2001 Chevrolet Venture Problems

WE WERE DRIVING ON THE FREEWAY AND NOTICED THE HEAT GAUGE STARTING TO RISE VERY QUICKLY TO THE RED ZONE. THE ENGINE STALLED AND ONCE THE TEMP CAME DOWN WE PROCEEDED TO AN AUTO PARTS STORE. THERE WE PURCHASED A THERMOSTAT, RADIATOR CAP, AND 2 GALLONS OF PREMIX DEX-COOL. WE INSTALLED THE NEW CAP AND FILLED SYSTEM WITH THE DEX-COOL. WE DROVE ABOUT 7 MILES TO A LAKE FOR A DAY OF FISHING. THE INACCESSIBILITY OF THE THERMOSTAT, I COULD NOT CHANGE THE THERMOSTAT THAT DAY. AFTER SITTING (NOT RUNNING) WE STARTED FOR HOME (60 MILES). WE HAD ONLY GONE ABOUT 10 MILES WHEN IT OVERHEATED FOR THE FIRST TIME. WE COULD ONLY GO ABOUT 10 MILES BEFORE WE'D HAVE TO STOP AND LET THE VAN COOL DOWN AND ADD MORE COOLANT AND WATER. IT TOOK 6 HOURS TO GET HOME. OVER THE NEXT COUPLE OF DAYS THE OVERHEATING PROBLEM CONTINUED. ON 28APR2014 WE HAD THE VAN TOWED TO A LOCAL (REPUTABLE) AUTO SHOP. THE NEXT DAY WE WERE INFORMED THAT THE INTAKE MANIFOLD WAS LEAKING AND WOULD HAVE TO BE REPAIRED BEFORE THEY COULD PRESSURE TEST THE SYSTEM TO CHECK THE OTHER COMPONENTS (RADIATOR, RADIATOR CAP, ETC.) THE COST OF JUST THE INTAKE REPAIR WAS ESTIMATED AT $1500-$2500. I HAVE BEEN RESEARCHING THE ISSUE ONLINE AND FOUND THAT THIS IS A COMMON ISSUE WITH THESE VANS BECAUSE OF THE DEX-COOL BEING A PLASTICIZER AND AN ALUMINUM CORROSIVE. ALSO FOUND OUT THAT GM HAS KNOWN OF THIS PROBLEM BUT HAVE CHOSE NOT TO FIX THE PROBLEM. I HAVE HAD RECALLS ON OTHER VEHICLES (FOR A LESS PROBLEM) BECAUSE THE MANUFACTURERS SAID OK WE HAVE THIS PROBLEM SO TO KEEP OUR CUSTOMERS WE'LL FIX IT, BUT NOT GM. IT WOULDN'T BE SO BAD IF GM EVEN TRIED TO FIX THIS ISSUE. WE ARE MIDDLE-CLASS AND HAVE A HARD TIME MAKING ENDS MEET AND CAN'T AFFORD THIS KIND OF EXPENSE. *TR

CAR WILL SPEED UP ON ITS OWN AND ACCELERATE. THE VENTURE WILL ALSO OVER HEAT AFTER RUNNING FOR 10 MIN. OR SO. THIS VAN LIKES TO STALL WHILE DRIVING AND YOU MUST KEEP YOUR FOOT ON THE BRAKE OR GAS TO PREVENT THIS FROM HAPPENING WHILE DRIVING. TRANSMISSION HAS BEEN SLIPPING SINCE I GOT THE CAR. ONLY OWNED IT LESS THAN A YEAR, NOW IT MADE A LOUD CLANKING NOISE LAST NIGHT AND NOW IT WILL NOT GO IN DRIVE ONLY IN REVERSE. YOU HAVE TO SHIFT GEARS ON THE STEERING COLUMN ONLY AND EVEN THEN IT'S DEBATABLE IF IT WILL RUN. *TR

OTHER PART AFFECTED IS THE JACK THIS STYLE VAN RUSTS THRU IN FRONT OF THE REAR WHEEL WELL WHERE THE JACK IS SUPPOSED TO BE PLACED TO REPLACE THE SPARE TIRE. THERE IS NO LONGER ANY STRUCTURAL SUPPORT RESULTING IN A DANGEROUS CONDITION WHERE THE VAN CAN FALL OFF THE JACK IF YOU ATTEMPT TO PUT THE SPARE TIRE ON. AS A MATTER OF FACT MY CHEVROLET DEALER, AT ABOUT 170,000 MILES, CRUSHED THE WHOLE AREA OF MY CAR WHILE THEY PUT IT ON A LIFT TO REPLACE MY TRANSMISSION LINES. I CAN NEVER SAFELY PUT THE JACK AT THAT LOCATION. THAT IS WHAT ALERTED ME TO THE PROBLEM WHEREAS THE RUST WAS THERE VERY EARLY IN THE LIFE OF THE VAN! *TR

