2001 Volvo S60 Driver assistance Problems

CAR STALLED WHILE DRIVING THEN WOULD NOT GO ANY FASTER THAN 15MPH.

NHTSA ID

11103393

Incident

Jun 20, 2018

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT THERE WAS A FAILURE IN WHICH THE THROTTLE BODY FAILED TO FUNCTION PROPERLY. THE CONTACT EXPERIENCED THE FAILURE WHEN MAKING A TURN OR WHILE DRIVING VARIOUS SPEEDS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INDICATED THAT THE TIME FRAME HAD EXPIRED FOR THE VEHICLE TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 06V441000 (VEHICLE SPEED CONTROL). THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO THE DEALER. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

10944579

Incident

Jan 9, 2017

TL* THE CONTACT OWNS A 2001 VOLVO S60. WITHOUT WARNING, THE VEHICLE FAILED TO ACCELERATE OVER 20 MPH. THE VEHICLE DRASTICALLY REDUCED SPEED AND STALLED SEVERAL TIMES WITHOUT WARNING. THE VEHICLE WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 06V441000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

10927183

Incident

Aug 1, 2016

CAR JERKS AND CLUNKS WHEN SWITCHING GEARS. ITS STARTING TO GRIND AND CLACK IN 1-2 GEAR AND I HOPS AROUND THE RPMS LINE CRAZY.

NHTSA ID

10838986

Incident

Feb 15, 2016

Mileage

118,632 mi

DESPITE SEVERAL SERVICE BULLETINS AND RECALL, THE VOLVO DEALERSHIP REFUSED TO HONOR THE RECALL #155 CAMPAIGN CHARGING ME $1,120.92 FOR A NEW ELECTRONIC THROTTLE. WE WOULD LIKE TO KNOW WHERE WE CAN SEND THIS INVOICE FOR REIMBURSEMENT. WE ALSO WOULD LIKE THE ADMINISTRATION TO TRIPLE FINE VOLVO CARS FOR ITS BLATANT DISREGARD OF THE LAWS GOVERNING RECALLS. *TR

NHTSA ID

10560161

Incident

Jul 6, 2013

Mileage

87,254 mi

TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 65 MPH ON CRUISE CONTROL, THERE WAS A SUDDEN LOSS OF ENGINE POWER AS THE SERVICE ENGINE URGENT WARNING LIGHT ILLUMINATED. THE SERVICE ENGINE URGENT WARNING ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNABLE TO BE REPLICATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 06V441000 (VEHICLE SPEED CONTROL) IN 2011. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 205,000.

NHTSA ID

10551150

Incident

Nov 1, 2013

Mileage

205,000 mi

TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE FAILED TO ACCELERATE FROM A COMPLETE STOP. THE CONTACT CONTINUED TO APPLY PRESSURE TO THE ACCELERATOR PEDAL AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE THROTTLE NEEDED TO BE REPLACED. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC WHERE THE ELECTRONIC CONTROL MODULE WAS REPLACED BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 131,000.

NHTSA ID

10450610

Incident

Feb 24, 2012

Mileage

131,000 mi

TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT THE ELECTRONIC THROTTLE MODULE WAS DEFECTIVE, CAUSING THE VEHICLE TO SURGE ABNORMALLY. THE VEHICLE WOULD ALSO STALL INTERMITTENTLY AND EXHIBIT AN ABNORMAL INCREASE IN ENGINE RPMS. THE DEALER AND MANUFACTURER WERE BOTH NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 105,000.

NHTSA ID

10441340

Incident

Dec 22, 2008

Mileage

90,000 mi

MAKING A LEFT TURN, CHANGING LANES, SLOWING DOWN. ENGINE REVVED UP TO NEAR MAXIMUM. I WAS ABLE TO CONTROL THE VEHICLE. AFTER ENGINE RETURNED TO NORMAL SPEED, NO FURTHER PROBLEMS UNTIL 12/14/11. ON THAT DATE, A REPEAT OF THE SURGE. I HAVE OWNED THIS CAR FOR 7 YEARS. THESE INCIDENTS HAPPENED ONLY AFTER THE LAST SERVICE AT THE DEALER. *TR

