2022 Volvo S60

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

My 2022 Volvo S60 Recharge T8 plug-in hybrid has an apparent failure of the High Voltage Coolant Heater (HVCH). When operating in electric mode or while the gasoline engine is off, the vehicle does not provide adequate cabin heat. This raises a safety concern because the electric heating system is also used to provide heated air for windshield defrosting and defogging. The vehicle may require the gasoline engine to operate to provide sufficient heat, potentially compromising windshield defogging performance during cold-weather operation. I am concerned that failure of this component could result in reduced windshield visibility, particularly during Michigan winter driving conditions. I am requesting that NHTSA investigate whether this is a recurring defect affecting Volvo S60 Recharge plug-in hybrid vehicles.

NHTSA ID

11775606

Incident

Oct 1, 2026

When parked, the driver side mirror of various SPA Volvos seem to automatically adjust the driver side mirror in random directions after the driver exits the car. Then, on returning to the car, the mirror is not re-adjusted. Thus, if the driver fails to check the position of the mirror before driving off, they may find themselves in a situation where the mirror is unexpectedly out of alignment and they are unable to view behind them and to the left. They then have to re-adjust the mirror to its proper position while driving, which is unsafe. This is a known problem that has been reproduced by countless dealerships. The common fix is to replace the driver door module, however I believe there should be a recall for this as it poses a safety concern and some drivers may not have the means to pay for the replacement.

NHTSA ID

11743095

Incident

Jun 9, 2026

I reported this issue last year when my car was just barely outside of the extended service plan agreement we had on the car. I had called the dealership with similar issues as well way before hand. My infotainment system which controls all and I mean all of the safety features I paid/am still paying for no longer works. It’s a known issue with Volvo they know and so do other mechanics. Prior to this my instrument panel completely blanked out:went black for a minute while driving. Thankfully the car never shut off but I called them they said see if it happens again and that was that. I only really have my blindspot indicators working everything else doesn’t. With that I lost access to my back up camera, and proximity sensors

NHTSA ID

11665222

Incident

Nov 26, 2024

I purchased a vehicle from a dealership that was aware of faulty airbags that was returned to dealership from another consumer. I discovered the issue a few months later when airbag warning light appeared and had it repaired which included steering wheel airbag, lower knee airbag and the seat belt in September. I did know it was involved in a accident prior to purchase since carfax states airbags did not deploy. A reporter approached me in September to inform me that my vehicle was involved in a story of said dealership selling cars with faulty airbags. The Volvo service advisor and myself did reach out the dealership seeking out financial assistance which they state since the vehicle passed a multi point inspection they are not liable to assist financially. The DA is aware of the situation and I am seeking damages that could have resulted in my bodily injury of lost of life.

NHTSA ID

11623092

Incident

Jul 20, 2024

The indirect measurement TPMS system of this car has misdetected low tire pressure on three occasions. Most recently, on October 3 while driving on the freeway at about 70 MPH the TPMS alert illuminated. I checked the information screen and the display showed low pressure in all four tires. Because I have had misdetection of the right front tire twice before, and that it seemed very unlikely that all four tires would deflate at the same time, I disregarded the alert as a false detection. Later I checked the air pressure in all four tires and found it to be exactly correct. In an earlier episode, as I mentioned the TPMS alerted that the right front tire was low. In this instance, I did not have a history of false detections, so I believed the information to be accurate and immediately exited the freeway and returned home where I had a (very accurate) tire pressure gauge. Of course, the pressure was correct in all tires. I then followed the Volvo recalibration procedure and this completed successfully until later that day when the same tire alerted to low pressure again. I rechecked, again pressure was correct, and re-ran the calibration procedure. I did not have any other false detection again until about a year later when the October 3 incident occurred. The car has had at least one “total system update” to the software to address other issues since the first false detection incident, possibly two (not sure). The problem I am having with this is that Volvo apparently decided to change from direct sensor measurement to indirect wheel speed measurement around 2019 or 2020 as a cost saving measure. That is fine, but the indirect measurement system they are using is causing so many false alarms that now the first thing I think when I see an alert is that it is not a real problem. This is not a good situation. Volvo forums are full of complaints by other owners of similar false alarms. Volvo should fix this problem through software or restore direct measurement.

NHTSA ID

11618880

Incident

Oct 3, 2024

POWER STEERING BRAKES BATTERY ADAS

NHTSA ID

11612411

Incident

May 30, 2022

Car is just back from the dealer for 40k service 2 days ago, while driving about 35mph a turtle icon and a check engine light came on car rate limited itself to 25mph had I been on a faster road I would’ve likely been rear ended

NHTSA ID

11610199

Incident

Aug 22, 2024

Main center display becomes blank at random times. Sometimes this is accompanied by a loud squealing sound from car audio. When display blanks, all HVAC functions stop including defog, also all audio including turn signal indication sound. Sometimes display and functions self recover after approximately 15-20 seconds, sometimes it does not self recover and in these cases the ignition needs to be turned off and the drivers door opened to "turn off" the vehicle systems so that they can restart. The condition is completely random. The condition has been noted by other 2022+ Volvo owners in various forums. The software in my car has been updated following a complaint for this concern, however it has occurred again since the update. Date provided in report details is most recent event.

NHTSA ID

11587636

Incident

Mar 1, 2024

This is a Technical Journal: Text only no attachments - This TJ is issued to highlight potential keyless issues caused by electromagnetic interference from aftermarket equipment and to emphasize the importance of keeping the remote control key away from objects that may emit interference or obstruct radio signals to or from the vehicle.

This is a Technical Journal text only no attachments : Improved 12V battery test in VIDA. The 12V battery test in VIDA has been improved. The improved test lets you check batteries below 11.5V with the battery in the vehicle and a shorter test time. (Follow the instructions in VIDA)Don´t charge the battery before the test, jump start the vehicle if needed. Read out the vehicle with VIDA and start the test.

This is a Tech Journal - Text only no attachments - If a customer experiences a “Propulsion System Performance” message in the DIM with diagnostic trouble code IEM P060700, often in combination with IEM P061A00, please follow the instructions under "Service".

This is a TJ - Text plus 1 PDF attachment - f the headlamp horizontal light aim cannot be adjusted via the set screw, If the horizontal light aim cannot be adjusted because the cogwheel knob is broken, do not replace the entire headlamp. Instead, use the spare part kit part number 32476677 to replace the affected component, please follow the instructions under "Service".

This is a TJ - text only no attachments - If customer complains of a headlamp error message in DIM, in combination with any of the DTCs stated below, follow advice under "Service".

This is a Tech Journal - Text only no attachments - If a customer experiences a “Propulsion System Performance” message in the DIM with diagnostic trouble code IEM P060700, often in combination with IEM P061A00, please follow the instructions under "Service".