ON 3, JUNE, 2011, THE RIGHT PASSENGER SLIDING DOOR ON OUR 2001 CHEVROLET VENTURE MINIVAN WOULD NOT LATCH ON THE BACK LATCH, RESULTING IN THE DOOR ONLY BEING PARTIALLY, AND DANGEROUSLY LATCHED BY ONLY THE FRONT LATCH. SOMETIMES IT WON'T LATCH ON THE FRONT LATCH EITHER. THIS IS NOT A POWER SLIDING DOOR; BUT I'VE SEEN SEVERAL RECALLS FOR FAILED LATCHES ON THE POWER SLIDING DOORS. WE HAVE CALLED, GONE TO JUNK YARDS TO NO AVAIL, AND DEALERSHIPS SAY THEY DO NOT HAVE THE PARTS TO REPAIR THE LATCH. THIS IS A SAFETY CONCERN, AS THE DOOR COULD COME OFF DURING TRAVEL, OR WORSE, FLY OPEN DURING MOTION, PLACING THE MIDDLE SEAT PASSENGER AT RISK OF FALLING OUT OF A MOVING VEHICLE. FOR SAFETY, DOOR LATCHES ARE SOMETHING THAT SHOULD BE FAIL SAFE IN AUTOMOBILES. ONE DEALERSHIP SAID IT WOULD COST OVER $220.00 TO REPAIR, IF THEY COULD GET THE PARTS. IF??? THE CAR ONLY HAS 152K MILES. IN LIGHT OF THE RECALLS FOR THE POWER SLIDING DOOR LATCHES FAILING, I WOULD THINK GM WOULD HONOR THE FAILURE OF THE DOOR LATCHES ON THE MANUAL SLIDING DOORS. THIS JUST HAPPENED OUT OF THE BLUE, WITH NO PROBLEMS PRIOR TO THE FAILURE. IT JUST QUIT LATCHING. THANK YOU. *TR

SHIFT CABLE BROKEN AT TRANSMISSION. TRANSMISSION WILL NOT SHIFT TO ANOTHER GEAR CAUSING VEHICLE REMAIN IN LAST GEAR SELECTED. PART IS PLASTIC AND LOW QUALITY. *TR

TL*THE CONTACT OWNS A 2001 CHEVROLET VENTURE. THE CONTACT STATED THAT THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN DEPRESSED. THE VEHICLE WAS TAKEN TO A BRAKE SHOP (ALL TUNE AND LUBE) AND THEY REPLACED THE BRAKE PADS, CYLINDER, AND ROTORS. THE CONTACT ALSO STATED THAT THE TEMPERATURE GAUGE WOULD MOVE TO HOT. THE CONTACT HAD THE VEHICLE INSPECTED AND WAS INFORMED THAT THE MANIFOLD GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE REPAIR WAS PERFORMED. THE TRANSMISSION WAS ALSO SLIPPING GEARS. THE CONTACT HAD THE TRANSMISSION FLUID FLUSHED, BUT THAT DID NOT CORRECT THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 96,000.

Symptoms similar to recall 07V349000. Smell of fuel accompanied by liquid on the ground. Inspection by mechanic indicates failure of fuel filler neck and accompanying inlet of the fuel tank itself. Unable to secure fuel filler neck replacement that fits, nor replacement fuel tank.

I HAVE A LEAKING FUEL TANK. IT IS DESCRIBED PERFECTLY IN RECALL: 07V349000, GM RECALL # 06230. WHEN I TOOK IT TO THE DEALER, THEY TOLD ME BECAUSE OF HIGHER MILEAGE, IT IS NOT COVERED. I THEN CALLED GM AND THEY TOLD ME THE SAME THING. HOW CAN YOU SELL A VEHICLE WITH A DEFECTIVE PART, PUT IT ON RECALL AND THEN NOT FIX IT? I AM GLAD I FOUND IT BEFORE MY VEHICLE CAUGHT ON FIRE!