NHTSA ID

10440129

Incident

Sep 1, 2011

Mileage

66,000 mi

2001 VOLVO S60. ATTORNEY WRITES ON BEHALF OF CONSUMER IN REGARDS TO PROBLEMS WITH VEHICLE AS DESCRIBED IN NHTSA ACTION NUMBER PE05-041*TGW THE VEHICLE WAS TAKEN TO THE DEALER REGARDING THE RECALL. HOWEVER, THE VEHICLE WAS NOT EXHIBITING THE CHARACTERISTICS AT THE TIME. THE DEALER CLAIMED THEIR DIAGNOSTIC TEST DID NOT INDICATE ANYTHING WRONG WITH THE ETM, BUT THERE COULD HAVE BEEN SOMETHING WRONG WITH AN OUTSIDE TEMPERATURE SENSOR, WHICH THEY SUGGESTED MIGHT BE A PART OF THE PROBLEM. THE CONSUMER WAS CHARGED $103 FOR THE DIAGNOSTIC TEST, AND THEY INDICATED IT WOULD COST $270 TO REPLACE THE SENSOR. THE CONSUMER DECLINED THE REPAIRS. THE CONSUMER TOOK THE VEHICLE TO A REPAIR FACILITY AND THEY REPLACED BOTH TEMPERATURE SENSORS. FOLLOWING THE REPLACEMENT OF THE SENSORS, THE TECHNICIAN REPORTED THE VEHICLE EXHIBITED SYMPTOMS OF SURGING, IDLE FLUCTUATING AND LOSS OF POWER. CLEARLY, THE SENSORS WERE NOT THE PROBLEM. THE CONSUMER IS SEEKING REIMBURSEMENT FOR THE DIAGNOSTIC TEST.*JB

NHTSA ID

10430921

Incident

Oct 1, 2011

2001 VOLVO S60 - GAS LEAK FROM ABOVE THE FUEL TANK. STRONG GAS ODOR, DISCOVERED FUEL DRIPPING DOWN SIDE OF TANK UNDER VEHICLE ON PASSENGER'S SIDE. DROVE FOR AT LEAST 2 WEEKS OR MORE BEFORE I FIGURED OUT IT WAS MY CAR THAT CREATING THAT GAS SMELL AT LIGHTS (ONLY NOTICED WHEN WINDOW WAS DOWN). UNTIL VEHICLE BEGAN LEAKING A LOT OF GAS AND ODOR WAS OVER POWERING. WAS TOLD VOLVO'S "EXTENDED WARRANTY" WOULD NOT COVER THE DEFECTIVE FUEL PUMP BECAUSE THE "EXTENDED WARRANTY" WAS ONLY FOR 10 YEARS OR 150,000 MILES. HAD VEHICLE REPAIRED AT MY EXPENSE. ONE DAY AFTER REPAIR AN EVEN WORSE GAS LEAK APPEARED UNDER VEHICLE ON DRIVER'S SIDE ABOVE REAR GAS TANK. NOT RESOLVED AS OF DATE OF COMPLAINT. PUDDLE OF GAS UNDER VEHICLE. GAS ODOR STRONG REALLY AFRAID TO DRIVE IT BACK TO THE MECHANIC. ADDITIONAL COMPLAINT: INTERMITTENT LURCHING OR SURGING OF SAME VOLVO S60 AT LOW SPEEDS SHORTLY AFTER STARTING. IT LUNGES FORWARD AND THEN PULLS BACK WITH NO DEPRESSING OF ACCELERATOR. IT IS A MANUAL TRANSMISSION SO THE LURCHING IS VERY ALARMING CONSIDERING NO ADDITIONAL DEPRESSION OF THE ACCELERATOR IS HAPPENING WHEN IT RANDOMLY LUNGES FORWARD. USUALLY STOPS LUNGING AFTER 10 MINUTES OF DRIVING. *TR

