2001 Volvo S60

VOLVO IS RECALLING APPROXIMATELY 1,681 MODEL YEAR (MY) 2001-2002 S60 VEHICLES WITHIN THE STATES OF ARIZONA AND NEVADA TO REPLACE THE FUEL PUMP.VOLVO REPORTS THAT THE FUEL PUMP IN THESE VEHICLES MAY EXPERIENCE A FUEL LEAK AS A RESULT OF FUEL QUALITY AND HOT CLIMATE CONDITIONS.THE MOST COMMON SYMPTOM REPORTED IS FUEL SMELL.NO FIRES, CRASHES OR INJURIES ARE REPORTED.MY 2003 AND LATER S60 VEHICLES CONTAIN A DIFFERENT DESIGN FUEL PUMP.DATA FROM VOLVO INDICATES THAT A HIGHER RATE OF FUEL PUMP ODOR AND/OR LEAKAGE EXISTS WITH VEHICLES REGISTERED IN THE HOT STATES OF ARIZONA AND NEVADA.WARRANTY DATA SHOWS MANY MORE FUEL PUMP CLAIMS FOR MY 2001 AND 2002 (244 AND 140) COMPARED WITH MY 2003, 04, 05 AND 06 (18, 3, 4, AND 1 RESPECTIVELY).FURTHERMORE, THE FUEL PUMP WARRANTY CLAIM ACTIVITY IS HIGHEST IN THE STATES OF ARIZONA AND NEVADA (25% AND 10%) COMPARED WITH THE REMAINDER OF THE US (0.16%) BASED ON VEHICLE SALES POPULATION IN THESE AREAS.FOR ADDITION DETAILS SEE RECALL 07V152.THIS INVESTIGATION IS CLOSED

ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.

PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.

1. The vehicle caught fire while driving. The radiator cooling fan stayed on after parking, The vehicle the night before. The vehicle had to be jump started the next morning. yes the vehicle is available for inspection. 2. bodily injury and property damage could have been caused by the fire. 3. Yes. independent service center. Automotive Body and Tire Center. (Skokie IL) 4. Yes. Fire was put out by prospect heights fire department. Police report #PHP23-004049 5. No warning lamps prior to the fire. Symptom of problem was the radiator cooling fan staying on after vehicle was turned off, which caused the battery to discharge.

NHTSA ID

11527162

Incident

May 29, 2023

TERRIBLE GAS SMELL EVERY TIME I DRIVE IT. I GOT SOMEONE TO CHECK IT OUT, THERE IS GAS LEAKING FROM THE FUEL PUMP. THIS PERSON PUT SOME PUTTY OVER THE LEAK WHICH STOPPED THE SMELL BUT THIS IS NOT SAFE. I SEE A RECALL FOR THE FUEL PUMP BUT IT SAYS MY CAR DOESN'T HAVE A CURRENT RECALL.

NHTSA ID

11415529

Incident

Apr 30, 2021

I HAVE AN SRS AIRBAG WARNING LIGHT STAYS ON AND WILL NOT GO AWAY. THE ELECTRICAL WIRING FOR THE HEADLIGHTS ARE FAULTY, I TRIED EVERYTHING TO FIX THEM NOTHING WORKS. I USED AN INLINE FUSE WITH THE HEADLIGHT WIRING BECAUSE THE BULBS THE CONTINUE TO BLOWOUT. THE VOLVO FORUM SUGGESTED THE INLINE FUSE TO FIX THE ISSUE, BUT IT DID NOT. ONE HEADLIGHT REMAINS ON THE DRIVER SIDE AND THE PASSENGER SIDE COMES ON AND OFF WHEN IT WANTS TO AND IT ALSO DISPLAYS DIPPED BULB FAILURE OR BEAM FAILURE.

NHTSA ID

11309767

Incident

Feb 14, 2019

TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL FROM THE TOP OF THE FUEL TANK AND FUEL PUMP. THE CONTACT CALLED THE MANUFACTURER AFTER RESEARCHING THE FAILURE AND WAS INFORMED THAT THERE WAS NO RECALL. THE MANUFACTURER FURTHER STATED THAT THE FAILURE OCCURRED IN STATES IN WARMER ZONES THAN THE CONTACT'S STATE, AND DISCONNECTED THE CALL. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE MILEAGE WAS 220,000.

NHTSA ID

11203643

Incident

Apr 18, 2019

Mileage

220,000 mi

EXTREME GAS SMELL INSIDE CAR. NOTICED GAS LEAKING FROM TOP OF TANK BY THE SCREWS THAT HOLD IT. VEHICLE WAS PARKED IN MY DRIVE WAY AND AS SOON AS MY KIDS GOT IN THEY NOTICED THE STRONG SMELL. NOT DRIVING IT DEFENETLY CAN CAUSE A FIRE.

NHTSA ID

11197029

Incident

Apr 15, 2019

CAR STALLED WHILE DRIVING THEN WOULD NOT GO ANY FASTER THAN 15MPH.

NHTSA ID

11103393

Incident

Jun 20, 2018

Mileage

160,000 mi

I HAVE NOTICED A STRONG FUEL ODOR INSIDE AND OUTSIDE OF CAR. IT IS ALSO LEAKING FUEL. THE FUEL LEAKING IS UNDERNEATH THE CAR. I DO NOT KNOW EXACTLY WHERE FUEL IS LEAKING. IT IS NOT COMING FROM FUEL FILTER.

NHTSA ID

11016091

Incident

Jun 15, 2017

Mileage

139,000 mi

TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT THERE WAS A FAILURE IN WHICH THE THROTTLE BODY FAILED TO FUNCTION PROPERLY. THE CONTACT EXPERIENCED THE FAILURE WHEN MAKING A TURN OR WHILE DRIVING VARIOUS SPEEDS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INDICATED THAT THE TIME FRAME HAD EXPIRED FOR THE VEHICLE TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 06V441000 (VEHICLE SPEED CONTROL). THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO THE DEALER. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

10944579

Incident

Jan 9, 2017

This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform the test. Follow service procedure
 Description and Service sections updated to clarify that vehicle reports are not required.

This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval. This TJ will be regularily updated as items are added or removed from prior approval.
 Current items under prior approval are listed in the "Service" section

This is a Technical Journal. Vehicle type and platform identification.

This is a Technical Journal: Remote connection, BOMGAR application. Before joining a remote session:
 •Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V.
 •Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.

Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles.
 Volvo Car Investigations have identified that there is a pairing issue with the key fob.
 As a result, there is a possibility that the customer’s key fob is not paired to the vehicle.
 The corrective action is to download SP Software.
 S10303 affects 151 vehicles in the U.S and 5 in Canada.

Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles.
 Volvo Car Investigations have identified that there is a pairing issue with the key fob.
 As a result, there is a possibility that the customer’s key fob is not paired to the vehicle.
 The corrective action is to download SP Software.
 S10303 affects 151 vehicles in the U.S and 5 in Canada.