I WAS TOLD IT HAD INTERMITTENT REAR LIGHTING PROBLEM (DRIVER SIDE REAR LIGHTS WOULD GO IN AND OUT) WHEN PURCHASING VEHICLE USED IN 2012 WITH160,000 MILES, 90% HIGHWAY. HAD REPAIRED IMMEDIATELY FOR SAFETY, LEGAL AND STATE REQUIRED ANNUAL INSPECTIONS (OR SO I THOUGHT). WITHIN 3 MONTHS/75 MILES LATER, IT STARTED AGAIN. ENTIRE WIRING HARNESS AND LIGHT ASSEMBLY WAS REPLACED, TO NO AVAIL. BEFORE I COULD TAKE IT IN AGAIN, BOTH REAR LIGHTS INTERMITTENTLY STOPPED WORKING. PASSENGER SIDE WIRING HARNESS AND LIGHT ASSEMBLY REPLACED. IT WASN'T FIXED.AND BEFORE I COULD GET IT BACK IN THE SHOP, THE FRONT PASSENGER SIDE LIGHTS STARTED THE SAME THING. NEW MECHANIC ASSURES ME, " DON'T WORRY, THERE ARE MANY THINGS I CAN TRY!" LITTLE CONSOLATION FOR THE DRIVERS BEHIND ME OR FOR ME FROM BEING PULLED OVER BY & TICKETED OR WHEN I NEED THE VA STATE MANDATORY "ANNUAL INSPECTION" STICKER. THEY ARE ABLE TO GET THEM TO WORK LONG ENOUGH BUT AGAIN, AT WHAT COST? MEANWHILE, THE INTERMITTENT PROBLEM MOVED TO THE PASSENGER FRONT LIGHTS, WHEN HITTING BRAKES I SEE THAT FLASHERS START TO WORK. ALL OF THE MECHANICS ARE "PUTTING A BAND-AID ON A BROKEN ARM". & II'M PAYING DEARLY EACH AND EVERY TIME. THEY NOW WANT TO REPLACE THINGS IN THE STEERING WHEEL BUT I WANT CHEVROLET TO CORRECT THE PROBLEM THIS TIME OR TELL THE MECHANICS WHAT TO DO. THIS IS A MINI-VAN THAT I DRIVE BACK AND FORTH TO THE GROCERY AND SCHOOL, .5 MILES - 5 MILES A WAY 3-4 TIMES A WEEK.

MY MOTHER PURCHASED THE VEHICLE BRAND NEW IN 2001, IT HAS BEEN A PROBLEM SINCE SHE BROUGHT IT HOME. TURN SIGNALS HAVE NEVER WORKED PROPERLY, HEADLIGHTS FILL UP WITH WATER CAUSING THEM TO BURN OUT, INTERIOR LIGHTS DON'T WORK PROPERLY. I ACQUIRED THE VEHICLE AFTER HER PASSING IN 2012 . THE VAN ONLY HAS 66000 MILES ON IT AND I'VE HAD TO REPLACE THE LIGHTS 6 TIMES SINCE I'VE HAD IT. WHEN SHE HAD IT SHE TOOK IT BACK TO THE DEALERSHIP SEVERAL TIMES ONLY TO HAVE THE SAME PROBLEMS HAPPEN AGAIN. I RECENTLY RAN INTO SOMEONE THAT WAS IN THE SAME MAKE, MODEL AND YR VEHICLE AT A GAS STATION, HE ASKED ME IF I HAD ANY ELECTRICAL ISSUES AND OF COURSE I SAID YES..THIS VAN IS A DISASTER WAITING TO HAPPEN.. WHY IS THERE NOT A RECALL ON THIS LEMON? *TR

TL* THE CONTACT OWNS A 2001 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 50 MPH IN THE RAIN, THE WINDSHIELD WIPERS FAILED TO OPERATE PROPERLY. AFTER ACTIVATING THE WIPERS, THEY BECAME JAMMED TOGETHER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WIPER TRANSMISSION WAS FAULTY. THE TRANSMISSION WAS REPLACED, BUT THE CONTACT CONTINUED TO EXPERIENCE THE FAILURES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 15,000.