NHTSA ID

10295479

Incident

Dec 1, 2009

INTERMITTENT FAILURE OF ELECTRONIC THROTTLE IN 2001 VOLVO S60. FORTUNATELY OCCURRED IN PARKING LOT WITH VEHICLE AT REST. VEHICLE SUDDENLY STOPPED RESPONDING TO THROTTLE. TURNED OFF VEHICLE AND DID VISUAL AND TACTILE SURVEY OF THROTTLE PEDAL AREA. RESTARTED VEHICLE AND PROBLEM DISAPPEARED. COULD HAVE BEEN VERY SERIOUS SITUATION HAD VEHICLE BEEN AT SPEED. *TR

NHTSA ID

10262814

Incident

Mar 23, 2009

Mileage

157,430 mi

I GOT THE ETM VEHICLE SPEED CONTROL RECALL FIXED BUT MY CAR IS DOING IT AGAIN. IS IT NORMAL FOR THIS TO HAPPEN AGAIN AND CAN I GET IT FIXED FOR FREE AGAIN? PLEASE LET ME KNOW BECAUSE MY CAR IS STARTING TO STALL OUT ON ME AND I'M AFRAID OF GETTING INTO AN ACCIDENT. THANK YOU *TR

NHTSA ID

10252904

Incident

Dec 10, 2008

WHILE STOPPING AT A TRAFFIC LIGHT, I NOTICED ALL THE WARNING LIGHTS ON THE LOWER RIGHT SIDE OF THE INSTRUMENT PANEL CAME ON AND IMMEDIATELY WENT OFF, NO OTHER INDICATIONS. WHILE WAITING AT THE LIGHT, EVERYTHING APPEARED NORMAL. WHEN THE LIGHT CHANGED TO GREEN, I PUSHED ON THE GAS PEDAL TO PULL AWAY AND NOTHING HAPPENED. THE CAR WOULD NOT ACCELERATE AT ALL. NO LIGHTS WERE ON. I PUSHED TO GAS PEDAL TO THE FLOOR AND BACK UP AND THEN HALF WAY DOWN, ABSOLUTELY NOTHING WORKED. IT WOULD NOT GO ANY FASTER THAN IDLE. NO INCREASE IN RPM'S AT ALL, NO MATTER WHAT POSITION THE GAS PEDAL WAS IN. I'M IN THE FAST LANE AT RUSH HOUR AND COULD ONLY GO ABOUT 4 MILES PER HOUR. I MANAGED TO WORK MY WAY OVER THE SIDE OF THE ROAD AND PULL INTO A PARKING LOT. I STOPPED AND PUT THE CAR INTO PARK. I HEARD A "CLICK" AS IF A RELAY WAS RESET. I THEN PUT THE CAR INTO REVERSE AND IT SEEMED TO WORK. I PUT IT IN DRIVE AGAIN AND EVERYTHING APPEARED TO WORK OKAY AFTER THAT. I TOOK IT TO TURNER VOLVO, HERE IN SACRAMENTO, CA AND THEY SAID THEY COULDN'T DUPLICATE THE PROBLEM AND THERE WEREN'T ANY CODES IN THE COMPUTER SO THERE WAS NOTHING THEY COULD DO. THIS WAS AN "EXTREMELY" DANGEROUS SITUATION AND COULD HAVE CAUSED A VERY SERIOUS ACCIDENT, MADE WORSE BY THE FACT THAT MY 5 YEAR OLD NIECE WAS WITH ME AT THE TIME THIS HAPPENED. WE COULD HAVE BEEN KILLED AND TURNER VOLVO SAYS THERE'S NOTHING THEY CAN DO. WELL TURNER, THANKS FOR NOTHING AND FOR TAKING OUR LIVES SO LIGHTLY. MAYBE SOMEDAY A MEMBER OF YOUR FAMILY WILL BE INVOLVED IN AN ACCIDENT CAUSED BY THIS PROBLEM AND THEN WE'LL SEE WHAT YOU THINK. THIS IS AN ONGOING PROBLEM WITH VOLVO'S AND NEEDS TO BE TAKING CARE OF BY THE MANUFACTURER NOT THE PEOPLE WHO TRUSTED YOU ENOUGH TO BUY YOUR CARS. *TR

