2001 Volvo V70

ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.

PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.

The contact owns a 2001 Volvo V70. The contact stated that while the vehicle was idling, the engine caught fire. The air bag warning light was illuminated. There was damage to the garage. There were no reported injuries. The fire department extinguished the fire and confirmed the origin of the fire was the engine. A police report was filed. The vehicle was towed to an independent mechanic. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 178,000.

NHTSA ID

11451932

Incident

Jan 30, 2022

Mileage

178,000 mi

Been trying to get the airbags serviced and replace since I received the notice from Volvo on Dec.14 2021. I have made several appointments in my area to get this matter fixed, Dealers in my area either don't have replacement in stock or don't know of the recall contract Volvo CarUSA LLC they could not help me, now I am receiving text message on dash saying SRS Airbag service Urgent. Any help would be appreciated. Sincerely [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11451736

Incident

Dec 14, 2021

Received an airbag recall. There is no local dealer but there are authorized non-dealer service shops that do replace airbags. Under the recall a Volvo dealer must do the replacement. The nearest Volvo dealer is 300 miles away. Volvo will only reimburse for 25 miles of towing. The recall states "If you are unable to have this procedure performed without charge....". Towing cost would be approximately $800.00. How do I, and several others in my area, resolve this issue?

NHTSA ID

11447515

Incident

Jan 10, 2022

I was notified of the recall. Because I live 300 miles away from the nearest volvo dealership, there is no option for me to replace the airbag free of charge. Additionally, there is no plan in place to provide me with a safe vehicle until such a time that my volvo can be repaired. Until I undertake a great risk by traveling 300 miles at great inconvenience and expense, to have this problem resolved, I am expected to take a daily risk by driving this unsafe vehicle.

NHTSA ID

11444282

Incident

Dec 18, 2021

Heater core burst causing severe burn on drivers right foot. An inch and a half deep puddle of boiling hot antifreeze poured out with no warning from center console over gas pedal. Passenger floor area also had boiling antifreeze. Daughter was driving and taken to hospital treated for second degree burns.

NHTSA ID

11419842

Incident

Jun 5, 2021

THE DRIVER'S SIDE SEATBELT DOES NOT ROLL SMOOTHLY EITHER BEING PULLED OUT OR ALLOWED TO RETRACT.WHEN YOU PULL OUT ' OR RELEASE TO RETURN THE DRIVER'S SIDE SEATBELT, IT CATCHES IN THE BOTTOM OF THE SLOT IN THE SIDE POST WHERE IT CURVES FORWARD SO THAT IT EITHER WON'T COME OUT FAR ENOUGH TO LATCH, OR IF YOU CAN PULL IT OUT AND INSERT IT IN THE LATCH, IT STICKS WHEN YOU LET IT GO SO THAT IT STAYS SLACK AND DOES NOT RETRACT TO KEEP THE BELT TIGHT. EVEN IF YOU MANAGE TO GET IT OUT AND PROPERLY INSERTED, IT WILL NOT RETRACT WHEN RELEASED. . THE BELT HAS TO BE KEPT UP IN THE HIGHEST PART PF THE SLOT IN THE POST THAT IT COMES OUT OF, OR IS RETRACTED BACK INTO, WITH MY LEFT HAND WHILE BEING PULLED OUT OR ALLOWED TO RETRACT, OR ELSE IT GETS STUCK IN THE BOTTOM OF THE SLOT.. IT IS NOT SAFE. EVEN IF PROPERLY CLICKED IN, YOU COULD NOT COUNT ON IT TO RETRACT TIGHTLY IF THERE IS A COLLISION OR SUDDEN STOP.

NHTSA ID

11331366

Incident

Jun 1, 2020

Mileage

82,000 mi

TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT NOTICED A FUEL ODOR AROUND AND INSIDE THE VEHICLE. THE CONTACT ALSO NOTICED FUEL LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 69,000.

NHTSA ID

11280896

Incident

Apr 1, 2019

Mileage

69,000 mi

TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE FRONT DRIVER AND PASSENGER SEATS WERE MELTING AND BLACK SMOKE WAS EMERGING FROM THE SEATS. ADDITIONALLY, THERE WAS AN ABNORMAL BURNING SMELL EMERGING FROM THE VEHICLE. THE CONTACT STATED THAT THE BATTERY WAS REPLACED IN THE VEHICLE PRIOR TO THE FAILURE. THE CONTACT DISCONNECTED THE CIRCUITS TO THE SEATS. THERE WERE NO WARNING LIGHTS ILLUMINATED. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE FAILURE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000. THE VIN WAS INVALID.

NHTSA ID

11217130

Incident

Sep 1, 2017

Mileage

105,000 mi

This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform the test. Follow service procedure
 Description and Service sections updated to clarify that vehicle reports are not required.

This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval. This TJ will be regularily updated as items are added or removed from prior approval.
 Current items under prior approval are listed in the "Service" section

This is a Technical Journal. Vehicle type and platform identification.

This is a Technical Journal: Remote connection, BOMGAR application. Before joining a remote session:
 •Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V.
 •Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.

Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles.
 Volvo Car Investigations have identified that there is a pairing issue with the key fob.
 As a result, there is a possibility that the customer’s key fob is not paired to the vehicle.
 The corrective action is to download SP Software.
 S10303 affects 151 vehicles in the U.S and 5 in Canada.

Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles.
 Volvo Car Investigations have identified that there is a pairing issue with the key fob.
 As a result, there is a possibility that the customer’s key fob is not paired to the vehicle.
 The corrective action is to download SP Software.
 S10303 affects 151 vehicles in the U.S and 5 in Canada.