OUR 2001 CHEVY VENTURE MINIVAN'S WINDSHIELD WIPERS FAILED TO GO BACK DOWN; REMAINING UP, ON THE SIDES OF THE WINDSHIELD AT ABOUT 150,000 MILES. I AM FILING THIS COMPLAINT BECAUSE I SEE MANY OTHER COMPLAINTS WITH THE SAME OR SIMILAR ISSUE. WE HAVE NOT REPLACED THE MOTOR AS YET. *TR

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) I OWN A 2001 GRAY CHEVROLET VENTURE MINIVAN & OFTEN TIMES FOR ABOUT THE LAST 5 YEARS NOW AND EVEN AT THE PRESENT TIME, THE ACCELERATOR SPEEDS UP WITHOUT ANY EXPLANATION AND I HAVE TO PUMP THE BRAKES SEVERAL TIMES BEFORE ATTEMPTING TO TURN THE CAR BACK ON AGAIN TO STOP IT FROM CONTINUOUSLY ACCELERATING. WHEN THE VEHICLE IS OFF AND WHEN I HAVE TO PUMP THE BRAKES, THE BRAKE PEDAL ACTUALLY PUMPS UP TO DEACTIVATE THE ACCELERATION PROCESS TEMPORARILY. THIS HAPPENS OFTEN DURING THE SUMMER MONTHS WHEN AIR CONDITION IS IN USE AND IT ALSO HAPPENS ALOT WHEN YOU ARE DRIVING AND THE ACCELERATOR WILL JUST SPEED UP SUDDENLY FOR NO REASON. I HAVE HAD IT INSPECTED BY THE DEALERSHIP ONCE ABOUT 5 YEARS AGO WHEN THIS FIRST STARTED AND THEY SAY THAT IT IS SOME KIND OF BRAKING SECURITY FEATURE ONCE THEY HOOKED IT UP TO THEIR COMPUTER SYSTEM AND SAID IT WAS NOTHING TO BE CONCERNED ABOUT BUT OTHER AUTO MECHANICS THAT HAVE INSPECTED MY BRAKES ON THE VEHICLE DON'T SEEM TO KNOW ANYMORE THAN THE DEALERSHIP KNOWS BECAUSE THE VEHICLE IS COMPUTERIZED. ALL THE OTHER MECHANICS DO IS CHANGE MY BRAKES PADS WHEN THEY WEAR DOWN BUT CAN'T EXPLAIN THE SUDDEN ACCELERATION NOW THAT I AM HEARING ABOUT ALL OF THE CONTROVERSIES WITH TOYOTA MOTORS BRAKING DEFAULTS AND THE DEATHS AND INJURIES ASSOCIATED WITH IT I AM REALLY GETTING CONCERNED ABOUT MY VEHICLE CONTINUOUSLY ACCELERATING FOR NO EXPLAINABLE REASON. I THINK CHEVROLET WILL PROBABLY TRY AND HID SOMETHING BECAUSE THEY DON'T WANT THE BAD EXPOSURE THAT TOYOTA IS GETTING SO I REALLY DON'T WANT TO DEAL WITH THEM RIGHT NOW ESPECIALLY AFTER THEM TELLING ME BASICALLY NOTHING IN THE PAST. CAN YOU PLEASE ADVICE ME WHAT TO DO??? [XXX] *TR

TL*THE CONTACT OWNS A 2001 CHEVROLET VENTURE. THE CONTACT STATED THAT THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN DEPRESSED. THE VEHICLE WAS TAKEN TO A BRAKE SHOP (ALL TUNE AND LUBE) AND THEY REPLACED THE BRAKE PADS, CYLINDER, AND ROTORS. THE CONTACT ALSO STATED THAT THE TEMPERATURE GAUGE WOULD MOVE TO HOT. THE CONTACT HAD THE VEHICLE INSPECTED AND WAS INFORMED THAT THE MANIFOLD GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE REPAIR WAS PERFORMED. THE TRANSMISSION WAS ALSO SLIPPING GEARS. THE CONTACT HAD THE TRANSMISSION FLUID FLUSHED, BUT THAT DID NOT CORRECT THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 96,000.

THE DRIVER'S SEATBELT WILL ONLY LATCH INTO THE BRACKET ABOUT HALF THE TIME. SOMETIMES IT TAKES UP TO 5 MINUTES TO GET IT TO CLICK IN. OTHERWISE IT JUST WILL NOT CLICK. I HAVE HAD TO STRETCH IT ACROSS TO HOOK IT INTO THE PASSENGER'S SIDE SEATBELT. LUCKILY FOR ME I DIDN'T HAVE A PASSENGER SO I COULD DO THIS BUT I AM WORRIED THAT IN ATTACHING IT INTO THE PASSENGER'S SIDE THAT IT WILL NOT PERFORM SHOULD I NEED IT TO. *TR