NHTSA ID

10244370

Incident

Oct 2, 2008

Mileage

112,133 mi

I OWN A VOLVO S60 AND HAVE EXPERIENCED AN ELECTRONIC THROTTLE MODULE FAILURE. AS THE VOLVO DEALER HAS TOLD ME. "OH YEAH, WE KEEP THOSE IN STOCK. MANUFACTURING FLAW. THEY ARE BURNING OUT LIKE CRAZY." THE REPAIR IS GOING TO COST ME $900 USD AND I AM ABSOLUTELY LIVID. SOME RESEARCH HAS YIELDED THAT AN EXCESS OF 200,000 VEHICLES COULD BE AFFECTED AND SO FAR TENS OF THOUSANDS HAVE BEEN DIAGNOSED AND CLEANED, OR REPLACED. MY VEHICLE HAS RECEIVED THE "SOFTWARE UPGRADE 'RECALL'", BUT CLEARLY TO NO AVAIL. MY CAR HAS ONLY 60,000 MILES ON IT AND HAS TO HAVE A FAULTY MANUFACTURED PART REPLACED. I BOUGHT VOLVO FOR THE RELIABILITY AND SERVICE AND THUS FAR, HAVE RECEIVED NEITHER. THIS IS A SERIOUS PROBLEM THAT RESULTS IN EXCESSIVE AND SUDDEN STALLING IN TRAFFIC, OPEN ROAD, AND PARKED CONDITIONS. AS A DIRECT RESULT OF THIS DEFECT, I WAS ALMOST SANDWICHED AND NO DOUBT WOULD HAVE BEEN SERIOUSLY INJURED, IF NOT KILLED, BY TWO TRACTOR TRAILERS ON A MERGE ON ROUTE 295. I'M AFRAID THAT VOLVO AND THE US GOVERNMENT IS AWAITING FATALITIES OR FORD'S SALE TO A FOREIGN COMPETITOR (BMW) BEFORE ISSUING THE RECALL. THIS IS DIRTY POOL AND I AM REQUESTING THIS ASSOCIATION TO MAKE A ONCE GOOD COMPANY REMEMBER THEIR ROOTS IN SAFETY AND RESPONSIBILITY. THANK YOU FOR YOUR TIME. *TR

NHTSA ID

10192205

Incident

May 27, 2007

Mileage

58,240 mi

DT*: THE CONTACT STATED AFTER NHTSA RECALL #06V441000 CONCERNING THE VEHICLE SPEED CONTROL WAS PERFORMED ON THE VEHICLE, IT STALLED WHILE DRIVING 60 MPH WITHOUT PRIOR WARNING. IT WAS MANEUVERED OFF THE ROAD AND RESTARTED. HOWEVER, IT WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHO SUGGESTED THE VEHICLE BE TAKEN TO THE DEALER FOR INSPECTION. THE DEALER WAS NOT CONTACTED. *AK

