY ALLEVIATE STATIC BUILDUP IN THE IGNITION SYSTEM. *JS

NHTSA ID

10592111

Incident

May 12, 2014

Mileage

128,000 mi

I STARTED THE CAR, PLACED THE CAR IN DRIVE GEAR AND IDLED THROUGH THE PARKING LOT TRAFFIC TO THE INTERSECTION BUT THE CAR WOULD NOT ACCELERATE THROUGH THE INTERSECTION THOUGH THE CONDITION RESTORED AFTER I PULLED OVER AND TURNED OFF THE IGNITION AND RESTARTED IT. THEN THE ACCELERATOR FUNCTIONED NORMALLY.HAD A SEMI TRUCK BEEN COMING ALONG, I WOULD NOT BE HERE TO WRITE YOU THIS LETTER. *TR

NHTSA ID

10586226

Incident

May 29, 2013

Mileage

128,000 mi

I BEGAN TO NOTICE A FUEL SMELL AND DRIP MARKS UNDER THE VEHICLE AFTER PARKING THE VEHICLE IN THE GARAGE IN THE EVENING. UPON INVESTIGATION, I NOTED FUEL DRIPS ON THE UNDERBODY OF THE VEHICLE IN AN AREA SLIGHTLY IN FRONT OF THE FUEL TANK AND A DEVELOPING FUEL PUDDLE IMMEDIATELY UNDER THE VEHICLE. FOLLOWING AN INSPECTION AT THE VOLVO DEALER, IT WAS DETERMINED THAT THE ELECTRIC FUEL PUMP WAS LEAKING FUEL. IT WAS EXPLAINED TO ME THAT THE FUEL PUMP HOUSING WAS CRACKED AND LEAKING FUEL AT AN UNSAFE CONDITION. I WAS ADVISED TO REPLACE THE PUMP IMMEDIATELY DUE TO THE HIGH LEVEL OF FUEL LEAKAGE. I WAS ALSO ADVISED THAT THE FUEL TANK SENDING PUMP WAS ALSO DEFECTIVE AND REQUIRED IMMEDIATE REPLACEMENT.

NHTSA ID

10567240

Incident

Oct 15, 2013

Mileage

206,450 mi

I BEGAN TO NOTICE A FUEL SMELL AND DRIP MARKS UNDER THE VEHICLE AFTER PARKING THE VEHICLE AFTER DRIVING INTO THE GARAGE IN THE EVENING. UPON INVESTIGATION, I NOTED FUEL DRIPS ON THE UNDERBODY OF THE VEHICLE IN THE AREA SLIGHTLY IN THE FRONT OF THE FUEL TANK. I ALSO NOTICED THE DEVELOPMENT OF A FUEL PUDDLE IMMEDIATELY UNDER THE VEHICLE IN THAT LOCATION. I IMMEDIATELY CONTACTED THE VOLVO DEALER FOR SERVICING. ONCE AT THE DEALER, IT WAS DETERMINED THAT THE ELECTRIC FUEL PUMP WAS LEAKING FUEL. IT WAS EXPLAINED TO ME THAT THE FUEL PUMP HOUSING WAS CRACKED AND LEAKING FUEL AT AN UNSAFE CONDITION. I WAS ADVISED TO REPLACE THE PUMP IMMEDIATELY DUE TO THE HIGH LEVEL OF FUEL LEAKAGE. I WAS ALSO ADVISED THAT THE FUEL TANK SENDING PUMP WAS ALSO DEFECTIVE AND REQUIRED IMMEDIATE REPLACEMENT. THE VOLVO DEALER, JENKINS IMPORTS, REPLACED THE DEFECTIVE UNITS ON 22 OCTOBER 2013. I HAVE RETAINED THE DEFECTIVE PARTS. *TR

NHTSA ID

10557644

Incident

Oct 15, 2013

Mileage

206,450 mi

TRANSMISSION SHIFTS WITH A CLUNK INTO 2ND AND 3RD GEARS AS WELL AS INTO FIRST. HESITANT TO SHIFT INTO FIRST GEAR WHEN MOVING FROM A STOP. TRANSMISSION NOT SAFE!!!!

NHTSA ID

10541842

Incident

Sep 1, 2013

Mileage

127,000 mi

TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT THE TRANSMISSION SERVICE WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE ENGINE RPMS INCREASED AND THE VEHICLE SHIFTED SLOWLY, GOING THROUGH EVERY GEAR. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE TRANSMISSION NEEDED TO REPLACE. THE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 113,448 AND THE FAILURE MILEAGE WAS UNKNOWN. *TR

NHTSA ID

10505612

Incident

Feb 4, 2013