THE SAFETY HARNESSES ON SOME SEATS RATCHET UP, LOCK, AND CHOKE THE PERSON USING THEM. THE FIRST ONE TO DO THAT WAS IN THE FAR BACK AND HAD BEEN USED ONLY A FEW TIMES WHEN IT FAILED AND WE REQUESTED THE DEALERSHIP TO REPAIR IT. WE WERE TOLD THAT THE 12-MONTH WARRANTY WAS EXPIRED AND SAFETY BELTS ARE NOT COVERED UNDER EXTENDED WARRANTY. NOW, THE ASSEMBLY THAT HOLDS THE SHOULDER HARNESS TO THE SIDEWALL OF THE VEHICLE, THE BOLTS PULLED COMPLETELY OUT AND THE SHOULDER STRAP IS NOT ATTACHED TO ANYTHING. ALL BUT THE DRIVER'S SHOULDER HARNESS ALSO RATCHETS UP AND LOCKS, NEARLY STRANGLING THE PERSON USING IT. I BELIEVE THERE ARE MAJOR SAFETY ISSUES WITH THESE SEAT BELTS. WE ARE A FAMILY OF 3 AND THE SEAT BELTS IN THE BACK SEATS ARE SELDOM USED, THE PROBLEMS BEGAN WHEN THE VEHICLE WAS FAIRLY NEW, AND THIS IS A MAJOR SAFETY ISSUE, ESPECIALLY THE ONE WHERE THE BOLTS FELL OUT. FORTUNATELY THAT HAPPENED WHEN OUR 13-YEAR-OLD GRANDSON WAS LATCHING IT, NOT IN AN ACCIDENT. I CONTACTED GM AND THEY DENIED ANY RESPONSIBILITY FOR REPAIRING THE SAFETY BELTS. *NM

TL* THE CONTACT OWNS A 2001 CHEVROLET VENTURE. THE CONTACT STATED THAT WHILE INVOLVED IN A CRASH, THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND MINOR INJURIES WERE SUSTAINED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000. THE VIN WAS NOT AVAILABLE. UPDATED 10/2/14*CN UPDATED 05/12/2015 *JS

WE WERE TRAVELING NORTH BOUND GOING ABOUT 60 MPH ON HWY 99 JUST NORTH OF SACRAMENTO. AN AMBULANCE CUT IN FRONT OF US AND SLOWED DOWN. THE RIGHT FRONT OF THE 2001 CHEVY VENTURE STRUCK THE LEFT REAR END OF THE AMBULANCE. THE AIR BAGS DID NOT DEPLOY MY DAUGHTER INJURED HER HAND AND LEGS. I INJURED MY STERNUM, BRUISED MY STOMACH, AND INJURED MY RIGHT LEG. WE DO HAVE PICTURES SHOWING THAT THE AIR BAGS DID NOT DEPLOY. *TR

ON 3, JUNE, 2011, THE RIGHT PASSENGER SLIDING DOOR ON OUR 2001 CHEVROLET VENTURE MINIVAN WOULD NOT LATCH ON THE BACK LATCH, RESULTING IN THE DOOR ONLY BEING PARTIALLY, AND DANGEROUSLY LATCHED BY ONLY THE FRONT LATCH. SOMETIMES IT WON'T LATCH ON THE FRONT LATCH EITHER. THIS IS NOT A POWER SLIDING DOOR; BUT I'VE SEEN SEVERAL RECALLS FOR FAILED LATCHES ON THE POWER SLIDING DOORS. WE HAVE CALLED, GONE TO JUNK YARDS TO NO AVAIL, AND DEALERSHIPS SAY THEY DO NOT HAVE THE PARTS TO REPAIR THE LATCH. THIS IS A SAFETY CONCERN, AS THE DOOR COULD COME OFF DURING TRAVEL, OR WORSE, FLY OPEN DURING MOTION, PLACING THE MIDDLE SEAT PASSENGER AT RISK OF FALLING OUT OF A MOVING VEHICLE. FOR SAFETY, DOOR LATCHES ARE SOMETHING THAT SHOULD BE FAIL SAFE IN AUTOMOBILES. ONE DEALERSHIP SAID IT WOULD COST OVER $220.00 TO REPAIR, IF THEY COULD GET THE PARTS. IF??? THE CAR ONLY HAS 152K MILES. IN LIGHT OF THE RECALLS FOR THE POWER SLIDING DOOR LATCHES FAILING, I WOULD THINK GM WOULD HONOR THE FAILURE OF THE DOOR LATCHES ON THE MANUAL SLIDING DOORS. THIS JUST HAPPENED OUT OF THE BLUE, WITH NO PROBLEMS PRIOR TO THE FAILURE. IT JUST QUIT LATCHING. THANK YOU. *TR