NHTSA ID

10175764

Incident

Nov 21, 2006

Mileage

83,000 mi

I HAVE APPROXIMATELY 80,000 MILES ON MY VEHICLE AND ON INTERMITTENT OCCASIONS I HAD EXPERIENCED PROBLEMS WITH IDLE FLUCTUATION AND SLIGHT ERRATIC ACCELERATION AND POWER BEHAVIOR. ON ANOTHER OCCASION I WAS ENTERING THE FREEWAY AND AS I ACCELERATED INTO POSITION ON THE FREEWAY THE CAR FELT SLOW TO RESPOND AND SLUGGISH, THEN I RECEIVED AN URGENT ENGINE SERVICE REQUIRED MESSAGE ON MY DASH DISPLAY. AS SOON I HAD THE CHANCE I PULLED OVER TO CHECK ENGINE VITALS, OIL, COOLANT ETC, EVERYTHING WAS GOOD AND I HADN'T NOTICED ANY SERIOUS DRIVABILITY ISSUES BUT RELUCTANT TO TRAVEL AT HIGHWAY SPEEDS ON THE FREEWAY. I INQUIRED WITH THE VOLVO DEALER AT MY NEXT SERVICE WHICH COINCIDED WITH THIS MOST RECENT ISSUE. IT WAS EXPLAINED TO ME THAT THE FAULT CODE INDICATED PROBLEMS WITH THE ELECTRONIC THROTTLE MODULE/SYSTEM (ETM/ETS), AND THAT I COULD EITHER HAVE IT CLEANED WHICH WOULD BE A TEMPORARY FIX, OR REPLACED WHICH WOULD COST OVER $1000.00. THE SERVICE REP CHECKED TO SEE IF THERE WERE ANY RECALLS FOR MY VEHICLE AND THERE WERE NONE THAT APPLIED TO MY VEHICLE AND AS FAR AS TECHNICAL SERVICE BULLETINS WERE CONCERNED THERE WERE TWO THAT APPLIED BUT EVEN THOUGH, MY VEHICLE STILL WOULD NOT QUALIFY UNDER ANY EXTENDED WARRANTY BECAUSE MY VEHICLE WAS PURCHASED IN EUROPE AND SHIPPED IT BACK TO THE U.S. WHAT IS THAT? I THOUGHT ALL VOLVO'S INEVITABLY COME FROM THE SAME PLACE. WHAT SETS MY VEHICLE APART FROM ANY OTHER, ITS STILL U.S. SPEC AND ITS STILL A VOLVO AND WE ARE ALL EXPERIENCING THE SAME PROBLEMS IT APPEARS. AFTER DOING SOME RESEARCH ON THE INTERNET, I HAVE LEARNED THAT THIS IS A COMMON PROBLEM EFFECTING SEVERAL MODEL VEHICLES RANGING FROM YEARS 1999-2002 AND IS A POTENTIALLY LIFE-THREATENING PROBLEM UNDER CERTAIN CIRCUMSTANCES AND WHICH VOLVO HAS REFUSED TO RECOGNIZE AND REFUSES TO ISSUE A RECALL ON THE PROBLEM PART THAT IS NOT MECHANICAL AND IN MY OPINION DOES NOT QUALIFY AS NORMAL WEAR AND TEAR. *JB

NHTSA ID

10173193

Incident

Nov 10, 2006

Mileage

75,000 mi

DT*: THE CONTACT STATED THE VEHICLE ACCELERATED ON ITS OWN AFTER REACHING 30 MPH AND CAUSED AN ACCIDENT. THE CONTACT TRIED BRAKING, BUT THE BRAKES FAILED, DUE TO THE THROTTLE ISSUE. THE VEHICLE WAS NOT TAKEN TO A SERVICE DEALER TO ADDRESS THE ISSUE. A POLICE REPORT WAS TAKEN.

NHTSA ID

10167514

Incident

Sep 5, 2006

Mileage

142,000 mi

AT 53,000 MILES (FEBRUARY 2006) MY CHECK ENGINE LIGHT, SERVICE TRANSMISSION LIGHT AND URGENT SERVICE WARNING LIGHTS CAME ON AT THE SAME TIME. HOWEVER, I WAS I NOT EXPERIENCING ANY NOTICEABLE DRIVABILITY ISSUES. (WITH THE EXCEPTION OF SOME SLIGHTLY ROUGH GEAR SHIFTING - BUT I DIDN'T THINK MUCH OF IT). THE DEALER TOLD ME THAT THE FAULT CODE WAS RELATED TO MY TRANSMISSION AND THAT I NEED A SOFTWARE UPGRADE TO MY TCM (TRANSMISSION CONTROL MODULE). IF THE FAULT CODE RETURNED AFTER THE UPGRADE, MY TRANSMISSION WOULD HAVE TO BE REPLACED. AND THAT MOST LIKELY (99.9%) THE SOFTWARE UPGRADE WOULD CORRECT THE PROBLEM. IN ADDITION, I HAD TO PAY $340 FOR THE SOFTWARE UPGRADE BECAUSE I WAS 6 MONTHS / 3,000 MILES OUT OF WARRANTY AND SOFTWARE ISSUES WHERE NOT COVERED BY THE EXTENDED WARRANTY (3RD PARTY - EASYCARE -[VIA FORD]). A FEW WEEKS LATER (3/5/06), THE CHECK ENGINE COMES ON AGAIN AND THE DRIVABILITY DETERIORATES RAPIDLY ON MY TRIP HOME FROM WORK. HIGH RPM'S - LITTLE POWER - ABRUPT SHIFTING. FORTUNATELY, I WAS CLOSE TO HOME (WITHIN 1 MILE). IT FELT LIKE THE TRANSMISSION FELL APART. I BROUGHT IT TO THE DEALER (3/8/06), AFTER TWO DAYS OF 'TESTING', I'M TOLD THE ETM WAS REPLACED AT NO CHARGE AND TO COME PICK UP THE CAR. I PICKED IT UP AND COULD NOT LEAVE THE DEALER DRIVEWAY. THEY APOLOGIZED PROFUSELY AND SAID THE ETM WAS REPLACED BUT NOTICED THAT THERE IS STILL A PROBLEM. AFTER A FEW DAYS OF TROUBLESHOOTING BY THE DEALER, I WAS INFORMED THAT THE CAR NEEDED A NEW TRANSMISSION (AND I HAD TO PAY AN ADDITIONAL $200 FOR EXTENDED WARRANTY CO-PAY). *NM

