2001 Chevrolet Venture

SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.

Symptoms similar to recall 07V349000. Smell of fuel accompanied by liquid on the ground. Inspection by mechanic indicates failure of fuel filler neck and accompanying inlet of the fuel tank itself. Unable to secure fuel filler neck replacement that fits, nor replacement fuel tank.

NHTSA ID

11493015

Incident

Nov 10, 2022

I HAVE A LEAKING FUEL TANK. IT IS DESCRIBED PERFECTLY IN RECALL: 07V349000, GM RECALL # 06230. WHEN I TOOK IT TO THE DEALER, THEY TOLD ME BECAUSE OF HIGHER MILEAGE, IT IS NOT COVERED. I THEN CALLED GM AND THEY TOLD ME THE SAME THING. HOW CAN YOU SELL A VEHICLE WITH A DEFECTIVE PART, PUT IT ON RECALL AND THEN NOT FIX IT? I AM GLAD I FOUND IT BEFORE MY VEHICLE CAUGHT ON FIRE!

NHTSA ID

11156082

Incident

Dec 4, 2018

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2001 CHEVROLET VENTURE. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, AN ODOR OF FUEL WAS PRESENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL TANK WAS CRACKED CAUSING FUEL TO LEAK OUT. THE FUEL TANK WAS REPLACED AND THE FAILURE WAS REMEDIED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 117,000.

NHTSA ID

10947291

Incident

Jan 10, 2017

Mileage

117,000 mi

I WAS TOLD IT HAD INTERMITTENT REAR LIGHTING PROBLEM (DRIVER SIDE REAR LIGHTS WOULD GO IN AND OUT) WHEN PURCHASING VEHICLE USED IN 2012 WITH160,000 MILES, 90% HIGHWAY. HAD REPAIRED IMMEDIATELY FOR SAFETY, LEGAL AND STATE REQUIRED ANNUAL INSPECTIONS (OR SO I THOUGHT). WITHIN 3 MONTHS/75 MILES LATER, IT STARTED AGAIN. ENTIRE WIRING HARNESS AND LIGHT ASSEMBLY WAS REPLACED, TO NO AVAIL. BEFORE I COULD TAKE IT IN AGAIN, BOTH REAR LIGHTS INTERMITTENTLY STOPPED WORKING. PASSENGER SIDE WIRING HARNESS AND LIGHT ASSEMBLY REPLACED. IT WASN'T FIXED.AND BEFORE I COULD GET IT BACK IN THE SHOP, THE FRONT PASSENGER SIDE LIGHTS STARTED THE SAME THING. NEW MECHANIC ASSURES ME, " DON'T WORRY, THERE ARE MANY THINGS I CAN TRY!" LITTLE CONSOLATION FOR THE DRIVERS BEHIND ME OR FOR ME FROM BEING PULLED OVER BY & TICKETED OR WHEN I NEED THE VA STATE MANDATORY "ANNUAL INSPECTION" STICKER. THEY ARE ABLE TO GET THEM TO WORK LONG ENOUGH BUT AGAIN, AT WHAT COST? MEANWHILE, THE INTERMITTENT PROBLEM MOVED TO THE PASSENGER FRONT LIGHTS, WHEN HITTING BRAKES I SEE THAT FLASHERS START TO WORK. ALL OF THE MECHANICS ARE "PUTTING A BAND-AID ON A BROKEN ARM". & II'M PAYING DEARLY EACH AND EVERY TIME. THEY NOW WANT TO REPLACE THINGS IN THE STEERING WHEEL BUT I WANT CHEVROLET TO CORRECT THE PROBLEM THIS TIME OR TELL THE MECHANICS WHAT TO DO. THIS IS A MINI-VAN THAT I DRIVE BACK AND FORTH TO THE GROCERY AND SCHOOL, .5 MILES - 5 MILES A WAY 3-4 TIMES A WEEK.

NHTSA ID

10934328

Incident

Jan 11, 2012

Mileage

160,000 mi

THE FUEL TANK LEAKS AT THE FUEL TANK, LEAK AT THE FUEL TANK FILLER TUBE ATTACHMENT POINT TO THE TANK. THERE IS A RUBBER GROMMET ON THE TANK THAT THE TUBE ATTACHES TO THE TANK WHERE THE LEAK IS. DEFIANTLY A FIRE HAZARD. LEAKS WHEN TANK IS MORE THAN 1/2 FULL. THIS TUBE IS METAL AND THE FUEL TANK FILLER TUBE ATTACHES TO WITH A RUBBER HOSE AND CLAMP. THE CHEVROLET DEALER SAYS THE VIN WAS EXCLUDE FROM NHTSA CAMPAIGN ID NUMBER 07V349000 (FUEL SYSTEM, GASOLINE:STORAGE), ALTHOUGH THE FAILURES WERE IDENTICAL. THE DEALER STATED HAVE TO REPLACE THE FUEL TANK WHICH NOT COVERED.

NHTSA ID

10915570

Incident

Jul 1, 2016

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2001 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 50 MPH IN THE RAIN, THE WINDSHIELD WIPERS FAILED TO OPERATE PROPERLY. AFTER ACTIVATING THE WIPERS, THEY BECAME JAMMED TOGETHER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WIPER TRANSMISSION WAS FAULTY. THE TRANSMISSION WAS REPLACED, BUT THE CONTACT CONTINUED TO EXPERIENCE THE FAILURES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 15,000.

NHTSA ID

10904899

Incident

May 1, 2002

Mileage

15,000 mi

FUEL LEAKING IN THE GROUND AROUND THE DRIVERS SIDE REAR TIRE.

NHTSA ID

10808965

Incident

Nov 10, 2015

Mileage

111,000 mi

THE COOLING SYSTEM OVERHEATS ALOT AND IVE BOUGHT ALOT OF COOLANT BECAUSE OF THIS PROBLEM AND IVE GOTTEN STRANDED A COUPLE OF TIMES AND ITS CRAZY IVE DID SOME RESEARCH AND IT COULD BE MULTIPLE THINGS BUT FOR SURE ITS GOING TO COST ALOT FOR THIS I CANT LAY FOR THESE EXSPENSIVE REPAIRS IM STILL GOING AND PAYING FOR SCHOOL ID JUST WOULD LIKE SOME HELP TO GET THESE EXSPENSIVE REPAIRS FIXED BECAUSE THIS VAN IS MY OWNLY TRANSPORTATION.

NHTSA ID

10749018

Incident

Jul 31, 2015

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.