SHIFT CABLE BROKEN AT TRANSMISSION. TRANSMISSION WILL NOT SHIFT TO ANOTHER GEAR CAUSING VEHICLE REMAIN IN LAST GEAR SELECTED. PART IS PLASTIC AND LOW QUALITY. *TR

I WAS TOLD IT HAD INTERMITTENT REAR LIGHTING PROBLEM (DRIVER SIDE REAR LIGHTS WOULD GO IN AND OUT) WHEN PURCHASING VEHICLE USED IN 2012 WITH160,000 MILES, 90% HIGHWAY. HAD REPAIRED IMMEDIATELY FOR SAFETY, LEGAL AND STATE REQUIRED ANNUAL INSPECTIONS (OR SO I THOUGHT). WITHIN 3 MONTHS/75 MILES LATER, IT STARTED AGAIN. ENTIRE WIRING HARNESS AND LIGHT ASSEMBLY WAS REPLACED, TO NO AVAIL. BEFORE I COULD TAKE IT IN AGAIN, BOTH REAR LIGHTS INTERMITTENTLY STOPPED WORKING. PASSENGER SIDE WIRING HARNESS AND LIGHT ASSEMBLY REPLACED. IT WASN'T FIXED.AND BEFORE I COULD GET IT BACK IN THE SHOP, THE FRONT PASSENGER SIDE LIGHTS STARTED THE SAME THING. NEW MECHANIC ASSURES ME, " DON'T WORRY, THERE ARE MANY THINGS I CAN TRY!" LITTLE CONSOLATION FOR THE DRIVERS BEHIND ME OR FOR ME FROM BEING PULLED OVER BY & TICKETED OR WHEN I NEED THE VA STATE MANDATORY "ANNUAL INSPECTION" STICKER. THEY ARE ABLE TO GET THEM TO WORK LONG ENOUGH BUT AGAIN, AT WHAT COST? MEANWHILE, THE INTERMITTENT PROBLEM MOVED TO THE PASSENGER FRONT LIGHTS, WHEN HITTING BRAKES I SEE THAT FLASHERS START TO WORK. ALL OF THE MECHANICS ARE "PUTTING A BAND-AID ON A BROKEN ARM". & II'M PAYING DEARLY EACH AND EVERY TIME. THEY NOW WANT TO REPLACE THINGS IN THE STEERING WHEEL BUT I WANT CHEVROLET TO CORRECT THE PROBLEM THIS TIME OR TELL THE MECHANICS WHAT TO DO. THIS IS A MINI-VAN THAT I DRIVE BACK AND FORTH TO THE GROCERY AND SCHOOL, .5 MILES - 5 MILES A WAY 3-4 TIMES A WEEK.

MY MOTHER PURCHASED THE VEHICLE BRAND NEW IN 2001, IT HAS BEEN A PROBLEM SINCE SHE BROUGHT IT HOME. TURN SIGNALS HAVE NEVER WORKED PROPERLY, HEADLIGHTS FILL UP WITH WATER CAUSING THEM TO BURN OUT, INTERIOR LIGHTS DON'T WORK PROPERLY. I ACQUIRED THE VEHICLE AFTER HER PASSING IN 2012 . THE VAN ONLY HAS 66000 MILES ON IT AND I'VE HAD TO REPLACE THE LIGHTS 6 TIMES SINCE I'VE HAD IT. WHEN SHE HAD IT SHE TOOK IT BACK TO THE DEALERSHIP SEVERAL TIMES ONLY TO HAVE THE SAME PROBLEMS HAPPEN AGAIN. I RECENTLY RAN INTO SOMEONE THAT WAS IN THE SAME MAKE, MODEL AND YR VEHICLE AT A GAS STATION, HE ASKED ME IF I HAD ANY ELECTRICAL ISSUES AND OF COURSE I SAID YES..THIS VAN IS A DISASTER WAITING TO HAPPEN.. WHY IS THERE NOT A RECALL ON THIS LEMON? *TR

1. NORMAL OPERATION 2. AIR CONDITION SYSTEM FAILURE. 3. HAD DYE, REFRIGERANT & SEAL CONDITIONER INSTALLED INITIALLY SYSTEM OK BUT, OVER NIGHT REFRIGERANT LEAKED DOWN. NO EVIDENCE OF DYE IN MOTOR COMPARTMENT. *TR