NHTSA ID

10164035

Incident

Feb 15, 2006

Mileage

53,000 mi

DT*: THE CONTACT STATED WHILE TRYING TO ACCELERATE TO HIGHWAY SPEEDS, THE VEHICLE STALLED THREE TIMES. THE VEHICLE WAS TRAVELING 30-40 MPH EACH TIME. THE VEHICLE WAS PULLED OVER; THE BATTERY WAS DISCONNECTED, AND THEN RECONNECTED. THE VEHICLE RESTARTED AFTER THE COMPUTER RESET. ALSO, THE VEHICLE WOULD ACCELERATE WHEN THE ACCELERATOR PEDAL HAD BEEN RELEASED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THE ECM MODULE WAS REPLACED. THERE HAVE BEEN NO FURTHER PROBLEMS.

NHTSA ID

10152091

Incident

Jan 12, 2006

Mileage

76,000 mi

SPEED CONTROL PROBLEM. MY 2001 VOLVO S60 LOST POWER LAST NIGHT, WHILE I WAS IN THE FAST LANE DRIVING 70 MPH ON INTERSTATE 5! I RAPIDLY LOST SPEED AND BY SOME MIRACLE WAS ABLE TO WEAVE THROUGH TRAFFIC TO THE ROADSIDE. THE ENGINE CONTINUED TO RUN BUT IT WAS AS IF THE GAS PEDAL WAS NOT CONNECTED TO THE ENGINE. I MANAGED TO PROCEED AT FAST IDLE SPEED TO AN OFF RAMP AND FOUND A PARKING LOT, WHERE I SHUT OFF THE ENGINE. I CONTACTED THE COMPANY I BOUGHT THE CAR FROM AND THEY SUGGESTED THAT I TRY TO RE-START THE ENGINE, WHICH I DID AND THE PROBLEM HAD CORRECTED ITSELF. I HAVE SCHEDULED MY VOLVO FOR SERVICE. THE IRONY IS THAT MY WIFE HAS A 2001 VOLVO XC STATION WAGON AND THE SAME PROBLEM OCCURRED WITH HER VEHICLE LAST SEPTEMBER. THE VOLVO DEALER CORRECTED THE PROBLEM BY REPLACING AN ECM AND RE-PROGRAMMING IT. THE PROBLEM WITH HER VOLVO XC HASN'T RE-OCCURRED. THE REAL CONCERN IS THAT IN BOTH INSTANCES, WE WERE TRAVELING ON AN INTERSTATE FREEWAY AT HIGH SPEED WHEN THE PROBLEM OCCURRED AND ONLY BY PURE LUCK DIDN'T CAUSE AN ACCIDENT!!*JB