BAD/LEAKING MANIFOLD GASKET...... COOLANT LEAKS....CAUSING WATER PUMP TO BURN OUT...REPLACED TWICE ALREADY....AND COOLANT TO GET IN WITH OIL. *TR ESTIMATED REPAIR COST > $700

OTHER PART AFFECTED IS THE JACK THIS STYLE VAN RUSTS THRU IN FRONT OF THE REAR WHEEL WELL WHERE THE JACK IS SUPPOSED TO BE PLACED TO REPLACE THE SPARE TIRE. THERE IS NO LONGER ANY STRUCTURAL SUPPORT RESULTING IN A DANGEROUS CONDITION WHERE THE VAN CAN FALL OFF THE JACK IF YOU ATTEMPT TO PUT THE SPARE TIRE ON. AS A MATTER OF FACT MY CHEVROLET DEALER, AT ABOUT 170,000 MILES, CRUSHED THE WHOLE AREA OF MY CAR WHILE THEY PUT IT ON A LIFT TO REPLACE MY TRANSMISSION LINES. I CAN NEVER SAFELY PUT THE JACK AT THAT LOCATION. THAT IS WHAT ALERTED ME TO THE PROBLEM WHEREAS THE RUST WAS THERE VERY EARLY IN THE LIFE OF THE VAN! *TR

AIR CONDITIONING CONDENSER LEAKING. DEALER WANTS $1000 TO REPAIR. THIS IS A KNOWN DEFECT ON THIS CONDENSER, BAD WELDS, YET GM TAKES NO FAULT EVEN THOUGH TENS OF THOUSANDS OF THESE HAVE FAILED. WITH ASTHMA, I NEED A/C AND THIS VEHICLE IS NO SAFE WITHOUT IT. *TR

WHILE DRIVING 50 MPH REAR PASSENGER TIRE BLEW OUT. CONSUMER MANAGED TO PULLOVER, AND CHANGED THE TIRE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. FIRESTONE, 21570R15 , DOT#W2M3

WHILE TRAVELING ON HIGHWAY AT 70 MPH WE HAD A SIDEWALL BLOW OUT ON THE RIGHT REAR TIRE. FIRESTONE FR680 P215/70R15 TIRES WERE INSTALLED ON APRIL 29, 2003 AND HAD LESS THAN 5,000 MILES AT TIME OF BLOW OUT. CHECKED TIRE PRESSURE PREVIOUS SATURDAY AND ALL WERE OK. ALSO CHECKED TIRE PRESSURE ON OTHER 3 TIRES AFTER BLOW OUT AND ALL WERE OK. THE INCIDENT OCCURRED AT 10:00 P.M. WHILE DRIVING ON I-75 NORTH DOWN A 4% GRADE. FORTUNATELY WE DIDN'T HAVE AN ACCIDENT. WE HAD OUR FOUR KIDS IN THE CAR AGES 10 AND UNDER. NEEDLESS TO SAY WE DON'T FEEL VERY SAFE DRIVING ON THESE TIRES. *NLM

TL* THE CONTACT OWNS A 2001 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 65 MPH, A LOUD NOISE WAS COMING FROM THE ENGINE. IN ADDITION, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. AND THE VEHICLE FAILED TO CHANGE GEARS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE OXYGEN SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 162,000.

CAR WILL SPEED UP ON ITS OWN AND ACCELERATE. THE VENTURE WILL ALSO OVER HEAT AFTER RUNNING FOR 10 MIN. OR SO. THIS VAN LIKES TO STALL WHILE DRIVING AND YOU MUST KEEP YOUR FOOT ON THE BRAKE OR GAS TO PREVENT THIS FROM HAPPENING WHILE DRIVING. TRANSMISSION HAS BEEN SLIPPING SINCE I GOT THE CAR. ONLY OWNED IT LESS THAN A YEAR, NOW IT MADE A LOUD CLANKING NOISE LAST NIGHT AND NOW IT WILL NOT GO IN DRIVE ONLY IN REVERSE. YOU HAVE TO SHIFT GEARS ON THE STEERING COLUMN ONLY AND EVEN THEN IT'S DEBATABLE IF IT WILL RUN. *TR