NHTSA ID

10150961

Incident

Feb 21, 2006

Mileage

88,590 mi

2001 VOLVO S60 2.4T WITH 88,000 MILES AND RECORD OF REGULAR MAINTENANCE BEGAN SPUTTER AND SHOW A PERFORMANCE REDUCED MESSAGE, CAUSING THE ENGINE TO STOP ACCELERATING AND SLOW DOWN TO A CRAWL. THIS HAPPENED ONCE ON A MAJOR STREET, AND THEN AGAIN ON THE INTERSTATE. BOTH TIMES I WAS ABLE TO GET OUT OF TRAFFIC QUICKLY, THANKFULLY PREVENTING ANY POTENTIAL INCIDENTS. THE MECHANIC, WHO HAS IT NOW, INDICATED THE COMPUTER RECOGNIZED A THROTTLE PROBLEM, BUT NOTHING FROM THERE. VARIOUS OUTLETS MENTIONED A PROBLEM WITH THE ELECTRONIC THROTTLE MECHANISM, THAT WAS NOT BEING PUBLICLY REPORTED BY VOLVO.*AK

NHTSA ID

10149008

Incident

Jan 30, 2006

SEVERAL EPISODES OF SUDDEN LOSS OF POWER WHILE DRIVING. EPISODE 1/28/06 NEARLY RESULTED IN COLLISION AT INTERSECTION WHEN ATTEMPTING TO ACCELERATE THROUGH TURN. ENGINE WARNING LIGHT CAME ON, INDICATING: "REDUCED POWER" MAX SPEED 18 MPH, UPHILL 5 MPH. ENGINE ROUGH, ETM FAILURE.*AK

NHTSA ID

10148927

Incident

Jan 28, 2006

Mileage

72,220 mi

(1) AT AROUND 6:30AM, SATURDAY, JANUARY 7, 2006, I WAS DRIVING IN SAN FRANCISCO GOING DOWNHILL. ONCE I HIT THE BOTTOM OF THE HILL, I BEGAN TAKING A LEFT TURN. (2) IN THE PROCESS OF CONDUCTING MY LEFT TURN, MY CAR COMPLETELY STALLED AND ALL POWER STEERING WAS LOST. HAD THERE BEEN PARKED CARS ON THE ROAD THAT MORNING, I WOULD HAVE DIRECTLY HIT THEM DUE TO THE LACK OF POWER STEERING AS I SLAMMED ON MY BRAKES TO STOP FROM HITTING THE SIDEWALK. IMMEDIATELY, THE "REDUCED PERFORMANCE" LIGHT CAME ON AND FORTUNATELY, AFTER 10 MINUTES OF LEAVING MY CAR IN THE MIDDLE OF THE ROAD BECAUSE IT WOULD NOT START, I WAS ABLE TO START IT AGAIN AND DRIVE IT BACK TO MY HOME. (3) I TOOK THE CAR TO ROYAL MOTORS, 1525 HOWARD STREET, SAN FRANCISCO, CA AND THEY INFORMED ME THAT THERE HAD BEEN AN EXTENDED WARRANTY ASSOCIATED WITH THE ETM FAILURE. HOWEVER, VOLVO HAD INSTRUCTED THEM TO FIRST ATTEMPT TO CLEAN THE ETM AND SEE IF THERE ARE ANY FAILURES AFTER CLEANING. I TOLD THE REPRESENTATIVE THAT IF THIS HAPPENS AGAIN, I MAY NOT BE IN SAN FRANCISCO AS I COMMUTE ON THE FREEWAY TO WORK IN PALO ALTO EACH DAY. THEY SAID THIS IS THE ONLY WAY TO HAVE VOLVO PAY FOR THE ETM FAILURE. SO, I SIMPLY SAID OKAY AND RECEIVED MY CAR BACK THE NEXT DAY. *NM

NHTSA ID

10148047

Incident

Jan 7, 2006

Mileage

56,357 mi

THROTTLE CONTROL MODULE OF MY 2001 VOLVO S60 FAILED. THE VEHICLE WOULD GO FROM A NORMAL DRIVING CONDITION (ROAD LOAD, APPROX. 45 MPH) TO A REDUCED SPEED OF A MAX. 20 - 25 MPH. AFTER TRAIL AND ERROR, I LEARNED THAT AFTER 5 TO 6 ENGINE RESTARTS, I COULD GET THE VEHICLE TO DRIVE NORMAL, WITHOUT THE REDUCED POWER. BUT OVER TIME THE VEHICLE WOULD GO BACK INTO THE SAME REDUCED POWER MODE. *JB

NHTSA ID

10147427

Incident

Mar 1, 2005

Mileage

65,000 mi