CAR WILL SPEED UP ON ITS OWN AND ACCELERATE. THE VENTURE WILL ALSO OVER HEAT AFTER RUNNING FOR 10 MIN. OR SO. THIS VAN LIKES TO STALL WHILE DRIVING AND YOU MUST KEEP YOUR FOOT ON THE BRAKE OR GAS TO PREVENT THIS FROM HAPPENING WHILE DRIVING. TRANSMISSION HAS BEEN SLIPPING SINCE I GOT THE CAR. ONLY OWNED IT LESS THAN A YEAR, NOW IT MADE A LOUD CLANKING NOISE LAST NIGHT AND NOW IT WILL NOT GO IN DRIVE ONLY IN REVERSE. YOU HAVE TO SHIFT GEARS ON THE STEERING COLUMN ONLY AND EVEN THEN IT'S DEBATABLE IF IT WILL RUN. *TR

CRUISE CONTROL WILL INTERMITTENTLY NOT WORK. DEALER HAS BEEN CONTACTED.*AK

DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT VARIOUS SPEEDS, THERE WAS A VIBRATION WITHIN THE STEERING WHEEL. THE VEHICLE WAS SEEN BY A DEALER AND IT WAS DETERMINED THE KNUCKLE COLLAR AROUND THE FRONT TIE ROD ASSEMBLY WAS BROKEN. THE DEALER REPLACED THE TIE ROD ASSEMBLY WHICH CORRECTED THE PROBLEM.

CONSUMER HAD NOTICED SOME PROBLEM WITH THE STEERING. HAD TAKEN VEHICLE TO DEALER, AND THEY REPLACED INNER TIE ROD. PLEASE PROVIDE MORE INFORMATION.*AK

WHEEL HUB ASSEMBLY/WHEEL BEARING FAILED. *AK

PURCHASED VAN JULY 2001. I HAVE DISCONTINUED PUTTING MY SON IN INSTALLED CHILD SEAT BECAUSE HE COMPLAINS IT HURTS HIS LEGS; WHEN HE GOES TO GET OUT HE CAN'T HARDLY WALK;I THINK THE POSITION OF THE SEAT CAUSES HIS LEGS TO GO TO SLEEP. SINCE PURCHASE OF VAN I HAVE HAD IT IN FOR SERVICE SEVERAL TIMES. (1) I COMPLAINED OF VIBRATION IN THE FRONT WHEN I GOT UP TO A SPEED OVER 50 MPH; THE SERVICE TECHS COULD NOT FIND ANYTHING WRONG. (2) I COMPLAINED OF (WHILE TRAVELING) HEARING AIR VENTILATION (LIKE A WINDOW WAS DOWN) ON THE PASSENGER SIDE; NOTHING WAS FOUND. (3) WHEN PURCHASED THE VEHICLE WE STATED OUR CONCERN THAT DOOR DID NOT RETRACT IMMEDIATELY. I PUT MY ARM IN TO DEMONSTRATE; IT PINCHED MY ARM AND BRUISED IT BEFORE IT FINALLY RETRACTED (4) I HAVE ALSO HAD MY VAN IN COMPLAINING THAT THE CD PLAYER DID NOT OPERATE PROPERLY. THEY SAID IT WAS DEFECTIVE AND REPLACED MY ENTIRE RADIO/CD. (5) COMPLAINED THAT WHILE DRIVING (NOTICING AT NIGHT) MY HEADLIGHTS WOULD DIM AND COME BACK ON. AFTER NOT FINDING ANYTHING THEY REPLACED THE ALTERNATOR. IT IS AGAIN HAPPENING. (6) RECENT CONCERN IS WHILE ON AN UPWARD HILL AT A RED LIGHT WATER STARTED COMING IN THROUGH THE STORAGE COMPARTMENT BETWEEN THE VISORS. NOW THEY ARE DECLARING THAT THE WINDSHIELD WAS NOT PROPERLY SEALED WHEN IT WAS INSTALLED. I HAVE HAD THIS VEHICLE NOW FOR ALMOST TWO YEARS. MY THOUGHT IS THAT IT MAY HAVE BEEN LEAKING BUT NOW JUST TO THE POINT THAT I AM NOTICING IT. HOW MUCH DAMAGE HAS IT CAUSED IN MY HEAD LINER, ETC. THAT THEY WILL NOT BE ABLE TO DETECT WITH THE NAKED EYE AND IS THE AIR VENTILATION THAT I WAS HEARING A RESULT OF THE WINDSHIELD NOT BEING SEALED; AND IS THE WATER LEAKAGE CAUSING MY SHORTAGE IN THE WIRING OF THE LIGHTS AND RADIO, ETC. MY CONCERN IS LATER DOWN THE ROAD WILL I HAVE MORE DETERIORATING PROBLEMS BECAUSE OF WATER DAMAGE THAT COULD NOT BE SEEN AT THIS POINT. *NLM